overheating DODGE SPRINTER 2004 1.G Owners Manual

82 UNDERSTANDING YOUR INSTRUMENT PANEL
Windshield Heater (Optional) . . . . . . . . . . . . . 114Residual Engine Heat Utilization (REST) . . . . 115

Air Conditioning, Regulated (Optional) . . . . . . 115Climate Control (on Vehicles with Air
Conditioning) . . . . . . . . . . . . . . . . . . . . . . . . . . . 116Dehumidification
(on Vehicles with Air Conditioning) . . . . . . . . 117Air Conditioner for the Rear Passenger
Compartment (Optional) . . . . . . . . . . . . . . . . . 118Air Recirculation . . . . . . . . . . . . . . . . . . . . . . . . 119Air Strainer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 120

Electric Blower (Optional) . . . . . . . . . . . . . . . . . . . 121

Heater Booster . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 122

Auxiliary Heater – Water or Air Heater
(Optional) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 123Auxiliary Heater Switch
(Water Heater only) . . . . . . . . . . . . . . . . . . . . . . 124
Timer Auxiliary Heater
(Water and Air Heater) . . . . . . . . . . . . . . . . . . . 125Settings with the Auxiliary Heater
switched on (only with Water Heater) . . . . . . 129

Auxiliary Heat Exchanger in Load
Compartment, only with Auxiliary Water
Heater (Optional) . . . . . . . . . . . . . . . . . . . . . . . . . . 129

Auxiliary Heater – Tips for Coping with
Problems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 130Overheating (Water Heater) . . . . . . . . . . . . . . . 131Overheating (Air Heater) . . . . . . . . . . . . . . . . . 131
Freightliner-all.book Pag e 82 Monday , December 1, 2003 2:54 PM

UNDERSTANDING YOUR INSTRUMENT PANEL 131
4
Overheating (Water Heater) Insufficient coolant, check coolant level.
 The heater will remain switched off after it has been
overheated a number of times (about 10 times in
succession). Have the fault repaired by an
authorized Sprinter Dealer.
Overheating (A ir Heater) The air channels are clogged.
The heater can be restarted once the fault has been
repaired. When this is done, the heater should be
switched on and off.
 The heater will remain switched off after it has been
overheated a number of times (about 3 times in
succession). Have the fault repaired by an
authorized Sprinter Dealer.
NOTE: Repairs should only be made by an authorized
Sprinter Dealer.
Freightliner-all.book Pag e 131 Monday, December 1, 2003 2:54 PM

146 STARTING AND OPERATING Protect sharp edges with padding.
 Check the tire pressures after loading the vehicle.
For passenger vans:
 Do not stack loads higher than the upper edge of the
backrests.
 Always place the load against the backrests of the
seat benches.
 Whenever possible, transport loads behind seats
that are not occupied.
 Distribute the load in such a way that the
permissible axle loads are not exceeded when the
vehicle is equipped with the maximum number of
seats. Loading the luggage compartment up to the
maximum payload would cause the permissible
rear axle load to be exceeded.
BRA KES
Service Brake
WARNING!
When the engine is not running, the brake and
steering systems are without power assistance.
Under these circumstances, a much greater effort
is necessary to stop or steer the vehicle.
After driving in heavy rain for some time without
applying the brakes or through water deep
enough to wet brake components, the first
braking action may be somewhat reduced and
increased pedal pressure may be necessary. Be
sure to maintain a safe distance from vehicles in
front.
Resting your foot on the brake pedal will cause
excessive and premature wear of the brake pads.
It can also result in the brakes overheating,
thereby significantly reducing their effectiveness.
It may not be possible to stop the vehicle in
sufficient time to avoid an accident.
Freightliner-all.book Pag e 146 Monday, December 1, 2003 2:54 PM

158 STARTING AND OPERATINGA cceleration Skid Control (A SR)ASR makes it possible to pull away and accelerate on a
slippery surface. A spinning wheel is braked and its
tractive power is transferred to the wheel with full
grip.
The acceleration skid control (ASR) improves driving
stability at all speeds only on vehicles of the chassis
and cargo/passenger vans type 3500 C/HC/SHC
(without ESP).
The engine’s torque is limited to improve driving
stability. When this is happening, the warning
lampv in the speedometer flashes.
If the road surface is not capable of providing traction,
bearing in mind the tires, load and grade, it may not be
possible to pull away even with ASR.
If wheels with tires of a different size than those offered
by an authorized Sprinter Dealer are used, the correct
operation of the ASR cannot be guaranteed.
WARNING!
ASR cannot prevent the natural laws of physics
from acting on the vehicle, nor can it increase the
traction afforded.
The ASR cannot prevent accidents, including
those resulting from excessive speed in turns,
following another vehicle too closely, or
hydroplaning. Only a safe, attentive, and skillful
driver can prevent accidents.
The capabilities of an ASR equipped vehicle must
never be exploited in a reckless or dangerous
manner which could jeopardize the user’s safety
or the safety of others.
If the ASR function is used for a prolonged period
of time, the rear axle brakes may fail due to
overheating.
If the vehicle is to be towed away with the front
wheels clear of the ground, or if the brakes are to
be tested on a brake dynamometer, do not pull the
key in position 2 in the ignition lock, because the
drive wheels could lock.
Freightliner-all.book Pag e 158 Monday, December 1, 2003 2:54 PM

STARTING AND OPERATING 159
5
Deactivating the A cceleration Skid Control (A SR)See Section 4, Understanding Your Instrument Panel,
for switch locations.
When driving with snow chains, in
deep snow, or on sand or gravel, it
can be beneficial to deactivate the
acceleration skid control (ASR).
The engine
’s torque is then no longer
limited and the drive wheels are free
to spin, which can help them cut into
loose surfaces.
The ASR can only be shut off with the engine running.
If the engine is shut off with the ASR deactivated, the
ASR is automatically re-activated after the engine is
started again.Cargo/passenger vans type 2500 C/HC/SHC only:
If there is a danger of skidding, and/or starting at a
speed of 38 mph (60 km/h) ESP activates ASR
automatically.
WARNING!
On a slippery road surface if both drive wheels
start to spin there is a risk of skidding. Adapt your
speed and driving style to the prevailing road,
traffic and weather conditions.
P54.25-0294-20
WARNING!
Vehicles type 2500 C/HC/SHC only:
Even when ASR is deactivated, ESP remains
active and regulates braking to improve stability
as necessary. The warning lampv flashes in
the speedometer.
The danger of your vehicle’s brake system
overheating and being damaged is increased
during long, demanding application of the
brakes. Furthermore, an overheated brake system
could result in a longer stopping distance.
Thus, only deactivate ASR if it is absolutely
necessary.
Freightliner-all.book Pag e 159 Monday, December 1, 2003 2:54 PM

STARTING AND OPERATING 163
5
STEERINGWhen the engine is not running, there is no power
assistance for the steering. Greater force will be
required to steer the vehicle.WHEELS AND TIRESCheck tires regularly for even tread wear, tread depth
(note legal requirements) and signs of external
damage.
Only use wheels and tires of the same size, make and
pattern.
Do not install tires that are not approved for the size
and type of wheel installed or the vehicle itself. Only
use those wheel sizes which were delivered to you by
your authorized Sprinter Dealer.
Use only wheels and tires which have been tested and
approved by the vehicle manufacturer.
Break in new tires at moderate speeds for a distance of
about 65 miles (about 100 km).
WARNING!
ESP cannot prevent the natural laws of physics
from acting on the vehicle, nor can it increase the
traction afforded.
The ESP cannot prevent accidents, including
those resulting from excessive speed in turns,
following another vehicle too closely, or
hydroplaning. Only a safe, attentive, and skillful
driver can prevent accidents.
The capabilities of an ESP equipped vehicle must
never be exploited in a reckless or dangerous
manner which could jeopardize the user’s safety
or the safety of others.If the vehicle is to be towed away with the front
wheels clear of the ground, or if the brakes are to be
tested on a brake dynamometer, do not put the key
in position 2 in the ignition lock because the ESP
would engage the brakes to stabilize the vehicle.If the ESP function is used for a prolonged period
of time, the rear axle brakes may fail due to
overheating.
Freightliner-all.book Pag e 163 Monday, December 1, 2003 2:54 PM

STARTING AND OPERATING 181
5
WARNING!
Take into consideration that when towing a trail-
er, the handling characteristics are different and
less stable from those when operating the vehicle
without a trailer.
It is important to avoid sudden maneuvers.
Sudden maneuvers may lead to loss of control
over the vehicle-trailer combination. This could
cause an accident resulting in property damage or
injury to you or others.
CAUTION!
If the transmission hunts between gears on
inclines, manually shift to a lower gear (select
"4",
"3", "2" or
"1"). A lower gear and reduction of
speed reduces the chance of engine overloading
and / or overheating.
When going down a long hill, shift into a lower
gear and use the engine’s braking effect. Avoid
riding the brakes, thus overheating the vehicle
and trailer brakes.
If the engine coolant rises to an extremely high
temperature (coolant temperature needle
approaching the red zone) when the air
conditioner is on, turn off the air conditioner.
Engine coolant heat can be additionally vented by
opening the windows, switching the climate
control fan speed to high and setting the
temperature control to the maximum hot position.
Freightliner-all.book Pag e 181 Monday, December 1, 2003 2:54 PM

INDEX 269
10
Overheating (Air Heater) . . . . . . . . . . . . . . . . . . . . . . 131
Overheating (Water Heater) . . . . . . . . . . . . . . . . . . . 131PPassenger Compartment Protection . . . . . . . . . . . . . . 21
Alarm Pushbutton . . . . . . . . . . . . . . . . . . . . . . . . . . 22
Switching off . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
Pedals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46
Permissible Roof Load . . . . . . . . . . . . . . . . . . . . . . . . 177
Programmed Top Speed . . . . . . . . . . . . . . . . . . . . . . . 173RRear Cargo Doors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
Rear Seat Bench . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 58
Removal and Installation . . . . . . . . . . . . . . . . . . . . . 58
Recommended Fluids and Lubricants . . . . . . . . . . . 245
Refueling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 172
Regular Checks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 208
Relay Assignment, Standard Equipment . . . . . . . . . 230
Remote Keyless Entry . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Locking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
Replacing Batteries . . . . . . . . . . . . . . . . . . . . . . . . . . 18
Unlocking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17Removing a Wheel. . . . . . . . . . . . . . . . . . . . . . . . . . . . 195
Replacing Wiper Blades . . . . . . . . . . . . . . . . . . . . . . . 218
Reporting safety Defects . . . . . . . . . . . . . . . . . . . . . . . 259
Reserve Fuel Indicator Lamp . . . . . . . . . . . . . . . . . . . . 94
Residual Engine Heat Utilization . . . . . . . . . . . . . . . 115
Residual Engine Heat Utilization (REST). . . . . . . . . 115
Restraints, Occupant . . . . . . . . . . . . . . . . . . . . . . . . . . . 35
Retrofitting Seat Mounting Cups . . . . . . . . . . . . . . . . 59
Ribbed V-Belt . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 211
Roof Load . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 177
RPMs, Constant . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 137
SSafety Tips . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 47
Seat Belt Warning Lamp and Airbag Malfunction . . 38
Seat Belts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37
Belt Tensioners . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43
Fastening and Removing . . . . . . . . . . . . . . . . . . . . . 38
Height Adjustment . . . . . . . . . . . . . . . . . . . . . . . . . . 40
Seat Heater . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57
Freightliner-all.book Pag e 269 Monday, December 1, 2003 2:54 PM