check engine GMC SIERRA CLASSIC 2007 Repair Manual

Scheduled Maintenance (cont’d)
Service MaintenanceIMaintenanceII
Inspect suspension and steering components.See footnote (b).•
Inspect engine cooling system.See footnote (c).•
Inspect wiper blades.See footnote (d).•
Inspect restraint system components.See footnote (e).•
Lubricate body components.See footnote (f).•
Check transmission uid level and add uid as needed.•
Inspect shields, vehicles with diesel engine or with GVWR above
10,000 lbs (4 536 kg) only.See footnote (n).•
620

Maintenance Footnotes
(Gasoline Engine)
This maintenance section applies to vehicles with
a gasoline engine. If your vehicle has a diesel
engine, see the maintenance schedule section in
the DURAMAX
®Diesel Engine Supplement.
†The U.S. Environmental Protection Agency or
the California Air Resources Board has determined
that the failure to perform this maintenance item
will not nullify the emission warranty or limit
recall liability prior to the completion of the
vehicle’s useful life. We, however, urge that all
recommended maintenance services be performed
at the indicated intervals and the maintenance
be recorded.
#Lubricate the front suspension, steering linkage,
transmission shift linkage, and parking brake
cable guides. Control arm ball joints require
lubrication but should not be lubricated unless
their temperature is 10°F (−12°C) or higher, or they
could be damaged. Vehicles used under severe
commercial operating conditions require lubrication
on a regular basis every 3,000 miles (5 000 km).(a)Visually inspect brake lines and hoses for
proper hook-up, binding, leaks, cracks, chang,
etc. Inspect disc brake pads for wear and rotors for
surface condition. Inspect drum brake
linings/shoes for wear or cracks. Inspect other
brake parts, including drums, wheel cylinders,
calipers, parking brake, etc.
(b)Visually inspect front and rear suspension and
steering system for damaged, loose or missing
parts, signs of wear or lack of lubrication. Inspect
power steering lines and hoses for proper
hook-up, binding, leaks, cracks, chang, etc.
Visually check constant velocity joints, rubber
boots, and axle seals for leaks.
(c)Visually inspect hoses and have them replaced
if they are cracked, swollen, or deteriorated.
Inspect all pipes, ttings and clamps; replace with
genuine GM parts as needed. To help ensure
proper operation, a pressure test of the cooling
system and pressure cap and cleaning the outside
of the radiator and air conditioning condenser is
recommended at least once a year.
(d)Visually inspect wiper blades for wear or
cracking. Replace wiper blades that appear worn
or damaged or that streak or miss areas of
the windshield.
623

(e)Make sure the safety belt reminder light and all
your belts, buckles, latch plates, retractors, and
anchorages are working properly. Look for
any other loose or damaged safety belt system
parts. If you see anything that might keep a safety
belt system from doing its job, have it repaired.
Have any torn or frayed safety belts replaced. Also
look for any opened or broken airbag coverings,
and have them repaired or replaced. The
airbag system does not need regular maintenance.
(f)Lubricate all key lock cylinders, body door
hinges, hood latch assembly, secondary latch,
pivots, spring anchor, release pawl, tailgate hinges,
tailgate linkage, tailgate handle pivot points,
latch bolt, fuel door hinge, locks, and folding seat
hardware. More frequent lubrication may be
required when exposed to a corrosive
environment. Applying silicone grease on
weatherstrips with a clean cloth will make them
last longer, seal better, and not stick or squeak.
(g)Check vent hose at transfer case for kinks and
proper installation.(h)Change automatic transmission uid and lter
if the vehicle Gross Vehicle Weight Rating
(GVWR) is over 8600 lbs or if the vehicle is mainly
driven under one or more of these conditions:
In heavy city traffic where the outside
temperature regularly reaches 90°F (32°C) or
higher.
In hilly or mountainous terrain.
When doing frequent trailer towing.
Uses such as found in taxi, police or delivery
service.
(i)Drain, ush, and rell cooling system. This
service can be complex; you should have
your dealer perform this service. See Engine
Coolant on page 502 for what to use. Inspect
hoses. Clean radiator, condenser, pressure cap,
and ller neck. Pressure test the cooling
system and pressure cap.
(j)A uid loss in any vehicle system could indicate
a problem. Have the system inspected and
repaired and the uid level checked. Add uid if
needed.
624

(k)Inspect system. Check all fuel and vapor lines
and hoses for proper hook-up, routing, and
condition. Check that the purge valve, if the vehicle
has one, works properly.
(m)Change automatic transmission uid and
external transmission lter if the vehicle is mainly
driven under one or more of these conditions:
In heavy city traffic where the outside
temperature regularly reaches 90°F (32°C) or
higher.
In hilly or mountainous terrain.
When doing frequent trailer towing.
Uses such as found in taxi, police, or delivery
service.
(n)Vehicles with diesel engine or with GVWR
above 10,000 lbs (4 536 kg) only: Inspect shields
for damage or looseness. Adjust or replace as
required. This is a Noise Emission Control Service.
Applicable to vehicles sold in the United States
and recommended for vehicles sold in Canada.
(p)If you drive regularly under dusty conditions,
inspect the lter or change indicator (if equipped)
at each engine oil change.(q)Visually inspect belt for fraying, excessive
cracks, or obvious damage. Replace belt if
necessary.
Owner Checks and Services
These owner checks and services should be
performed at the intervals specied to help
ensure the safety, dependability, and emission
control performance of your vehicle. Your
GM Goodwrench
®dealer can assist you with
these checks and services.
Be sure any necessary repairs are completed at
once. Whenever any uids or lubricants are added
to your vehicle, make sure they are the proper
ones, as shown inRecommended Fluids and
Lubricants on page 629.
At the First 100, 1,000 and 6,000
Miles (160, 1 600 and 10 000 km)
Check dual wheel nut torque. For proper torque,
seeCapacities and Specications on page 609.
625

At Each Fuel Fill
It is important to perform these underhood checks
at each fuel ll.
Engine Oil Level Check
Check the engine oil level and add the proper oil if
necessary. SeeEngine Oil (Gasoline Engine)
on page 486for further details.
Notice:It is important to check your oil
regularly and keep it at the proper level. Failure
to keep your engine oil at the proper level
can cause damage to your engine not covered
by your warranty.
Engine Coolant Level Check
Check the engine coolant level and add
DEX-COOL®coolant mixture if necessary. See
Engine Coolant on page 502for further details.
Windshield Washer Fluid Level Check
Check the windshield washer uid level in
the windshield washer uid reservoir and add the
proper uid if necessary.
At Least Once a Month
Tire Ination Check
Visually inspect your vehicle’s tires and make sure
they are inated to the correct pressures. Do not
forget to check the spare tire. SeeInation - Tire
Pressure on page 551. Check to make sure the
spare tire is stored securely. SeeChanging a Flat
Tire on page 564.
Tire Wear Inspection
Tire rotation may be required for high mileage
highway drivers prior to the Engine Oil Life System
service notication. Check the tires for wear
and, if necessary, rotate the tires. SeeTire
Inspection and Rotation on page 553.
626

At Least Once a Year
Starter Switch Check
{CAUTION:
When you are doing this inspection, the
vehicle could move suddenly. If the
vehicle moves, you or others could be
injured.
1. Before you start, be sure you have enough
room around the vehicle.
2. Firmly apply both the parking brake and the
regular brake. SeeParking Brake on
page 169.
Do not use the accelerator pedal, and be
ready to turn off the engine immediately if
it starts.
3. Try to start the engine in each gear. The
vehicle should start only in PARK (P) or
NEUTRAL (N). If the vehicle starts in any
other position, contact your GM Goodwrench
®
dealer for service.
Automatic Transmission Shift Lock
Control System Check
{CAUTION:
When you are doing this inspection, the
vehicle could move suddenly. If the
vehicle moves, you or others could be
injured.
1. Before you start, be sure you have enough
room around the vehicle. It should be parked
on a level surface.
2. Firmly apply the parking brake. SeeParking
Brake on page 169.
Be ready to apply the regular brake
immediately if the vehicle begins to move.
3. With the engine off, turn the ignition to RUN,
but do not start the engine. Without applying
the regular brake, try to move the shift
lever out of PARK (P) with normal effort. If the
shift lever moves out of PARK (P), contact
your GM Goodwrench
®dealer for service.
627

Park on a fairly steep hill, with the vehicle facing
downhill. Keeping your foot on the regular
brake, set the parking brake.
To check the parking brake’s holding ability:
With the engine running and transmission in
NEUTRAL (N), slowly remove foot pressure
from the regular brake pedal. Do this until the
vehicle is held by the parking brake only.
To check the PARK (P) mechanism’s holding
ability: With the engine running, shift to
PARK (P). Then release the parking brake
followed by the regular brake.
Contact your GM Goodwrench
®dealer if service is
required.
Underbody Flushing Service
At least every spring, use plain water to ush any
corrosive materials from the underbody. Take
care to clean thoroughly any areas where mud and
other debris can collect.
Recommended Fluids and
Lubricants
This maintenance section applies to vehicles with
a gasoline engine. If your vehicle has a diesel
engine, see the maintenance schedule section in
the DURAMAX
®Diesel Engine Supplement.
Fluids and lubricants identied below by name,
part number, or specication may be obtained from
your dealer.
Usage Fluid/Lubricant
Engine OilEngine oil which meets
GM Standard GM6094M and
displays the American Petroleum
Institute Certied for Gasoline
Engines starburst symbol.
GM Goodwrench
®oil meets all the
requirements for your vehicle. To
determine the proper viscosity for
your vehicle’s engine, seeEngine
Oil (Gasoline Engine) on page 486.
Engine Coolant50/50 mixture of clean, drinkable
water and use only DEX-COOL
®
coolant. SeeEngine Coolant on
page 502.
629

Bulb Replacement (cont.)
Headlamps............................................... 533
License Plate Lamps................................ 541
Pickup Box Identication and Fender
Marker Lamps...................................... 538
Replacement Bulbs.................................. 541
Roof Marker Lamps................................. 535
Taillamps, Turn Signal, Stoplamps
and Back-up Lamps.............................. 539
Buying New Tires........................................ 556
C
Calibration..........................................176, 180
California Fuel............................................. 471
California Proposition 65 Warning................ 469
Canadian Owners........................................... 3
Capacities and Specications...................... 609
Carbon Monoxide..............127, 174, 402, 429
Care of
Safety Belts............................................. 592
Your Cassette Tape Player....................... 350
Your CD and DVD Player........................ 352
Your CDs and DVDs................................ 352
Cargo Lamp................................................ 228
Center Console Storage Area...................... 202Center Front Passenger Position,
Safety Belts............................................... 37
Center High-Mounted Stoplamp
(CHMSL) and Cargo Lamp...................... 537
Chains, Tire................................................. 562
Check
Engine Light............................................ 258
Checking Things Under the Hood ................ 478
Chemical Paint Spotting .............................. 596
Child Restraints
Child Restraint Systems............................. 51
Infants and Young Children........................ 47
Lower Anchors and Tethers
for Children............................................ 58
Older Children........................................... 44
Securing a Child Restraint in a
Rear Seat Position................................. 71
Securing a Child Restraint in the
Center Front Seat Position..................... 74
Securing a Child Restraint in the Right
Front Seat Position (Crew Cab).............. 74
Securing a Child Restraint in the Right
Front Seat Position (Regular and
Extended Cab)................................ 78, 85
Where to Put the Restraint........................ 55
Chime Level Adjustment .............................. 353
661

Engine (cont.)
Check and Service Engine Soon Light..... 258
Coolant.................................................... 502
Coolant Heater......................................... 139
Coolant Temperature Gage...................... 256
Drive Belt Routing.................................... 633
Engine Compartment Overview................ 480
Exhaust................................................... 174
Fan Noise................................................ 514
Oil ........................................................... 486
Oil Life System........................................ 489
Overheated Protection Operating Mode.... 508
Overheating............................................. 505
Starting.................................................... 137
Entry Lighting.............................................. 227
Event Data Recorders (EDR)...................... 650
Exit Lighting................................................ 227
Extender, Safety Belt..................................... 43
F
Filter
Engine Air Cleaner................................... 491
Finish Damage............................................ 596
Fixed Mast Antenna.................................... 353
Flashers, Hazard Warning........................... 212Flash-to-Pass.............................................. 216
Flat Tire...................................................... 563
Flat Tire, Changing...................................... 564
Flat Tire, Storing......................................... 584
Fluid
Automatic Transmission...................494, 497
Manual Transmission................................ 500
Power Steering........................................ 515
Windshield Washer.................................. 516
Fog Lamps.................................................. 225
Four-Wheel Drive...............................153, 528
Four-Wheel-Drive Light................................ 263
Front Axle................................................... 529
Front Reading Lamps.................................. 227
Front Storage Area...................................... 202
Fuel............................................................ 470
Additives.................................................. 472
California Fuel.......................................... 471
E85 (85% Ethanol)................................... 473
Filling a Portable Fuel Container.............. 477
Filling Your Tank...................................... 474
Fuels in Foreign Countries....................... 474
Gage....................................................... 264
Gasoline Octane...................................... 470
Gasoline Specications............................ 471
Low Warning Light................................... 265
664

Fuses
Center Instrument Panel Fuse Block........ 602
Fuses and Circuit Breakers...................... 600
Instrument Panel Fuse Block................... 600
Underhood Fuse Block............................. 603
Windshield Wiper..................................... 599
G
Gage
Engine Coolant Temperature.................... 256
Fuel......................................................... 264
Oil Pressure............................................. 262
Speedometer........................................... 246
Tachometer.............................................. 246
Transmission Temperature........................ 257
Voltmeter Gage........................................ 253
Garage Door Opener..........................191, 192
Gasoline
Octane..................................................... 470
Specications........................................... 471
Glove Box................................................... 202
GM Mobility Reimbursement Program.......... 643
H
Hazard Warning Flashers............................ 212
Head Restraints............................................ 18
Headlamps.........................................221, 533
Automatic Headlamp System.................... 223
Bulb Replacement.................................... 532
Daytime Running Lamps.......................... 222
Flash-to-Pass........................................... 216
Front Turn Signal, Sidemarker and
Daytime Running Lamps....................... 534
Halogen Bulbs......................................... 532
High/Low Beam Changer......................... 215
On Reminder........................................... 222
Pickup Box Identication and Fender
Marker Lamps...................................... 538
Roof Marker Lamps................................. 535
Heated Seats................................................ 11
Heater................................................230, 231
Heater......................................................... 235
Highbeam On Light..................................... 263
Highway Hypnosis....................................... 399
Hill and Mountain Roads............................. 400
Hood
Checking Things Under............................ 478
Release................................................... 479
665