snow chains DODGE SPRINTER 2006 1.G Owners Manual

STARTING AND OPERATING 143
5
…Winter tires . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 206
Q Snow Chains . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 207
Q Fuel Requirements . . . . . . . . . . . . . . . . . . . . . . . . . 209
…Fuel Filter with Water Separator . . . . . . . . . . . 210…Diesel Fuels for Use at Very
Low Temperatures . . . . . . . . . . . . . . . . . . . . . . . 211
Q Refueling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 212
…Capacity . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 213
Q Programmed Top Speed (Optional) . . . . . . . . . . 213
Q Bleeding Diesel Fuel System . . . . . . . . . . . . . . . . . 214
Q Draining Fuel Filter with Water Separator . . . . 214
…Bleeding the Diesel Fuel System . . . . . . . . . . . 216
Q Permissible Roof Load . . . . . . . . . . . . . . . . . . . . . . 216
Q Loading the Vehicle . . . . . . . . . . . . . . . . . . . . . . . . 216
…Tire and Loading Information . . . . . . . . . . . . . 217
Q Trailer Towing . . . . . . . . . . . . . . . . . . . . . . . . . . . . 221
…Trailer Hitches (Optional) . . . . . . . . . . . . . . . . . 222
…Electrical Connections (Optional) . . . . . . . . . . 222
…Vehicle and Trailer Weights and Ratings . . . . 222
…Trailer Tongue Load . . . . . . . . . . . . . . . . . . . . . 223
…Loading a Trailer . . . . . . . . . . . . . . . . . . . . . . . . 223…Checking Weights of Vehicle and Trailer . . . . 224
…Attaching a Trailer . . . . . . . . . . . . . . . . . . . . . . . 224…Towing a Trailer . . . . . . . . . . . . . . . . . . . . . . . . . 225
…Parking a Trailer . . . . . . . . . . . . . . . . . . . . . . . . . 227
Q Emissions Control System
(Catalytic Converter) . . . . . . . . . . . . . . . . . . . . . . . 228
Q Inhalation of Exhaust Gas . . . . . . . . . . . . . . . . . . . 228
Q Fording (Wading Capability) . . . . . . . . . . . . . . . . 228
Q Body Builder Guideline . . . . . . . . . . . . . . . . . . . . . 229
…A Special Note Concerning
Vehicle Alteration . . . . . . . . . . . . . . . . . . . . . . . . 230

STARTING AND OPERATING 163
5
Driving Safety Systems
The vehicle can be equipped with the following
Driving Safety Systems:
 Anti-lock brake system (ABS)
 Electronic brake force distribution (EBV)
 Acceleration skid control (ASR)
 Brake assist system (BAS)
1
 Electronic stability program (ESP®)*
NOTE: The maximum effectiveness of ABS, EBV, ASR
and ESP®* is only achieved if you drive with correct
tire pressures and adjust tire pressures to correspond
with the vehicle’s load. In winter operation, the
maximum effectiveness of the ABS and the ESP
®* is
only achieved with winter tires (M+S tires), or snow
chains as required.
*Vehicle type 2500 only
WARNING!
When leaving the vehicle always remove the key
from the ignition lock, and lock your vehicle.
Do not leave children unsupervised in the vehicle,
even if they are secured by a child restraint
system. The children could
 injure themselves on parts of the vehicle
 release the child-proof locks by pressing the
central locking button and could thereby open
the doors and
 cause injury to others as a result
 get out of the vehicle and could either injure
themselves when doing so or they could be
injured by the traffic approaching from the rear
 suffer serious or fatal effects in the event of long
periods of hot weather
 release the parking brake. The vehicle could
then start moving of its own accord.
Unsupervised use of vehicle equipment may cause
severe personal injuries, death and property damage.

STARTING AND OPERATING 171
5
Deactivating the Acceleration Skid Control (ASR)
See Section 4, Understanding Your Instrument Panel,
for switch locations.
When driving with snow chains, in
deep snow, or on sand or gravel, it
can be beneficial to deactivate the
acceleration skid control (ASR).
The engine’s torque is then no longer
limited and the drive wheels are free
to spin, which can help them cut into
loose surfaces.
The ASR can only be shut off with the engine running.
If the engine is shut off with the ASR deactivated, the
ASR is automatically re-activated after the engine is
started again.Vehicle Type 2500 only:
If there is a danger of skidding, and/or starting at a
speed of 38 mph (60 km/h) ESP
® activates ASR
automatically.
WARNING!
On a slippery road surface if both drive wheels
start to spin there is a risk of skidding. Adapt your
speed and driving style to the prevailing road,
traffic and weather conditions.
P54.25-0294-20
WARNING!
Vehicle type 2500 only:
Even when ASR is deactivated, ESP
® remains
active and regulates braking to improve stability
as necessary. The warning lampv flashes in
the speedometer.
The danger of your vehicle’s brake system
overheating and being damaged is increased
during long, demanding application of the
brakes. Furthermore, an overheated brake system
could result in a longer stopping distance.
Thus, only deactivate ASR if it is absolutely
necessary.

STARTING AND OPERATING 207
5
Information placard, refer to "Tires and Wheels". Not
all M+S rated radial-ply tires provide special winter
performance. Make sure the tires you use show M+S
and the mountain/snowflake marking.on the tire
sidewall. These tires meet specific snow traction
performance requirements of the Rubber
Manufacturers Association (RMA) and the Rubber
Association of Canada (RAC) and have been designed
specifically for use in snow conditions. Use of winter
tires is the only way to achieve the maximum
effectiveness of the ABS and ESP
® in winter operation.
For safe handling, make sure all winter tires mounted
are of the same make and have the same tread design.
Always observe the speed rating of the winter tires
installed on your vehicle. If the maximum speed for
which your tires are rated is below the speed rating of
your vehicle, you must place a notice to this effectwhere it will be seen by the driver. Such notices are
available at your tire dealer or any authorized Sprinter
Dealer.
While studded tires improve performance on ice, skid
and traction capability on wet or dry surfaces may be
poorer than that of non-studded tires. Some states
prohibit studded tires; therefore, local laws should be
checked before using these tire types.
SNOW CHAINS
Use "Class U" chains , or other traction aids that meet
SAE Type "U" specifications.
WARNING!
Winter tires with a tread depth under 1/6 in (4 mm)
must be replaced. They are no longer suitable for
winter operation.
WARNING!
If you use your spare tire when winter tires are fit-
ted on the other wheels, be aware that the differ-
ence in tire characteristics may very well impair
turning stability and that overall driving stability
may be reduced. Adapt your driving style accord-
ingly.
Have the spare tire replaced with a winter tire at
the nearest authorized Sprinter Dealer.

208 STARTING AND OPERATING
NOTE: Chains must be the proper size for the vehicle,
as recommended by the chain manufacturer.
Snow chains should only be driven on snow-covered
roads at speeds not to exceed 30 mph (50 km/h).
Remove chains as soon as possible when driving on
roads without snow.
NOTE: When driving with snow chains, you may wish
to deactivate the ASR before setting the vehicle in
motion. This will improve the vehicle’s traction.Please observe the following guidelines when using
snow chains:
 Snow chains should only be used on rear wheels. In
vehicles with dual rear wheels, they should be
mounted on the exterior wheels. Follow the
manufacturer’s mounting instructions.
 Only use snow chains that are approved by the
vehicle manufacturer. For approved snow chains,
please contact your authorized Sprinter Dealer.
 Use of snow chains may be prohibited depending
on location. Always check local and state laws
before installing snow chains.
WARNING!
Use snow chains on rear wheels only.
Some tire sizes do not leave adequate clearance for
snowchains. To help avoid serious damage to
your vehicle or tires, use of snow chains is not
permissible with the spare wheel.

326 INDEX
Rear Seat Bench . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 64
Security System with Towing and Passenger
Compartment Protection . . . . . . . . . . . . . . . . . . . . . . . 23
Audible Alarm . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
Switching off the Alarm . . . . . . . . . . . . . . . . . . . . . . 24
Visual Alarm . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
Service Products . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 255
Disposal of Service Products . . . . . . . . . . . . . . . . . 256
Skid Control, Acceleration . . . . . . . . . . . . . . . . . . . . . 167
Sliding Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
Snow Chains . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 207
Spare Wheel Location . . . . . . . . . . . . . . . . . . . . . . . . . 236
Special Maintenance Requirements . . . . . . . . . . . . . 307
Speed Control. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 77
Sprinter Original Parts . . . . . . . . . . . . . . . . . . . . . . . . 255
SRS Malfunction Indicator Lamp . . . . . . . . . . . . . . . . 49
Standard Fuse and Relay Equipment . . . . . . . . . . . . 277
Starter Switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Starting the Engine . . . . . . . . . . . . . . . . . . . . . . . . . . . 144
Stopping the Engine . . . . . . . . . . . . . . . . . . . . . . . . . . 147
Storing Tires . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 182Suggestions For Obtaining Service For
Your Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 312
Sun Roof
Electrical . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 81
Mechanical Operation . . . . . . . . . . . . . . . . . . . . . . . 81
Sun Roof, Electrical . . . . . . . . . . . . . . . . . . . . . . . . . . . . 81
Switch Locations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 110
Switch,Starter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
TTachometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 101, 103
Telephone . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 84
Tie Down Rings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 54
Tire
Size . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 197
Tire and Loading Information . . . . . . . . . . . . . . . . . . 217
Tire Care and Maintenance . . . . . . . . . . . . . . . . . . . . 180
Tire Grip . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 176
Tire Inspection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 180
Tire Sizes for Sprinter Vehicles . . . . . . . . . . . . . . . . . 193
Tires . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 183
Alignment and Balance . . . . . . . . . . . . . . . . . . . . . 206
Aspect Ratio . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 193

INDEX 327
10
Care and Maintenance . . . . . . . . . . . . . . . . . . . . . . 180
Changing the Tire . . . . . . . . . . . . . . . . . . . . . . . . . . 234
Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 182
Date of Manufacture. . . . . . . . . . . . . . . . . . . . . . . . 197
Design Standard . . . . . . . . . . . . . . . . . . . . . . . . . . . 193
Direction of Rotation . . . . . . . . . . . . . . . . . . . . . . . 182
DOT, Tire Identification Number (TIN) . . . . . . . 196
Hydroplaning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 185
Important Notes on Tire Inflation Pressure . . . . 187
Inspection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 180
Installing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 242
Jack . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 239
Labeling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 191
Life of . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 181
Load . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 192
Load Rating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 193
Maximum Inflation Pressure . . . . . . . . . . . . . . . . 199
Maximum Load. . . . . . . . . . . . . . . . . . . . . . . . . . . . 198
Recommended Tire Inflation Pressure . . . . . . . . 186
Removing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 242
Rim Diameter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 193Rotating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 204
Size Designation . . . . . . . . . . . . . . . . . . . . . . . . . . . 192
Sizes. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 193
Snow Chains . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 207
Spare Wheel Location . . . . . . . . . . . . . . . . . . . . . . . 236
Speed Rating . . . . . . . . . . . . . . . . . . . . . . . . . . 192, 195
Storing. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 182
Tire and Loading Information. . . . . . . . . . . . . . . . 217
Tire and Loading Terminology . . . . . . . . . . . . . . . 200
Tire Code . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 193
Tire Grip . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 185
Tire Ply Material . . . . . . . . . . . . . . . . . . . . . . . . . . . 200
Tire Width . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 193
Tread Depth . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 181
Type Code . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 197
Vehicles type 2500 C/HC/SHC . . . . . . . . . . . . . . 185
Vehicles type 3500 C/HC/SHC . . . . . . . . . . . . . . 185
Winter Tires . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 206
Tires, Wheels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 176
Towing. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 221
Towing a Trailer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 225