jump start DODGE SPRINTER 2004 1.G Owners Manual

WHAT TO DO IN EMERGENCIES
6
CONTENTS
Hazard Warning Flasher Switch . . . . . . . . . . . . . 186

Vehicle Tool Kit . . . . . . . . . . . . . . . . . . . . . . . . . . . 187

Changing the Tire . . . . . . . . . . . . . . . . . . . . . . . . . . 187Spare Wheel Location . . . . . . . . . . . . . . . . . . . . 189

Jack . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 192Using the Jack . . . . . . . . . . . . . . . . . . . . . . . . . . . 193

Removing a Wheel . . . . . . . . . . . . . . . . . . . . . . . . . 195

Installing a Wheel . . . . . . . . . . . . . . . . . . . . . . . . . . 196

Jump Starting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 198

Towing the Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . 200If the Engine is Damaged . . . . . . . . . . . . . . . . . 201If the Transmission is Damaged . . . . . . . . . . . . 201If the Front Axle is Damaged . . . . . . . . . . . . . . 202If the Rear Axle is Damaged . . . . . . . . . . . . . . . 202
Freightliner-all.book Pag e 185 Monday, December 1, 2003 2:54 PM

198 WHAT TO DO IN EMERGENCIES
Tightening torque for 9,990 lbs (4,530 kgs)
(vehicle type 3500 C/HC/SHC):
Steel wheel – 138 lbf.ft ±14 lbf.ft (190 N.m ±20 N.m)
 Remove jack and stow it in the vehicle tool kit.
 Check the tire pressure.
 Re-tighten the wheel bolts to the specified torque
with a torque wrench after a distance of 30 miles
(about 50 km).
JUMP STA RTINGIf the battery is dead, the engine can be started with
jumper cables from another vehicle’s battery.
WARNING!
After changing a wheel, you must, for safety reasons,
 have the specified tightening torque checked. The
wheels could otherwise work loose.
 check the tire pressure and correct it if necessary.
 retighten the wheel bolts and wheel nuts to the
specified tightening torque once the vehicle has
been driven for 30 miles (50 km).
 have a reversed direction of tire rotation corrected
as soon as possible at a qualified specialist
workshop. The vehicle handling characteristics
could otherwise be affected.
WARNING!
A battery will also produce hydrogen gas, which
is flammable and very explosive. Avoid open
flames and the formation of sparks in the vicinity
of the batteries. Refrain from smoking or cell
phone use. Avoid improper connection of jumper
cables.
Observe safety precautions when handling
batteries.
Exercise care near moving engine components and
electrical cables.
Failure to follow these directions will cause
damage to the electronic components and can lead
to a battery explosion and severe injury or death.
Freightliner-all.book Pag e 198 Monday, December 1, 2003 2:54 PM

WHAT TO DO IN EMERGENCIES 199
6
 A dead battery can freeze at a temperature of 14
°F
(–10
°C). Never try to start the engine if the battery
is frozen. Thaw the battery out first.
 Only use a battery of the same rated voltage and of
approximately the same capacity for jump-starting.
 The two vehicles must not touch.
 Switch off all electrical accessories.
 Run the vehicle with the booster battery at idle.
 Connect the jumper cables in the sequence given in
the illustration. Battery fluid contains sulfuric acid. Do not allow
this fluid to come in contact with eyes, skin or
clothing. In case it does, immediately flush
affected area with water, and seek medical help.
The battery housing could be damaged. Never
lean over batteries while connecting or jump-
starting. You might get injured.
Read all instructions before proceeding.
Freightliner-all.book Pag e 199 Monday, December 1, 2003 2:54 PM

200 WHAT TO DO IN EMERGENCIES1. First connect the positive terminals of the two
batteries (see illustration, Items 1 + 2). Start with the
booster battery.
2. Then connect the negative terminal of the vehicle
with the booster battery to a vehicle ground point
of the vehicle with the discharged battery, such as
to the engine block (see illustration, Items 3 + 4).
Start with the booster battery.
3. Start the engine in the customary manner.
4. Allow the engine to run for a short time.
5. Before disconnecting the jumper cables from the
vehicle with the booster battery, switch on an
electrical consumer (e.g. the blower, but not the
lamps).
6. Disconnect the jumper cables in the reverse order to
that in which they were connected.
7. Disconnect the jumper cable from negative
terminal and vehicle ground point first (see
illustration, items 3 + 4), then from positive
terminals of the batteries (see illustration 1 + 2).
NOTE: Never try to start the engine with the aid of a
battery quick-charge unit.
TOWING THE VEHICLE
Freightliner-all.book Pag e 200 Monday, December 1, 2003 2:54 PM

INDEX 267
10
Interior Lighting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63
Cargo Area . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 65
Driver and Rear-Seat Passenger/Cargo Area . . . 63
Interior Sensor Protection . . . . . . . . . . . . . . . . . . . . 63
Reading Lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 64
Intervals, Maintenance . . . . . . . . . . . . . . . . . . . . . . . . 249
Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Intrument Cluster
Fuel Gauge . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 94JJack . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 192
Location . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 193
Jump Starting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 198LLamps
Acceleration Skid Control . . . . . . . . . . . . . . . . . . . 155
Acceleration Skid Control Warning Lamp . 137, 157
Additional Brake Lamp . . . . . . . . . . . . . . . . . . . . . 240
Anti-Lock Brake System (ABS) Indicator Lamp. 152
Battery Charge Indicator Lamp . . . . . . . . . . . . . . . 95
Brake Lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 148Brake System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 155
Coolant Level Indicator Lamp . . . . . . . . . . . . . . . . 98
Electronic Brake Force Distribution . . . . . . . . . . . 148
Engine Control Unit Indicator Lamp . . . . . . . . . . . 99
Engine Oil Level . . . . . . . . . . . . . . . . . . . . . . . . . . . 108
Engine Oil Level Indicator Lamp . . . . . . . . . . . . . . 97
Exit Lamps . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 243
Indicator Lamps . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85
License Plate Lamp . . . . . . . . . . . . . . . . . . . . . . . . . 240
Reading Lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 242
Reserve Fuel Indicator Lamp . . . . . . . . . . . . . . . . . 94
Seat Belt Warning Lamp . . . . . . . . . . . . . . . . . . . . . 38
Side-Marker Lamp . . . . . . . . . . . . . . . . . . . . . . . . . 241
SRS Malfunction Indicator Lamp . . . . . . . . . . . . . . 40
Taillamp . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 238
Water in Fuel Indicator Lamp . . . . . . . . . . . . . . . . . 96
Lifting Points . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 193
Lighter, Cigar . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 76
Lighting, Interior . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63
Loading . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 144Freightliner-all.book Pag e 267 Monday, December 1, 2003 2:54 PM