sensor FORD F-450 2020 Repair Manual

•
To reduce the chances of interference
from another vehicle, perform the
system reset procedure at least 3 ft
(1 m) away from another Ford Motor
Company vehicle undergoing the
system reset procedure at the same
time.
• Do not wait more than two minutes
between resetting each tire sensor or
the system can time-out and you have
to repeat the entire procedure on all
four wheels.
• A double horn sounds indicating the
need to repeat the procedure.
Performing the System Reset Procedure
- Single Rear Wheel
Read the entire procedure before
attempting.
1. Drive the vehicle above
20 mph
(32 km/h) for at least two minutes,
then park in a safe location where you
can easily get to all four tires and have
access to an air pump.
2. Place the ignition in the off position and
keep the key in the ignition.
3. Cycle the ignition to the on position with the engine off.
4. Turn the hazard flashers on then off three times. You must accomplish this
within 10 seconds. If you successfully
enter the reset mode, the horn sounds
once, the system indicator flashes and
a message shows in the information
display. If this does not occur, please
try again starting at step 2. If after
repeated attempts to enter the reset
mode, the horn does not sound, the
system indicator does not flash and no
message shows in the information
display, seek service from your
authorized dealer. 5. Train the tire pressure monitoring
system sensors in the tires using the
following system reset sequence
starting with the left front tire in the
following clockwise order: Left front -
driver side front tire, Right front -
passenger side front tire, Right rear -
passenger side rear tire, Left rear -
driver side rear tire.
6. Remove the valve cap from the valve stem on the left front tire. Decrease the
air pressure until the horn sounds.
Note: The single horn tone confirms that
the sensor identification code has been
learned by the module for this position. If a
double horn is heard, the reset procedure
was unsuccessful, and you must repeat it.
7. Remove the valve cap from the valve stem on the right front tire. Decrease
the air pressure until the horn sounds.
8. Remove the valve cap from the valve stem on the right rear tire. Decrease the
air pressure until the horn sounds.
9. Remove the valve cap from the valve stem on the left rear tire. Decrease the
air pressure until the horn sounds.
Training is complete after the horn
sounds for the last tire trained, driver
side rear tire, the system indicator
stops flashing, and a message shows
in the information display.
10. Turn the ignition off. If two short horn
beeps are heard, the reset procedure
was unsuccessful and you must
repeat it. If after repeating the
procedure and two short beeps are
heard when the ignition is turned to
off, seek assistance from your
authorized dealer.
414
Super Duty (TFE), enUSA, Edition date: 201909, Third-Printing- Wheels and Tires

11.
Set all four tires to the recommended
air pressure as indicated on the
Safety Compliance Certification
Label, affixed to either the door hinge
pillar, door-latch post, or the door
edge that meets the door-latch post,
next to the driver seating position or
Tire Label located on the B-Pillar or
the edge of the driver door.
Performing the System Reset Procedure
- Dual Rear Wheel
For further information see
Understanding Your Tire Pressure
Monitoring System and refer to Dual
Rear Wheel, earlier in this section.
Read the entire procedure before
attempting.
1. Drive the vehicle above
20 mph
(32 km/h) for at least two minutes,
then park in a safe location where you
can easily get to all six tires and have
access to an air pump.
2. Place the ignition in the off position and
keep the key in the ignition.
3. Cycle the ignition to the on position with the engine off.
4. Turn the hazard flashers on then off three times. You must accomplish this
within 10 seconds. If you successfully
enter the reset mode, the horn sounds
once, the system indicator flashes and
a message shows in the information
display. If this does not occur, please
try again starting at step 2. If after
repeated attempts to enter the reset
mode, the horn does not sound, the
system indicator does not flash and no
message shows in the information
display, seek service from your
authorized dealer. 5. Train the tire pressure monitoring
system sensors in the tires using the
following system reset sequence
starting with the left front tire in the
following order: Left front - driver side
front tire, Right front - passenger side
front tire, Right outer rear -passenger
side rear outer tire, Right inner rear -
passenger side rear inner tire, Left outer
rear - driver side rear outer tire, Left
inner rear - driver side rear inner tire.
6. Remove the valve cap from the valve stem on the left front tire. Decrease the
air pressure until the horn sounds.
Note: The single horn chirp confirms that
the sensor identification code has been
learned by the module for this position. If a
double horn is heard, the reset procedure
was unsuccessful, and you must repeat it.
7. Remove the valve cap from the valve stem on the right front tire. Decrease
the air pressure until the horn sounds.
8. Remove the valve cap from the valve stem on the right outer rear tire.
Decrease the air pressure until the horn
sounds.
9. Remove the valve cap from the valve stem on the right inner rear tire.
Decrease the air pressure until the horn
sounds.
10. Remove the valve cap from the valve
stem on the left outer rear tire.
Decrease the air pressure until the
horn sounds.
11. Remove the valve cap from the valve
stem on the left inner rear tire.
Decrease the air pressure until the
horn sounds. Training is complete
after the horn sounds for the last tire
trained, the system indicator stops
flashing, and a message is shown in
the information display.
415
Super Duty (TFE), enUSA, Edition date: 201909, Third-Printing- Wheels and Tires

12.
Turn the ignition off. If two short horn
beeps are heard, the reset procedure
was unsuccessful and you must
repeat it. If after repeating the
procedure and two short beeps are
heard when the ignition is turned to
off, seek assistance from your
authorized dealer.
13. Set all six tires to the recommended air pressure as indicated on the
Safety Compliance Certification
Label, affixed to either the door hinge
pillar, door-latch post, or the door
edge that meets the door-latch post,
next to the driver seating position or
Tire Label located on the B-Pillar or
the edge of the driver door.
Trailer Tire Pressure Monitoring
System (If Equipped)
Note: Additional equipment may be
required for your vehicle to support trailer
tire pressure monitoring. See your authorized
dealer for more information.
Note: The trailer tire pressure monitoring
system is not a substitute for proper tire
maintenance. It is your responsibility to
maintain correct tire pressures at all times.
Note: If a trailer tire is repaired, replaced or
broken down for service, the screw and valve
on the trailer tire pressure sensor should be
replaced. See your authorized dealer for
details. The trailer tire pressure monitoring system
is an added safety feature that allows you
to view your trailer tire pressures through
the information display.
See General
Information (page 109). Tire pressure
sensors are mounted into each tire on your
trailer. The sensors send a message to your
vehicle indicating the current trailer tire
pressure.
If the trailer tire pressure monitoring
system detects that a tire is low, a warning
message appears in the information
display. The trailer tire pressure status
screen in the information display highlights
the tire with a low pressure.
The main function of the trailer tire
pressure monitoring system is to warn you
when your trailer tires need air. It can also
warn you in the event the system is no
longer capable of functioning as intended.
See
Information Messages (page 120).
When a Temporary Spare or New Tire
is Installed
If you have replaced a trailer tire with a new
or spare tire, a warning message appears
and pressure readings are no longer
displayed for that tire.
To restore the full function of the trailer
tire pressure monitoring system:
• Have the damaged wheel and tire
assembly repaired and remounted to
your trailer.
• Install the trailer tire pressure
monitoring sensor into the new wheel
and tire assembly.
• Perform the trailer tire pressure
monitoring system reset procedure.
Trailer Tire Pressure Monitoring
System Reset Procedure
Note: You need to perform the tire pressure
monitoring system reset procedure after
each tire rotation, or when a new trailer tire
pressure sensor is installed into a trailer tire.
416
Super Duty (TFE), enUSA, Edition date: 201909, Third-Printing- Wheels and TiresE235807

The trailer tire pressure monitoring system
can be reset through the menu in the
information display. See General
Information (page 109). Performing the
trailer setup process also resets the trailer
tire pressure monitoring system.
CHANGING A ROAD WHEEL WARNING:
If the tire pressure
monitor sensor becomes damaged it
may not function.
Note: If your vehicle is equipped with the
tire pressure monitoring system, the
indicator light illuminates when the spare
tire is in use. To restore the full function of
the monitoring system, all road wheels
equipped with tire pressure monitoring
sensors must be mounted on the vehicle.
Note: You should only use tire sealants in
roadside emergencies as they may cause
damage to the tire pressure monitoring
system sensor.
If you get a flat tire when driving, do not
apply the brake heavily. Instead, gradually
decrease your speed. Hold the steering
wheel firmly and slowly move to a safe
place on the side of the road.
If your vehicle is equipped with the tire
pressure monitoring system, have a flat
serviced by an authorized dealer in order
to prevent damage to the system sensors.
See
Tire Pressure Monitoring System
(page 409). Replace the spare tire with a
road tire as soon as possible. During
repairing or replacing of the flat tire, have
the authorized dealer inspect the system
sensor for damage. Dissimilar Spare Wheel and Tire
Assembly Information WARNING:
Failure to follow these
guidelines could result in an increased
risk of loss of vehicle control, injury or
death.
If you have a dissimilar spare wheel and
tire, then it is intended for temporary use
only. This means that if you need to use it,
you should replace it as soon as possible
with a road wheel and tire assembly that
is the same size and type as the road tires
and wheels that were originally provided
by Ford. If the dissimilar spare tire or wheel
is damaged, it should be replaced rather
than repaired.
A dissimilar spare wheel and tire assembly
is defined as a spare wheel and tire
assembly that is different in brand, size or
appearance from the road tires and
wheels.
Full-size dissimilar spare
When driving with the full-size dissimilar
spare wheel and tire assembly, do not:
• Exceed
70 mph (113 km/h).
• Use more than one dissimilar spare
wheel and tire assembly at a time.
• Use snow chains on the end of the
vehicle with the dissimilar spare wheel
and tire assembly.
When driving with the full-size dissimilar
spare wheel and tire assembly, 4WD
functionality may be limited. You may
experience the following:
• Additional noise from the transfer case
or other drive components.
• Difficulty shifting out of a mechanically
locked 4WD mode.
417
Super Duty (TFE), enUSA, Edition date: 201909, Third-Printing- Wheels and Tires

App Permissions
App permissions are organized by groups.
You can grant these group permissions
individually. You can change a permission
group status any time when not driving, by
using the settings menu.
When you launch an app using SYNC, the
system may ask you to grant certain
permissions, for example:
•
To allow your vehicle to provide vehicle
information to the app such as, but not
limited to: Fuel level, fuel economy, fuel
consumption, engine speed, rain
sensor, odometer, VIN, external
temperature, gear position, tire
pressure, and head lamp status.
• To allow your vehicle to provide driving
characteristic information such as, but
not limited to: MyKey, seat belt status,
engine revolutions per minute, gear
position, braking events, steering wheel
angle, and accelerator pedal position.
• To allow your vehicle to provide
location information, including: GPS
and speed.
• To allow the app to send push
notifications using the vehicle display
and voice capabilities while running in
a background state. Push notifications
may be particularly useful for news or
location based apps.
Note: You only need to grant permissions
the first time you use an app with SYNC.
Note: Ford is not responsible or liable for
any damages or loss of privacy relating to
usage of an app, or dissemination of any
vehicle data that you approve Ford to
provide to an app. Enabling SYNC Mobile Apps
In order to enable mobile apps, SYNC
requires user consent to send and receive
app authorization information and updates
using the data plan associated with the
connected device.
Data is sent to Ford in the United States
through the connected device. The
information is encrypted and includes your
VIN, SYNC module number, anonymous
usage statistics and debugging
information. Updates may take place.
Note:
You must enable mobile apps for
each connected device the first time you
select a mobile app using the system.
Note: Standard data rates apply. Ford is
not responsible for any additional charges
you may receive from your service provider,
when your vehicle sends or receives data
through the connected device. This includes
any additional charges incurred due to
driving in areas when roaming out of a home
network.
USING SYNC™ WITH YOUR
MEDIA PLAYER
SYNC supports digital media sources
including: iPod, Bluetooth devices, and
most USB drives. SYNC also supports
audio formats, such as MP3, WMA, WAV
and ACC.
Media Sources
The AUX or MEDIA button allows you to
view and select available media sources.
Press the
AUX or MEDIA button to view
your sources. Use the directional arrows
and OK button to select your source. You
can also use the steering wheel audio
controls.
491
Super Duty (TFE), enUSA, Edition date: 201909, Third-Printing- SYNC™
(If Equipped)

Connecting the Vehicle to a Mobile
Network........................................................470
Enabling the Modem Using FordPass.......................................................... 470
Enabling the Modem Using the Touchscreen................................................... 470
What Is the Modem.......................................... 470
Coolant Check See: Engine Coolant Check - 6.2L...............353
See: Engine Coolant Check - 6.7L
Diesel................................................................. 357
See: Engine Coolant Check - 7.3L...............360
Crash Sensors and Airbag Indicator.........51
Creating a MyKey............................................61 Programming or Changing Configurable
Settings............................................................... 62
Creating a Vehicle Wi-Fi Hotspot..........473 Connecting a Device to the Wi-Fi
Hotspot............................................................. 473
Finding the Wi-Fi Hotspot Name and Password.......................................................... 473
Cross Traffic Alert........................................253
Cross Traffic Alert Behavior When Trailer
is Attached...................................................... 255
Cross Traffic Alert Indicator........................... 255
Cross Traffic Alert Information Messages......................................................... 255
Cross Traffic Alert System Limitations...................................................... 254
Cross Traffic Alert System Sensors............254
Switching the System On and Off..............255
Using Cross Traffic Alert.................................. 253
Cruise Control...............................................236
Cruise Control Indicators
...........................237
Cruise Control - Vehicles With: Adaptive Cruise Control................................................81
Cruise Control - Vehicles With: Cruise Control.............................................................81
Customer Assistance.................................322
D
Data Recording
................................................10
Comfort, Convenience and Entertainment
Data....................................................................... 12
Event Data................................................................. 11
Service Data............................................................. 11
Services That Third Parties Provide...............12 Services That We Provide..................................
12
Vehicles With a Modem...................................... 12
Vehicles With an Emergency Call System.................................................................. 13
Vehicles With SYNC............................................. 13
Daytime Running Lamps - Vehicles With: Configurable Daytime Running
Lamps..............................................................87
Daytime Running Lamps - Vehicles With: Daytime Running Lamps (DRL)............88
Declaration of Conformity.......................609
Declaration of Conformity - Vehicles With: SYNC 3.............................................609
Radio Frequency Statement........................ 609
Diesel Particulate Filter..............................196 Oxidation Catalytic Converter and Diesel
Particulate Filter System............................ 196
Regeneration........................................................ 196
Digital Radio..................................................478 HD Radio Reception and Station
Troubleshooting............................................ 479
Direction Indicators
.......................................89
Doors and Locks.............................................65
Draining the Fuel Filter Water Trap - 6.7L Diesel............................................................350
Draining the Diesel Fuel Conditioner Module............................................................... 351
Filter Location...................................................... 351
Drive Control..................................................262 Selectable Drive Modes.................................. 262
Driver Alert
.....................................................244
Using Driver Alert............................................... 244
Driver and Passenger Airbags...................44 Children and Airbags.......................................... 49
Passenger Airbag On and Off Switch ..........44
Proper Driver and Front Passenger Seating Adjustment....................................................... 48
Driving Aids....................................................244
Driving Hints
...................................................307
Driving Through Water...............................310
For Vehicles without Tremor Off-Road
Package............................................................. 310
For Vehicles with Tremor Off-Road Package.............................................................. 311
617
Super Duty (TFE), enUSA, Edition date: 201909, Third-Printing- Index

P
Parking Aids...................................................228
Principle of Operation...................................... 228
Parking Brake.................................................219
Passive Anti-Theft System.........................75 SecuriLock®........................................................... 75
PATS See: Passive Anti-Theft System..................... 75
Perchlorate........................................................14
Phone................................................................521 Android Auto........................................................ 523
Apple CarPlay...................................................... 523
Pairing Your Cell Phone for the First Time................................................................... 522
Text Messaging................................................... 522
Using Your Cell Phone...................................... 522
Post-Crash Alert System
...........................319
Power Door Locks See: Locking and Unlocking............................. 65
Power Running Boards
.................................77
Power Seats...................................................150
Adjusting the Lumbar Support....................... 151
Adjusting the Multi-Contour Front Seats With Active Motion ........................................ 151
Power Steering Fluid Check
.....................367
Power Take-Off............................................205 Split Shaft Capability...................................... 206
Power Windows.............................................94 Accessory Delay................................................... 95
Bounce-Back......................................................... 94
One-Touch Up or Down.................................... 94
Window Lock......................................................... 95
Pre-Collision Assist
.....................................258
Adjusting the Pre-Collision Assist
Settings............................................................ 260
Blocked Sensors................................................. 261
Distance Indication and Alert....................... 259
Using the Pre-Collision Assist System.............................................................. 258
Protecting the Environment........................17
Puncture See: Changing a Road Wheel......................... 417
R
Rear Axle..........................................................215 Rear Parking Aid...........................................228
Obstacle Distance Indicator.......................... 229
Rear Seats
.......................................................154
Folding Up the Rear Seat Cushion ..............154
Rear Under Seat Storage................................. 155
Returning the Seat to the Seating Position.............................................................. 155
Rear View Camera
.......................................229
Camera Guidelines........................................... 230
Obstacle Distance Indicator........................... 231
Rear Camera Delay............................................ 231
Using the Rear View Camera System.............................................................. 230
Rear View Camera See: Rear View Camera................................... 229
Recommended Towing Weights
...........290
Calculating the Maximum Loaded Trailer
Weight for Your Vehicle.............................. 294
Refueling - Diesel.........................................184 Dual Fuel Tanks................................................... 186
Fueling Tips.......................................................... 185
Refueling................................................................ 185
Refueling - Gasoline....................................183 Fuel Filler Cap...................................................... 184
Remote Control..............................................53 Car Finder................................................................ 58
Integrated Keyhead Transmitter..................... 53
Intelligent Access Key......................................... 54
Memory Feature.................................................... 57
Remote Start......................................................... 58
Replacing the Battery......................................... 55
Sounding the Panic Alarm................................ 58
Remote Start.................................................144 Automatic Settings............................................ 145
Removing the Tailgate
...................................71
Repairing Minor Paint Damage...............387
Replacement Parts Recommendation........................................14
Collision Repairs.................................................... 14
Scheduled Maintenance and Mechanical Repairs.................................................................. 14
Warranty on Replacement Parts..................... 14
Replacing a Lost Key or Remote Control............................................................59
Replacing the Cabin Air Filter..................146
Reporting Safety Defects (Canada Only)..............................................................327
623
Super Duty (TFE), enUSA, Edition date: 201909, Third-Printing- Index

Opening the Step..................................................
72
Tailgate...............................................................70
Technical Specifications See: Capacities and Specifications............429
Terrain Control..............................................226 Principle of Operation...................................... 226
The Better Business Bureau (BBB) Auto Line Program (U.S. Only).......................324
Tire Care..........................................................392
Glossary of Tire Terminology........................ 393
Information About Uniform Tire Quality Grading............................................................. 392
Information Contained on the Tire Sidewall........................................................... 394
Temperature A B C............................................ 393
Traction AA A B C............................................... 392
Treadwear............................................................. 392
Tire Pressure Monitoring System
..........409
Trailer Tire Pressure Monitoring
System............................................................... 416
Vehicle Tire Pressure Monitoring System............................................................. 409
Tires See: Wheels and Tires..................................... 390
Towing a Trailer.............................................272 Load Placement................................................. 273
Towing Points
...............................................320
Towing the Vehicle on Four Wheels.........................................................304
Emergency Towing........................................... 304
Recreational Towing........................................ 304
Towing..............................................................272
Traction Control.............................................221 Principle of Operation....................................... 221
Trail Control Indicators...............................225
Trail Control
....................................................225
Trailer Reversing Aids..................................274 Conventional Trailer Setup............................. 276
Fifth Wheel and Gooseneck Trailer Setup................................................................. 278
Positioning Your Vehicle and Trailer............275
Pro Trailer Backup Assist With Trailer Reverse Guidance......................................... 274
Setting Up the System..................................... 275
Troubleshooting - Conventional Trailer................................................................. 282
Troubleshooting - Fifth Wheel and Gooseneck Trailer......................................... 287Using Pro Trailer Backup Assist....................
279
Using Trailer Reverse Guidance................... 280
Trailer Sway Control...................................290
Transfer Case Fluid Check
.......................366
Transmission Code Designation............436
Transmission..................................................201
Transporting the Vehicle............................319
Type Approvals
.............................................610
Radio Frequency Certifications for Blind
Spot Information System.......................... 610
U
Under Hood Overview - 6.2L...................338
Under Hood Overview - 6.7L Diesel.............................................................339
Under Hood Overview - 7.3L...................340
Under Seat Storage.....................................165 Front Under Seat Storage Compartment -
Vehicles With Locking Storage.................166
Front Under Seat Storage Compartment - Vehicles Without Locking Storage..........165
Rear Under Seat Storage................................ 166
Universal Garage Door Opener...............158 HomeLink Wireless Control System...........158
USB Port
.........................................................483
Locating the USB Ports................................... 483
Using Adaptive Cruise Control................237 Automatic Cancellation................................... 241
Blocked Sensor................................................... 242
Canceling the Set Speed................................ 240
Changing the Set Speed................................. 240
Detection Issues.................................................. 241
Following a Vehicle........................................... 238
Hilly Condition and Trailer Tow Usage.................................................................. 241
Overriding the Set Speed............................... 240
Resuming the Set Speed................................ 240
Setting the Adaptive Cruise Speed.............238
Setting the Gap Distance............................... 239
Switching Adaptive Cruise Control Off........................................................................\
241
Switching Adaptive Cruise Control On....................................................................... 238
Switching to Normal Cruise Control...........243
System Not Available....................................... 242
Using Four-Wheel Drive............................207 4WD Indicator Lights........................................ 207
626
Super Duty (TFE), enUSA, Edition date: 201909, Third-Printing- Index