ignition HONDA S2000 2004 2.G Owner's Guide

Turn the ignition switch to LOCK
(0). Make sure the headlights and
all other accessories are off.
Remove the cover f rom the f use
box.
Check each of the large f uses in
the under-hood f use box by
looking through the top at the wire
inside. Remove the screws with a
Phillips-head screwdriver.Check the smaller f uses in the
under-hood f use boxes and all the
fuses in the interior fuse box by
pulling out each one with the f use
puller provided in the primary
under-hood f use box.
Look f or a burned wire inside the
f use. If it is burned, replace it with
oneof thesparefusesof thesame
rating or lower.
If you cannot drive the vehicle
without f ixing the problem, and you
do not have a spare fuse, take a fuse
of the same rating or a lower rating
f rom one of the other circuits. Make
sureyoucandowithoutthatcircuit
temporarily (such as the accessory
power socket or radio).
If you replace the blown f use with a
spare f use that has a lower rating, it
might blow out again. This does not
indicate anything wrong. Replace the
f use with one of the correct rating as soon as you can.
If the replacement fuse of the
same rating blows in a short time,
there is probably a serious
electrical problem in your vehicle.
Leave the blown fuse in that
circuit, and have your vehicle
checked by a qualif ied mechanic.
If the radio f use is removed, the
audio system will disable itself . The
nexttimeyouturnontheradioyou
will see ‘‘Code’’ in the f requency
display. Use the preset buttons to
enter the f ive-digit code (see page ).
1.
2.
3. 4.
5.
6.
94
Fuses
T aking Care of t he Unexpect ed171
NOTICE:
BLOWN
Replacing a f use with one
that has a higher rating greatly
increases the chances of damaging the
electrical system. If you do not have a
replacement f use with the proper rating
f or the circuit, install one with a lower
rating.

µ
µµ
µ
µ
Î
Î
No. Amps.No. Amps. Circuits Protected
Circuits Protected
1
2
3
4
5
6
7
8
9
10
11
12
13 7.5 A
15 A
10 A
20 A
7.5 A 15 A
7.5 A
15 A
7.5 A 15 A
10 A 14
15
16
17
18
19
20
21
22
23
24
25
26
2710 A
10 A
7.5 A
7.5 A 10 A
15 A
7.5 A
7.5 A
7.5 A 20 A
20 A Daytime Running Lights
Keyless Entry
Back-up
Interior Light
Small Lights
Radio
Starter Signal
Heater Control,
Cooling Fan Relay
Power Mirrors
Right Power Window
Lef t Power Window
Not used
Not used
Not used
Windshield Wiper,
Auto Stop Signal
Washer Motor
Not used
Not used
Accessory Socket
Windshield Wiper
Turn signal Light
ACG
Instrument Light, Backup
Lights
Ignition Coil
Engine Start
Fuel Pump, SRS
SRS
: Canadian Model
Fuse Locations
T aking Care of t he Unexpect ed172
I IN NT TE
ER
RI IOOR R F
FU
US SEE B
BOOX X

Thediagramsinthissectiongive
you the dimensions and capacities of
your Honda, and the locations of the
identif ication numbers. It also
includes inf ormation you should
know about your vehicle’s tires and
emissions control systems.................
Identif ication Numbers . 178
................................
Specif ications .180
DOT Tire Quality Grading ......................
(U.S. Vehicles) .182
.................................
Treadwear .182
......................................
Traction .182
.............................
Temperature .183
.................................
Tire Labeling .184 .......................
Emissions Controls .185
.....................
The Clean Air Act .185
Crankcase Emissions Control ....................................
System .185
Evaporative Emissions Control ....................................
System .185
...
Exhaust Emissions Controls . 186
....................
PGM-FI System .186
Ignition Timing Control ................................
System .186
Secondary Air Injection ................................
System .186
Three Way Catalytic ...........................
Converter .186
....................
Replacement Parts . 186
Onboard Ref ueling Vapor ................................
Recovery .186
..
Three Way Catalytic Converter . 187
..............
State Emissions Testing . 188
T echnical Inf ormat ion
T echnical Inf ormation177

The exhaust emissions controls
include f our systems: PGM-FI,
Ignition Timing Control, Secondary
Air Injection System, and Three Way
Catalytic Converter. These four
systems work together to control the
engine’s combustion and minimize
the amount of HC, CO, and NOx that
comes out the tailpipe. The exhaust
emissions control systems are
separate f rom the crankcase and
evaporative emissions control
systems.
The PGM-FI System uses sequential
multiport f uel injection.
It has three subsystems: Air Intake,
Engine Control, and Fuel Control.
The Engine Control Module (ECM)
uses various sensors to determine
how much air is going into the
engine. It then controls how much
f uel to inject under all operating con-
ditions.During engine warm-up, air is
pumped into the exhaust to reduce
emissions when the engine is cold.
The three way catalytic converter is
in the exhaust system. Through
chemical reactions, it converts HC,
CO, and NOx in the engine’s exhaust
to carbon dioxide (CO ), nitrogen
(N ), and water vapor.
The emissions control systems are
designed and certif ied to work to-
gether in reducing emissions to
levels that comply with the Clean Air
Act. To make sure the emissions
remain low, you should use only new
Honda replacement parts or their
equivalent f or repairs. Using lower
qualitypartsmayincreasethe
emissions f rom your vehicle.
The emissions control systems are
covered by warranties separate from
the rest of your vehicle. Read your
warranty manual f or more informa-
tion.
The Onboard Ref ueling Vapor
Recovery (ORVR) system captures
the f uel vapors during ref ueling. The
vapors are adsorbed in a canister
f illed with activated carbon. While
driving, the f uel vapors are drawn
into the engine and burned of f .
This system constantly adjusts the
ignition timing, reducing the amount
of HC, CO, and NOx produced.
2
2
Emissions Cont rols
T echnical Inf ormation
Exhaust Emissions Controls
Onboard Ref ueling Vapor
Recovery Replacement Parts
PGM-FI Syst emSecondary A ir Inject ion Syst em
Three Way Catalytic Converter
Ignit ion T iming Cont rol Syst em
186

CONT INUED
Accessories.................................
Installation .105
...............
Accessory Power Socket . 70
ACCESSORY (Ignition Key .......................................
Position) .53
....................
Additives, Engine Oil . 130
...............................
Airbag (SRS) .9, 18
..............................
Air Conditioning .74
.......................
Air Pressure, Tires .146
.............................
Alarm, Anti-theft .53
......................................
Antif reeze .132
Anti-lock Brakes (ABS) ....................
Indicator Light .41, 118
...................................
Operation .117
.
Anti-thef t Steering Column Lock . 53
............................
Anti-thef t System .94
......................................
Audio Panel .71
..................................
Audio System .78
...............
Automatic Speed Control . 95 ............................
Capacities Chart .180
.............
Carbon Monoxide Hazard . 34
........................
Cargo, .107
..............
CAUTION, Explanation of . ii
...........................................
CD Care .85
........................
CD Error Messages .86
.....................................
CD Changer .84
.......
CD Changer Error Messages . 87
.........................................
CD Player .83
........................
Certif ication Label .178
...................................
Chains, .150
Changing Oil ........................................
How to .130
......................................
When to .121
....................
Changing a Flat Tire .155
...
Charging System Indicator . 40,166
............
Checklist, Bef ore Driving . 112
........
Back-up Light Replacement . 141Battery
Charging System ...........................
Indicator .40, 166
............................
Jump Starting .162
..............................
Maintenance .151
............................
Specif ications .181
................................
Bef ore Driving .99
....................................
Belts,Seat .8,15
.............................
Beverage Holder .70
..................................
Booster Seats .31
............................................
Brakes .116
...........
Anti-lock System (ABS) . 117
.............
Break-in, New Linings . 100
...........................................
Fluid .136
.........................................
Parking .67
.................
System Indicator . 40,168
..............
Wear Indicators, Disc . 117
.............................
Braking System .116
.................
Break-in, New Vehicle . 100
..
Brightness Control, Instruments . 49
........................
Brights, Headlights .48
.........................
Bulb Replacement .137
..........................
Back-up Lights .141
.................................
Headlights .137
...........
Side Turn Signal Lights . 139
............................
Specif ications .181 ............
Turn Signal Lights . 139,141
..............................
Bulbs, Halogen .137
how to carry
tires
Index
B A C
I

....................................
Hood Latch .135
.......................
Hood, Opening the .102
...........................
Hydraulic Clutch .136
................
Jacking Up the Vehicle . 156
.......................................
Jack, Tire .155
................................
Jump Starting .162
..................................................
Keys .51 .........................
Label, Certif ication .78
.................
Lane Change, Signaling . 48
..................
Lap/Shoulder Belts . 12,15
Lights ....................
Bulb Replacement .137
.......................................
Indicator .40
..................................
Turn Signal .48
.....................................
Load Limit .108
...............................
Loading Cargo .107
......
LOCK (Ignition Key Position) . 53
Locks .......
Anti-thef t Steering Column . 53
............................
Fuel Fill Door .101
.................................
Power Door .54
...........................................
Trunk .54
........................
Low Coolant Level .103
...
Lower Gear, Downshif ting to a . 114
.........................
Low Fuel Indicator .42
...
Low Oil Pressure Indicator . 40,166
...
Lubricant Specif ications Chart . 180
...............
Luggage, .107
Identif ication Number,
.......................................
Vehicle .178
Ignition ..............................................
Keys .51
...........................................
Switch .53
............
Timing Control System . 186
Indicator Lights, Instrument .........................................
Panel .40
..............
ABS (Anti-Lock Brake) . 41
Brake (Parking and Brake ....................................
System) .40
........................
Charging System .40
.............................
Cruise Control .42
....................................
Door-open .41
DRL(Daytime Running ......................................
Lights) .42
EPS (Electrical Power ..................................
Steering) .41
...................................
High Beam .42
........
Key (Immobilizer System) . 42......................................
Low Fuel .42
........................
Low Oil Pressure .40
...............
Maintenance Required . 43
.......................................
Seat Belt .40
...............................................
SRS .41
..................................
Trunk-open .41
Turn Signal and Hazard ...................................
Warning .42
...................
Inf lation, Proper Tire . 146
...................................
Inside Mirror .66
.............................
Inspection, Tire .147
............................
Instrument Panel .39
........
Instrument Panel Brightness . 49
.................................
Interior Lights .68
........................................
Introduction .i
storing (cargo)
Index
I
J
KL
IV

CONT INUED
..............
Panel Brightness Control . 49
.................................
Parking Brake .67
.................................
Parking Lights .48
.............................
PGM-FI System .186
Power ..................................
Door Locks .54
..............
Engine, Specif ications . 180
.........................................
Mirrors .66
......................................
Windows .59
..........................
Power Door Locks .54
..................
Power Socket Location . 70..............................
Power Windows .59
.........
Pregnancy, Using Seat Belts . 14
.........
Protecting Adults and Teens . 10
...
Additional Safety Precautions . 15
.....
Advice f or Pregnant Women . 14
........................
Protecting Children .22
.....................
General Guidelines .22
.......
Protecting Larger Children . 30
.........
Protecting Small Children . 26
..................................
Maintenance .119
Owner’s Maintenance ...................................
Checks .122
........................................
Record .125
....................................
Schedule .121
..
Maintenance Required Indicator . 43
.
Malf unction Indicator Lamp . 41,167
...................
Manual Transmission . 114
........
Manual Transmission Fluid . 134
...............................
Meters, Gauges .44
..........................
Mirrors, Adjusting .66
...............
Modif ying Your Vehicle . 106
..................
New Vehicle Break-in . 100
.....................
Normal Shif t Speeds .115
..................
NOTICE, Explanation of . ii
...............
Numbers, Identif ication . 178
...
Octane Requirement, Gasoline . 100
.........................................
Odometer .44 ...............................
Odometer, Trip .44
Oil ........................
Change, How to .130
......................
Change, When to .121
......................
Checking Engine .103
..............
Pressure Indicator . 40,166
Selecting Proper Viscosity ......................................
Chart .130
...........
ON (Ignition Key Position) . 53
.........................
Opening the Trunk .54
..............................
Outside Mirrors .66
....................
Overheating, Engine .163
...................
Radiator Overheating . 163
.......................
Radio Sound System .78
...................
Readiness Codes . 167,188
..
Rear Lights, Bulb Replacement . 141
............................
Rear View Mirror .66
................
Reclining the Seat-backs . 58
.......
Recommended Shif t Speeds . 115
Recovery Vehicle, Emergency .......................................
Towing .176
.............................
Reminder Lights .40
.......................
Remote Transmitter .56
Index
M
N
O P
R
V