wheel DODGE NITRO 2007 1.G Workshop Manual

WARNING!
Any procedure other than above could result in:
1. Personal injury caused by electrolyte squirting
out the battery vent;
2. Personal injury or property damage due to battery
explosion;
3. Damage to charging system of booster vehicle or
of immobilized vehicle.
TOWING A DISABLED VEHICLE
Proper towing or lifting equipment is required to prevent
damage to your vehicle. Use of safety chains is recom-
mended.Attach towing device to main structural mem-
bers of the vehicle — not to bumpers or associated
brackets. State and local laws applying to vehicles
under tow must be observed.
Two-Wheel Drive Vehicles
Provided that the transmission is operable, tow with the
transmission in N (Neutral) and the ignition key in the
OFF position along with the front wheels raised and the
rear wheels on the ground. The speed must not exceed 30
mph (50 km/h) and the distance must not exceed 15
miles (25 km).
If the vehicle is to be towed more than 15 miles (25 km )
or faster than 30 mph, it must be towed on a flatbed, or
with the rear wheels raised and the front wheels on the
ground, or with the front end raised and the rear wheels
on a towing dolly.
NOTE:Towing the vehicle, with the rear wheels on the
ground, at more than 30 mph (50 km/h) or for more than
15 miles (25 km) can cause severe transmission damage.
Four-Wheel Drive Vehicles
The manufacturer recommends towing with all wheels
OFFthe ground. Acceptable methods are to tow the
vehicle on a flatbed or with one end of the vehicle raised
and the opposite end on a towing dolly.
334 WHAT TO DO IN EMERGENCIES

CAUTION!
Do not use abrasive or strong cleaning materials
such as steel wool or scouring powder, which will
scratch metal and painted surfaces.
Special Care
•
If you drive on salted or dusty roads or if you drive
near the ocean, hose off the undercarriage at least once
a month.
•It is important that the drain holes in the lower edges
of the doors, rocker panels and tailgate must be kept
clear and open.
•If you detect any stone chips or scratches in the paint,
touch them up immediately. The cost of such repairs is
considered the responsibility of the owner.
•If your vehicle is damaged due to an accident or
similar cause which destroys the paint and protective
coating have your vehicle repaired as soon as possible.
The cost of such repairs is considered the responsibil-
ity of the owner.
•If you carry special cargo such as chemicals, fertilizers,
de-icer salt, etc., assure that such materials are well
packaged and sealed.
•If a lot of driving is done on gravel roads, consider
mud or stone shields behind each wheel.
•Use MoparTouch Up Paint on scratches or chips as
soon as possible. Your authorized dealer has touch up
paint to match the color of your vehicle.
Wheel and Wheel Trim Care
All wheels and wheel trim, especially aluminum and
chrome plated wheels should be cleaned regularly with a
mild soap and water to prevent corrosion. To remove
368 MAINTAINING YOUR VEHICLE

heavy soil, use MoparWheel Cleaner or select a non-
abrasive, non-acidic cleaner. Do not use scouring pads,
steel wool, a bristle brush or metal polishes. Only Mo-
parcleaners are recommended. Do not use oven cleaner.
Avoid automatic car washes that use acidic solutions or
harsh brushes that may damage the wheels’ protective
finish.
YES EssentialsFabric Cleaning Procedure – If
Equipped
YES Essentialsseats may be cleaned in the following
manner:
•Remove as much of the stain as possible by blotting
with a clean, dry towel.
•Blot any remaining stain with a clean, damp towel.
•For tough stains, apply MoparTotal Clean or a mild
soap solution to a clean, damp cloth and remove stain.
Use a fresh, damp towel to remove soap residue.
•For grease stains, apply MoparMulti-Purpose
Cleaner to a clean, damp cloth and remove stain. Use
a fresh, damp towel to remove soap residue.
•Do not use any solvents or protectants on Yes Essen-
tialsproducts.
Interior Care
Use MoparTotal Clean to clean fabric upholstery and
carpeting.
Interior Trim should be cleaned starting with a damp
cloth, a damp cloth with MoparTotal Clean, then
MoparSpot & Stain Remover if absolutely necessary. Do
not use harsh cleaners or Armorall. Use MoparTotal
Clean to clean vinyl upholstery.
MAINTAINING YOUR VEHICLE 369
7

BULB REPLACEMENT
Head Light
1. Open the hood.
2. Reach behind the headlamp unit in the engine com-
partment to access the headlamp bulb lock ring.
3. Firmly grasp the lock ring on the back of the headlamp
unit housing.
4. Rotate the lock ring on the back of the headlamp
housing counter-clockwise to unlock it.
CAUTION!
Do not touch the new bulb with your fingers. Oil
contamination will severely shorten bulb life. If the
bulb comes in contact with any oily surface, clean
the bulb with rubbing alcohol.
5. Disconnect the electrical connector and replace the
bulb.
Left Front Turn Signal
1. Turn the steering wheel all the way to the right (full
right lock).
2. Remove the door in the left wheel liner by twisting
counter clockwise. Access to the bulb can be gained
through the wheel liner hole.
3. Disconnect the electrical connector.
4. Twist the bulb counter clockwise to remove.
Right Front Turn Signal
1. Open the hood.
2. Reach behind the headlamp unit in the engine com-
partment to access the turn signal bulb.
3. Twist the bulb counter clockwise to remove.
MAINTAINING YOUR VEHICLE 379
7

4. Disconnect the electrical connector and replace the
bulb.
Front Side Marker
1. Open the hood.
2. Remove the grille assembly, as follows:
a. Remove eight fasteners.
b. Remove two screws from each headlamp.
c. Remove two scrivets from the center of the grille.
d. Remove one push pin from the top of each fender.
e. Pull the grille assembly toward you to disconnect
the grille clips to the fender and the headlamp ball-
studs to the front end module.
3. Disconnect electrical connector.
4. Turn the bulb counterclockwise to remove.
Front Fog Light (Front Fascia Mounted)
1. Reach between the front fascia and wheel liner from
under the vehicle.
2. Turn the front fog light bulb 1/4 turn counter clock-
wise to remove from housing.
3. Disconnect the electrical connector and replace bulb.
CAUTION!
Do not touch the new bulb with your fingers. Oil
contamination will severely shorten bulb life. If the
bulb comes in contact with any oily surface, clean
the bulb with rubbing alcohol.
380 MAINTAINING YOUR VEHICLE

on specified government test surfaces of asphalt and
concrete. A tire marked C may have poor traction perfor-
mance.
WARNING!
The traction grade assigned to this tire is based on
straight-ahead braking traction tests, and does not
include acceleration, cornering, hydroplaning, or
peak traction characteristics.
Temperature Grades
The temperature grades are A (the highest), B, and C,
representing the tire’s resistance to the generation of heat
and its ability to dissipate heat when tested under
controlled conditions on a specified indoor laboratory
test wheel. Sustained high temperature can cause the
material of the tire to degenerate and reduce tire life, and
excessive temperature can lead to sudden tire failure. Thegrade C corresponds to a level of performance which all
passenger car tires must meet under the Federal Motor
Vehicle Safety Standard No. 109. Grades B and A repre-
sent higher levels of performance on the laboratory test
wheel than the minimum required by law.
WARNING!
The temperature grade for this tire is established for
a tire that is properly inflated and not overloaded.
Excessive speed, under inflation, or excessive load-
ing, either separately or in combination, can cause
heat buildup and possible tire failure.
418 IF YOU NEED CONSUMER ASSISTANCE

Flooded Engine Starting................... 240
Fluid, Brake........................... 384
Fluid Capacities......................... 382
Fluid Leaks............................. 76
Fluid Level Checks...................... 366
Automatic Transmission................. 363
Engine Oil........................... 343
Manual Transmission................... 364
Power Steering........................ 352
Fluids, Lubricants and Genuine Parts.......... 383
Fog Light Service........................ 380
Fog Lights..........................121,380
Folding Rear Seat........................ 115
Four Wheel Drive....................... 259
Operation........................... 259
Systems............................. 259
Four Wheel Drive Operation................ 259
Four-Way Hazard Flasher.................. 324
Front Axle (Differential)................... 366Fuel................................. 296
Filler Cap (Gas Cap).................... 300
Filter ............................... 350
Gasoline............................ 296
Gauge.............................. 164
Materials Added....................... 298
Octane Rating......................296,383
Requirements......................... 382
Tank Capacity........................ 382
Fuel System Caution................298,301,302
Fuses................................ 371
Garage Door Opener (HomeLink) ........... 134
Gas Cap (Fuel Filler Cap)............300,302,340
Gas Gauge (Fuel Gauge)................... 164
Gasoline (Fuel)......................... 296
Gasoline, Reformulated................... 297
Gasoline/Oxygenate Blends................ 297
INDEX 425
10

Bulb Replacement...................378,379
Cargo .............................. 150
Center Mounted Stop................... 381
Cruise .............................. 174
Daytime Running...................... 122
Dimmer Switch, Headlight............... 120
Electronic Stability Program
(ESP) Indicator.......................132,166
Fog ..........................121,170,380
Hazard Warning Flasher................. 324
Headlight Switch...................... 120
Headlights........................... 379
Illuminated Entry....................... 20
Instrument Cluster..................120,164
Interior............................. 119
Lights On Reminder.................... 120
Low Fuel............................ 164
Malfunction Indicator (Check Engine)........ 173
Passing............................. 121Rear Servicing........................ 381
Rear Tail............................ 381
Seat Belt Reminder..................... 165
Service...........................378,379
Side Marker.......................... 381
Traction Control....................... 132
Turn Signal.....................121,379,381
Warning (Instrument Cluster Description)..... 164
Load Floor, Cargo....................... 151
Load N Go
SlidingCargoFloor ..................... 153
Loading Vehicle......................... 303
Tires ............................... 274
Locks................................. 27
Automatic Door........................ 30
Child Protection........................ 30
Door................................ 27
Power Door........................... 29
Steering Wheel......................... 16
428 INDEX

Settings, Personal........................ 188
Shift Lock Manual Override................ 248
Shift Speeds, Manual Transmission........... 245
Shifting
Automatic Transmission...............249,254
Manual Transmission................... 243
Shoulder Belts........................... 38
Signals, Turn...................121,167,379,381
Sliding Cargo Floor
LoadNGo ........................... 153
Snow Chains (Tire Chains)................. 285
Spare Tire............................. 327
Spark Plugs............................ 347
Specifications
Fuel (Gasoline)........................ 296
Oil ................................ 345
Speed Control (Cruise Control).............. 125
Speedometer........................... 166
Starting............................... 239Automatic Transmission................. 239
Cold Weather......................... 240
Emergency (Jump Starting)............... 332
Engine Block Heater.................... 243
Engine Fails to Start.................... 240
Manual Transmission................... 239
Remote.............................. 26
Steering
Power...........................268,352
TiltColumn .......................... 124
Wheel Lock........................... 16
Wheel, Tilt........................... 124
Steering Wheel Mounted Sound
System Controls......................... 226
Storage............................... 148
Storage Bin............................ 148
Storage, Vehicle......................... 233
Sun Roof.............................. 141
Sun Visor Extension....................... 84
Supplemental Restraint System - Airbag........ 47
INDEX 433
10

Universal Transmitter..................... 134
Upholstery Care........................ 369
Utility Table........................... 152
Vacuum/Vapor Harnesses................. 360
VanityMirrors ........................... 84
Variance, Compass....................177,184
Vehicle Identification Number (VIN)............ 8
Vehicle Loading......................275,303
Vehicle Modifications/Alterations.............. 9
Vehicle Storage......................... 233
Video Entertainment System
(Rear Seat Video System).................. 225
Viscosity, Engine Oil...................... 346
Warning Flasher, Hazard.................. 324
Warning Lights
(Instrument Cluster Description)............. 164
Warnings and Cautions..................... 8
Warranty Information..................... 415Washer, Adding Fluid..................... 156
Washers, Windshield..................... 354
WaxingandPolishing ..................... 367
Wheel Alignment and Balance............... 284
Wheel and Wheel Trim.................... 368
Wheel and Wheel Trim Care................ 368
Wheel Mounting........................ 331
WindBuffeting ....................... 35,143
Window Fogging........................ 232
Windows.............................. 31
Power............................... 31
Windshield Defroster...................... 76
Windshield Washers...................122,354
Fluid ............................... 354
Windshield Wiper Blades.................. 354
Windshield Wipers....................... 122
Wiper, Rear............................ 155
Wrecker Towing......................... 334
YES EssentialsFabric Cleaning Procedure...... 369
436 INDEX