FORD KUGA 2011 1.G Workshop Manual

'(7$,/65(68/76$&7,216
7(67 &21',7,216
$ &+(&. 7+( )5217 3$5.,1* $,' 63($.(5 )25 &255(&7 23(5$7,21
 5HPRYH WKH IURQW SDUNLQJ DLG VSHDNHU
5()(5 WR
)URQW 3DUNLQJ $LG 6SHDNHU 
3DUNLQJ $LG 5HPRYDO DQG ,QVWDOODWLRQ
 0HDVXUH WKH UHVLVWDQFH EHWZHHQ WKH IURQW
SDUNLQJ DLG VSHDNHU SLQ  DQG SLQ 

'(7$,/65(68/76$&7,216
7(67 &21',7,216
$ &+(&. 7+( &,5&8,7 *1 )25 23(1
 0HDVXUH WKH UHVLVWDQFH EHWZHHQ WKH SDUNLQJ
DLG PRGXOH & SLQ  FLUFXLW *1
*<:+ KDUQHVV VLGH DQG SDUNLQJ DLG VSHDNHU
& SLQ  FLUFXLW *1 *<:+ KDUQHVV
VLGH

'(7$,/65(68/76$&7,216 7(67 &21',7,216
% &+(&. 7+( '/& &,5&8,7 )25 23(1
0HDVXUH WKH UHVLVWDQFH EHWZHHQ WKH '/& SLQ 
DQG WKH SDUNLQJ DLG PRGXOH & SLQ 
KDUQHVV VLGH

'(7$,/65(68/76$&7,216 7(67 &21',7,216
& &+(&. &,5&8,7 *1 :+*1 )25 6+257 72 *5281'
0HDVXUH WKH UHVLVWDQFH EHWZHHQ WKH SDUNLQJ
DLG PRGXOH & SLQ  FLUFXLW *1 :+*1
KDUQHVV VLGH DQG JURXQG

3,132,17 7(67 (  '7& &  )5217 ,11(5 /()7 6(1625 6,*1$/ &,5&8,7 23(1 25 6+257
72 *5281'
'(7$,/65(68/76$&7,216
7(67 &21',7,216
( &+(&. &,5&8,7 *1 :+%8 )25 23(1
 'LVFRQQHFW 3DUNLQJ DLG PRGXOH &
'LVFRQQHFW 3DUNLQJ DLG VHQVRU &
0HDVXUH WKH UHVLVWDQFH EHWZHHQ WKH SDUNLQJ
DLG PRGXOH & SLQ  FLUFXLW *1 :+%8
KDUQHVV VLGH DQG SDUNLQJ DLG VHQVRU & SLQ
 FLUFXLW *1 :+%8 KDUQHVV VLGH

'(7$,/65(68/76$&7,216 7(67 &21',7,216
0HDVXUH WKH UHVLVWDQFH EHWZHHQ WKH SDUNLQJ
DLG PRGXOH & SLQ  FLUFXLW *1 :+5'
KDUQHVV VLGH DQG SDUNLQJ DLG VHQVRU & SLQ
 FLUFXLW *1 :+5' KDUQHVV VLGH

'(7$,/65(68/76$&7,216
7(67 &21',7,216
* &+(&. ($&+ 3$5.,1* $,' 6(1625 )25 6+257 %(7:((1 3,16  $1' 
 0HDVXUH WKH UHVLVWDQFH RI HDFK SDUNLQJ DLG
VHQVRU EHWZHHQ SLQV  DQG  FRPSRQHQW VLGH

Parking Aid — Vehicles With: Rear Parking Aid
Refer to
Wiring Diagrams Section 413-13, for
schematic and connector information. General Equipment
Ford diagnostic equipment
Principles of Operation
NOTE: The rear parking aid system will be
de-activated when a Ford rear trailer tow module
is attached to the vehicle.
The ultrasonic parking aid system will default to
enabled when the ignition switch is turned to the
RUN position, the system is activated by selecting
reverse gear. The parking aid system will be
disabled if a fault is detected in one of the four rear
parking aid sensors, the parking aid speaker or the
parking aid module. An error tone approximately
3 seconds long will be emitted from the rear parking
aid speaker if a fault is detected. The rear parking
aid speaker will also sound for approximately 3
seconds if an error is detected at each ignition
cycle or if an error is detected when the system
has been activated.
Inspection and Verification
1. Verify the customer concern. 2. Visually inspect for obvious signs of electrical
damage.
Visual Inspection Chart Electrical
– Fuse(s)
– Wiring harness(s)
– Electrical connector(s)
– Battery junction box (BJB)
– Rear parking aid sensor(s)
– Rear parking aid speaker
– Parking aid module
3. If an obvious cause for an observed or reported concern is found, correct the cause (if possible)
before proceeding to the next step
4. If the cause is not visually evident, connect the Ford diagnostic equipment to the data link
connector (DLC) and select the vehicle system
to be tested from the diagnostic menu.
5. Retrieve the Diagnostic Trouble Code (DTC)s and refer to the DTC Index.
6. If no DTCs are retrieved or there is no communication with the module, proceed to the
Symptom Chart to continue diagnostics.
Diagnostic Trouble Codes (DTC) Index
DTC Index Action
Possible Source
Description
DTC
Check the circuit 8-GN22
(WH/GN) for short to battery.
IF the circuit is OK, INSTALL
a new parking aid module.
REFER to:Parking Aid
Module (413-13 Parking
Aid, Removal and Installa-
tion).
TEST the system for normal
operation.
• Parking aid sensor signal
circuit.
• Parking aid module.
Rear outer left sensor signal
circuit short to battery
C1699
GO toPinpoint Test C.
• Parking aid sensor signal
circuit.
• Parking aid sensor.
• Parking aid module.
Rear outer left sensor signal
circuit open or short to
ground
C1700 G295937en
2008.50 Kuga 8/2011 413-13-29
Parking Aid
413-13-29
DIAGNOSIS AND TESTINGTO MODEL INDEX
BACK TO CHAPTER INDEX
FORD KUGA 2011.0MY WORKSHOP REPAIR MANUAL

Action
Possible Source
Description
DTC
CHECK parking aid sensor
for contamination. IF a
parking sensor is OK.
INSTALL a new parking aid
sensor. TEST the system for
normal operation.
•
Rear outer left parking aid
sensor.
Concern with rear outer left
parking aid sensor
C1701
CHECK the circuit 8-GN19
(WH) for short to battery. IF
the circuit is OK, INSTALL a
new parking aid module.
REFER to:Parking Aid
Module (413-13 Parking
Aid, Removal and Installa-
tion).
TEST the system for normal
operation.
• Parking aid sensor signal
circuit.
• Parking aid module.
Rear outer right sensor
signal circuit short to battery
C1702
GO toPinpoint Test D.
• Parking aid sensor signal
circuit.
• Parking aid sensor.
• Parking aid module.
Rear outer right sensor
signal circuit open or short
to ground
C1703
CHECK parking aid sensor
for contamination. IF a
parking sensor is OK.
INSTALL a new parking aid
sensor. TEST the system for
normal operation.
• Rear outer right parking
aid sensor.
Concern with rear outer right
parking aid sensor
C1704
CHECK the circuit 8-GN21
(WH/BU) for short to battery.
IF the circuit is OK, INSTALL
a new parking aid module.
REFER to:Parking Aid
Module (413-13 Parking
Aid, Removal and Installa-
tion).
TEST the system for normal
operation.
• Parking aid sensor signal
circuit.
• Parking aid module.
Rear inner left sensor signal
circuit short to battery
C1705
GO toPinpoint Test E.
• Parking aid sensor signal
circuit.
• Parking aid sensor.
• Parking aid module.
Rear inner left sensor signal
circuit open or short to
ground
C1706
CHECK parking aid sensor
for contamination. IF a
parking sensor is OK.
INSTALL a new parking aid
sensor. TEST the system for
normal operation.
•
Rear inner left parking aid
sensor.
Concern with rear inner left
parking aid sensor
C1707 G295937en
2008.50 Kuga 8/2011 413-13-30
Parking Aid
413-13-30
DIAGNOSIS AND TESTINGTO MODEL INDEX
BACK TO CHAPTER INDEX
FORD KUGA 2011.0MY WORKSHOP REPAIR MANUAL

Action
Possible Source
Description
DTC
CHECK the circuit 8-GN20
(WH/RD) for short to battery.
IF the circuit is OK, INSTALL
a new parking aid module.
REFER to:Parking Aid
Module (413-13 Parking
Aid, Removal and Installa-
tion).
TEST the system for normal
operation.
• Parking aid sensor signal
circuit.
• Parking aid module.
Rear inner right sensor
signal circuit short to battery
C1708
GO toPinpoint Test F.
• Parking aid sensor signal
circuit.
• Parking aid sensor.
• Parking aid module.
Rear inner right sensor
signal circuit open or short
to ground
C1709
CHECK parking aid sensor
for contamination. IF a
parking sensor is OK.
INSTALL a new parking aid
sensor. TEST the system for
normal operation.
• Rear inner right parking
aid sensor.
Concern with rear inner right
parking aid sensor
C1710
GO toPinpoint Test G.
• Parking aid sensors
voltage supply circuits.
Parking aid sensor voltage
supply short to ground
B1299
GO toPinpoint Test H.
• Parking aid module.
• circuit(s).
Parking aid speaker circuit
short to ground
C1742
GO toPinpoint Test I.
• Parking aid module.
• circuit(s).
Parking aid speaker circuit
short to battery
C1743
INSTALL a new parking aid
module.
REFER to:Parking Aid
Module (413-13 Parking
Aid, Removal and Installa-
tion).
TEST the system for normal
operation.
• Parking aid module.
RAM Error
B1342
INSTALL a new parking aid
module.
REFER to:Parking Aid
Module (413-13 Parking
Aid, Removal and Installa-
tion).
TEST the system for normal
operation.
• Parking aid module.
ROM/EEPROM Error
B2477 G295937en
2008.50 Kuga 8/2011 413-13-31
Parking Aid
413-13-31
DIAGNOSIS AND TESTINGTO MODEL INDEX
BACK TO CHAPTER INDEX
FORD KUGA 2011.0MY WORKSHOP REPAIR MANUAL