warning FORD E SERIES 2007 4.G Owner's Guide

4. Turn the engine off.
For E-450 and E-550 vehicles with the Hydro-Boost Brake
System, do not press the brake pedal after the engine has been
turned off. Pressing the brake pedal after the engine has been turned
off will give a false power steering fluid level reading.
5. Recheck the fluid level on the dipstick. Do not add fluid if the level is
between the arrows in the FULL COLD range.
6. If the fluid is low, add fluid in small amounts, continuously checking
the level until it reaches the FULL COLD range. Be sure to put the
dipstick back in the reservoir.
BRAKE FLUID
The fluid level will drop slowly as
the brakes wear, and will rise when
the brake components are replaced.
Fluid levels below the “MAX” line
that do not trigger the brake system
warning lamp are within the normal
operating range, there is no need to
add fluid. If the fluid levels are outside of the normal operating range,
the performance of your brake system could be compromised, seek
service from your authorized dealer immediately.
DRIVELINE UNIVERSAL JOINT AND SLIP YOKE
Your vehicle may be equipped with universal joints that require
lubrication. Refer to thescheduled maintenance informationfor
maintenance intervals. If the original universal joints are replaced with
universal joints equipped with grease fittings, lubrication will also be
necessary.
TRANSMISSION FLUID
Checking automatic transmission fluid (if equipped)
Refer to yourscheduled maintenance informationfor scheduled
intervals for fluid checks and changes. Your transmission does not
consume fluid. However, the fluid level should be checked if the
transmission is not working properly, i.e., if the transmission slips or
shifts slowly or if you notice some sign of fluid leakage.
Automatic transmission fluid expands when warmed. To obtain an
accurate fluid check, drive the vehicle until it is at normal operating
MAX
2007 Econoline(eco)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
234

A
Accessory delay ..........................49
AdvanceTrac ..............................145
Air cleaner filter ...............237–239
Airbag supplemental restraint
system ....................................76–77
and child safety seats ..............78
description ................................77
disposal ......................................80
driver airbag ..............................79
indicator light ...........................80
operation ...................................79
passenger airbag .......................79
passenger deactivation
switch ........................................81
Ambulance packages ....................8
Antifreeze
(see Engine coolant) ................216
Anti-lock brake system
(see Brakes) ..............................144
Audio system
(see Radio) ......................19, 21, 25
Automatic transmission
driving an automatic
overdrive .................152, 155, 157
fluid, adding ............................234
fluid, checking ........................234
fluid, refill capacities ..............241
fluid, specification ..................241
Auxiliary power point .................48
Axle
lubricant specifications ..........241
refill capacities ........................241
traction lok ..............................149
B
Battery .......................................214acid, treating emergencies .....214
battery saver .............................34
jumping a disabled battery ....185
maintenance-free ....................214
replacement, specifications ...239
servicing ..................................214
BeltMinder
.................................72
Brakes ........................................143
anti-lock ...................................144
anti-lock brake system (ABS)
warning light ...........................144
fluid, checking and adding ....234
fluid, refill capacities ..............241
fluid, specifications .................241
lubricant specifications ..........241
parking ....................................145
shift interlock ..........................151
Break-in period .............................5
Bulbs ............................................39
C
Capacities for refilling fluids ....241
Cell phone use ..............................9
Child safety restraints ................86
child safety belts ......................86
Child safety seats ........................90
in front seat ..............................91
in rear seat ................................91
tether anchorage hardware .....94
Cleaning your vehicle
engine compartment ..............202
exterior ....................................205
instrument panel ....................203
interior .....................................204
interior trim ............................204
plastic parts ............................202
safety belts ..............................204
washing ....................................200
waxing .....................................201
2007 Econoline(eco)
Owners Guide (post-2002-fmt)
USA(fus)
Index
253

wheels ......................................201
wiper blades ............................203
Climate control (see Air
conditioning or Heating) ......31–33
Clock adjust
6-CD in dash .......................22, 27
AM/FM .......................................20
Compass, electronic ....................47
calibration .................................48
set zone adjustment .................47
Console
overhead ..............................45–46
Controls
power seat .................................61
Coolant
checking and adding ..............216
refill capacities ................220, 241
specifications ..........................241
Cruise control
(see Speed control) ....................51
Customer Assistance ................163
Ford Extended Service
Plan ..........................................196
Getting assistance outside
the U.S. and Canada ..............197
Getting roadside assistance ...163
Getting the service
you need .................................192
Ordering additional owner’s
literature .................................198
Utilizing the
Mediation/Arbitration
Program ...................................196
D
Daytime running lamps
(see Lamps) ................................35Dipstick
automatic transmission
fluid ..........................................234
engine oil .................................211
Driveline universal joint and
slip yoke ....................................234
Driving under special
conditions
through water .........................162
E
Emergencies, roadside
jump-starting ..........................185
Emergency Flashers .................165
Emission control system ..........230
Engine ........................................247
cleaning ...................................202
coolant .....................................216
diesel ...........................................7
fail-safe cooling .......................221
idle speed control ...................214
lubrication specifications .......241
refill capacities ........................241
service points ..........................209
starting after a collision .........165
Engine block heater .................143
Engine oil ..................................211
change oil soon warning,
message center .......................211
checking and adding ..............211
dipstick ....................................211
filter, specifications ........213, 239
recommendations ...................213
refill capacities ........................241
specifications ..........................241
Exhaust fumes ..........................143
F
Fail safe cooling ........................221
2007 Econoline(eco)
Owners Guide (post-2002-fmt)
USA(fus)
Index
254

headlamps, flash to pass ..........35
instrument panel, dimming .....36
interior lamps ...........................38
replacing bulbs .........................40
Lane change indicator
(see Turn signal) ........................38
Lights, warning and indicator ....12
anti-lock brakes (ABS) ..........144
Load limits .................................122
Loading instructions .................128
Locks ............................................54
autolock .....................................54
doors ..........................................54
Lubricant specifications ...........241
Lug nuts ....................................184
Lumbar support, seats ...............61
M
Mirrors
fold away ...................................50
side view mirrors (power) .......50
Motorcraft parts ........205, 222, 239
O
Octane rating ............................226
Oil (see Engine oil) ..................211
P
Parking brake ............................145
Parts (see Motorcraft parts) ....239
Power distribution box
(see Fuses) ...............................171
Power door locks ........................54
Power mirrors .............................50Power point .................................48
Power steering ..........................148
fluid, checking and adding ....233
fluid, refill capacity ................241
fluid, specifications .................241
Power Windows ...........................49
Preparing to drive
your vehicle ...............................149
R
Radio ................................19, 21, 25
Relays ................................167, 174
Remote entry system .................56
illuminated entry ......................59
locking/unlocking doors ...........57
panic alarm ...............................57
replacement/additional
transmitters ...............................58
replacing the batteries .............58
Reverse sensing system ...........160
Roadside assistance ..................163
S
Safety Belt Maintenance ............76
Safety belts (see Safety
restraints) ........................66, 68–70
Safety defects, reporting ..198–199
Safety restraints ..............66, 68–70
BeltMinder
..............................72
extension assembly ..................75
for adults .............................68–69
for children .........................85–86
lap belt ......................................71
safety belt maintenance ...........76
warning light and chime ....71–72
Safety seats for children ............90
2007 Econoline(eco)
Owners Guide (post-2002-fmt)
USA(fus)
Index
256

Seat belts
(see Safety restraints) ...............66
Seats ............................................60
child safety seats ......................90
front seats .................................60
Servicing your vehicle ..............207
Setting the clock
AM/FM stereo ...........................20
AM/FM/In-dash 6 CD ..........22, 27
Spare tire
(see Changing the Tire) ...........178
Spark plugs,
specifications .....................239, 247
Special notice ................................8
ambulance conversions ..............8
diesel-powered vehicles .............7
utility-type vehicles ....................7
Specification chart,
lubricants ...................................241
Speed control ..............................51
Starting your vehicle ........140–142
jump starting ..........................185
Steering wheel
tilting .........................................45
T
Temperature control
(see Climate control) ...........31, 33
Tilt steering wheel ......................45
Tires ...................................104–105
alignment ................................114
care ..........................................110
changing ..........................178–179
checking the pressure ............109
inflating ...................................106
label .........................................121
replacing ..........................112, 181
rotating ....................................114safety practices .......................113
sidewall information ...............116
snow tires and chains ............122
spare tire .........................176, 178
terminology .............................105
tire grades ...............................105
treadwear ........................104, 111
Towing .......................................128
recreational towing .................139
trailer towing ..........................128
wrecker ....................................191
Traction-lok rear axle ...............149
Transmission .............................151
brake-shift interlock (BSI) ....151
fluid, checking and adding
(automatic) .............................234
fluid, refill capacities ..............241
lubricant specifications ..........241
Turn signal ..................................38
V
Vehicle Identification Number
(VIN) ..........................................248
Vehicle loading ..........................122
Ventilating your vehicle ...........143
W
Warning lights (see Lights) .......12
Washer fluid ..............................210
Water, Driving through .............162
Windows
power .........................................49
Windshield washer fluid and
wipers ..........................................44
checking and adding fluid .....210
replacing wiper blades ...........210
Wrecker towing .........................191
2007 Econoline(eco)
Owners Guide (post-2002-fmt)
USA(fus)
Index
257