engine coolant Hyundai Creta 2016 Owner's Guide

Page 428 of 512

7-34
Maintenance
ENGINE COOlANT
The highpressure cooling system
has a reservoir filled with yearround
antifreeze coolant. The reservoir is
filled at the factory.
Check the antifreeze protection and
coolant level at least once a year, at
the beginning of the winter season,
and before traveling to a colder cli
mate.
•Do not drive with no engine
coolant. It may cause water pump
failure and engine seizure, etc.
•When the engine overheats from
low engine coolant, suddenly
adding engine coolant may cause
cracks in the engine. To prevent
damage, add engine coolant slow
ly in small quantities.
Checking the coolant level
NOTICE
Removing radiator cap
•Never attempt to
remove the radiator cap while
the engine is operating or hot.
Doing so might lead to cooling
system and engine damage and
could result in serious personal
injury from escaping hot coolant
or steam.
(Continued)
WARNING
(Continued)
•Turn the engine off and wait until
it cools down. Use extreme care
when removing the radiator cap.
Wrap a thick towel around it,
and turn it counterclockwise
slowly to the first stop. Step
back while the pressure is
released from the cooling sys
tem. When you are sure all the
pressure has been released,
press down on the cap, using a
thick towel, and continue turning
counterclockwise to remove it.
•Even if the engine is not operat
ing, do not remove the radiator
cap or the drain plug while the
engine and radiator are hot. Hot
coolant and steam may still blow
out under pressure, causing
serious injury.
OGS0750004

Page 429 of 512

7-35
7
Maintenance
Check the condition and connections
of all cooling system hoses and
heater hoses. Replace any swollen
or deteriorated hoses.
The coolant level should be filled
between F (Full) and L (Low)
marked on the side of the coolant
reservoir when the engine is cool. If the coolant level is low, add enough
distilled (deionized) water (except
Middle East) or add enough pre
mixed coolant (for Middle East).
Bring the level to F (Full), but do not
overfill. If frequent additions are
required, we recommend that the
system be inspected by an author
ized HYUNDAI dealer.
The electric motor
(cooling fan) is con
trolled by engine
coolant temperature,
refrigerant pressure
and vehicle speed. It may some
times operate even when the
engine is not running. Use
extreme caution when working
near the blades of the cooling fan
so that you are not injured by a
rotating fan blades. As the engine
coolant temperature decreases,
the electric motor will automatical
ly shut off. This is a normal condi
tion.
The electric motor (cooling fan)
may operate until you disconnect
the negative battery cable.
WARNING
OGS075061
OGS075005

Gasoline Engine
■Diesel Engine

Page 430 of 512

7-36
Maintenance
Recommended engine coolant
• Use only soft (distilled) water in thecoolant mixture.
• The engine in your vehicle has alu minum engine parts and must be
protected by an ethyleneglycol
based coolant to prevent corrosion
and freezing.
• DO NOT USE alcohol or methanol coolant or mix them with the spec
ified coolant.
• Do not use a solution that contains more than 60% antifreeze or less
than 35% antifreeze, which would
reduce the effectiveness of the
solution.
For mixture percentage, refer to the
following table.
Changing the coolant
We recommend that the coolant be
replaced by an authorized HYUNDAI
dealer.
Put a thick cloth or fabric around the
radiator cap before refilling the
coolant in order to prevent the
coolant from overflowing into engine
parts such as the alternator.
NOTICE
AmbientTemperature
Mixture Percentage (volume)
AntifreezeWater
15°C (5°F) 35 65
25°C (13°F) 40 60
35°C (31°F) 50 50
45°C (49°F) 60 40
•Do not use radiator coolant or
antifreeze in the washer fluid
reservoir.
•Radiator coolant can severely
obscure visibility when sprayed on
the windshield and may cause
loss of vehicle control or damage
to paint and body trim.
WARNING

Page 433 of 512

7-39
7
Maintenance
WAShER FluId
Checking the washer fluid level
Check the fluid level in the washer
fluid reservoir and add fluid if neces
sary. Plain water may be used if
washer fluid is not available.
However, use washer solvent with
antifreeze characteristics in cold cli
mates to prevent freezing. Do not use engine coolant or
antifreeze in the washer fluid reser
voir.
Checking the parking brake
Check the stroke of the parking
brake by counting the number of
“clicks’’ heard while fully applying it
from the released position.
Also, the parking brake alone should
securely hold the vehicle on a fairly
steep grade. If the stroke is more or
less than specified, we recommend
that the system be inspected by an
authorized HYUNDAI dealer.
Stroke : 6~8 “clicks’’ at a force of 20
kg (44 lbs, 196 N).
NOTICE
OGS075007
OGS075008
•Engine coolant can severely
obscure visibility when sprayed
on the windshield and may
cause loss of vehicle control or
damage to paint and body trim.
•Windshield Washer fluid agents
contain some amounts of alco
hol and can be flammable under
certain circumstances. Do not
allow sparks or flame to contact
the washer fluid or the washer
fluid reservoir. Damage to the
vehicle or occupants could
occur.
•Windshield washer fluid is poi
sonous to humans and animals.
Do not drink and avoid contact
ing windshield washer fluid.
Serious injury or death could
occur.
WARNING
PARKING BRAKE

Page 490 of 512

7-96
Maintenance
EMISSION CONTROl SYSTEM
The emission control system of your
vehicle is covered by a written limited
warranty. Please see the warranty
information contained in the Service
Passport in your vehicle.
Your vehicle is equipped with an
emission control system to meet all
emission regulations.
There are three emission control
systems which are as follows.
(1) Crankcase emission control system
(2) Evaporative emission control sys tem
(3) Exhaust emission control system
In order to assure the proper function
of the emission control systems, it is
recommended that you have your
car inspected and maintained by an
authorized HYUNDAI dealer in
accordance with the maintenance
schedule in this manual.1. Crankcase emission control
system
The positive crankcase ventilation
system is employed to prevent air
pollution caused by blowby gases
being emitted from the crankcase.
This system supplies fresh filtered air
to the crankcase through the air
intake hose. Inside the crankcase,
the fresh air mixes with blowby
gases, which then pass through the
PCV valve into the induction system.
2. Evaporative emission control
system
The Evaporative Emission Control
System is designed to prevent fuel
vapors from escaping into the atmos
phere.
Canister
Fuel vapors generated inside the fuel
tank are absorbed and stored in the
onboard canister. When the engine is
running, the fuel vapors absorbed in
the canister are drawn into the surge
tank through the purge control sole
noid valve.
Purge Control Solenoid Valve(PCSV)
The purge control solenoid valve is
controlled by the Engine Control
Module (ECM); when the engine
coolant temperature is low during
idling, the PCSV closes so that evap
orated fuel is not taken into the
engine. After the engine warms up
during ordinary driving, the PCSV
opens to introduce evaporated fuel to
the engine.

Page 497 of 512

8-5
8
Specifications & Consumer information
rECommENDED lubrICaNtS aND CapaCItIES
To help achieve proper engine and powertrain performance and durability, use only lubricants of the proper quality.
The correct lubricants also help promote engine efficiency that results in improved fuel economy.
These lubricants and fluids are recommended for use in your vehicle.
LubricantVolumeClassification
Engine oil * 1
*2
(drain and refill)
Recommends Gamma 1.6
3.6
l(3.8 US qt.)
ACEA A5*3
(or above)
U2 1.4/U2 1.65.3 l(5.6 US qt.)ACEA B4* 4
Manual transaxle fluid Gamma 1.6
1.6~1.7
l
(1.7~1.8 US qt.) HK MTF 70W (SK)
SPIRAX S6 GHME 70W (H.K.SHELL) GS MTF HD 70W (GS CALTEX)
(HYUNDAI genuine transaxle fluid)
U2 1.4/U2 1.6 1.7~1.9
l
(1.9~2.0 US qt.)
Automatic transaxle fluid Gamma 1.6
7.3
l(7.71 US qt.) MICHANG ATF SPIV,
SK ATF SPIV,
NOCA ATF SPIV,
HYUNDAI genuine ATF SPIV
U2 1.6
7.1
l(7.5 US qt.)
Coolant Gamma 1.6
M/T
5.7
l(6.0 US qt.)
Mixture of antifreeze and water
(Phosphatebased Ethylene glycol coolant for aluminum radiator)
A/T
5.5
l(5.8 US qt.)
U2 1.4 M/T 7.2
l(7.6 US qt.)
U2 1.6 M/T
7.2
l(7.6 US qt.)
A/T 7.0
l(7.4 US qt.)
M/T : Manual transaxle
A/T : Automatic transaxle

Page:   < prev 1-10 11-20 21-30