FORD AEROSTAR 1996 1.G Owners Manual

333
driving to complete the checkº of the OBD II
system. As soon as all of the OBD II system
checks are successfully completed, the OBD II
system is set to the ready condition. The amount
of driving required to reach the ready condition
varies with individual driving patterns. To
complete this requirement in the minimum
amount of time, refer to the OBD II Drive Cycle
defined below. If the vehicle owner cannot or
does not want to do the additional driving
required by law, a service center can perform
this drive cycle as it would any other type of
repair work.
*
[SV50030(ALL)07/95]
OBD II Drive Cycle
*
[SV50040(ALL)06/95]
The following steps must be run in the order
shown. If any steps are interrupted, repeat the
preceding step. Any safe driving mode is
acceptable between steps.
*
[SV50050(ALL)06/95]
Always drive vehicle in safe manner according
to traffic conditions and obey all traffic laws.
[SV50055(ALL)08/95]
NOTE: When instructions read ªin drive,º use
the standard Overdrive gear. It is not
necessary to turn Overdrive off with
the OVERDRIVE OFF button. For more
information on Overdrive, refer to the
Automatic Overdrive Transmission
section of theDriving Your Aerostar
chapter.
*
[SV50060(ALL)07/95]
The engine must be warmed up and at
operating temperature before proceeding with
the drive modes of the following OBD II Drive
Cycle.
*
[SV50070(ALL)06/95]
1. Start the engine. Drive or idle (in neutral)
the vehicle for 4 minutes.
*
[SV50080(ALL)06/95]
2. Idle the vehicle in drive for 40 seconds.
*
[SV50090(ALL)07/95]
3. Accelerate the vehicle to 45 mph (70 km/h)
at 1/4 to 1/2 throttle for 10 seconds.
File:15cpsva.ex
Update:Tue Aug 29 17:51:51 1995

334
*
[SV50100(ALL)07/95]
4. Drive the vehicle with a steady throttle at
45 mph (70 km/h) for 30 seconds.
*
[SV50110(ALL)06/95]
5. Idle the vehicle in drive for 40 seconds.
*
[SV50120(ALL)07/95]
6. Continue to drive the vehicle in city traffic at
speeds between 25 and 40 mph
(40-60 km/h) for 15 minutes. During the 15
minute drive cycle the following modes must
be achieved:
*
[SV50130(ALL)07/95]
a. at least 5 stop and idle modes at 10
seconds each
*
[SV50140(ALL)07/95]
b. acceleration from idles at 1/4 to 1/2
throttle position, and
*
[SV50150(ALL)07/95]
c. choose 3 different speeds to do 1.5
minute steady state throttle drives.
*
[SV50160(ALL)07/95]
7. Accelerate the vehicle up to between 45 and
60 mph (70-100 km/h). This should take
approximately 5 minutes.
*
[SV50170(ALL)07/95]
8. Drive vehicle and hold the throttle steady at
the selected speed between 45 and 60 mph
(70-100 km/h) for approximately 5 minutes.
*
[SV50180(ALL)07/95]
9. Drive the vehicle for 5 minutes at varying
speeds between 45 and 60 mph
(70-100 km/h).
*
[SV50190(ALL)07/95]
10. Bring the vehicle back to idle. Idle in Drive
for 40 seconds.
*
[SV50200(ALL)07/95]
11. OBD II drive cycle has been completed.
Vehicle can be turned off when convenient.
File:15cpsva.ex
Update:Tue Aug 29 17:51:51 1995

335
*
[SV51500(ALL)07/95]
Refill Capacities, Motorcraft Parts,
and Lubricant Specifications
%*
[SV51600(ALL)07/95]
Refill Capacities
[SV51700(ALL)08/95]
26 pica chart:0095044-BFile:15cpsva.ex
Update:Tue Aug 29 17:51:51 1995

336 [SV51750(ALL)08/95]
twenty pica chart:0095001-B
File:15cpsva.ex
Update:Tue Aug 29 17:51:51 1995

337 %
*
[SV52800(ALL)05/95]
Motorcraft Parts
[SV52900(ALL)08/95]
eighteen pica chart:0095002-AFile:15cpsva.ex
Update:Tue Aug 29 17:51:51 1995

338 %
*
[SV53500(ALL)05/95]
Lubricant Specifications
[SV53600(ALL)08/95]
thirty-six pica chart:0095043-BFile:15cpsva.ex
Update:Tue Aug 29 17:51:51 1995

339 [SV53650(ALL)08/95]
twelve pica chart:0095058-A
File:15cpsva.ex
Update:Tue Aug 29 17:51:51 1995

340 [SV53700(ALL)08/95]
thirty-six pica chart:0095003-B
File:15cpsva.ex
Update:Tue Aug 29 17:51:51 1995

341 [SV53800(ALL)08/95]
26 pica chart:0095025-A
File:15cpsva.ex
Update:Tue Aug 29 17:51:51 1995

342 [SV53850(ALL)08/95]
eighteen pica chart:0095074-A
%*
[SV56000(ALL)01/95]
Vehicle Storage
*
[SV56100(ALL)01/95]
Maintenance Tips
*
[SV56150(ALL)01/95]
If you plan on storing your vehicle for an
extended period of time (60 days or more), refer
to the following maintenance recommendations
to ensure your vehicle stays in good operating
condition.
*
[SV56200(ALL)01/95]
General
*
[SV56300(ALL)01/95]
q
Store all vehicles in a dry, ventilated place.
*
[SV56400(ALL)01/95]
q
Protect from sunlight, if possible.
*
[SV56500(ALL)01/95]
q
If vehicles are stored outside, they require
regular maintenance to protect against rust
and damage.
File:15cpsva.ex
Update:Tue Aug 29 17:51:51 1995