Fluid FIAT STILO 2006 1.G Owner's Manual

224
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
Prevent brake fluid, which is
highly corrosive, from coming
into contact with painted
parts. Should it happen, im-
mediately wash with water.
Brake fluid is poisonous and
highly corrosive. In the event
of accidental contact, wash the parts
involved immediately with neutral
soap and water, then rinse thor-
oughly. Call the doctor immediately
if the fluid is swallowed.
WARNING
Symbol πon the container
indicates synthetic brake flu-
id, distinguishing it from the mineral
kind. Using mineral fluids irreversibly
damages the special braking system
rubber seals.
WARNING
BRAKE FLUID fig. 19
Unscrew cap Aand check that the fluid
level in the reservoir is at maximum.
Fluid level in the reservoir shall not exceed
the MAXmark.
If fluid has to be added, it is suggested to
use the brake fluid in table "Fluids and lu-
bricants" (see chapter "Technical charac-
teristics").
NOTE Clean accurately the tank cap A
and the surrounding surface.
fig. 19F0C0098m
At plug opening, pay maximum attention
in order to prevent any impurities from
entering the tank.
For topping up, always use a funnel with
integrated filter with mesh equal to or
lower than 0.12 mm.
IMPORTANT Brake fluid absorbs mois-
ture. For this reason, if the car is mainly
used in areas with a high degree of at-
mospheric humidity, the fluid should be
replaced at more frequent intervals than
specified in the “Service schedule”.

The liquid in the battery is
poisonous and corrosive.
Avoid contact with eyes and skin. Do
not bring naked flames or possible
sources of sparks near the battery:
risk of fire and explosion.
WARNING
Running the battery with
low fluid level can damage
the battery beyond repair and could
also cause its explosion.
WARNING
226
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
BATTERY
The battery is of the “Limited mainte-
nance” type: under normal conditions of
use the electrolyte does not need topping
up with distilled water.
Contact Fiat Dealership to have the bat-
tery checked/replaced.
CHECKING THE CHARGE fig. 20
The battery charge may be checked
through the indicator A(where required)
set on the battery cover and acting ac-
cording to the colour the indicator
shows.Should the battery be not fitted with bat-
tery charge inspection device (optical elec-
trolyte indicator), inspection operations
shall be carried out by skilled personnel
only.
Refer to the table below or to the label
Bon the battery.
fig. 20F0C0506m
Bright white colour
Dark colour
without green area
in the centre
Dark colour
with green area
in the centreTop up electrolyte
Low charge level
Electrolyte level and charge
sufficientContact
Fiat Dealership
Charge the battery
(advisable to contact Fiat
Dealership)
No action

230
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
RUBBER HOSES
As far as the brake system and fuel rubber
hoses are concerned, carefully follow the
“Service schedule” in this section.
Indeed ozone, high temperatures and pro-
longed lack of fluid in the system may
cause hardening and cracking of the hoses,
with possible leaks. Careful control is
therefore necessary.Remember that road holding
depends also on the correct
tyre inflating pressure.
WARNING
If the pressure is too low the
tyre overheats and this can
cause it serious damage.
WARNING
Do not cross switch the
tyres, moving them from the
right of the car to the left and vice
versa.
WARNING
Never submit alloy rims to
repainting treatments re-
quiring to use temperatures exceed-
ing 150°C since the mechanical prop-
erties of the wheels could be im-
paired.
WARNING

232
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
Changing the rear window blade
Proceed as follows:
❒raise the cover A-fig. 24and remove
the arm from the car, slackening the nut
Bthat fastens it to the pivot pin;
❒ fit the new arm, positioning it correct-
ly, and fully tighten the nut;
❒ lower the cover.SPRAY NOZZLES
Windscreen wiper fig. 25
If the jet of fluid is inadequate, firstly check
that there is fluid in the reservoir: see
“Checking fluid levels” in this section).
Then check that the nozzle holes are not
clogged, if necessary use a needle.
The windscreen jets are directed by ad-
justing the angle of the nozzles: turn the
nozzle cylinder by inserting a screwdriv-
er in A.
Fluid jets shall be directed at about 1/3
height from the window upper edge.Rear window wiper fig. 26-27
Rear window washer jets can be adjust-
ed in the same way.
The nozzle holder is on the rear window.
fig. 24F0C0160mfig. 25F0C0163mfig. 26F0C0161m
fig. 27F0C0350m

237
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
IDENTIFICATION DATA ................................................... 238
ENGINE CODES - BODYWORK VERSIONS .............. 240
ENGINE .................................................................................... 241
FUEL FEED/IGNITION ........................................................ 243
TRANSMISSION .................................................................... 243
BRAKES ..................................................................................... 244
SUSPENSIONS......................................................................... 244
STEERING ................................................................................. 244
WHEELS .................................................................................... 245
DIMENSIONS .......................................................................... 250
PERFORMANCE ..................................................................... 253
WEIGHTS ................................................................................. 254
CAPACITIES ........................................................................... 257
FLUIDS AND LUBRICANTS ............................................... 259
FUEL CONSUMPTION ........................................................ 261
CO
2EMISSIONS .................................................................... 263
T T
E E
C C
H H
N N
I I
C C
A A
L L
S S
P P
E E
C C
I I
F F
I I
C C
A A
T T
I I
O O
N N
S S

254
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
1.416V1.616V1.816V
WEIGHTS
Weights (kg)(Saloon versions)
Weight empty
(including fluids, 90% fuel
in the tank and no optional)
Payload (*) including the driver:
Maximum admitted loads (**)
– front axle:
– rear axle:
– total:
Towable loads
– trailer with brakes:
– trailer without brakes:
Maximum load on roof (***):
Maximum load on tow hitch
(trailer with brakes):
(*) If special equipment is fitted (sunroof, tow hitch, etc.) the unladen car weight increases thus reducing the specified payload.
(**) Loads not to be exceeded. The driver is responsible for arranging the loads in the boot an/or on the roof so that they com-
ply with these limits.
(***) Lineaccessori Fiat roof rack, max capacity: 50 kg.
(
❍) “DYNAMIC” versions.
(
❒) For specific markets.3-door
1090
1135 (
❍)
510
900
830
1600
1645 (
❍)
1000/500 (
❒)
500
80
605-door
1145
1190 (
❍)
510
900
860
1655
1700 (
❍)
1000/500 (
❒)
500
80
603-door
1150
1195 (
❍)
510
950
830
1660
1705 (
❍)
1100/500 (
❒)
500
80
605-door
1205
1250 (
❍)
510
950
860
1715
1760 (
❍)
1100/500 (
❒)
500
80
603-door
1240
510
990
830
1750
1200/500 (❒)
500
80
605-door
1295
510
990
860
1805
1200/500 (❒)
500
80
60

255
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
2.420V1.9 Multijet 8V1.9 Multijet 16VWeights (kg)(Saloon versions)
Weight empty
(including fluids, 90% fuel
in the tank and no optional)
Payload (*) including the driver:
Maximum admitted loads (**)
– front axle:
– rear axle:
– total:
Towable loads
– trailer with brakes:
– trailer without brakes:
Maximum load on roof (***):
Maximum load on tow hitch
(trailer with brakes):
(*) If special equipment is fitted (sunroof, tow hitch, etc.) the unladen car weight increases thus reducing the specified payload.
(**) Loads not to be exceeded. The driver is responsible for arranging the loads in the boot an/or on the roof so that they com-
ply with these limits.
(***) Lineaccessori Fiat roof rack, max capacity: 50 kg.
(
❒) For specific markets.3-door
1265
510
1030
830
1775
1300/500 (
❒)
500
80
603-door
1320
510
1030
830
1830
1300/500 (❒)
500
80
603-door
1265
510
1020
830
1775
1300/500 (❒)
500
80
603-door
1320
510
1020
860
1830
1300/500 (❒)
500
80
603-door
1285
510
1030
830
1795
1300/500 (❒)
500
80
603-door
1340
510
1030
860
1850
1300/500 (❒)
500
80
60

256
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
1.416V
1235
510
950
960
1745
1000/500 (
❒)
500
80
601.6
16V
1295
510
950
960
1805 (
❍)
1100/500 (
❒)
500
80
601.8
16V
1385
510
990
960
1895
1200/500 (
❒)
500
80
601.9 Multijet
8V
1410
510
1020
960
1920
1300/500 (
❒)
500
80
601.9 Multijet
16V
1430
510
1030
960
1940
1300/500 (
❒)
500
80
60
Weights (kg)(Multi Wagon versions)
Weight empty
(including fluids, 90% fuel
in the tank and no optional)
Payload (*) including the driver:
Maximum admitted loads (**)
– front axle:
– rear axle:
– total:
Towable loads
– trailer with brakes:
– trailer without brakes:
Maximum load on roof (***):
Maximum load on tow hitch
(trailer with brakes):
(*) If special equipment is fitted (sunroof, tow hitch, etc.) the unladen car weight increases thus reducing the specified payload.
(**) Loads not to be exceeded. The driver is responsible for arranging the loads in the boot an/or on the roof so that they com-
ply with these limits.
(***) Lineaccessori Fiat roof rack, max capacity: 50 kg.
(
❍) “ACTUAL” versions
(
❒) For specific markets.

CAPACITIES
257
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
1.416V1.616V1.816V2.420V
Fuel tank:
including a reserve of:
Engine cooling
system
– with climate control:
Engine sump:
Engine sump and filter:
Gearbox/differential casing:
Selespeed transmission
hydraulic system
(where provided):
Hydraulic brake circuit
with ABS:
Windscreen /
rear window / headlight
washer fluid reservoir: (*)
(*) The values in brackets refer to versions with headlight washers.Recommended products and
genuine lubricants
Unleaded petrol
with no less than 95 R.O.N
(Specification EN228)
Mixture of 50% demineralised
water and 50%
PARAFLU UP
SELENIA K
(versions 1.4
16V, 1.616Vand 1.816V)
SELENIA RACING
(versions 2.4
20V)
TUTELA CAR TECHNYX
TUTELA CAR
CS SPEED
TUTELA TOP 4
Mixture of water and
TUTELA PROFESSIONAL
SC 35 litres
58
9
–
2.5
2.8
1.87
–
–
3 (6)kg
–
–
5.25
2.2
2.5
1.7
–
0.525
–litres
58
9
–
4.3
4.5
1.65
–
–
3 (6)kg
–
–
6.55
3.9
4.0
1.5
–
0.525
–litres
58
9
–
3.7
4.2
1.98
–
–
3 (6)kg
–
–
7.3
3.3
3.7
1.8
–
0.525
–litres
58
9
–
4.5
4.7
1.76
0.8
–
3 (6)kg
–
–
8.3
3.9
4.0
1.6
0.73
0.525
–

258
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
1.9 Multijet 8V1.9 Multijet 16V
Fuel tank:including a reserve of:
Engine cooling system
– with climate control:
Engine sump:
Engine sump and filter:
Gearbox/differential casing:
Hydraulic brake circuit
with ABS:
Windscreen /
rear window / headlight
washer fluid reservoir: (*)
(*) The values in brackets refer to versions with headlight washers.litres
58
9
–
4.4
4.7
1.76
–
3 (6)kg
–
–
7.3
3.8
4.0
1.6
0.525
–litres
58
9
–
4.4
4.7
1.87
–
3 (6)kg
–
–
7.3
3.8
4.0
1.7
0.525
–Recommended products and
genuine lubricants
Diesel fuel formotor vehicles
(Specification EN590)
Mixture of 50% demineralised
water and 50% PARAFLU UP
SELENIA WR
TUTELA CAR TECHNYX
TUTELA TOP 4
Mixture of water and
TUTELA PROFESSIONAL
SC 35