ABS DODGE JOURNEY 2009 1.G User Guide

TIRE SIZING TERMS
Service Description: 95= Load Index
— A numerical code associated with the maximum load a tire can carry
H = Speed Symbol
— A symbol indicating the range of speeds at which a tire can carry a load corresponding to
its load index under certain operating conditions
— The maximum speed corresponding to the speed symbol should only be achieved under
specified operating conditions (i.e., tire pressure, vehicle loading, road conditions, and
posted speed limits)
Load Identification: \b....blank....\b = Absence of any text on the sidewall of the tire indicates a Standard Load (SL) Tire
Extra Load (XL) = Extra load (or reinforced) tire
Light Load = Light load tire
C, D, E = Load range associated with the maximum load a tire can carry at a specified pressure
Maximum Load — Maximum load indicates the maximum load this tire is designed to carry
Maximum Pressure —
Maximum pressure indicates the maximum permissible cold tire inflation pressure for this tire
STARTING AND OPERATING 339
5

Refrigerant Recovery and Recycling
R-134a Air Conditioning Refrigerant is a hydrofluoro-
carbon (HFC) that is endorsed by the Environmental
Protection Agency and is an ozone-saving product. How-
ever, the manufacturer recommends that air conditioning
service be performed by authorized dealers or other
service facilities using recovery and recycling equipment.
NOTE:Use only manufacturer approved A/C system
sealers, stop leak products, seal conditioners, compressor
oil, and refrigerants.
A/C Air Filter — If Equipped
Refer to the Maintenance Schedule in Section 8 for A/C
air filter service intervals.
WARNING!
Do not remove the A/C air filter while the blower is
operating or personal injury may result.
The A/C air filter is located in the fresh air inlet behind
the glove box. Perform the following steps to replace the
filter:
1. Open the glove box and remove all contents.
2. Push the retaining tab on each side of the glove box
inward while gently pulling the glove box door outward
until both tabs clear the door opening in the instrument
panel.
434 MAINTAINING YOUR VEHICLE

3. Pivot the glove box downward.
4. Disengage the two retaining tabs that secure the filter
cover to the HVAC housing and remove the cover.5. Remove the A/C air filter by pulling it straight out of
the housing.
6. Install the A/C air filter with the arrow on the filter
pointing toward the floor. When installing the filter
cover, make sure the retaining tabs fully engage the
cover.
Glove Box RemovalA/C Air Filter Replacement
MAINTAINING YOUR VEHICLE 435
7

•Use Mopartouch up paint on scratches as soon as
possible. Your authorized dealer has touch up paint to
match the color of your vehicle.
Wheel and Wheel Trim Care
All wheels and wheel trim, especially aluminum and
chrome plated wheels should be cleaned regularly with a
mild soap and water to prevent corrosion. To remove
heavy soil and/or excessive brake dust, use Mopar 
Wheel Cleaner (05066247AB) or equivalent or select a
nonabrasive, non-acidic cleaner. Do not use scouring
pads, steel wool, a bristle brush, or metal polishes. Only
Mopar or equivalent is recommended. Do not use oven
cleaner. Avoid automatic car washes that use acidic
solutions or harsh brushes that may damage the wheels’
protective finish.
Interior Care
Instrument Panel Cover
The instrument panel cover has a low glare surface,
which minimizes reflections in the windshield. Do not
use protectants or other products, which may cause
undesirable reflections. Use soap and warm water to
restore the low glare surface.
Cleaning Interior Trim
Interior Trim should be cleaned starting with a damp
cloth, a damp cloth with Mopar Total Clean, then
Mopar Spot & Stain Remover if absolutely necessary. Do
not use harsh cleaners or Armorall. Use Mopar Total
Clean to clean vinyl upholstery
Cleaning Leather Upholstery
Mopar Total Clean is specifically recommended for
leather upholstery.
454 MAINTAINING YOUR VEHICLE

CAUTION!
•When installing the power module cover, it is
important to ensure the cover is properly posi-
tioned and fully latched. Failure to do so may
allow water to get into the TIPM, and possibly
result in an electrical system failure.
•When replacing a blown fuse, it is important to
use only a fuse having the correct amperage rating.
The use of a fuse with a rating other than indicated
may result in a dangerous electrical system over-
load. If a properly rated fuse continues to blow, it
indicates a problem in the circuit that must be
corrected.
CavityCartridge
Fuse Mini-
Fuse Description
J1 40 Amp Green —Power Folding Seat
J2 30 Amp Pink —Transfer Case Module
- if equipped
J3 30 Amp Pink —Rear Door Module
J4 25 Amp White —Driver Door Node
J5 25 Amp White —Passenger Door Node
J6 40 Amp Green —Anti-Lock Brake Sys-
tem (ABS) Pump/
Electronic Stability
Program (ESP)
458 MAINTAINING YOUR VEHICLE

CavityCartridge
Fuse Mini-
Fuse Description
J7 30 Amp Pink —Anti-Lock Brake Sys-
tem (ABS) Valve/
Electronic Stability
Program (ESP)
J8 40 Amp Green —Power Memory Seat -
if equipped
J9 40 Amp Green —Flex Fuel/PZEV Mo-
tor - if equipped
J10 30 Amp Pink —(If Equipped) Head-
lamp Washer Relay-
(BUX), Manual Tun-
ing Valve
J11 30 Amp Pink —(If Equipped) Sway
Bar/Thatchum Secu-
rity (BUX)/Power
Sliding DoorCavity
Cartridge
Fuse Mini-
Fuse Description
J13 60 Amp Yellow —Ignition Off Draw
(IOD) Main
J14 40 Amp Green —Electric Back Light
(EBL)
J15 30 Amp Pink —Rear Blower - if
equipped
J17 40 Amp Green —Starter Solenoid
J18 20 Amp Yellow — NGC (Powertrain
Control Module)/
Transmission Range
J19 60 Amp Yellow —Radiator Fan Motor
J20 30 Amp Pink —Front Windshield
Wiper Hi/Low
J21 20 Amp Blue —Front/Rear Washer
MAINTAINING YOUR VEHICLE 459
7

CavityCartridge
Fuse Mini-
Fuse Description
M37
—10 Amp
Red
Anti-Lock Brake Sys-
tem (ABS), Electronic
Stability Program
(ESP), STOP LIGHT
Switch
M38 —25 Amp
Natural Lock/Unlock Motors
K1
—— Ignition Run/
Accessory Relay
K2 — — Ignition Run Relay
K3 — — Starter Solenoid Relay
K4 —— Ignition Run/Start
Relay
K5 —— (NGC) Powertrain
Control Module Relay
K6 —— Electric Back Light
(EBL) Relay
K7 — — —
K8 — — —
K9 — — Rear Blower Relay
K10 —— ASD Relay (Feed for
M19 and M21)
K11 —— Radiator Fan Relay
Low Speed
VEHICLE STORAGE
If you will not be using your vehicle for more than 21
days you may want to take steps to preserve your battery.
You may:
•Remove the IOD (Ignition Off-Draw) mini-fuses from
the Totally Integrated Power Module located in the
engine compartment.
•Or, disconnect the batter negative cable.
464 MAINTAINING YOUR VEHICLE

Contract, and you require service after the manufactur-
er’s New Vehicle Limited Warranty expires, please refer
to the contract documents, and contact the person listed
in those documents.
We appreciate that you have made a major investment
when you purchased the vehicle. An authorized dealer
has also made a major investment in facilities, tools, and
training to assure that you are absolutely delighted with
the ownership experience. You’ll be pleased with their
sincere efforts to resolve any warranty issues or related
concerns.WARNING!
Engine exhaust, some of its constituents, and certain
vehicle components contain, or emit, chemicals
known to the State of California to cause cancer and
birth defects or other reproductive harm. In addition,
certain fluids contained in vehicles and certain prod-
ucts of component wear contain, or emit, chemicals
known to the State of California to cause cancer and
birth defects or other reproductive harm.
WARRANTY INFORMATION (U.S. Vehicles Only)
See the Warranty Information Booklet for the terms and
provisions of Chrysler LLC warranties applicable to this
vehicle.
490 IF YOU NEED CONSUMER ASSISTANCE

About Your Brakes.................... 323,326
ABS (Anti-Lock Brake System) .........215,327,328
Adding Engine Coolant (Antifreeze) .......... 442
Adding Fuel ........................... 372
Adding Rear Washer Fluid ................. 194
Adding Washer Fluid ...............157,194,438
Additives, Fuel ......................... 371
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . 429
Air Conditioner Maintenance ............... 433
Air Conditioning ..................... 288,289
Air Conditioning Controls ...............288,289
Air Conditioning Filter .................301,434
Air Conditioning, Operating Tips ............ 302
Air Conditioning Refrigerant .............433,434
Air Conditioning System ..........288,289,293,433
Air Pressure, Tires .................... 213,346
Airbag ................................ 50
Airbag Deployment ..................... 56,60
Airbag Light ..................... 57,63,80,218Airbag Maintenance
....................... 62
Airbag, Side .......................... 52,58
Airbag, Window (Side Curtain) .............52,58
Alarm, Panic ............................ 24
Alarm (Security Alarm) .................18,208
Alarm System (Security Alarm) ............... 18
Alignment and Balance ................... 354
All Wheel Drive (AWD) ................... 319
Alterations/Modifications, Vehicle ............. 7
Antenna, Satellite Radio ................... 272
Antifreeze (Engine Coolant) ...........441,442,472
Disposal ............................ 443
Anti-Lock Brake System (ABS) ............327,328
Anti-Lock Warning Light .............215,328,329
Anti-Theft Security Alarm (Theft Alarm) ........ 18
Anti-Theft System ....................... 208
Appearance Care ........................ 452
Arming Theft System (Security Alarm) ......... 18
Assistance Towing ....................... 106
496 INDEX

Brake Assist System...................... 330
Brake Assist Warning Light ................. 216
Brake Control System, Electronic ............. 328
Brake Fluid ............................ 476
Brake, Parking .......................... 323
Brake System ........................ 326,446
Anti-Lock (ABS) .................... 327,328
Fluid Check ....................... 447,476
Hoses .............................. 446
Master Cylinder ....................... 447
Parking ............................. 323
Warning Light ........................ 217
Brakes ............................. 326,446
Brake/Transaxle Interlock .................. 312
Break-In Recommendations, New Vehicle ........ 77
Brightness, Interior Lights .................. 152
Bulb Replacement ..................... 465,466
Bulbs, Light .......................... 81,465Calibration, Compass
.................. 219,228
Camera, Rear ........................... 92
Capacities, Fluid ........................ 472
Caps, Filler Fuel ................................ 372
Oil (Engine) .................. 418,419,420,427
Radiator (Coolant Pressure) ............... 442
Car Washes ............................ 452
Carbon Monoxide Warning ...............79,372
Cargo Area Cover ....................... 191
Cargo Area Features ...................... 188
Cargo Compartment ...................... 188
Light ............................ 151,188
Luggage Carrier ....................... 196
Cargo Light ............................ 151
Cargo Load Floor ........................ 188
Cargo Management System ................. 188
Rollaway Tonneau Cover ................. 191
Tri-Fold Load Floor ..................... 188
498 INDEX