d 16 HONDA CIVIC 1996 6.G Workshop Manual

rlr
*='96-98 models
\c50?(Iermlnals 11-16)PHOTO 51vtEw 56
DASH LIGHTSBRIGHTNESSCONTBOLLER4.I HAZARDI WARNING
i swrTcHa vtEw 32
I
I
IJ
3mllnput I
Olmsignalinput
BLK
Ia3)
r;
t;
lir
Lr2)'t9(,A
\
1 cRUrsEI CoNTROLi MAINI swrTcH
.l REAR ;I wrNDow ,
: DEFOG. .
I GER :
I swrrcH ,
STEREORADIOTUNERc96,'98models)
vlEW 68orAUDIOUNIT(99-'00models)
S€€ GroundDistributjon,page 1.{-7.I
I
IJ
""[__
ffermlnals 7-lo) : G401iHorost P4ofo 57
I
lr
I
I
f
i$9Y
114-1

Ceiling Light, Trunk Light, and Spotlights
LT GRN/ALK
'96.98 USA: CX, DX'96.[98 Canada: All
'96-'98 USA:LX, EX, and HX
'98: GX'99100: All except DX
UNIT
"""*f,*u*
iiffiinFll,+l*
Lisi___i
c411
vtEw 6a
- - - Canadar EX and Si - - -
''"o","." 2 sEcuRlTY-;,;( 3[t"l'$,o"C516 (OpTtON)PHO|O 73vtEw 58
i Door open i /,Ew z5 Wft
Lsl__j [:tf*"Y
., o"n I"tol .ro"n,r.o 2 g5ggi.tw
?- coNNECroR ,
I "';'16 ''u (ott'o"l iI vtEw 58-----l-
lt
iGFNi REo
i
t
ITGFN/RED
13LTGRN/RED
See PowerDoor Locksirruot L-T:i"iiy @o
* = '99-'00 models except cX
IT GRN/fiED
LT GFN/AEO
11(- 15)
LT GAN/RED
c401
- Sedan -
RIGHT ;REARDOORSWITCH :Closed with ;door open. ,
LEFTREARDOORswtTcHClosed withdoor open.
--azt
*'*"n
6n
LT GRN/FEO
LT GFN/
i
- - - -
;'T
- - - - -
I iig",BP'f;""
ii$fltfi'J$T'*"'=""'
"
L----:+-----Jf
ii ln*i1,,
""**".!,
q;,{"i};}',,Hgt:$
pHoro 96 - door o
LT
114-2

\,f
r=Male-Female
terminals aeversedfor'99-'00 models
Se€ Pow€rDisfibution,pag61o-t0.
_J_____ __J PHoto 58
:I
DASHFUSE/RELAYBOX
20
-",,".'"f ftTll,'
Hatchback I Coupe & S€dan
H'**
\,,
A sxcept'9$'98 SedanwilioutMoonroof
c407
(vtEw 2
'95-'98
SedanwithoutMoonroo{
fr (e6-
lt
lt
I
I
INot used
Seo GroundDistdbution,pags t+10ot 1+1'l.
"'"ll
^ BLU/ALK I
in?i"",o." 19
arn""r"aol
:
::.:ix:
qmgswrTcHClosed withtrunk open.c407
(v/Fw2 98r0o mod€rs)"il
\
)-rra
"*l
PHOTO 102
LT GAN/EIK or lT GRN/RED
+
114-3

Power Windows
- Driver's Door and Front Passenger Door
FUSE 24
{s/n nElav)
Se€ PowefDistribution,page 106.
l' l-'G'-.i
- -
I i',I3.',8J39"
i ) lo1*" **oo*
i f,?T" ,
L-9------J'rF,*%,
*rtier-u |
'ry'
6I i[ff'3"
PowER !wtNDow IRELAYPHOfO 6S
see GroundDistribution,page 14-7.
I
I
I\
\
I
D ver'5SwitchContrslUnlt
POWERwtNDowMASTERswtTcrlPHATO 88vlEw 36
I
I
I
(Sedan A4)8(Sedan A5)
REO/^YEL
1
FED or aEO/BLU
(Sedan A7)4
RED/BLU
(Sedan A6)12
ALU
c633
YEL o. REo/YELLT BLU oT BLU
DRIVER'SwlNDowMOTOR
BLK
4
ALK
c633
See GroundDistribution,page 14-7.
I
I
I
See Ground Distibution,page 14€.
.---+<- G401PHOIA 57
0
c42O I Y C552
ii,?;?,* "., ".* ! f[fflo,u,
2 e C556".,,".* | f[ff11r,1 (Sedan A3) l
12
G551

\
t
\
7and8on Jollowingp490.
liiciio'u
I
I
I
c653
GNN/BLK
1
GRN/ALK
1
c552
vtEw22c557PHOIO 93vtEw 62
\
FRONTPASSENGER'SwtNDowMOTOR
FRONTPASSENGER'SwtNDowswtTcH
lwrNDowI MASTER: swrTcHI PHO|O 88
lvtEw J6
I
*l]o,,-Goow{ -UPC}FF
BLU/YEL
Motor has a sell-reseftingcircuit breaker.
7(Sedan Al)
Frod PasSengsr'aSwichSae Left and Hight IRear Swilches :----.,:,1":l -,:l--J
\
(cont'd)
| *:""fi:{t Distribution'
I
-t
"'-!r+J
120-1

Power Windows (cont'd)
- Rear Doors
BEDAI/IITBEDAV}IT
c5?rPtlQTO 99VIEW 6
LEFTREARwtNDowswtTcH
LEFTREARwtNDowMOTOR
Motor has a selt-reseningcircuit breaker2
YEUGBN
1
Lai Rraar Sfiici
c571PHOTO
--
c556
vtEw 61
99
z
93
FEOAIVHTGRN,^/EL
10
GRN,^TEL
A14
| | Sos Front Passonoer's i
-siq-r"a{::l=-.i
qR|i
11
GFN
At6
:I
I 3s"qni'
"-l-'J
il
POWERwlNDowMASTEBSWITCH
vtEw 36
DOWiItp
Oisuibdion,
120-2

\
r--------.|UNDER.DASHr I FUSE/RELAY, I rur
t' f -,,--" J iFiona
5l'.il;;, i-l
l"o^ |L------- -"f-_-_=--_-=*"Er---,
vtEw 22
c570PHOfO 99
RIGHTREARwtNDowMOTOR
Motor has aself-resetiingcircurt breaker.
BLUMHT Ior REO nED/BLU
"ru"ao IorYEL2 neo,tea 4
c672
RIGHTREARwtNDowSWITCH
\,,YEI
I
YEL
A9POWERwtNDowMASTERSWITCH
vtEw 36
orowt{ofFUP
f
',
120-3

Power Windows (contd)
- How the Circuit Works
CAUTION: You could iniure your arms, hands, or
fingers if you unintentionally switch the driver's
window to "automatic down" while working in
that door with the power on. Disconnect the
window switch conneclot or the battery when
working in the driver's door.
System Description
The operation of the power windows is controlled by
the main switch in the power window master switch.
When the main switch is in OFF, only the driver's door
window can be opened or closed. With the main
switch ON, all windows can be ooened or closed
either by swtches in the master panel, or swttches in
the doors. The driver's window switch also has an
automatic down mode which is tumed on by pushing
the switch down to its second oosition.
The power windows are driven by reversible motors.
Each motor is protect€d by a built-in circuit breaker.
lf the window switch is held on too long (with the
window obstructed, or after the window is fully up or
down), the circuit breaker opens the circuit. The
circuit breaker resets automaticallv as it cools.
Driver's Window
With the ignition switch in ON, voltage is provided to
the coil of the power window relay through fus€ 24.
The contacts of the power window relay close, and
voltage is applied to the driver's switch. When you
push the power window master switch to UP, voltage
is applied to the driver's window motor. (The motor's
ground path is back through the master power
window switch.) The driver's window motor then
drives the window up. When you push the switch to
DOWN, voltage is applied in the opposite direction
and the motor drives the window down.
Automatic Down (Driver's Window)
With the ignition switch in ON or START, voltage is
applied to the coil of the power window relay. The
contacts of the power window relay close and
voltage is applied lo the power window master
switch. When you push the driveas switch to the
AUTO DOWN position, voltage is applied through
the driver's switch to the driver's window motor. The
control unit receives pulses at the pulser input while
the motor is running. When the window is fully
down, the motor stops, and pulses are no longer
generated by the pulser. This is sensed by the
control unit at the pulser input, and voltage is no
longer applied to the driver's window motor.
Passenger Windows
With the ignition switch in ON, voltage is applied to
the coil of the power window relay through fuse 24.
The contacts of the power window relay then close,
applying voltage to the individual window switches
and the power window master switch. With the
master panel main switch ON, the passenger
windows can be ooerated from the individual
window switches or from tho master panel switches.
When you push the front passengsr's window
switch to UP, voltage is applied to the f ront
passenger's window motor. (The motor is grounded
through the contacts in the front passenger's
window switch and the oower window master
switch.) The window moves up as long as you hold
the switch in the UP position. lf you push the switch
to DOWN, voltage is applied in th€ opposite
direction to the front passenger's window motor, and
the window movss down as long as you hold the
switch in the DOWN Dosition. The window switches
in the other doors operate similarly.
When you push the front passenger's switch in the
master panel to UP, voltage is applied through the
front passenger's window switch contacts to the
front passengefs window motor. (The motor is
grounded through the contacts in the front
passenger's window switch and the power window
master switch.) The window moves up as long as
you hold the switch in the UP position. lf you push
the switch to DOWN, voltage is applied in the
opposite direction to lhe front passenger's window
motor, and the window moves down as long as you
hold the switch in the DOWN position. The other
passenger window switches in the master panel
operate similarly.
Refer to the Service Manual (Section 23, Electrical)
for specific tests or troubleshooting procedures.
120-4

Moonroof
'96-'97 Models
@---1 UNDER.DASHFUSE 24(PAV AELAY}(slF FEraY)
GFN/OFN
i-tffil**l ii3-.',BJi9g"
I J lff' liffio,L-*------J9 Y C3s1
""tio"nr ! ffo"tfl,I wxt cnl See PowerOF' Dr$nouton.wHr cRN

C4l9 Page 10-12.
B lii:;?"u'l.-F'I UNDER.DASH! | | ruserneuv
I | | "B-gt..L-*..J " "''""
":.,1 Fl:,""*
IFUSE/RELAY
i""3Io,,
MOONROOFOPENRELAY
vtEw 15
-a
__tu
c7't8
MOONROOFCLOSERELAY
vtEw 13
GFN/BED
'+
To A on thispage.
2 veL
GFN/FEO
c717PHOTO 107 1
MOONROOFMOTOR
OPEN/CLOSEswtTcH
TILT/CLOSEswtTcH
MOONROOFswtTcH
2BLU2
S€e GroundDistributiofl,page 14-7.
OPENcrosETILT
122

'98-'00 Models
@
\
I
I
I
I
---1 UNDER.DASH
c7'12PHOfO s8
trr-ii--'lH$3.'A.|39"
ffi**'iF,?T",-----J
MOONROOFOPENRELAY
MOONROOFclosERELAYPHO|O 51vtEw 13
I Y C3s1
""t,cntr ! fflo"tL'I wrricnl So€ Powsra-> DsrrDul'on
wuicnr ll C419
't" l',i'!,11"*
pag€ t&12.
UTIDER.DASHFUSE/RELAYBOXPHOTO 58
,al ,cl:,z,,
-a
_iu
\lr
-
4s
To splice ontnrs page.
c717
c718
OPEN/CLOSEswrTcH
TILT/CLOSEswficH
MOONROOFswtrcH
29LU
c7t8
o*irCLOAElltl
Sa€ Grolx|dDistribution,pag€ 1+7-
122-1