fuses DODGE SPRINTER 2004 1.G Owners Manual

UNDERSTANDING THE FEATURES OF YOUR VEHICLE 75
3
Mechanical Sun Roof OperationThe sun roof does not open or close:
Check electrical fuse. Electrical fuses refer to “Electrical
Fuses“.
If the fuse works correctly, the sun roof can also be
closed or opened manually.
Remove cover (1) at the front frame of the sun roof.
Remove tool (2) from the cover (1) and insert.
Open manually:
Press in tool (2) and turn counterclockwise (3).
Close manually:
Press in tool (2) and turn clockwise (4).
Have malfunctions rectified by an authorized Sprinter
Dealer.Freightliner-all.book Pag e 75 Monday , December 1, 2003 2:54 PM

130 UNDERSTANDING YOUR INSTRUMENT PANELTo switch on at blower speed 1:
Press the upper section, the left-hand indicator lamp in
the switch lights up.
To switch on at blower speed 2:
Press the lower section, the right-hand indicator lamp
in the switch lights up.
To switch off :
Press the switch to the middle position.
Operation is only possible when the key is turned to
position 2 in the ignition lock.
NOTE: The auxiliary heat exchanger in the load
compartment should be switched off at coolant
temperatures below 176 °F (+80 °C) to quickly de-fog
and de-ice the windshield and front side windows.
A UXILIA RY HEA TER – TIPS FOR COPING WITH
PROBLEMSThe heater either does not switch on or automatically
switches off:
 Insufficient fuel, fill up the fuel tank. Start up heater
several times, until the fuel lines are filled.
 The auxiliary heater will automatically switch off if
the fuel level is under about 4 US gal (15 l).
 The fuses in the fuse box are damaged. Electric
fuses.
 The battery voltage is too low, an undervoltage
protector switches off the heater if the battery
voltage falls below about 10 volts.
The heater motor does not run
 The battery voltage is too low, check the battery.
Batteries.
 The fuses in the fuse box are damaged.
Electric fuses.
 The heater motor is damaged.
Freightliner-all.book Pag e 130 Monday, December 1, 2003 2:54 PM

204 MAINTAINING YOUR VEHICLE
Wiper Blade . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 223Light Alloy Wheels . . . . . . . . . . . . . . . . . . . . . . 224Instrument Cluster . . . . . . . . . . . . . . . . . . . . . . . 224Steering Wheel and Gear Selector Lever . . . . 224Cup Holder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 224Seat Belts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 224Headliner and Shelf Below Rear Window . . . 224Upholstery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 224Hard Plastic Trim Items . . . . . . . . . . . . . . . . . . 225Plastic and Rubber Parts . . . . . . . . . . . . . . . . . . 225

Electrical Fuses . . . . . . . . . . . . . . . . . . . . . . . . . . . . 225Standard Fuse and Relay Equipment . . . . . . . 226Relay Assignment, Standard Equipment . . . . 230Fuse and Relay Optional Equipment . . . . . . . 230

Bulb Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . 233Front Lamp Unit . . . . . . . . . . . . . . . . . . . . . . . . . 233Taillamps . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 238
License Plate Lamps
(Cargo/Passenger Vans Only) . . . . . . . . . . . . . 240Additional Brake Lamp
(Cargo/Passenger Vans Only) . . . . . . . . . . . . . 240Side-Mounted Turn Signals . . . . . . . . . . . . . . . 241Side-Marker Lamps,
Standing Lamps (Optional) . . . . . . . . . . . . . . . . 241Interior Lighting in Passenger Compartment
and Load Compartment . . . . . . . . . . . . . . . . . . 242Interior Lighting with Reading Lamp . . . . . . . 242Interior Lighting with Interior Sensor
Protection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 243Exit Lamps (Optional) . . . . . . . . . . . . . . . . . . . . 243

Capacities . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 244Recommended Fluids and Lubricants . . . . . . 245
Freightliner-all.book Pag e 204 Monday, December 1, 2003 2:54 PM

206 MAINTAINING YOUR VEHICLELegend For Engine Compartment
1. Windshield washer system fluid reservoir.
2. Maintenance indicator for air cleaner element
(Optional).
3. Oil dipstick.
4. Oil filler neck.
5. Ribbed V-belt.
Auxiliary drive (Optional) refer to “Auxiliary
drive“.6. Fuel filter with water separator.
7. Hydraulic brake fluid reservoir.
8. Coolant reservoir.
9. Battery
The auxiliary battery is located underneath the
front passenger seat (optional equipment).
10. Fuse box
(These special fuses should only be replaced at by
an authorized Sprinter Dealer).Freightliner-all.book Pag e 206 Monday, December 1, 2003 2:54 PM

MAINTAININ G YOUR VEHICLE 225
7
etc.) may cause the upholstery to become permanently
discolored. By lining the seats with a proper
intermediate cover, contact discoloration will be
prevented.
Leather Upholstery
Wipe leather upholstery with a damp cloth and dry
thoroughly or clean with a leather care product.
Exercise particular care when cleaning perforated
leather as its underside should not become wet.
Cloth Upholstery
Clean with soft bristle brush, or use a dry-shampoo
cleaner in case of excessive dirt.
Tex Upholstery
Pour an interior care product onto soft lint-free cloth
and apply with light pressure.Hard Plastic Trim ItemsPour an interior care product onto soft lint-free cloth
and apply with light pressure.Plastic and Rubber PartsDo not use oil or wax on these parts.
ELECTRICAL FUSESDamaged fuses are recognizable from their burnt-out
filament.
Prior to exchanging a fuse, turn the key in the ignition-
column lock to the 0 position and switch off the
consumer involved.
NOTE: Fuses must not be bridged. Replace fuses with
specified rated current. Only replace fuses when the
cause of the malfunction has been rectified.
NOTE: Fuses and relays (standard equipment) are on
the underside of the ignition column, refer to "Fuses
and Relays Standard Equipment".
Fuses, relays and diodes (optional equipment) are
below the driver’s seat, refer to "Optional Fuse and
Relay Equipment".
Freightliner-all.book Pag e 225 Monday, December 1, 2003 2:54 PM

MAINTAININ G YOUR VEHICLE 227
7
Position of fuses and relays
4. Fuses
5. RelaysFreightliner-all.book Pag e 227 Monday, December 1, 2003 2:54 PM

232 MAINTAINING YOUR VEHICLENOTE: The arrangement of the fuses (1) depends on
the optional equipment installed on the vehicle. The
assignments are shown on the inside of the cover of the
fuse box.
Diodes:No. Circuit
1. Not in use
2. Not in use
3. Not in use
4. Not in use
Fuses:No. Rated Circuit
5. 10A Immobilizer
6. 7.5A Anti-lock brake system (ABS)
7. 25A Anti-lock brake system (ABS)
8. 40A Not in use
9. 40A Anti-lock brake system (ABS)
10. Not in useRelays:No. Circuit
11. Not in use
12. Starter relay
13. Not in use
Freightliner-all.book Pag e 232 Monday, December 1, 2003 2:54 PM

264 INDEXCleaning
Cup Holder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 224
Hard Plastic Trim Items . . . . . . . . . . . . . . . . . . . . . 225
Instrument Cluster . . . . . . . . . . . . . . . . . . . . . . . . . 224
Light Alloy Wheels . . . . . . . . . . . . . . . . . . . . . . . . . 224
Plastic and Rubber Parts . . . . . . . . . . . . . . . . . . . . 225
Seat Belts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 224
Steering Wheel and Gear Selector Lever . . . . . . . 224
Upholstery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 224
Wiper Blade . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 223
Climate Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 116
Clock . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 89
Comfort Tire Pressures . . . . . . . . . . . . . . . . . . . . . . . . 169
Compartments in Front Doors. . . . . . . . . . . . . . . . . . . 79
Constant RPMs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 137
Consumer Assistance
Be Reasonable with Request . . . . . . . . . . . . . . . . . 256
If You Need Assistance . . . . . . . . . . . . . . . . . . . . . 256
Prepare a List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 256
Prepare for the Appointment . . . . . . . . . . . . . . . . 256Coolant Level Indicator Lamp . . . . . . . . . . . . . . . . . . . 98
Coolant Temperature Gauge . . . . . . . . . . . . . . . . . . . . 93
Corrosion Protection . . . . . . . . . . . . . . . . . . . . . . . . . . 219
Cup Holder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 78
DDe-Fogging . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 112
Dehumidification . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 117
De-Icing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 112
Diesel Fuels for Use at Very Low Temperatures. . . 171
Displaying Engine Oil Level . . . . . . . . . . . . . . . . . . . 106
Doors
Front Doors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
Rear Cargo Doors . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
Sliding Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26
Draining Fuel Filter with Water Separator . . . . . . . 175
Driver’s Airbag. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41EElectric Sun Roof . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 74
Electrical Fuses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 225
Fuse and Relay Optional Equipment . . . . . . . . . . 230
Freightliner-all.book Pag e 264 Monday, December 1, 2003 2:54 PM

266 INDEX
Fuel Tank Capacity . . . . . . . . . . . . . . . . . . . . . . . . . 173
Refueling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 172
Fuse and Relay Optional Equipment . . . . . . . . . . . . 230
Fuse, Relay, and Diode Assignments - Optional
Equipment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 230
Fuses, Electrical . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 225
GGlove Compartment . . . . . . . . . . . . . . . . . . . . . . . . . . . 79
Lockable Glove Compartment . . . . . . . . . . . . . . . . 79HHazard Warning Flasher Switch . . . . . . . . . . . . . . . . 186
Head Restraint . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 56
Headlamp Range Control. . . . . . . . . . . . . . . . . . . . . . . 62
Headlamps, taillamps, turn signal lenses . . . . . . . . 222
Heated Rear Window . . . . . . . . . . . . . . . . . . . . . . . . . 114
Heater, Seat. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57
Heating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 109, 111
Hood . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 60
How to Use this Manual . . . . . . . . . . . . . . . . . . . . . . . . . 4
Hydroplaning. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 165Ignition
Lock . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Starter Switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Immobilizer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Indicator Lamp Symbols . . . . . . . . . . . . . . . . . . . . . . . . 99
Inhalation of Exhaust Gas. . . . . . . . . . . . . . . . . . . . . . . 48
Installing a Wheel . . . . . . . . . . . . . . . . . . . . . . . . . . . . 196
Instrument and Display Lighting . . . . . . . . . . . . . . . . 90
Instrument Cluster
Battery Charge Indicator Lamp . . . . . . . . . . . . . . . 95
Clock . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 89
Coolant Level Indicator Lamp . . . . . . . . . . . . . . . . 98
Coolant Temperature Gauge . . . . . . . . . . . . . . . . . . 93
Engine Control Unit Indicator Lamp . . . . . . . . . . . 99
Engine Oil Level Indicator Lamp . . . . . . . . . . . . . . 97
Tachometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 92
Trip Meter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 90
Water in Fuel Indicator Lamp . . . . . . . . . . . . . . . . . 96
Instrument Cluster and Indicator Lamps. . . . . . . . . . 85
Instruments and Controls . . . . . . . . . . . . . . . . . . . . . . . 83Freightliner-all.book Pag e 266 Monday, December 1, 2003 2:54 PM