engine oil DODGE SPRINTER 2006 1.G Owner's Guide

MAINTAINING YOUR VEHICLE 299
7
1. Engine oil also meets API classification CI-4.
Other oils may meet requirements - see oil label to determine.
Raloy Motor Diesel 15W-40 228.3
Repsol Turbo UHPD 10W-40 228.5
Roshfrans Voltro Diesel
115W-40 228.3
Shell Helix Ultra 5W-30 229.3
Shell Helix Ultra 5W-40 229.3
Shell Rimula X CH-4 15W-40 228.3
Shell Rimula X CH-4 20W-50 228.3
Shell Rotella T Multigrade
115W-40 228.3
Super Diesel Oil MB-3 15W-40 228.3
Supreme Duty Diesel Engine Oil Multi-
grade15W-40 228.3
Unoil GX-7 5W-40 229.3
Ursa Premium TDX 10W-30 228.3
Ursa Premium TDX 15W-40 228.3
Valvoline SynPower MXL 0W-30 229.3

300 MAINTAINING YOUR VEHICLE
COMPONENT SERVICE
INTERVALPRODUCT NAME/PRODUCT NUMBER MB
SHEET
Air Conditioning
The air conditioning system of your vehicle contains R-134a, a refrigerant that does not deplete the ozone layer in the
upper atmosphere.
Refrigerant R-134a — Refrigerant R-134a 361.0
Automatic
Transmission Fluidonce only at
80,000 mi
(128,000 km)Shell ATF 3403/M-115
MOPAR® Part No. 05127382AA, or equivalent
Fuchs/Shell ATF 3353236.10
236.12
Brakes
Use brake fluid approved to DaimlerChrysler standard MB 331.0 and/or DaimlerChrysler material standard MS-9971,
brake fluid certified to DOT 4 Plus standards, that also maintains a minimum dry boiling point (ERBP) of 500°F (260°C),
a minimum wet boiling point (WERBP) of 356°F (180°C) and maximum viscosity of 1500 mm
2/s, conforming to FMVSS
116 and ISO 4925.
Brake Fluid 2 years Intac B026D Dry boiling point: 500°F (260°C)
Wet boiling point: 356°F (180°C),
MOPAR® MS-9971 Part No. 04549625AC, or equivalent331.0
Engine Oil 12 months or
10,000 mi
(16,000 km)See "Approved Engine Oils"

MAINTAINING YOUR VEHICLE 301
7
COMPONENT SERVICE
INTERVALPRODUCT NAME/PRODUCT NUMBER MB
SHEET
Engine Coolant,
Anticorrosion/
Antifreeze Fluid15 years or
160,000 mi
(256,000 km)EURO Peak Coolant/Anti-freeze, OLD WORLD INDUSTRIES
Zerex G05, The Valvoline Company
Zerex G48, The Valvoline Company
Glysantin G05, BASF AG
MOPAR® Part No. 05066386AA, or equivalent325.0
Power Steering
Power Steering, no fluid service required
Power Steering fluid — Mobil ATF-D, Exxon Mobil Corporation, or equivalent 236.3
Rear Axle
Gear Oil 120,000 mi
(192,000 km)Shell Spirax MB 90
MOPAR® Part No. 05136033AA, or equivalent235.0

MAINTENANCE SCHEDULES
CONTENTS
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S
Q Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 304
Q Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 304
Q Maintenance - Without ASSYST
Maintenance Computer . . . . . . . . . . . . . . . . . . . . . 305
…Maintenance Intervals . . . . . . . . . . . . . . . . . . . . 305
Q Maintenance - With ASSYST
Maintenance Computer . . . . . . . . . . . . . . . . . . . . . 306
Q Regular Check-Ups. . . . . . . . . . . . . . . . . . . . . . . . . 306
Q Special Maintenance Requirements . . . . . . . . . . . 307
…Brake Fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 307
…Coolant . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 307
…Dust Filter for Heating/Ventilation
Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . 307
Q Engine Oil Change and Filter Replacement . . . . 307
…Once a Year . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 307
Q Scope of Work for Maintenance service . . . . . . . 308
…Oil Service . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 308
…Additional Maintenance Work . . . . . . . . . . . . . 310
…Additional Maintenance Work After ... Years 310

MAINTENANCE SCHEDULES 305
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S
The use of Special lubricant additives is not
recommended. The use of such additives may affect
your warranty rights. With regard to legal stipulations
concerning emissions control, please note that engines
have to be serviced and adjusted in accordance with
special instructions and using special measuring
equipment. Modifications to or interference with the
emissions control systems are not permissible.
All Sprinter Dealer are familiar with the relevant and
appliable regulations.MAINTENANCE - WITHOUT ASSYST
MAINTENANCE COMPUTER
Maintenance Intervals
Additional work must be carried out at yearly
intervals.
As a general rule, to avoid unnecessary visits to the
workshop you should try to have necessary repair
work performed together with other maintenance
work.Oil service and fuel filter
replacement – Refer toNormal Operation
every
10,000 miles or
16,000 km or 12 months
Maintenance serviceevery
30,000 miles or
48,000 km

306 MAINTENANCE SCHEDULESM
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S
8
MAINTENANCE - WITH ASSYST MAINTENANCE
COMPUTER
ASSYST provides you with information on the best
possible timing for maintenance work.
When the next maintenance service is due, this will be
indicated in the multi-function display with the
symbol
9 Oil service and fuel filter replacement
9 Maintenance service - displayed in km/miles
or days.
9
If the display shows the number of days, the symbol
È will also appear in the multi-function display.
You should have the maintenance performed within
the stated period/distance.
The service indicator will be reset by your Sprinter
Dealer after an oil service and/or maintenance service
has been performed.REGULAR CHECK-UPS
To maintain the safe operation of your vehicle, it is
recommended that you perform the following tasks on
a regular basis (i.e., weekly or whenever the vehicle is
refueled). Check:
 Engine oil level
 Brake system, clutch mechanism – fluid level
 Battery – acid level
 Windshield washer system and headlamp cleaning
system – fluid level
 Mechanical assemblies (e. g. ,engine, transmission,
etc.) – check for leaks
 Condition of tires and tire pressures
 All exterior lights

MAINTENANCE SCHEDULES 307
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S
SPECIAL MAINTENANCE REQUIREMENTS
If bodies built by manufacturers other than
DaimlerChrysler Corporation are fitted to the vehicle, the
maintenance requirements and lubrication intervals
specified by the body manufacturer must be adhered to,
in addition to all standard maintenance requirements.
Brake Fluid
Only use brake fluids approved by the manufacturer
(DOT 4 plus). Information about brake fluids is
available from your Sprinter Dealer.
Coolant
Have the corrosion inhibitor/antifreeze concentration
in the coolant checked before the onset of winter (once
a year in countries with high prevailing temperatures).
Have the coolant renewed every fifteen years or
100,000 miles.
Dust Filter for Heating/Ventilation Replacement
The dust filter and the tailgate interior filter are
renewed during routine maintenance service.
However, if operating conditions are dusty, these
filters should be renewed more frequently.ENGINE OIL CHANGE AND FILTER
REPLACEMENT
In a minimum, change the engine oil and oil filter once
a year - even if the vehicle mileage per year is extremly
low. For standard oil service schedules, please see the
chapter oil service and maintenance service.
Once a Year
Select the viscosity of the engine oil (SAE classes)
according to the outside air temperature.
Only use engine oil approved by DaimlerChrysler
Corporation if following the ASSYST system
guidelines.
Information is available from your Sprinter Dealer.
If the fuel used has a sulphur content exceeding 0.05 %
by weight, the service intervals should be split in half.
If the sulphur content of the fuel used is between 0.3%
and 0.8% by weight, the service intervals should be
split in half (i.e. every 5,000 miles instead of every
10,000 miles).

308 MAINTENANCE SCHEDULESM
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S
8
SCOPE OF WORK FOR MAINTENANCE SERVICE
Oil Service
Oil change
Engine:
Oil change and filter replacement
Check fluid levels of the following system, refill as
necessary.
If fluid is lost, trace and eliminate cause – as a separate
order.
Power-assisted steering
Lubrication work:
Trailer tow hitch (original equipment)
Maintenance
ASSYST maintenance computer resetFunction check
Signalling system,
warning and indicator lamps
Headlamps, exterior lighting
Windscreen wipers,
windscreen washer system
Check for leaks and damage.
Check for abrasion points and ensure that
lines are correctly routed!
All assemblies:
Engine, transmission, transfer case, front axle, rear
axle, steering, power steering pump
All lines and hoses, sensor cables
Rubber boots on front axle drive shafts,
rubber boots on front axle suspension ball joints, shock
absorbers

320 INDEX
Climate Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 125
Clock . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 98
Comfortseat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 61
Comfortseat (Optional) . . . . . . . . . . . . . . . . . . . . . . . . . 61
Compartments in Front Doors. . . . . . . . . . . . . . . . . . . 87
Constant RPMs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 146
Consumer Assistance
Be Reasonable with Request . . . . . . . . . . . . . . . . . 312
If You Need Assistance . . . . . . . . . . . . . . . . . . . . . 312
Prepare a List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 312
Prepare for the Appointment . . . . . . . . . . . . . . . . 312
Coolant Level Indicator Lamp . . . . . . . . . . . . . . . . . . 108
Coolant Temperature Gauge . . . . . . . . . . . . . . . . . . . 103
Coolant, Engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 262
Cooling System, Engine . . . . . . . . . . . . . . . . . . . . . . . 261
Corrosion Protection . . . . . . . . . . . . . . . . . . . . . . . . . . 269
Cup Holder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85
DDe-Fogging . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 121
Dehumidification . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 126
De-Icing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 121
Diesel Fuels for Use at Very Low Temperatures . . 211Direction of Rotation . . . . . . . . . . . . . . . . . . . . . . . . . . 182
Displaying Engine Oil Level . . . . . . . . . . . . . . . . . . . 115
Doors
Front Doors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
Rear Cargo Doors . . . . . . . . . . . . . . . . . . . . . . . . . . . 33
Sliding Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
Draining Fuel Filter with Water Separator . . . . . . . 214
Driver’s Airbag. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 47
Driving Safety Systems . . . . . . . . . . . . . . . . . . . . . . . . 163
EElectric Sun Roof . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 81
Electrical Fuses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 276
Fuse and Relay Optional Equipment . . . . . . . . . . 281
Fuse, Relay, and Diode Assignments - Optional
Equipment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 282
Relay Assignment, Standard Equipment . . . . . . 281
Standard Fuse and Relay Equipment. . . . . . . . . . 277
Electrical Outlet . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 84
Electronic Brake Force Distribution . . . . . . . . . . . . . 167
Electronic Brake Force Distribution Lamp . . . . . . . . 160
Electronic Stability Program . . . . . . . . . . . . . . . . . . . 169
Emission Label, Vehicle/Engine . . . . . . . . . . . . . . . . . . 8

INDEX 321
10
Emission Related Component . . . . . . . . . . . . . . . . . . 256
Emissions Control System . . . . . . . . . . . . . . . . . . . . . 228
Engine Break-in Recommendations . . . . . . . . . . . . . . 52
Engine Cleaning. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 272
Engine Control Unit Indicator Lamp . . . . . . . . . . . . 109
Engine Coolant. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 262
Engine Cooling System . . . . . . . . . . . . . . . . . . . . . . . . 261
Engine Oil Consumption . . . . . . . . . . . . . . . . . . . . . . . 53
Engine Oil Level . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 259
Indicator in Instrument Cluster . . . . . . . . . . . . . . 117
Engine Oil Level - Display in Instrument Cluster . 114
Engine Oil Level Indicator Lamp . . . . . . . . . . . . . . . 107
Engine Oils . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 258
Engine oils . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 259
Engine Speed, Maximum . . . . . . . . . . . . . . . . . . . . . . 145
Engine, Stopping . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 147
Exhaust Gas . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 228
Exhaust Gas, Inhalation of . . . . . . . . . . . . . . . . . . 54, 228
FFax Machines . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85
Fire Extinguisher . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 233
Fog Lamp Switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 68Folding Seat at Partition . . . . . . . . . . . . . . . . . . . . . . . . 63
Fording . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 228
Front Seat Passenger Airbag . . . . . . . . . . . . . . . . . . . . 48
Fuel Filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 214
Fuel Filter with Water Separator . . . . . . . . . . . . . . . . 210
Fuel Gauge . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 105
Fuel Tank Capacity . . . . . . . . . . . . . . . . . . . . . . . . . . . 213
Fuels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 209
Bleeding the Diesel Fuel System . . . . . . . . . . . . . . 216
Diesel Fuels for Use at Very Low Temperatures 211
Draining Fuel Filter with Water Separator . . . . . 214
Fuel Filter with Water Separator . . . . . . . . . . . . . 210
Fuel Tank Capacity . . . . . . . . . . . . . . . . . . . . . . . . . 213
Refueling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 212
Fuse and Relay Optional Equipment . . . . . . . . . . . . 281
Fuse, Relay, and Diode Assignments - Optional
Equipment. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 281
Fuses, Electrical . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 276
GGear Selector Lever Position . . . . . . . . . . . . . . . . . . . 150
Glove Compartment . . . . . . . . . . . . . . . . . . . . . . . . . . . 87
Lockable Glove Compartment . . . . . . . . . . . . . . . . 87