coolant capacity FORD CROWN VICTORIA 2000 2.G Owners Manual

To avoid scalding hot steam or coolant from being released from
the engine cooling system, never remove the radiator cap while
the engine is running or hot. Failure to follow this warning may result
in damage to the engine’s cooling system and possible severe personal
injury.
If you must remove the radiator cap, follow these steps to avoid personal
injury:
1. Before you remove the cap, turn the engine off and let it cool.
2. When the engine is cool, wrap a thick cloth around the cap. Slowly
turn cap counterclockwise until pressure begins to release.
3. Step back while the pressure releases.
4. When you are sure that all the pressure has been released, use the
cloth to turn it counterclockwise and remove the cap.
Recycled engine coolant
Ford Motor Company recommends the use of a recycled engine coolant
produced by Ford-approved processes.
Not all coolant recycling processes produce coolant which meets Ford
specification ESE-M97B44-A. Use of a recycled engine coolant which
does not meet the Ford specification may harm engine and cooling
system components.
Always dispose of used automotive fluids in a responsible manner.
Follow your community’s regulations and standards for recycling and
disposing of automotive fluids.
Coolant refill capacity
To find out how much fluid your vehicle’s cooling system can hold, refer
toRefill capacitiesin theCapacities and specificationschapter.
Fill your engine coolant reservoir as outlined inAdding engine coolant
in this chapter.
Severe climates
If you drive in extremely cold climates (less than –36° C [–34° F]):
•it may be necessary to increase the coolant concentration
above 50%.
Maintenance and care
164

MOTORCRAFT PART NUMBERS
Component 4.6L SOHC V8 engine
Air filter element FA-1668
Fuel filter FG-986B
Battery-standard BXT-65–650
Battery-heavy duty BXT-65–750
Oil filter FL-820-S
PCV valve EV-98
Spark plugs* AWSF-32P
* Refer to Vehicle Emissions Control Information (VECI) decal for spark
plug gap information.
REFILL CAPACITIES
Fluid Ford Part Name Capacity
Engine oil (includes
filter change)Motorcraft SAE 5W-30
Super Premium Motor
Oil4.7L (5.0 quarts)
Brake fluid
1Fill to line on reservoir
Power steering fluid Motorcraft MERCON
AT FFill to line on reservoir
Transmission fluid
2Motorcraft
MERCONVATF13.1L (13.9 quarts)3
Engine coolant4Premium Engine
Coolant15.0L (15.8 quarts)
Fuel tank N/A 71.9L (19.0 gallons)
Rear axle lubricant
5Motorcraft SAE
80W-90 Premium Rear
Axle Lubricant1.8L (3.75 pints)
Windshield washer
fluidUltra-Clear Windshield
Washer ConcentrateFill to line on reservoir
1Use only brake fluids certified to meet Ford specifications. Refer to
Lubricant Specificationsin this chapter. DOT 3 fluid is recommended.
However, if DOT 3 is not available, DOT 4 fluid can be used.
Capacities and specifications
201

2Ensure the correct automatic transmission fluid is used. MERCONand
MERCONV are not interchangeable. DO NOT MIX MERCONand
MERCONV. Refer to the Scheduled Maintenance Guide to determine
the correct service interval.
3Indicates only approximate dry-fill capacity. Some applications may
vary based on cooler size and if equipped with an in-tank cooler. The
amount of transmission fluid and fluid level should be set by the
indication on the dipstick’s normal operating range. Police Package refill
capacity-12.1L (12.8 quarts).
4Use Ford Premium Engine Coolant (green in color). DO NOT USE Ford
Extended Life Engine Coolant (orange in color). Refer toAdding engine
coolant, in the Maintenance and Care chapter.
5Rear axles are considered lubricated for life when the vehicle is used
for normal service. See your Scheduled Maintenance Guide for Severe
Duty requirements.
Traction-Lok axles use 1.6-1.8L (3.50-3.75 pints) of rear axle lubricant.
Add 118 ml (4 oz.) of Additive Friction Modifier C8AZ-19B546-A or
equivalent meeting Ford specification EST-M2C118–A for complete refill
of Traction-Lok rear axle.
Service refill capacities are determined by filling the rear axle 6 mm to
14 mm (1/4 inch to 9/16 inch) below the bottom of the filler hole.
LUBRICANT SPECIFICATIONS
Item Ford part
nameFord part
numberFord
specification
Brake fluid High
Performance
DOT 3 Motor
Vehicle Brake
Fluid
1
C6AZ-19542-AB ESA-M6C25-A
and DOT 3
Door
weatherstripsSilicone
LubricantF7AZ-19G208-BA
and
F5AZ-19553-AAESR-M13P4-A
Engine coolant Ford Premium
Engine CoolantE2FZ-19549-AA
(in Canada,
Motorcraft
CXC-8-B)ESE-M97B44-A
Capacities and specifications
202

set zone adjustment .................75
Controls
power seat ............................94,95
Coolant
checking and adding ..............161
coolant temperature light ........10
refill capacities .................164,201
specifications ...................202,204
Cruise control
(see Speed control) ....................66
Customer Assistance ................137
Ford accessories for your
vehicle .....................................214
Ford Extended
Service Plan ............................207
Getting assistance outside the
U.S. and Canada .....................213
Getting roadside assistance ...137
Getting the
service you need ....................207
Ordering additional
owner’s literature ...................217
The Dispute
Settlement Board ...................210
Utilizing the Mediation/
Arbitration Program ...............213
Daytime running lamps
(see Lamps) ................................24
Defrost
rear window ..............................25
Dipstick
automatic
transmission fluid ...................168
engine oil .................................157
Doors
lubricant specifications ..........202
Driving under special
conditions
through water .........................136
Emergencies, roadside
jump-starting ..........................148
Emission control system ..........187Engine ........................................204
check engine/
service engine soon light ...........9
cleaning ...................................197
coolant .....................................161
fail-safe coolant ......................165
idle speed control ...................171
lubrication
specifications ...................202,204
refill capacities ........................201
service points ..........................156
starting after a collision .........138
Engine block heater .................120
Engine oil ..................................157
change oil soon warning,
message center .......................157
checking and adding ..............157
dipstick ....................................157
filter, specifications .........159,201
recommendations ...................159
refill capacities ........................201
specifications ...................202,204
Exhaust fumes ..........................121
Fail safe cooling ........................165
Floor mats ...................................79
Fluid capacities .........................201
Fuel ............................................179
calculating fuel economy .......184
cap ...........................................181
capacity ...................................201
choosing the right fuel ...........182
comparisons with EPA fuel
economy estimates .................187
detergent in fuel .....................183
filling your vehicle
with fuel ....................179,181,184
filter, specifications .........184,201
fuel pump shut-off switch .....138
gauge .........................................15
improving fuel economy ........184
low fuel warning light ................8
octane rating ....................183,204
Index
220

anti-lock brakes (ABS) .....11,123
brake ..........................................11
charging system ........................12
check engine ...............................9
high beam .................................11
low coolant ................................10
low fuel ........................................8
oil pressure ...............................12
overdrive off ..............................13
safety belt .................................10
speed control ............................70
traction control active ..............13
turn signal indicator .................11
Load limits .................................131
GAWR ......................................131
GVWR ......................................131
trailer towing ..........................131
Locks
autolock .....................................81
childproof ..................................79
doors ..........................................78
Lubricant specifications ....202,204
Lug nuts, anti-theft ...................147
Lumbar support, seats ...............96
Message center ...........................20
reset button ..............................20
select button .............................21
Mirrors
automatic dimming
rearview mirror .........................74
cleaning ...................................196
side view mirrors (power) .......78
Motorcraft parts .................184,201
Octane rating ............................183
Odometer .....................................17
Oil (see Engine oil) ..................157
Overdrive ..............................66,129
Panic alarm feature, remote
entry system ................................83
Parking brake ............................123
Parts (see Motorcraft parts) ....201Power distribution box
(see Fuses) ...............................142
Power door locks ...................78,81
Power steering ..........................126
fluid, checking and adding ....168
fluid, refill capacity ................201
fluid, specifications ..........202,204
Radio ............................................35
Relays .................................139,144
Remote entry system ............80,83
illuminated entry ......................83
locking/unlocking doors ...........80
opening the trunk .....................83
panic alarm ...............................83
replacement/additional
transmitters ...............................85
replacing the batteries .............84
Safety belts (see Safety
restraints) .........14,96,97,98,99,100
Safety defects, reporting ..........218
Safety restraints ....96,97,98,99,100
belt minder .............................102
cleaning the
safety belts .......................105,199
extension assembly ................101
for adults .........................97,98,99
for children ......................110,111
lap belt ....................................100
warning light
and chime ...............10,14,101,102
Safety seats for children ..........112
Seat belts
(see Safety restraints) ...............96
Seats ............................................92
child safety seats ....................112
cleaning ............................199,200
SecuriLock passive
anti-theft system ....................85,86
Servicing your vehicle ..............154
Spark plugs,
specifications ......................201,204
Special notice ................................3
Index
222

Required fuel Unleaded fuel only - 87 octane
Fuel tank capacity 71.9L (19.0 gallons)
Engine oil capacity (includes filter
change)4.7L (5.0 quarts). Use Motorcraft
SAE 5W-30 Super Premium Motor
Oil, Ford specification
WSS-M2C153-G.
Tire pressure and size Refer to the Tire Pressure Label
located on the rear passenger door
jamb.
Hood release Pull handle under the left side of
the instrument panel.
Coolant capacity
115.0L (15.8 quarts)
Automatic transmission fluid
capacity
213.1L (13.9 quarts). Use
Motorcraft MERCONV ATF.3
Power steering fluid capacity Fill to line on reservoir. Use
Motorcraft MERCONAT F.
1Use Ford Premium Engine Coolant (green in color). DO NOT USE Ford
Extended Life Engine Coolant (orange in color). Refer toAdding engine
coolant, in the Maintenance and Care chapter.
2Ensure the correct automatic transmission fluid is used. Transmission
fluid requirements are indicated on the dipstick or on the dipstick
handle. MERCONand MERCONV are not interchangeable. DO NOT
mix MERCONand MERCONV. Refer to your Scheduled Maintenance
Guide to determine the correct service interval.
3Indicates only approximate dry-fill capacity. Some applications may
vary based on cooler size and if equipped with in-tank cooler. The
amount of transmission fluid and fluid level should be set by the
indication on the dipstick’s normal operating range. Police Package refill
capacity-12.1L (12.8 quarts).
Filling station information
224