engine HYUNDAI I10 2020 Manual Online
Page 361 of 486
7-9
07
If your temperature gauge indicates
overheating, you experience a loss of
power, or hear loud pinging or knock-
ing, the engine may be overheating. If
this happens, you should:
1. Pull off the road and stop as soon
as it is safe to do so.
2. Place the shift lever in N (Neutral,
for Automated manual transmis-
sion vehicle) or neutral (for Manual
transmission vehicle) and set the
parking brake. If the air condition-
ing is ON, turn it OFF.
3. If engine coolant is running out
under the vehicle or steam is com-
ing out from the bonnet, stop the
engine. Do not open the bonnet
until the coolant has stopped run-
ning or the steaming has stopped.
If there is no visible loss of engine
coolant and no steam, leave the
engine running and check to be
sure the engine cooling fan is oper-
ating. If the fan is not running, turn
the engine off.
WARNING
: K L O V W W K H H Q J L Q H L V U X Q-
Q L Q J N H H S K D Q G V F O R W K-
L Q J D Q G W R R O V D Z D \ I U R P
W K H P R Y L Q J S D U W V V X F K
D V W K H F R R O L Q J I D Q D Q G
G U L Y H E H O W W R S U H Y H Q W
V H U L R X V L Q M X U \ 4. Check for coolant leaking from the
radiator, hoses or under the vehi-
cle. (If the air conditioning had
been in use, it is normal for cold
water to be draining from it when
you stop.)
5. If engine coolant is leaking out,
stop the engine immediately and
we recommend that you call a
HYUNDAI authorised repairer for
assistance.
WARNING
1 ( 9 ( 5 U H P R Y H W K H U D G L-
D W R U F D S R U W K H G U D L Q
S O X J Z K L O V W W K H H Q J L Q H
D Q G U D G L D W R U D U H K R W + R W
F R R O D Q W D Q G V W H D P P D \
E O R Z R X W X Q G H U S U H V V X U H F D X V L Q J
V H U L R X V L Q M X U \
7 X U Q W K H H Q J L Q H R I I D Q G Z D L W X Q W L O
W K H H Q J L Q H F R R O V G R Z Q 8 V H
H [ W U H P H F D U H Z K H Q U H P R Y L Q J W K H
U D G L D W R U F D S : U D S D W K L F N W R Z H O
D U R X Q G L W D Q G W X U Q L W F R X Q W H U F O R F N-
Z L V H V O R Z O \ W R W K H I L U V W V W R S 6 W H S
E D F N Z K L O V W W K H S U H V V X U H L V
U H O H D V H G I U R P W K H F R R O L Q J V \ V W H P
: K H Q \ R X D U H V X U H D O O W K H S U H V V X U H
K D V E H H Q U H O H D V H G S U H V V G R Z Q R Q
W K H F D S X V L Q J D W K L F N W R Z H O D Q G
F R Q W L Q X H W X U Q L Q J F R X Q W H U F O R F N Z L V H
W R U H P R Y H L W
IF THE ENGINE OVERHEATS
Page 362 of 486
7-10
Emergency situations
TYRE PRESSURE
6. If you cannot find the cause of the
overheating, wait until the engine
temperature has returned to nor-
mal. Then, if coolant has been lost,
carefully add coolant to the reser-
voir to bring the fluid level in the
reservoir up to the halfway mark.
7. Proceed with caution, keeping
alert for further signs of overheat-
ing. If overheating happens again,
we recommend that you call a
HYUNDAI authorised repairer for
assistance.
NOTICE
Page 375 of 486
7-23
07
- D F N O D E H O
The actual Jack label in the vehicle
may differ from the illustration.
For more detailed specifications,
refer to the label attached to the jack.
1. Model Name
2. Maximum allowable load
3. When using the jack, set your park-
ing brake.
4. When using the jack, stop the
engine.
5. Do not get under a vehicle that is
supported by a jack.
6. The designated locations under
the frame7. When supporting the vehicle, the
base plate of jack must be vertical
under the lifting point.
8. Shift into R (Reverse) gear on vehi-
cles with Manual transmission or
move the shift lever to the N
(Neutral) position on vehicles with
Automated manual transmission.
9. The jack should be used on firm
level ground.
10. Jack manufacture
11. Production date
12. Representative company and
address
OHYK065011
Page 397 of 486
Engine compartment .........................................................................................8-3
Maintenance services ....................................................................................... 8-4
Owner’s responsibility .................................................................................... 8-4
Owner maintenance precautions.................................................................. 8-4
Owner maintenance ...........................................................................................8-5
Owner maintenance schedule .......................................................................8-5
Scheduled maintenance services ..................................................................... 8-7
Explanation of scheduled maintenance items ................................................ 8-8
Engine oil ............................................................................................................ 8-11
Checking the engine oil level ........................................................................ 8-11
Checking the engine oil and filter ................................................................ 8-12
Engine coolant .................................................................................................. 8-13
Checking the coolant level ........................................................................... 8-13
Changing the engine coolant ....................................................................... 8-15
Brake/clutch fluid ............................................................................................. 8-16
Checking the brake/clutch fluid level .......................................................... 8-16
Washer fluid ...................................................................................................... 8-18
Checking the washer fluid level ................................................................... 8-18
Checking the parking brake.......................................................................... 8-18
Parking brake .................................................................................................... 8-18
Air cleaner ......................................................................................................... 8-19
Filter replacement ......................................................................................... 8-19
Climate control air filter ................................................................................... 8-21
Filter inspection ............................................................................................. 8-21
Filter replacement ......................................................................................... 8-21
Wiper blades .....................................................................................................8-23
Blade inspection ............................................................................................8-23
Blade replacement ......................................................................................8-23
Battery ............................................................................................................... 8-25
For best battery service ................................................................................ 8-25
Battery capacity label ................................................................................... 8-27
Battery recharging ......................................................................................... 8-27
Reset items ....................................................................................................8-28
8. Maintenance
8
Page 398 of 486
8
Tyres and wheels...............................................................................................8-29
Tyre care .........................................................................................................8-29
Recommended cold tyre inflation pressures ............................................. 8-30
Check tyre inflation pressure ....................................................................... 8-30
Tyre rotation ................................................................................................... 8-31
Wheel alignment and tyre balance ..............................................................8-32
Tyre replacement ...........................................................................................8-32
Wheel replacement .......................................................................................8-34
Tyre traction ...................................................................................................8-34
Tyre maintenance ..........................................................................................8-34
Tyre sidewall labelling ...................................................................................8-34
Low aspect ratio tyres ................................................................................... 8-37
Fuses ................................................................................................................. 8-38
Instrument panel fuse replacement ........................................................... 8-39
Fuse switch ................................................................................................... 8-39
Engine compartment panel fuse replacement .......................................... 8-40
Fuse/relay panel description ....................................................................... 8-42
Light bulbs ........................................................................................................ 8-50
Headlight, Position Light, Turn signal Light, Fog Light and
Daytime Running Light, Low Beam Assist-Static light bulb
replacement .................................................................................................. 8-51
Headlight and front fog light aiming............................................................8-55
Side repeater light replacement .................................................................. 8-59
Rear combination light bulb replacement ................................................. 8-60
High mounted stop light replacement ........................................................ 8-61
License plate light bulb replacement ......................................................... 8-62
Interior light bulb replacement ................................................................... 8-62
Appearance care .............................................................................................. 8-63
Exterior care .................................................................................................. 8-63
Interior care................................................................................................... 8-69
Emission control system .................................................................................. 8-72
Crankcase emission control system ............................................................ 8-72
Evaporative emission control system .......................................................... 8-72
Exhaust emission control system ................................................................. 8-73
Page 399 of 486
8-3
08
ENGINE COMPARTMENT
1. Engine coolant reservoir
( Q J L Q H R L O
Page 404 of 486
8-8
Maintenance
Engine oil and filter
7 K H H Q J L Q H R L O D Q G I L O W H U V K R X O G E H
F K D Q J H G D W W K H L Q W H U Y D O V V S H F L I L H G L Q
W K H P D L Q W H Q D Q F H V F K H G X O H , I W K H Y H-
K L F O H L V E H L Q J G U L Y H Q L Q V H Y H U H F R Q G L-
W L R Q V P R U H I U H T X H Q W R L O D Q G I L O W H U
F K D Q J H V D U H U H T X L U H G
Drive belts
, Q V S H F W D O O G U L Y H E H O W V I R U H Y L G H Q F H R I
F X W V F U D F N V H [ F H V V L Y H Z H D U R U R L O
V D W X U D W L R Q D Q G U H S O D F H L I Q H F H V V D U \
' U L Y H E H O W V V K R X O G E H F K H F N H G S H U L-
R G L F D O O \ I R U S U R S H U W H Q V L R Q D Q G D G M X V W-
H G D V Q H F H V V D U \
CAUTION
When you are inspecting the belt,
place the ignition switch to the
lock/off or ACC position.
Fuel filter
7 K L V S H W U R O S R Z H U H G Y H K L F O H L V
H T X L S S H G Z L W K D O L I H W L P H I X H O I L O W H U W K D W
L V L Q W H J U D W H G Z L W K W K H I X H O W D Q N
5 H J X O D U P D L Q W H Q D Q F H R U U H S O D F H P H Q W
L V Q R W Q H H G H G K R Z H Y H U W K H T X D O L W \ R I
I X H O X V H G P D \ L P S D F W W K H I U H T X H Q F \
R I P D L Q W H Q D Q F H Q H H G H G , I W K H U H D U H
D Q \ I X H O U H O D W H G S U R E O H P V O L N H I X H O
I O R Z U H V W U L F W L R Q V X U J L Q J O R V V R I S R Z-
H U K D U G V W D U W L Q J S U R E O H P H W F I X H O I L O-
W H U L Q V S H F W L R Q R U U H S O D F H P H Q W P D \ E H
Q H H G H G : H U H F R P P H Q G W K H I X H O I L O W H U
E H L Q V S H F W H G R U U H S O D F H G E \ D
+ < 8 1 ' $ , D X W K R U L V H G U H S D L U H U
Fuel lines, fuel hoses and
connections
& K H F N W K H I X H O O L Q H V I X H O K R V H V D Q G
F R Q Q H F W L R Q V I R U O H D N D J H D Q G G D P-
D J H : H U H F R P P H Q G W K D W W K H I X H O
O L Q H V I X H O K R V H V D Q G F R Q Q H F W L R Q V E H
U H S O D F H G E \ D + < 8 1 ' $ , D X W K R U L V H G
U H S D L U H U
Vapour hose and fuel filler cap
7 K H Y D S R X U K R V H D Q G I X H O I L O O H U F D S
V K R X O G E H L Q V S H F W H G D W W K R V H L Q W H U-
Y D O V V S H F L I L H G L Q W K H P D L Q W H Q D Q F H
V F K H G X O H 0 D N H V X U H W K D W D Q H Z Y D-
S R X U K R V H R U I X H O I L O O H U F D S L V F R U U H F W O \
U H S O D F H G
EXPLANATION OF SCHEDULED MAINTENANCE ITEMS
Page 405 of 486
8-9
08
Vacuum crankcase ventilation
hoses (if equipped)
, Q V S H F W W K H V X U I D F H R I K R V H V I R U H Y L-
G H Q F H R I K H D W D Q G R U P H F K D Q L F D O
G D P D J H + D U G D Q G E U L W W O H U X E E H U
F U D F N L Q J W H D U V F X W V D E U D V L R Q V D Q G
H [ F H V V L Y H V Z H O O L Q J L Q G L F D W H G H W H U L R U D-
W L R Q 3 D U W L F X O D U D W W H Q W L R Q V K R X O G E H
S D L G W R H [ D P L Q H W K R V H K R V H V X U I D F H V
Q H D U H V W W R K L J K K H D W V R X U F H V V X F K D V
W K H H [ K D X V W P D Q L I R O G
, Q V S H F W W K H K R V H U R X W L Q J W R D V V X U H
W K D W W K H K R V H V G R Q R W F R P H L Q F R Q W D F W
Z L W K D Q \ K H D W V R X U F H V K D U S H G J H V R U
P R Y L Q J F R P S R Q H Q W Z K L F K P L J K W
F D X V H K H D W G D P D J H R U P H F K D Q L F D O
Z H D U , Q V S H F W D O O K R V H F R Q Q H F W L R Q V
V X F K D V F O D P S V D Q G F R X S O L Q J V W R
P D N H V X U H W K H \ D U H V H F X U H D Q G W K D W
Q R O H D N V D U H S U H V H Q W + R V H V V K R X O G
E H U H S O D F H G L P P H G L D W H O \ L I W K H U H L V
D Q \ H Y L G H Q F H R I G H W H U L R U D W L R Q R U G D P-
age.
Air cleaner filter
: H U H F R P P H Q G W K D W W K H D L U F O H D Q H U
I L O W H U E H U H S O D F H G E \ D + < 8 1 ' $ , D X-
W K R U L V H G U H S D L U H U
Spark plugs
(for petrol engine)
0 D N H V X U H W R L Q V W D O O Q H Z V S D U N S O X J V
of the correct heat range.
WARNING
Do not disconnect and inspect
spark plugs when the engine is
hot. You may burn yourself.
Cooling system
& K H F N W K H F R R O L Q J V \ V W H P S D U W V V X F K
D V U D G L D W R U F R R O D Q W U H V H U Y R L U K R V H V
D Q G F R Q Q H F W L R Q V I R U O H D N D J H D Q G
G D P D J H 5 H S O D F H D Q \ G D P D J H G
S D U W V
Engine coolant
7 K H F R R O D Q W V K R X O G E H F K D Q J H G D W
W K H L Q W H U Y D O V V S H F L I L H G L Q W K H P D L Q W H-
Q D Q F H V F K H G X O H
Manual transmission fluid
(if equipped)
, Q V S H F W W K H P D Q X D O W U D Q V P L V V L R Q I O X L G
D F F R U G L Q J W R W K H P D L Q W H Q D Q F H V F K H G-
ule.
Automated manual
transmission fluid (if equipped)
, Q V S H F W W K H $ X W R P D W H G P D Q X D O W U D Q V-
P L V V L R Q I O X L G D F F R U G L Q J W R W K H P D L Q W H-
Q D Q F H V F K H G X O H
NOTICE
The use of non-specified fluid
(even marked as compatible with
genuine) could result in shift qual-
ity deterioration and vibrations,
eventually, the transmission fail-
ure.
Use only specified Automated
manual transmission fluid. (Refer
to “Recommended lubricants and
capacities” in chapter 2.)
Page 407 of 486
8-11
08
ENGINE OIL
Checking the engine oil level
2 $ & 7 8
1. Be sure the vehicle is on level
J U R X Q G
6 W D U W W K H H Q J L Q H D Q G D O O R Z L W W R
U H D F K Q R U P D O R S H U D W L Q J W H P S H U D-
ture.
7 X U Q W K H H Q J L Q H R I I D Q G Z D L W I R U D
I H Z P L Q X W H V D E R X W P L Q X W H V I R U
W K H R L O W R U H W X U Q W R W K H R L O S D Q
3 X O O W K H G L S V W L F N R X W Z L S H L W F O H D Q
D Q G U H L Q V H U W L W I X O O \
WARNING
Radiator hose
Be very careful not to touch the ra-
diator hose when checking or add-
ing the engine oil as it may be hot
enough to burn you.
3 X O O W K H G L S V W L F N R X W D J D L Q D Q G
F K H F N W K H O H Y H O 7 K H O H Y H O V K R X O G
E H E H W Z H H Q ) D Q G /
NOTICE
Page 408 of 486
8-12
Maintenance
2 $ & 7 8
, I L W L V Q H D U R U D W / D G G H Q R X J K R L O W R
bring the level to F. Do not overfill.
Use a funnel to help prevent oil
from being spilled on engine com-
ponents.
8 V H R Q O \ W K H V S H F L I L H G H Q J L Q H R L O
5 H I H U W R