automatic transmission HONDA PILOT 2006 1.G User Guide

Fluid Locations
238
RADIATOR CAP
ENGINE OIL DIPSTICK
(Orange loop)
BRAKE FLUID
(Gray cap)
WASHER FLUID
(Blue cap)
AUTOMATIC
TRANSMISSION
FLUID DIPSTICK
(Yellow loop)
POWER STEERING
FLUID (Red cap) COOLANT
RESERVOIR
ENGINE OIL FILL CAP

Check the f luid level with the engine
at normal operating temperature.Park the vehicle on level ground.
Shut of f the engine.
Remove the dipstick (yellow loop)
f rom the transmission, and wipe it
with a clean cloth. Remove the dipstick and check
the f luid level. It should be
between the upper and lower
marks. Insert the dipstick all the way into
the transmission.If the level is below the lower
mark, remove the f ill plug and add
f luid into the tube to bring it to the
upper mark.
Always use Honda ATF-Z1
(automatic transmission f luid). If
it’s not available, you may use a
DEXRONIII automatic
transmission f luid as a temporary
replacement. However, continued
use can af f ect the shif t quality.
Have the transmission flushed and
ref illed with Honda ATF-Z1 as
soon as it is convenient. Pour the f luid slowly and caref ully
so you do not spill any. Clean up
any spill immediately; it could
damage components in the engine
compartment.
1.
2. 3.
4.5.
Automatic Transmission Fluid
Automatic Transmission
244
DIPSTICK
DIPSTICK
UPPER MARK
LOWER MARK

If the malf unction indicator lamp
comes on along with the ‘‘D’’
indicator, there is a problem in the
automatic transmission control
system.
Your vehicle has certain ‘‘readiness
codes’’ that are part of the on-board
diagnostics f or the emissions
systems. In some states, part of the
emissions testing is to make sure
these codes are set. If they are not
set, the test cannot be completed.If the battery in your vehicle has
been disconnected or gone dead,
these codes are erased. It
cantake
several days of driving under
various conditions to set the codes
again.
To check if they are set, turn the
ignition switch to the ON (II)
position, without starting the engine.
The malf unction indicator lamp will
come on f or 20 seconds. If it then
goes of f , the readiness codes are set.
If it blinks f ive times, the readiness
codes are not set. If possible, do not
take your vehicle for a state
emissions test until the readiness
codes are set. Ref er to for more
inf ormation (see page ).
If you have recently ref ueled your
vehicle, the indicator could come on
because of a loose or missing f uel f ill
cap. You will also see a ‘‘CHECK
FUEL CAP’’ message on the
inf ormation display. Tighten the cap
until it clicks at least once.
Tightening the cap will not turn the
indicator turn of f immediately; it
can take several days of normal
driving.
If the indicator remains on or the
f uel cap was not loose or missing,
have the vehicle checked by the
dealer as soon as possible. If this indicator comes on
while driving, it means one
of the engine’s emission control
systems may have a problem. Even
though you may f eel no dif f erence in
your vehicle’s perf ormance,
continued operation may cause
serious damage.
296
Malf unction Indicator
Readiness CodesState
Emissions T estingTaking Care of the Unexpected
277
If you keep driving with the
malf unction indicator lamp on, you can
damage your vehicle’s emission
controls and engine. Those repairs may
not be covered by your vehicle’s
warranties.

The transmission number is on a
label on top of the transmission. The engine number is stamped into
the engine block. It is on the f ront.
Identif ication Numbers
T echnical Inf ormation
287
ENGINE NUMBERAUTOMATIC TRANSMISSION NUMBER

µµÎ
Î
Î
Î
µ
ÎÎ Î
Î
Specif ications
288
Dimensions
Weights
Air Conditioning
Battery Capacities1.93 US gal (7.3
)
2.43 US gal (9.2)
4.5 US qt (4.3
)
4.2 US qt (4.0
)
5.3 US qt (5.0
)
20.34 US gal (77.0
)
188.0 in (4,775 mm)
76.5 in (1,943 mm)
ND-OIL8
24.7 26.5 oz (700 750 g) HFC-134a (R-134a)
Length
Width
Height
Wheelbase
Track
66.3 in (1,685 mm)
106.3 in (2,700 mm) 70.5 in (1,790 mm)
Gross vehicle weight rating
Gross combined weight
rating (GCWR) See the tire information label atta-
ched to the driver’s doorjamb.
9,700 lbs (4,400 kg)
Equipped with transmission fluid cooler and power steering
fluid cooler.
The GCWR must be reduced 2 percent for every 1,000 feet (305
meters) of elevation.
Refrigerant type
Charge quantity
Lubricant type 77.5 in (1,968 mm)
71.7 in (1,821 mm)
70.1 in (1,780 mm)
71.3 in (1,811 mm)
66.5 in (1,690 mm)
66.5 in (1,690 mm)
66.7 in (1,694 mm)
12 V 72 AH/20 HR
Capacity Excluding the oil remaining in the engine 0.193 US gal (0.73
)
Including the coolant in the reserve tank and that remaining in the
engine
Reserve tank capacity: 2.79 US qt (2.64
)
4.8 US qt (4.5
)
Fuel tank
Engine
coolant
Engine oil
Automatic
transmission
fluid
Rear
differential
fluid (4WD)
Windshield
washer
reservoir
8.3 US qt (7.9
)
3.5 US qt (3.3
)
8.9 US qt (8.4
)
4.0 US qt (3.8
)
Approx.
1:
2:
1:
2: Front
Rear
4WD
2WD
LX
EX
LX
EX
LX
EX
Front
Rear
4WD
2WD Change
Total
Change
Including
filter
Without
filter
Total
Change
Total
Change 4WD
2WD
4WD
2WD
2
1 1
2

CONT INUED
............................
Capacities Chart .288
.............
Carbon Monoxide Hazard . 57
.............................
Carrying Cargo .193
..............
CAUTION, Explanation of . ii
..........................
CD Changer .131, 134
.......................................
CD Player .130
...
Accessories and Modif ications . 191
ACCESSORY (Ignition Key .......................................
Position) .81
............
Accessory Power Sockets . 101
...........................
AC Power Outlet .102
....................
Additives, Engine Oil . 239
...............
AdvancedAirbagSystem . 30
.............................
Airbag (SRS) .11, 25
..........
Airbag System Components . 25
..............
Air Conditioning System . 106
.....................
Rear A/C Control .113
.......................
Air Pressure, Tires .258
......................................
Antif reeze .242
...............
Anti-lock Brakes (ABS) . 209
...............................
Indicator .63, 210
...................................
Operation .209
..............
Anti-thef t, Audio System . 139
.
Anti-thef t Steering Column Lock . 81
................................
Audio System .115
...
Automatic Seat Belt Tensioners . 23
...
Automatic Lighting Off Feature . 76
.............
Automatic Speed Control . 175
..............
Automatic Transmission . 200
..........................
Capacity, Fluid .288 ...............
Checking Fluid Level . 244
.......................................
Shif ting .200
.
Shif t Lever Position Indicator . 200
................
Shif t Lever Positions . 201
....................
Shif t Lock Release . 203
Battery Charging System ...........................
Indicator .62, 276
............................
Jump Starting .272
..............................
Maintenance .262
............................
Specif ications .289
..............................
Bef ore Driving .185
..................................
Belts, Seat .10, 21
...........................
Beverage Holders .99
..................................
Booster Seats .54
Brakes ...........
Anti-lock System (ABS) . 209
.............
Break-in, New Linings . 186
....................
Bulb Replacement .252
...........................................
Fluid .246
.........................................
Parking .97
.................
System Indicator . 63,278
........................
Wear Indicators .209 .............................
Braking System .208
.................
Break-in, New Vehicle . 186
..
Brightness Control, Instruments . 76
........................
Brights, Headlights .75
Bulb Replacement ..........................
Back-up Lights .252
.....................
Brake Lights .252, 253
................
Front Parking Lights . 249
........
Front Side Marker Lights . 249
.................................
Headlights .248
........
High-mount Brake Lights . 253
.................................
Rear Bulbs .252
............................
Specif ications .289
.............
Turn Signal Light . 249,252
..............................
Bulbs, Halogen .248
Index
A
B
C
INDEX
I

........................
Certif ication Label .286
............................................
Chains .261
....................
Changing a Flat Tire .267
Change Oil ........................................
How to .240
......................................
When to .229
...
Charging System Indicator . 62,276
............
Checklist, Bef ore Driving . 198
..................
Childproof Door Locks . 83
Child Seats .........................................
LATCH .47
..........
Tether Anchorage Points . 51
...............
Climate Control System . 112
.........................
Clock, Setting the .140
.....................
Code, Audio System .139
........................
CO in the Exhaust .293
............
Cold Weather, Starting in . 199
......................
Compact Spare Tire .266
...................
Console Compartment . 99
.................
Consumer Inf ormation . 300
.............
Controls, Instruments and . 59
Coolant ........................................
Adding .242
....................................
Checking .189
.........................
Proper Solution .242
...................
Temperature Gauge . 71...................
Conversation Mirror .100
Crankcase Emissions Control ........................................
System .293
............
Cruise Control Operation . 175
....
Customer Service Inf ormation . 300
................
DANGER, Explanation of . ii
...................................
Dashboard .4, 60
................
Daytime Running Lights . 76
Daytime Running Lights .......................................
Indicator .67
.................................
Dead Battery .272
............
Def ects, Reporting Saf ety . 302
................
Def ogger, Rear Window . 77
......
Def rosting the Windows . 108,110
....................................
Dimensions .288
...............
Dimming the Headlights . 75
Dipstick ..........
Automatic Transmission . 244
..................................
Engine Oil .189
....................
Directional Signals . 66,75
........
Disc Brake Wear Indicators . 210
.....................
Disposal of Used Oil .241 Doors
..............
Locking and Unlocking . 82
..........
DOT Tire Quality Grading . 290
...........
Driver and Passenger Safety . 7
...........................................
Driving .197
....................................
Economy .190
...................................
DVD Player .142
........
DVD Player Error Message . 171
..............................
Economy, Fuel .190
............
Emergencies on the Road . 265
.............
Battery, Jump Starting . 272
...........
Brake System Indicator . 278
................
Changing a Flat Tire . 267
.....
Charging System Indicator . 276
..................
Checking the Fuses . 279
.....
Low Oil Pressure Indicator . 276
...
Malf unction Indicator Lamp . 277
..................
Overheated Engine . 274
...........................
Emergency Brake .97
......................
Emergency Flashers .77
.......................
Emissions Controls .293
.............
Emissions Testing, State . 296
Index
D
E
II
Emergency Towing .......................278

CONT INUED
Engine....
Coolant Temperature Gauge . 71
Malf unction Indicator ................................
Lamp .62, 277
........
Oil Pressure Indicator . 62,276
..............
Oil, What Kind to Use . 239
...............................
Overheating .274
............................
Specif ications .289
............................
Speed Limiter .202
.......................................
Starting .199
.
Evaporative Emissions Controls . 293
...............................
Exhaust Fumes .57
Exhaust Gas Recirculation ........................................
System .294
Expectant Mothers, Use of Seat ........................................
Belts by .19
...............
Gas Mileage, Improving . 190
.........................................
Gasoline .186
...............
Fuel Reserve Indicator . 67
...........................................
Gauge .70
................
Octane Requirement . 186
........................
Tank, Filling the .187
................
Gas Station Procedures . 187Gauges
...
Engine Coolant Temperature . 71
...............................................
Fuel .70
GAWR (Gross Axle Weight .......................................
Rating) .214
GCWR (Gross Combined Weight .......................................
Rating) .214
............
Gearshif t Lever Positions . 200
........................................
Glove Box .99
GVWR (Gross Vehicle Weight .......................................
Rating) .214
.............
Halogen Headlight Bulbs . 248
.................
Hazard Warning Button . 77
...................................
Fan, Interior .106
.........................................
Features .105
....................
Filling the Fuel Tank . 187
Filters ...............................................
Oil .240
.............
Flashers, Hazard Warning . 77
...................
Flat Tire, Changing a . 267Fluids
..........
Automatic Transmission . 244
..........................................
Brake .246
..........................
Power Steering .247
................
Windshield Washers . 243
...................
Folding the Third Seat . 89
..........................
Four-way Flashers .77
.................................................
Fuel .186
...............................
Cap Message .72
......................
Fill Door and Cap .187
...........................................
Gauge .70
................
Octane Requirement . 186
........................
Reserve Indicator .67
........................
Tank, Filling the .187
.....................
Fuses, Checking the .279
Index
F GH
INDEX
III

...................
Radiator Overheating . 274
.............
Radio/CD Sound System . 115
...........................
Readiness Codes .296
...............................
Rear A/C Unit .113
............
Rear Audio Control Panel . 147
........
Rear Entertainment System . 142
..
Rear Lights, Bulb Replacement . 252
.
Rear View Camera and Monitor . 184
............................
Rear View Mirror .92
.................
Rear Window Def ogger . 77
.
Rear Window Wiper and Washer . 74
..........
Reclining the Seat Backs . 87-90
.............................
Reminder Lights .61
...............
Remoto Audio Controls . 138
.................
Remote Control (RES) . 169
.......................
Remote Transmitter .83
Replacement Inf ormation ................
Engine Oil and Filter . 240
.................................
Floor Mats .254
..........................................
Fuses .279
................................
Light Bulbs .248
........................................
Minder .235
................................
Timing Belt .245
...........................................
Tires .259 .............................
Wiper Blades .255
Replacing Seat Belts Af ter a ............................................
Crash .23
...
Reserve Tank, Engine Coolant . 189
...............................
Restraint, Child .38
..................
Reverse Gear Position . 201
................................
Rotation, Tire .259
......................................
Saf ety Belts .10
............
Safety Defects, Reporting . 302
.................................
Saf ety Features .9
.........................................
Airbags .11
.....................................
Seat Belts .10
.............
Saf ety Labels, Location of . 58
...............................
Saf ety Messages .ii
.........................................
Seat Belts .10
...............
Additional Information . 21
Automatic Seat Belt ...............................
Tensioners .23
.....................................
Cleaning .254
......................
Lap/Shoulder Belt .22
................................
Maintenance .23
Reminder Light and ................................
Beeper .21, 62 ...................
System Components . 25
...............
Use During Pregnancy . 19
...
Wearing a Lap/Shoulder Belt . 15
....................................
Seat Heaters .86
.................................................
Seats .87
............
Folding the Second Seat . 89
...............
Folding the Third Seat . 90
..........................
Head Restraints .91
.........
Reclining the Second Seat . 89
............
Reclining the Third Seat . 90
.......................
Third Seat Access .89
...................
Seats, Adjusting the . 87-90
............................
Security System .174
...............................
Serial Number .286
...........................
Service Intervals .229
.............................
Service Manual .303
.........
Service Station Procedures . 187
..........................
Setting the Clock .140
Shif ting the Automatic .............................
Transmission .200
.....
Shif t Lever Position Indicator . 200
........................
Shif t Lock Release .203
Side Marker Lights, Bulb .........................
Replacement in .249
..............................
Side Airbags .11, 31
..........................
Of f Indicator .34, 63
Index
R
S
VI

...............................................
Tires .257
..............................
Air Pressure .257
.........................
Checking Wear .258
..........................
Compact Spare .266
......
DOT Tire Quality Grading . 290
......................................
Inf lation .257
..................................
Inspection .258
..............................
Maintenance .259
...................................
Replacing .260
......................................
Rotating .259
...........................................
Snow .260
............................
Specif ications .289
...................
Tools, Tire Changing . 267
Towing .....................................
A Trailer .213
....
Equipment and Accessories . 219
.......................
Traction Devices .261
.............................
Weight Limit .215
......................
Trailer Driving Tips .220
Transmission ...............
Checking Fluid Level . 244
...........................
Fluid Selection .244
..............
Identif ication Number . 286
.............
Shif ting the Automatic . 200.....................................
Treadwear .290
.......................................
Trip Meter .70
....................................
Turn Signals .75
Unexpected, Taking Care ..........................................
of the .265
....
Unif orm Tire Quality Grading . 290
........................
Unleaded Gasoline .186
.......
Used Oil, How to Dispose of . 241
................................
Vanity Mirror .101
.................
Vehicle Capacity Load . 194
......................
Vehicle Dimensions .288
....
Vehicle Identif ication Number . 286
Vehicle Stability Assist (VSA) ....................................
System .211
.........................
VSA Of f Switch .212
.............................
Vehicle Storage .263
.................................................
VIN .286
..................................
Viscosity, Oil .239
..................................
VTM-4 Lock .204 .............
WARNING, Explanation of . ii
.........
Warning Labels, Location of . 58
....................
Warranty Coverages .301
Washer, Windshield ........
Checking the Fluid Level . 243
............................
Level Indicator .67
.....................................
Operation .74
Wheels ...............
Adjusting the Steering . 78
............
Alignment and Balance . 259
..........................
Compact Spare .266
...............................
Nut Wrench .269
Windows ..................
Operating the Power . 94
...........................
Rear, Def ogger .77
Windshield ...........................
Def roster .108, 110
.......................................
Washers .74
Wipers, Windshield .......................
Changing Blades .255
.....................................
Operation .74
Rear Window Wiper and .....................................
Washer .74
..................
Wireless Headphones . 172
Index
U
V W
VIII
Emergency Wrecker ................
.278