FORD F SERIES MOTORHOME AND COMMERCIAL CHASSIS 2013 12.G Owners Manual

DEALERVALIDATION:
P&A C
ODE:
RO#: HOURS:
DAT E:MILEAGE:D
EALERVALIDATION:
P&A C
ODE:
RO#: HOURS:
DAT E:MILEAGE:
D
EALERVALIDATION:
P&A C
ODE:
RO#: HOURS:
DAT E:MILEAGE:D
EALERVALIDATION:
P&A C
ODE:
RO#: HOURS:
DAT E:MILEAGE:
D
EALERVALIDATION:
P&A C
ODE:
RO#: HOURS:
DAT E:MILEAGE:D
EALERVALIDATION:
P&A C
ODE:
RO#: HOURS:
DAT E:MILEAGE:
D
EALERVALIDATION:
P&A C
ODE:
RO#: HOURS:
DAT E:MILEAGE:D
EALERVALIDATION:
P&A C
ODE:
RO#: HOURS:
DAT E:MILEAGE:
D
EALERVALIDATION:
P&A C
ODE:
RO#: HOURS:
DAT E:MILEAGE:D
EALERVALIDATION:
P&A C
ODE:
RO#: HOURS:
DAT E:MILEAGE:
150Scheduled Maintenance
2013 Motorhome(mot)
Owners Guide gf, 1st Printing
USA(fus)

EXCEPTIONS
Normal vehicle axle maintenance:Rear axles and power take-off
(PTO) units with synthetic fluid and light-duty trucks equipped with
Ford-design axles are lubricated for life; do not check or change fluid
unless a leak is suspected, service is required or the assembly has been
submerged in water. During long periods of trailer towing with outside
temperatures above 70°F (21°C) and at wide-open throttle for long
periods above 45 mph (72 km/h), non-synthetic rear axle fluids should
be changed every 3000 miles (4800 kilometers) or three months,
whichever comes first. This interval can be waived if the axle is filled
with 75W140 synthetic gear fluid meeting Ford specification
WSL-M2C192-A, part number F1TZ-19580-B or equivalent. Add friction
modifier XL-3 (EST-M2C118-A) or equivalent for complete refill of
Traction-Lok rear axles (refer toTechnical specificationsin the
Capacities and Specificationschapter for details).
California fuel filter replacement:If the vehicle is registered in
California, the California Air Resources Board has determined that the
failure to perform this maintenance item will not nullify the emission
warranty or limit recall liability prior to the completion of the vehicle’s
useful life. Ford Motor Company, however, urges you to have all
recommended maintenance services performed at the specified intervals
and to record all vehicle service.
Class A Motorhome:Change brake fluid every two years.
Hot climate oil change intervals:Vehicles operating in the Middle
East, North Africa, Sub-Saharan Africa or locations with similar climates
using an American Petroleum Institute (API) Certified for Gasoline
Engines (Certification mark) oil of SM or SN quality, the normal oil
change interval is 5000 miles (8000 kilometers).
If the available API “SM” or “SN” oils are not available, then the oil
change service interval is 3000 miles (4800 kilometers).
Engine air filter replacement:Engine air filter life is dependent on
exposure to dusty and dirty conditions. Vehicles operated in these
conditions require frequent inspection and replacement of the engine air
filter.
Scheduled Maintenance151
2013 Motorhome(mot)
Owners Guide gf, 1st Printing
USA(fus)

ENGINE COOLANT CHANGE RECORD
Initial change Six years or 105000 miles (168000 km)
(whichever comes first)
After initial change Every three years or 45000 miles (72000 km)
Engine Coolant Change Log
DEALERVALIDATION:
P&A C
ODE:
RO#: HOURS:
DAT E:MILEAGE:D
EALERVALIDATION:
P&A C
ODE:
RO#: HOURS:
DAT E:MILEAGE:
D
EALERVALIDATION:
P&A C
ODE:
RO#: HOURS:
DAT E:MILEAGE:D
EALERVALIDATION:
P&A C
ODE:
RO#: HOURS:
DAT E:MILEAGE:
D
EALERVALIDATION:
P&A C
ODE:
RO#: HOURS:
DAT E:MILEAGE:D
EALERVALIDATION:
P&A C
ODE:
RO#: HOURS:
DAT E:MILEAGE:
152Scheduled Maintenance
2013 Motorhome(mot)
Owners Guide gf, 1st Printing
USA(fus)

A
Air cleaner filter .......100–101, 132
Ambulance packages ....................9
Antifreeze
(see Engine coolant) ..................87
Automatic transmission
driving an automatic
overdrive ...................................39
fluid, adding ..............................91
fluid, checking ..........................91
fluid, refill capacities ..............128
fluid, specification ..................128
Axle
lubricant specifications ..........128
refill capacities ........................128
B
Battery .........................................98
acid, treating emergencies .......98
jumping a disabled battery ......64
maintenance-free ......................98
replacement, specifications ...132
servicing ....................................98
Brakes ..........................................44
fluid, checking and
adding ..................................94–95
fluid, refill capacities ..............128
fluid, specifications .................128
lubricant specifications ..........128
shift interlock ............................42
C
Capacities for refilling fluids ....128
Cell phone use ............................10
Changing a tire .........................121
Cleaning your vehicle ...............101
engine compartment ..............101wheels ......................................101
Coolant ........................................87
checking and adding ................87
refill capacities ........................128
specifications ..........................128
Cruise control .............................46
Customer Assistance ..................62
Ford Extended Service
Plan ..................................134, 136
Getting assistance outside
the U.S. and Canada ................70
Getting roadside assistance .....62
Getting the service you need ..67
Ordering additional owner’s
literature ...................................72
Utilizing the
Mediation/Arbitration
Program .....................................70
D
Dipstick
automatic transmission fluid ...91
engine oil ...................................86
Driving under special
conditions ....................................43
through water ...........................61
E
Electronic message center .........22
Emergencies, roadside
jump-starting ............................64
Emergency Flashers ...................63
Emission control system ............36
Engine ........................................127
cleaning ...................................101
coolant .......................................87
fail-safe cooling .........................90
idle speed control .....................98
Index153
2013 Motorhome(mot)
Owners Guide gf, 1st Printing
USA(fus)

lubrication specifications .......128
refill capacities ........................128
service points ......................84–85
Engine oil
checking and adding ................86
dipstick ......................................86
filter, specifications ................132
refill capacities ........................128
specifications ..........................128
Event data recording ....................6
Exhaust fumes ............................29
F
Fail safe cooling ..........................90
Fluid capacities .........................128
Fuel
cap .............................................33
capacity ...................................128
choosing the right fuel .............32
filling your vehicle with fuel ....33
filter, specifications ..........97, 132
octane rating .....................32, 127
quality ........................................32
running out of fuel ...................32
safety information relating to
automotive fuels .......................30
Fuses ................................74–75, 79
G
Gas cap (see Fuel cap) ..............33
Gauges .........................................16
H
Hazard flashers ...........................63
Headlamps
flash to pass ..............................13
high beam .................................13I
Ignition .................................28, 127
Information displays ...................22
Inspection/maintenance (I/M)
testing ..........................................38
Instrument panel
cluster ........................................18
J
Jump-starting your vehicle ........64
K
Keys
positions of the ignition ...........28
L
Lamps
headlamps, flash to pass ..........13
Lights, warning and indicator ....18
Loading instructions ...................53
Load limits ...................................48
Lubricant specifications ...........128
Lug nuts ....................................126
M
Message center ...........................22
english/metric button ...............24
system check button ................24
warning messages .....................24
Motorcraftparts ......................132
O
Octane rating ..............................32
154Index
2013 Motorhome(mot)
Owners Guide gf, 1st Printing
USA(fus)

P
Parking brake ..............................45
Parts
(see Motorcraftparts) ...........132
Power distribution box
(see Fuses) .................................75
Power steering
fluid, checking and adding ......96
fluid, refill capacity ................128
fluid, specifications .................128
R
Relays ..............................74–75, 78
Roadside assistance ....................62
S
Safety defects, reporting ............73
Scheduled Maintenance Guide
Normal Scheduled
Maintenance and Log .............142
Spark plugs,
specifications .....................127, 132
Special notice ................................9
Specification chart,
lubricants ...................................128
Starting your vehicle ..................28
jump starting ............................64
Steering wheel ............................11
tilting .........................................11
T
Tilt steering wheel ......................11
Tires ...................................104–105alignment ................................119
care ..........................................104
changing ..........................121, 123
checking the pressure ............114
inflating ...................................111
replacing ..................................117
rotating ....................................119
safety practices .......................118
snow tires and chains ............120
spare tire .................................121
terminology .............................106
tire grades ...............................105
treadwear ........................104, 116
Towing ...................................54, 59
trailer towing ............................54
wrecker ......................................59
Transmission ...............................39
brake-shift interlock (BSI) ......42
fluid, checking and adding
(automatic) ...............................91
fluid, refill capacities ..............128
lubricant specifications ..........128
Turn signal ..................................15
V
Vehicle Identification Number
(VIN) ..................................132–133
Vehicle loading ............................48
Ventilating your vehicle .............29
W
Warning lights (see Lights) .......18
Water, Driving through ...............61
Windshield washer fluid and
wipers ..........................................12
Wrecker towing ...........................59
Index155
2013 Motorhome(mot)
Owners Guide gf, 1st Printing
USA(fus)

2013 Motorhome(mot)
Owners Guide gf, 1st Printing
USA(fus)