sensor FORD FREESTAR 2005 1.G Owner's Manual

Brake Assist (if equipped as part of the AdvanceTracsystem)
The Brake Assist system provides full braking force during panic braking
situations. It detects a rapid application of the brake pedal and
maximizes the amount of brake booster assist, helping the driver to
achieve maximum braking pressure. Once a panic brake application is
detected, the system will remain activated as long as the brake pedal is
depressed. The system is deactivated by releasing the brake pedal.
When the system activates, the brake pedal will travel with very little
effort; this is normal.
Parking brake
To set the parking brake, pull the
handle up as far as possible. The
BRAKE warning lamp will illuminate
and will remain illuminated until the
parking brake is released.
To release, press and hold the
button, pull the handle up slightly,
then push the handle down.
Always set the parking
brake fully and make sure
that the gearshift is securely
latched in P (Park).
ADVANCETRACSTABILITY ENHANCEMENT SYSTEM
(IF EQUIPPED)
The AdvanceTrac
system helps the driver maintain the stability and
steer-ability of the vehicle. The system integrates anti-lock braking
system (ABS) and Traction Control
and a more advanced function to
further enhance the stability of the vehicle.
AdvanceTrac
constantly monitors the vehicle motion relative to the
driver’s intended course. This is done by using added sensors that
compare the steering inputs from the driver with the actual motion of
the vehicle. AdvanceTrac
determines whether an engine torque
reduction or brake application is needed to help control the vehicle. If
the vehicle begins to rotate excessively left or right, spin out, or slide
sideways, the system will attempt to correct the excessive motion. If the
P!
BRAKE
REVIEW COPY
2005 Freestar(win), Owners Guide (post-2002-fmt)(own2002),
Market:USA_English(fus)
Driving
222

with a message center will also have CHECK ADVANCETRAC shown in
the display. Have the vehicle system serviced immediately.
If the vehicle is stuck in snow or mud or when driving in deep sand,
switching off the AdvanceTrac
system may be beneficial so the wheels
are allowed to spin. If your vehicle seems to lose engine power while
driving in deep sand or very deep snow, switching off the AdvanceTrac

stability enhancement feature will restore full engine power and will
enhance momentum through the obstacle.
Some drivers may notice a slight movement of the brake pedal when the
AdvanceTrac
performs a system self-check. During AdvanceTrac

operation you may experience the following:
•A rumble or grinding noise
•A slight deceleration of the vehicle
•The TRAC ACTIVE indicator light will illuminate
•If your foot is on the brake pedal, you will feel a vibration in the
pedal.
•If the driving condition is severe and your foot is not on the brake, the
brake pedal will move to apply higher brake forces. You may also hear
a whoosh of air from under the instrument panel during this severe
condition.
All these conditions are normal during AdvanceTrac
operation.
If the AdvaceTrac system is activated for an extended period of time, the
brake portion of the system will shut down to allow the brakes to cool
down. A limited AdvanceTrac
function using only engine power
reduction will still help control the wheels from over-spinning. When the
brakes have cooled down, the system will again function normally.
Anti-lock braking is not affected by this condition and will function
normally during the cool-down period.
Do not alter or modify your vehicle’s suspension or steering; the
resulting changes to the vehicle’s handling can adversely affect
the AdvanceTrac
system. Also, do not install a stereo
loudspeaker near the front center console or under either front
seat. The speaker vibrations can adversely affect the
AdvanceTrac
sensors located in this area.
Aggressive driving in any road conditions can cause you to lose
control of your vehicle increasing the risk of severe personal
injury or property damage. The occurrence of an AdvanceTrac
event
is an indication that at least some of the tires have exceeded their
ability to grip the road; this may lead to an increased risk of loss of
vehicle control, vehicle rollover, personal injury and death. If you
experience a severe road event, SLOW DOWN.
REVIEW COPY
2005 Freestar(win), Owners Guide (post-2002-fmt)(own2002),
Market:USA_English(fus)
Driving
224

The RSS is automatically enabled
when the gear selector is placed in
R (Reverse) and the ignition is ON.
The park aid disable switch allows
the driver to disable the RSS only
when the ignition is ON, and the
gear selector is in R (Reverse). The
OFF indicator remains illuminated
when the system is disabled. If the
indicator light illuminates when the RSS is not turned off, it may indicate
a failure in the RSS.
The system defaults toenabledevery time the ignition is turned on.
Press the control to disable or enable the system.
Keep the RSS sensors (located on the rear bumper/fascia) free
from snow, ice and large accumulations of dirt (do not clean the
sensors with sharp objects). If the sensors are covered, it will
affect the accuracy of the RSS.
If your vehicle sustains damage to the rear bumper/fascia, leaving
it misaligned or bent, the sensing zone may be altered causing
inaccurate measurement of obstacles or false alarms.
DRIVING THROUGH WATER
If driving through deep or standing water is unavoidable, proceed very
slowly especially when the depth is not known. Never drive through
water that is higher than the bottom of the hubs (for trucks) or the
bottom of the wheel rims (for cars). When driving through water,
traction or brake capability may be limited. Also, water may enter your
engine’s air intake and severely damage your engine or your vehicle may
stall.Driving through deep water where the transmission vent
tube is submerged may allow water into the transmission and
cause internal transmission damage.
Once through the water, always dry the brakes by moving your
vehicle slowly while applying light pressure on the brake pedal.
Wet brakes do not stop the vehicle as quickly as dry brakes.OFF
REVIEW COPY
2005 Freestar(win), Owners Guide (post-2002-fmt)(own2002),
Market:USA_English(fus)
Driving
230

Fuse/Relay
LocationFuse Amp
RatingPower Distribution Box Description
40 15A* Engine #1 (A/C relay coil, IMRC, HEGO
sensors, Canister purge, Transaxle,
Canister vent)
41 25A* Horn
42 10A* A/C clutch
43 15A* Engine #2 (Cooling fan relays, Injectors,
PCM, MAF sensor, IAC, Ignition coil,
ESM)
44 10A* Heated PCV
45 15A* High beams
46 20A* Trailer stop/turn lamps
47 15A* Fuel pump driver module
48—Not used
49 10A* PCM KAP
50 10A* Alternator
51 10A* Adjustable pedals (non-memory) or
memory module
52 20A* Trailer tow park lamps
53 10A* Heated mirrors
54 30A* Front wiper motor
55 25A* Rear wiper motor
56 30A* Premium sound radio
57 20A* Cigar lighter
58 30A* SJB #1–Center High-Mounted Stop
Lamp (CHMSL), License plate lamps,
OBD II, Dome lamp, Auxiliary blend
doors, Switch illumination (feeds
F–8, F–9, F–10 and F–11)
59 20A* Radio (non-premium)
60 30A* SJB #4–Back-up lamps, Door locks
61 20A* 3rd row power point
REVIEW COPY
2005 Freestar(win), Owners Guide (post-2002-fmt)(own2002),
Market:USA_English(fus)
Roadside Emergencies
239

Changing the air filter element
1. Disconnect the Mass Air Flow
Sensor from the air outlet tube.
2. Reposition the locking clip (on
the connector) and squeeze
connector to remove.
3. Loosen the hose clamp located
closest to the air cleaner.
REVIEW COPY
2005 Freestar(win), Owners Guide (post-2002-fmt)(own2002),
Market:USA_English(fus)
Maintenance and Specifications
289

11. Ensure the pads on the bottom
of the air cleaner assembly are
properly seated.
12. Reconnect the outlet tube to the
air cleaner assembly and tighten the
clamp.
13. Reconnect the Mass Air Flow
Sensor electrical connector to the
outlet tube. Make sure the locking
tab on the connector is in“locked”
position.
Note:If hose clamp is not secured properly or Mass Air Flow Sensor
electrical connector is not properly installed the Check Engine light will
illuminate when vehicle is operated.
Note:Do not use oil-impregnated air filter elements. Failure to use the
correct air filter element may result in severe engine damage. The
customer warranty may be voided for any damage to the engine if the
correct air filter element is not used.
REVIEW COPY
2005 Freestar(win), Owners Guide (post-2002-fmt)(own2002),
Market:USA_English(fus)
Maintenance and Specifications
292

L
Lampsautolamp system .......................45
bulb replacement
specifications chart ..................51
daytime running light ...............46
headlamps .................................45
headlamps, flash to pass ..........47
instrument panel, dimming .....47
interior lamps .....................49 –51
replacing bulbs ...................51 –55
Lane change indicator
(see Turn signal) ........................49
Liftgate ....................88 –89, 93, 100
Lights, warning and indicator ....10 anti-lock brakes (ABS) ..........221
Load limits .................................208
Locks autolock ...........................104, 107
childproof ..................................96
doors ..........................................95
Low tire warning .........15, 201, 206
Lubricant specifications ...295, 297
Lug nuts ....................................192
Luggage rack ...............................93
Lumbar support, seats .............115
M
Message center ...........................79 english/metric button ...............82
system check button ................82
warning messages .....................83
Mirrors ...................................58, 69 automatic dimming rearview
mirror ........................................69
fold away ...................................70 heated ........................................70
programmable memory ..........105
side view mirrors (power) .......69
signal .........................................70
Motorcraft parts ................280, 293
O
Octane rating ............................279
Oil (see Engine oil) ..................266
Overdrive ...................................226
P
Parking brake ............................222
Parts (see Motorcraft parts) ....293
Passenger Occupant
Classification Sensor .................136
Pedals (see Power adjustable
foot pedals) .................................71
Power adjustable foot pedals .....71
Power distribution box
(see Fuses) ...............................237
Power door locks ........95, 104, 107
Power liftgate ......................89, 100
Power mirrors .............................69
Power point .................................66
Power steering ..........................225 fluid, checking and adding ....286
fluid, refill capacity ................294
fluid, specifications .........295, 297
Power Windows ...........................68
R
Radio ..........................18, 20, 23, 26
Relays ........................................233
REVIEW COPY
2005 Freestar (win), Owners Guide (post-2002-fmt) (own2002),
Market: USA_English (fus)
Index
306

Remote entry system .................99illuminated entry ......47, 102 –103
locking/unlocking doors .....95, 99
Reverse sensing system ...........228
Roadside assistance ..................231
Roof rack .....................................93
S
Safety Belt Maintenance ..........148
Safety belts (see Safety
restraints) ..................135, 138 –142
Safety Canopy ...........................158
Safety defects, reporting ..........256
Safety restraints ........135, 138 –142
belt minder .............................144
extension assembly ................148
for adults .........................139 –141
for children .............................162
Occupant Classification
Sensor ......................................136
safety belt maintenance .........148
warning light and chime 143 –144
Safety seats for children ..........165
Seat belts
(see Safety restraints) .............135
Seats ..........................................112 child safety seats ....................165
front seats ...............112, 114 –115
memory seat ...................105, 115
second row seats ............118, 121
third row seats ...............121, 128, 132–133
SecuriLock passive anti-theft
system ........................................109
Servicing your vehicle ..............263
Spare tire
(see Changing the Tire) ...182, 184 Spark plugs,
specifications .....................293, 297
Specification chart,
lubricants ...........................295, 297
Speed control ..............................71
Starting your vehicle ........217
–219
jump starting ..........................241
Steering wheel controls ......................................74
tilting .........................................57
T
Tilt steering wheel ......................57
Tire Pressure Monitoring
System (TPMS) Maintenance and
Specifications ..........................202
Tire warning ..............................206
Tires ...........................176 –177, 206
alignment ................................199
care ..........................................197
changing ..................182, 184, 187
checking the pressure ............179
inspecting and inflating .........178
label .........................................197
replacing ..................................180
rotating ....................................199
safety practices .......................198
sidewall information ...............192
snow tires and chains ............208
spare tire .................................183
terminology .............................177
tire grades ...............................177
treadwear ........................176, 197
Towing .......................................213 recreational towing .................216
trailer towing ..........................213
wrecker ....................................247
REVIEW COPY
2005 Freestar (win), Owners Guide (post-2002-fmt) (own2002),
Market: USA_English (fus)
Index
307