sensor FORD FUSION HYBRID 2019 Warranty Guide

is no factory-related defect involved and therefore no warranty our
policy is to provide free repair of paint damage due to the airborne
material for 12 months or 12,000 miles, whichever occurs first.
(4) The electrical drivetrain system of your vehicle is covered by the
Hybrid & Electric Vehicle Unique Component coverage for eight years or
100,000 miles, whichever comes first. The components in the electrical
drivetrain system of your vehicle will vary, depending on whether your
vehicle is a hybrid, plug-in hybrid, or all-electric vehicle, but you can rest
assured knowing that your vehicle’s electrical drivetrain system is
covered by this comprehensive warranty.
Depending on your vehicle, electrical drivetrain system components
covered by this warranty may include, and are not limited to:
high-voltage battery, high-voltage battery connector, high-voltage battery
isolation switch (manual disconnect switch), battery pack fan assembly,
battery pack sensor module (HBPSM), battery energy control module
(BECM), on-board charger, on-board charger fan assembly, inverter
system controller (ISC), DC/DC converter, hybrid continuously variable
transmission, transmission range sensor, and the electronic drive module
assembly (the electric motor and gearbox).
If an electrical drivetrain system component requires replacement under
warranty, it may be replaced with a new, factory remanufactured, or
factory refurbished component, at Ford’s discretion. Refurbished battery
components selected for your vehicle will align with your vehicle’s age
and mileage, and meet Ford’s stringent requirements and standards. (see
Note: High-Voltage Battery Gradual Capacity Lossbelow).
Note: High Voltage Battery Gradual Capacity Loss
The high voltage battery will experience gradual capacity loss with time
and use, similar to all batteries, which is considered normal wear and
tear. Loss of battery capacity due to or resulting from gradual capacity
loss is NOT covered under the New Vehicle Limited Warranty. See your
Owner’s Manual for important tips on how to maximize the life and
capacity of the high voltage battery.
12

•You are subject to a penalty or sanction under local, state, or federal
law because your vehicle has failed to conform to the emissions
standards. (A penalty or sanction can include being denied the right
to use your vehicle.)
• Your vehicle has not been tampered with, misused, or abused.
The warranty coverage period for:
Passenger cars and light duty trucks (applies to vehicles up to
8,500 pounds GVWR) as follows: -
8 years or 80,000 miles (whichever occurs first) for catalytic converters,electronic emissions control unit, and onboard emissions diagnostic
devices, including the Battery Energy Control Module (BECM).
- 2 years or 24,000 miles (whichever occurs first) for all other covered parts.
See WHAT IS COVERED below for list of covered parts.
Note that the warranty period begins on the Warranty Start Dateas
specified on page 2 of this booklet.
WHAT IS COVERED?
For your vehicle, if these parts contain an emissions-related defect, they
are covered by both the Emissions Defects Warranty and the Emissions
Performance Warranty.
• Air Flow Sensor
• Air/Fuel Feedback Control System and Sensors
• Air Induction System
• Battery Energy Control Module (BECM)
•
Brake Hydraulic/Electric Control Assembly (Plug-in Hybrid vehicles only)
• Brake Vacuum Pump (Plug-in Hybrid vehicles only)
• Catalytic Converter
• Electronic Engine Control Sensors and Switches
• Evaporative Emission Control System
• Exhaust Gas Recirculation (EGR) System
• Exhaust Manifold
• Exhaust Pipe (Manifold to Catalyst)
20

•Fuel Filler Door Sensor (Plug-in Hybrid vehicles only)
• Fuel Filler Tube and Seal
• Fuel Injection System
• Fuel Injector Supply Manifold
• Fuel Tank
• High Voltage Battery
• HVAC Controller (Plug-in Hybrid vehicles only)
• Ignition Coil and/or Control Module
• Intake Manifold
• Inverter System Controller (Plug-in Hybrid vehicles only)
• Malfunction Indicator Lamp (MIL)/On-Board Diagnostic (OBD) System
• Motor Electronics Coolant Pump (Plug-in Hybrid vehicles only)
• PCV System and Oil Filler Cap
• PHEV Onboard Charger
• Powertrain Control Module (PCM)/Engine Control Module (ECM)*
• Spark Control Components
• Spark Plugs and Ignition Wires
• Thermostat
• Throttle Body Assembly (MFI)
• Transmission Assembly (Plug-in Hybrid vehicles only)
• Transmission Auxiliary Oil Pump (Plug-in Hybrid vehicles only)
• Transmission Fluid Temperature Sensor (Plug-in Hybrid vehicles only)
• Vacuum Distribution System
* Includes hardware and emission related software changes only
21

WHAT IS COVERED?
The parts on the following list are covered by the Standard California
Defects Warranties and TZEV Defects Warranties.
•Air Flow Sensor
• Air/Fuel Feedback Control System and Sensors
• Air Induction System
• Battery Energy Control Module (BECM)
•
Brake Hydraulic/Electric Control Assembly (Plug-in Hybrid vehicles only)
• Brake Vacuum Pump (Plug-in Hybrid vehicles only)
• Catalytic Converter
• Electronic Engine Control Sensors and Switches
• Evaporative Emission Control System
• Exhaust Gas Recirculation (EGR) System
• Exhaust Manifold
• Exhaust Pipe (Manifold to Catalyst)
• Fuel Filler Door Sensor (Plug-in Hybrid vehicles only)
• Fuel Filler Tube and Seal
• Fuel Injection System
• Fuel Injector Supply Manifold
• Fuel Tank
• High Voltage Battery
• HVAC Controller (Plug-in Hybrid vehicles only)
• Ignition Coil and/or Control Module
• Intake Manifold
• Inverter System Controller (Plug-in Hybrid vehicles only)
• Malfunction Indicator Lamp (MIL)/On-Board Diagnostic (OBD) System
• Motor Electronics Coolant Pump (Plug-in Hybrid vehicles only)
• PCV System and Oil Filler Cap
• PHEV Onboard Charger
• Powertrain Control Module (PCM)/Engine Control Module (ECM)*
28

•Spark Control Components
• Spark Plugs and Ignition Wires
• Thermostat
• Throttle Body Assembly (MFI)
• Transmission Assembly (Plug-in Hybrid vehicles only)
• Transmission Auxiliary Oil Pump (Plug-in Hybrid vehicles only)
• Transmission Fluid Temperature Sensor (Plug-in Hybrid vehicles only)
• Vacuum Distribution System
* Includes hardware and emission related software changes only
Important Information about List of Parts
Also covered by this warranty are all emissions-related bulbs, hoses, clamps,
brackets, tubes, gaskets, seals, belts, connectors, non diesel fuel lines, and
wiring harnesses that are used with components on the list of parts above.
Concerning parts that should be replaced on a certain maintenance
schedule: these parts remain under warranty until the first required
replacement time that is specified in your Owner’s Manual.
NOTE: If the diagnosis does not reveal a defect, the Defects Warranty
does not apply.
Your Ford Motor Company dealer maintains a complete list of covered
parts. For more details about the specific parts that are covered by the
Defects Warranty, contact your dealer.
WHAT IS NOT COVERED?
Ford Motor Company may deny you emissions warranty coverage if your
vehicle or a part does not contain a defect that affects emissions or has
failed because of abuse, neglect, improper maintenance, unapproved
modifications, or any items included in What Is Not Covered?,
pages 13-16.
29