engine overheat HONDA S2000 2007 2.G Owners Manual

If this indicator comes on when the
ignition switch is turned to the ON
(II) position and the parking brake is
rele ased, it means there is a problem
in the high beam headlight’s circuit.
Have your vehicle checked by your
dealer.
Driving
with the power steering
system continuously overheating can
cause system damage.
The left or right turn signal indicator
blinks when you signal a lane change
or turn. If the indicator does not
blink or blinks rapidly, it usually
means one of the turn signal bulbs is
burned out (see page ). Replace
the bulb as soon as possible, since
other drivers cannot see that you are
signaling.
When you press the hazard warning
button, both turn signal indicators
blink. All turn signals on the outside
of the vehicle should f lash.
This indicator normally comes on
when you turn the ignition to the ON
(II) position and goes of f af ter the
engine starts. If it comes on at any
other time, there is a problem in the
electric power steering system. If
this happens, stop the vehicle in a
saf e place and turn of f the engine.
Reset the system by restarting the
engine. The indicator will not turn
of f immediately. If it does not go of f
after driving a short distance, or
comes on again while driving, take
the vehicle to your dealer to have it
checked. With the indicator on, the
EPS may be turned of f , making the
vehicle harder to steer.
If the power steering system
overheats while driving, the assist is
reduced and steering may f eel
slightly harder.
157
Instrument Panel Indicators
‘‘Daytime Running
Lights’’ Indicator
Turn Signal and
Hazard Warning
Indicators
Electric Power Steering
(EPS) Indicator
48

The manual transmission is
synchronized in all forward gears for
smooth operation. It has a lockout so
you cannot shift directly from fifth to
reverse instead of sixth (see page
). When shif ting up or down,
make sure you push the clutch pedal
down all the way, shift to the next
gear, and let the pedal up gradually.
When you are not shif ting, do not
rest your f oot on the clutch pedal.
This can cause your clutch to wear
out f aster. When slowing down, you can get
extra braking f rom the engine by
shifting to a lower gear. This extra
braking can help you maintain a safe
speed and prevent your brakes f rom
overheating while going down a
steep hill. Bef ore downshif ting,
make sure the engine speed will not
go into the tachometer’s red zone in
the lower gear.
Your vehicle is equipped with an
aluminum shif t lever. If you leave the
vehicle parked outside f or a long
time on a hot day, be caref ul bef ore
moving the shift lever. Because of
the heat, the shift lever may be
extremely hot. If the outside
temperature is low, the shif t lever
f eels cold.
Come to a full stop before you shift
into reverse. You can damage the
transmission by trying to shift into
reverse with the vehicle moving.
Push down the clutch pedal, and
pause f or a f ew seconds bef ore
shif ting into reverse, or shif t into one
of the f orward gears f or a moment.
This stops the gears so they won’t
‘‘grind.’’
126
Manual T ransmission
Driving
125
Rapid slowing or speeding up
can cause loss of control on
slippery surfaces. If you crash,
you can be injured.
Use extra care when driving on
slippery surfaces.

Make sure the convertible top and
the windows are closed.
Turn of f the lights.
Place any packages, valuables, etc.,
in the trunk or take them with you.
Lock the doors.
Never park over dry leaves, tall
grass, or other f lammable
materials. The hot three way
catalytic converter could cause
these materials to catch on fire.If the vehicle is f acing uphill, turn
the front wheels away from the
curb, and put the transmission in
f irst gear.
If the vehicle is f acing downhill,
turn the front wheels toward the
curb, and put the transmission in
reverse gear.
Make sure the parking brake is
f ully released bef ore driving away.
Driving with the parking brake
partially set can overheat or
damage the rear brakes.
Resting your f oot on the pedal keeps
the brakes applied lightly, builds up
heat, and reduces their ef f ectiveness.
It also keeps your brake lights on all
the time, conf using drivers behind
you.
Constant application of the brakes
when going down a long hill builds
up heat and reduces their ef f ective-
ness. Use the engine to assist the
brakes by taking your f oot of f the
accelerator and downshif ting to a
lower gear. Your vehicle is equipped with disc
brakes at all f our wheels. A power
assist helps reduce the ef f ort needed
on the brake pedal. The anti-lock
brake system (ABS) helps you retain
steering control when braking very
hard.
Always use the parking brake when
you park your vehicle. Make sure
the parking brake is set f irmly, or
your vehicle may roll if it is parked
on an incline.
CONT INUED
Parking
Parking T ips Braking System
Parking, Braking System
Driving
127

This section covers the more
common problems that motorists
experience with their vehicles. It
gives you inf ormation about how to
safely evaluate the problem and what
to do to correct it. If the problem has
stranded you on the side of the road,
you may be able to get going again.
If not, you will also f ind instructions
on getting your vehicle towed.......................
Compact Spare Tire .174
....................
Changing a Flat Tire .175
.............
If the Engine Won’t Start . 180
................................
Jump Starting .182
..............
If the Engine Overheats . 183
.........
Low Oil Pressure Indicator . 186
..........
Charging System Indicator . 186
.......
Malf unction Indicator Lamp . 187
...............
Brake System Indicator . 188
.......
Closing the Convertible Top . 189
..............................................
Fuses .190
..........
Checking and Replacing . 191
..............................
Fuse Locations .194
......................
Emergency Towing .196
..........
If Your Vehicle Gets Stuck . 196
Taking Care of the Unexpected
T aking Care of t he Unexpect ed
173

µThe reading on your vehicle’s
temperature gauge should stay in
the midrange under most conditions.
If it reaches the red mark, you
should determine the reason (hot
day, driving up a steep hill, etc.).
If your vehicle overheats, you should
take immediate action. The only
indication may be the temperature
gauge reading reaching the red
mark. Or you may see steam or
spray coming f rom under the hood.
Connect the second jumper cable
to the negative ( ) terminal on
the booster battery. Connect the
other end to the grounding strap
as shown. Do not connect this
jumper cable to any other part of
the engine. Keep the ends of the jumper
cables away from each other and
any metal on the vehicle until
everything is disconnected.
Otherwise, you may cause an
electrical short. Once your vehicle is running,
disconnect the negative cable f rom
your vehicle, then f rom the
booster battery. Disconnect the
positive cable f rom your vehicle,
then from the booster battery. Start your vehicle. If the starter
motor still operates slowly, check
that the jumper cables have good
metal-to-metal contact. If the booster battery is in another
vehicle, have an assistant start
that vehicle and run it at a fast idle.
6.
7. 5.
4.
CONT INUED
Jump Starting, If the Engine Overheats
If the Engine Overheats
T aking Care of t he Unexpect ed
183
Driving with the temperature gauge
reading at the red mark can cause
serious damage to your engine.

Look for any obvious coolant leaks,
such as a split radiator hose.
Everything is still extremely hot,
so use caution. If you find a leak, it
must be repaired before you
continue driving (see
on page ).
If
the temperatu re gauge stays at
the red mark, turn off the engine.
If you do not see steam or spray,
leave the engine running, and
watch the temperature gauge. If
the high heat is due to overloading,
the engine should start to cool
down almost immediately. If it
does, wait until the temperature
gauge comes down to the midpoint,
th en continue driving.
If
you see steam and/or spray
coming from under the hood, turn
off the engine. Wait until you see
no more signs of steam or spray,
th en open the hood.
Safely
pull to the side of the road.
Put the transmission in neutral,
and set the parking brake. Turn
off the all accessories, and turn on
the hazard warning indicators.
If you don’t find an obvious leak,
check the coolant level in the
radiator reserve tank. Add coolant
if the level is below the MIN mark
(see on
page ).
2. 1.
3. 4.
5.
6.
149 196
Emergency
Towing
A dding Engine Coolant
If theEngineOverheats
184
Steam and spray from an
overheated engine can
seriously scald you.
Do not open the hood if steam
is coming out.

If there was no coolant in the
reserve tank, you may need to add
coolant to the radiator. Let the
engine cool down until the reading
reaches the middle of the
temperature gauge or lower
befo re checking the radiato r. Using
gloves or a large heavy
cloth, turn the radiator cap
counterclockwise, without pushing
down, to the first stop. After the
pressure releases, push down on
the cap, and turn it until it comes
off. Put
the radiator cap back on
tightl y. Run the engine, and check
the temperatu re gauge. If it goes
back to the red mark, the engine
needs repair (see on page ).
If the temperature stays normal,
check the coolant level in the
radiator reserve tank. If it has
gone down, add coolant to the
MAX mark. Put the cap back on
tightly.
Start the engine, and set the
temperature control dial to
maximum heat. Add coolant to the
radiator up to the base of the f iller
neck. If you do not have the
proper coolant mixture available,
you can add plain water.
Remember to have the cooling
system drained and ref illed with
the proper mixture as soon as you
can.
9. 8.
7. 10.
11.196
Emergency
Towing
If theEngineOverheats
T aking Care of t he Unexpect ed
185
Removing the radiator cap
while the engine is hot can
cause the coolant to spray out,
seriously scalding you.
Always let the engine and
radiator cool down before
removing the radiator cap.

CONT INUED
................
Changing a Flat Tire . 175
.....
Charging System Indicator . 186
..................
Checking the Fuses . 191
...
Closing the Convertible Top . 189
.........
Hazard Warning Flashers . 58
............................
Jump Starting .182
.....
Low Oil Pressure Indicator . 186
...
Malf unction Indicator Lamp . 187
..................
Overheated Engine . 183
.......................................
Towing .196
...........................
Emergency Brake .76
......................
Emergency Flashers .58
......................
Emergency Towing .196
............
Emergency Trunk Opener . 64
.......................
Emissions Controls .207
.............
Emissions Testing, State . 210
Engine ............
Adding Engine Coolant . 149
....
Coolant Temperature Gauge . 53
.........................
If It Won’t Start .180
Malf unction Indicator ................................
Lamp . 47, 187
.......................
Oil Lif e Indicator .136
........
Oil Pressure Indicator . 46, 186
..............
Oil, What Kind to Use . 146
...............................
Overheating .183 ............................
Specif ications .202
............................
Speed Limiter .126
...............................
Start Button .124
.......................................
Starting .124
......................
Ethanol in Gasoline .110
...
Evaporative Emission Controls . 207
...............................
Exhaust Fumes .41
Expectant Mothers, Use of Seat ........................................
Belts by .14
.....................................
Fan, Interior .85
...........................................
Features .83
....................
Filling the Fuel Tank . 111
Filters .........................
Dust and Pollen .161
...............................................
Oil .147
.............
Flashers, Hazard Warning . 58
...................
Flat Tire, Changing a . 175
Fluids ..........................................
Brake .154
.........................................
Clutch .154
..............
Manual Transmission . 152
..................
Windshield Washer . 151
..........................
Four-way Flashers .58 .................................................
Fuel .110
......................
Fill Door and Cap .111
...........................................
Gauge .52
.....................
Low Fuel Indicator .49
................
Octane Requirement . 110
...............................
Oxygenated .110
........................
Tank, Ref ueling .111
...............................
Fuel Economy .114
..............
Fuel Station Procedures . 111
.....................
Fuses, Checking the .191
...............
Gas Mileage, Improving . 114
.........................................
Gasoline .110
...........................................
Gauge .52
.....................
Low Fuel Indicator .49
................
Octane Requirement . 110
........................
Tank, Ref ueling .111
.............................................
Gauges .51
...
Engine Coolant Temperature . 53
...............................................
Fuel .52
Gearshif t Lever Positions ..............
Manual Transmission . 126
Index
F
G
INDEX
III

CONT INUED
..................................
Maintenance .133
........................................
Minder .135
.........................
Minder Indicator .50 Owner’s Maintenance
...................................
Checks .141
........................................
Record .143
..........................................
Saf ety .134
.
Malfunction Indicator Lamp . 47, 187
...................
Manual Transmission . 125
........
Manual Transmission Fluid . 152
...............................
Meters, Gauges .51
...................
Methanol in Gasoline . 110
..........................
Mirrors, Adjusting .75
...............
Modif ying Your Vehicle . 116
..................
New Vehicle Break-in . 110
.....................
Normal Shif t Speeds .126
...................
NOTICE, Explanation of . i
...............
Numbers, Identif ication . 200..............
Panel Brightness Control . 58
...........................................
Parking .127
.................................
Parking Brake .76
Parking Brake and Brake System .....................................
Indicator .188
.................................
Parking Lights .57
.............................
PGM-FI System .208
.......................
Label, Certif ication .200
.................
Lane Change, Signaling . 57
..................
Lap/Shoulder Belts . 12, 17
Lights ....................
Bulb Replacement .155
..................................
Turn Signal .57
....................................
Load Limits .118
......
LOCK (Ignition Key Position) . 62
Locks .......
Anti-thef t Steering Column . 62
............................
Fuel Fill Door .111
.................................
Power Door .63
...........................................
Trunk .63
........................
Low Coolant Level .114
.........................
Low Fuel Indicator .49
...
Low Oil Pressure Indicator . 46, 186
...
Lubricant Specif ications Chart . 202
...........
Luggage, Storing (Cargo) . 117
...
Octane Requirement, Gasoline . 110
.........................................
Odometer .51
...............................
Odometer, Trip .51
Oil ........................
Change, How to .147 ......................
Change, When to .135
......................
Checking Engine .113
..............
Pressure Indicator . 46, 186
Selecting Proper Viscosity ......................................
Chart .147
...........
ON (Ignition Key Position) . 62
Onboard Ref ueling Vapor ....................................
Recovery .207
.........................
Opening the Trunk .63
..............................
Outside Mirrors .75
....
Outside Temperature Indicator . 53
....................
Overheating, Engine .183
....
Owner’s Maintenance Checks . 141
.........................
Oxygenated Fuels .110
Index
M N
O
P
LINDEX
V

ÎÎ Î
Î
...................................
Pollen Filter .161
..........................
Power Door Locks .63
..................
Power Socket Location . 78
..............................
Power Windows .68
.........
Pregnancy, Using Seat Belts . 14
........................
Preparing to Drive .123
.........
Protecting Adults and Teens . 10
...
Additional Safety Precautions . 15
.....
Advice f or Pregnant Women . 14
........................
Protecting Children .29
.....................
General Guidelines .29
.......
Protecting Larger Children . 37
.........
Protecting Small Children . 33
...................
Radiator Overheating . 183
...............
Radio/CD Sound System . 88
.................
Radio Thef t Protection . 105
...................
Readiness Codes . 187, 210
..
Rear Lights, Bulb Replacement . 159
............................
Rear View Mirror .75
.................
Rear Window Def ogger . 59
................
Reclining the Seat-backs . 67
.......
Recommended Shif t Speeds . 126Recovery Vehicle, Emergency
.......................................
Towing .196
........................................
Ref ueling .111
.......................
Reminder Indicators .45
.......................
Remote Transmitter .65
Replacement Inf ormation ..............
Dust and Pollen Filter . 161
................
Engine Oil and Filter . 147
..........................................
Fuses .190
................................
Light Bulbs .155
....................................
Schedule .142
...........................................
Tires .167
.............................
Wiper Blades .162
Replacing Seat Belts Af ter a ............................................
Crash .18
..........
Reporting Saf ety Def ects . 214
Reserve Tank, Engine ...............................
Coolant . 114, 149
...............................
Restraint, Child .29
...........................
Reverse Lockout .126
................................
Rotation, Tire .166
..................................
Safety Belts . 8, 16
.........
Safety Defects, Reporting . 214.................................
Saf ety Features .7
...........................................
Airbags .9
.......................................
Seat Belts .8
.............
Saf ety Labels, Location of . 42
..............................
Saf ety Messages .iii
................................
Satellite Radio .93
.....................................
Seat Belts . 8, 16
...............
Additional Information . 16
.....
Advice f or Pregnant Women . 14
Automatic Seat Belt ...............................
Tensioners .18
.....................................
Cleaning .160
......................
Lap/Shoulder Belt .17
................................
Maintenance .18
Reminder Indicator and ................................
Beeper . 16, 46
...................
System Components . 16
...............
Use During Pregnancy . 14
........................
Seats, Adjusting the .67
...............................
Serial Number .200
...................
Service Intervals . 141, 142
...........................
Service Manual .215
.........
Service Station Procedures . 111
............................
Setting the Clock .54
Shif ting ..............
Manual Transmission . 125
Index
S
R
VI