ESP HYUNDAI I20 2018 Owners Manual

No special break-in period is need-
ed. By following a few simple precau-
tions for the first 1,000 km (600
miles) you may add to the perform-
ance, economy and life of your vehi-
cle:
• Do not race the engine.
• While driving, keep your enginespeed (rpm, or revolutions per
minute) between 2,000 rpm and
4,000 rpm.
• Do not maintain a single speed for long periods of time, either fast or
slow.
Varying engine speed is needed to
properly break-in the engine.
• Avoid hard stops, except in emer- gencies, to allow the brakes to seat
properly.
• Don't tow a trailer during the first 2,000 km (1,200 miles) of opera-
tion.

*($'!#(%'*









o Incidental or consequential dam-ages, including without limitation,
loss of time, inconvenience, loss
of use of vehicle or commercial
loss.
This warranty is the entire warranty
given by HMIL for Hyundai vehicles
and no dealer or its or his agent or
employee is authorized to extend or
enlarge this warranty and no dealer
or its or his agent or employee is
authorized to make any oral warran-
ty on HMIL's behalf.
HMIL reserves the right to make any
change in design or make any
improvement on the vehicle at any
time without any obligation to make
the same change on vehicles previ-
ously sold.
HMIL reserves the right for the final
decision in all warranty matters.Owner's Responsibilities
o Proper use, maintenance and care of vehicle in accordance with
the instructions contained in this
Owner's Manual and Service
Booklet. If the vehicle is subject to
severe usage conditions, such as
operation in extremely dusty,
rough, more repeated short dis-
tance driving or heavy city traffic
during hot weather, maintenance
of vehicle should be done more
frequently as mentioned in this
Owner's Manual and Service
Booklet.
o Retention of maintenance service records. It may be necessary for
the customer to show that the
required maintenance has been
performed, as specified in this
Owner's Manual and Service
Booklet.
o Delivery of the vehicle during reg- ular service business hours to
any authorized Hyundai Dealer to
obtain warranty service.
o In order to maintain the validity of this Basic Warranty, the vehicle
must be serviced by Hyundai
Authorized workshop in accor-
dance to the Owner’s Manual and
Service Booklet. Hyundai Motor India Limited here-
inafter called "HMIL", warrants that
each new Hyundai Genuine replace-
ment part purchased from and
installed by Hyundai Authorized
Dealer shall be free from any defects
in material or workmanship, under
normal use and maintenance, sub-
ject to the following terms and condi-
tions.
1. Warranty period
This warranty shall exist for a period
of 6 months or until the vehicle has
been driven for a distance of 10,000
Kilometers from the date of installa-
tion of replacement part by Hyundai
Authorized Dealer, whichever occurs
first.
2. What is covered
Except as provided in paragraph 3
hereof, our Authorized Dealer who
had sold and installed the replace-
ment part earlier shall either repair or
replace the said Hyundai genuine
part that is acknowledged by HMIL to
be defective in material or workman-
ship within the warranty period stipu-
32
)#+$,(.,--,+').%(&)


IBi Eng 2_PA RHD 1.qxd 18-03-2016 16:49 Page 3
Batteries, Audio Systems, Tyres
and Tubes originally equipped on
Hyundai vehicles are warranted
directly by the respective manufac-
turers and not by HMIL.
Audio Video Navigation System,

lated above\b at no cost to the owner
of the Hyundai vehicle for parts or
labour.3. What is not covered
This warranty shall not apply to:
o Normal maintenance services of parts such as cleaning\b adjust
ment or replacement (i.e. spark
plugs that are oil fouled\b lead
fouled\b or which fail due to the use
of low grade fuel).
o Parts that fail due to abuse\b mis use\b neglect\b alteration or acci
dent or which have been improp
erly lubricated or repaired.
o Par ts used in applications for which they were not designed or
approved by HMIL.
o Failure due to normal wear of parts.
o Direct or indirect failures caused by misuse and improper mainte
nance of vehicle and installation
of nonHyundai parts on the vehi
cle.
o Any vehicle on which the odome ter reading has been altered so
that mileage cannot be accurate
ly determined. o Incidental or consequential dam
ages\b including without limitation\b
loss of time\b inconvenience\b loss
of use of vehicle or commercial
loss.
This warranty is the entire warranty
given by HMIL for Hyundai replace
ment parts and no dealer or its or his
agent or employee is authorized to
extend or enlarge this warranty and
no dealer or its or his agent or
employee is authorized to make any
oral warranty on HMIL's behalf.
HMIL reserves the right for the final
decision in all warranty matters.
Owner's Responsibilities
o Proper use\b maintenance and care of the vehicle in accordance
with the instructions contained in
the Owner's Manual and Service
Booklet.
o Retention of maintenance service records. It may be necessary for
the customer to show that the
required maintenance has been
performed\b as specified in this
Owner's Manual and Ser vice
Booklet. o Retention of the customer's copy
of the original repair order and its
invoice/bill against which the part
was replaced.
o Delivery of the vehicle during reg ular service business hours to the
same Hyundai Authorized Dealer
who had sold and installed the
replacement part.
o In order to maintain the validity of this Parts replacement Warranty\b
the vehicle must be serviced by
Hyundai Authorized workshop in
accordance to the Owner’s
Manual and Service Booklet.
   HMIL extends the Mass Emission
standards (BS
IV)
for its vehicle in
the following cities: (1)
Delhi/NCR\b (2) Mumbai\b (3)
Chennai\b (4) Chennai\b (5) Bangalore
(6)HyderabadincludingSecund
e-
rabad\b (7) Ahmedabad\b(8)Pune\b
(9) Surat\b (1\f) Kanpur\b (11)Agra.
(For the vehicles Manufactured
on or
after \f1/\f4/2\f1\f).
Hyundai Warran\fy Po\bicy
)%4

(12)
Luckno w (13) Sholapur (For the
v ehicles Manufactured on or after
\f1/\f6/2\f1\f).
(14) Puduchery \b (15) Mathur a\b (16)
vapi \b (17) Jamnagar \b (18)
Ankleshwar\b (19) Hissar\b (2\f)
Bharatpur\b (21) Silvasa\b (22) Daman
& Diu\b (23) Aligarh\b(24)RaeBareilly\b
(25) Unnao\b (26) Karnal\b (27)
Kurukshetra\b (28) Yamunanagar\b
(29 )Valsad\b (3\f) Nizamabad\b(31)
Medak & (3\f) Mehboobnagar (For
the vehicles Manufactured on or
after \f1/1\f/2\f1\f).
The Mass Emissipn Standards (BS
III) shall apply to all the states and
union territories\b except at above. As
and when Govt. of India notifies addi
tional/new cities under Mass
Emission Standards (BS IV)\b Such
cities would be auto matically cov
ered.
Subject to other terms of the warran
ty policy and the conditions and obli
gations laid down hereunder\b
Hyundai Motor India Limited here
inafter called “HMIL”\b certifies that
the components liable to affect the
emission of the gaseous pollutants in
the vehicle in normal use despite the
use to which it may be subjected\b
comply with the provisions of Rule 115(2) of the Central Motor Vehicle
Rules\b 1989 hereinafter referred to
as the “Inuse emission standard”\b
and further warrants that if on exam
ination by a dealer duly authorized
by HMIL\b the vehicle is discovered to
be failing to meet the Inuse emis
sion standard as specified in the said
rule\b our Authorized Dealer shall take
such corrective measures as may be
necessary and shall at its sole dis
cretion either repair or replace free of
charge\b such components of emis
sion control system as are specified
in paragraph 3 hereof.
1. Warranty period
This warranty will be in addition to
and run parallel to the New Vehicle
Warranty and shall exist for a period
of 36 months or until the vehicle has
been driven for a distance of 8\f\b\f\f\f
kilometers from the date of delivery
to the first purchaser\b whichever
occurs first. This warranty is transfer
able to subsequent owner for the
remaining warranty period.
2. What is covered Our Authorized Dealers shall either
repair or replace\b any Hyundai gen
uine part listed in paragraph 3 here
of\b that is acknowledged by HMIL to
be defective in material or workman
ship within the warranty period stipu
lated above\b after examinations car
ried out to confirm that none of the
original settings have been tampered
with\b at no cost to the owner of the
Hyundai vehicle for parts or labour.
Such defective par ts which have
been replaced will become the prop
erty of HMIL.
3. Emission Warranty Parts List
3.1 Engine Control Module System • Engine Control Module
• Crankshaft Position Sensor\bCamshaft Position Sensor\b
Throttle Position Sensor\b MAP
Sensor\b O 2Sensor\b IAT &
ECT Sensor
3.2 Fuel Metering System • Fuel injectors
• Fuel Pumps
3.3 Air Induction System • Air Cleaner Housing Assembly
+$,#-*0-//-,'+0 &*(+


)%5

HYUNDAI EXTENDED
WARRANTY
*
HMIL offers optional paid extend
ed warranty on selected models\b in
addition to the basic new vehicle
warranty. For more details on
Hyundai Extended Warranty
please call the nearest dealer or
our toll free number 18\f\f11
4645
*Conditions apply
+$,#-*0-//-,'+0 &*(+


)%

standards\b in addition to the replace
ment of the components covered
under Emission Warranty\b will not
be made free of cost unless such
parts are also found to be in war
rantable condition within the
scope and limit of the New
Vehicle Warranty.
o Incidental or consequential dam ages\b including without limitation\b
loss of time\b inconvenience\b loss
of use of vehicle or commercial
loss.
This warranty is the entire warranty
given by HMIL for Hyundai vehicles
and no dealer or its or his agent or
employee is authorized to extend or
enlarge this warranty and no dealer
or its or his agent or employee is
authorized to make any oral warran
ty on HMIL’s behalf.
HMIL reserves the right to make any
change in design or make any
improvement on the vehicle at any
time without any obligation to make
the same change on vehicles previ
ously sold.
HMIL reserves the right for the final
decision in all warranty matters. OWNER'S RESPONSIBILITIES
o Proper use\b maintenance and care of vehicle in accordance with
the instructions contained in this
Owner’s Manual and Ser vice
Booklet. If the vehicle is subject
to severe usage conditions\b such
as operation in extremely dusty\b
rough\b more repeated short dis
tance driving or heavy city traffic
during hot weather\b maintenance
of vehicle should be done more
frequently as mentioned in this
Owner’s Manual and Ser vice
Booklet.
o In order to maintain the validity of this Emission Warranty\b the vehi
cle must be serviced by Hyundai
Authorized Dealer or Ser vice
Centre in accordance to the
Owner’s Manual and Ser vice
Booklet.
o Retention of maintenance service records. It may be necessary for
the customer to show that the
required maintenance has been
performed\b as specified in this
Owner’s Manual and Ser vice
Booklet.
o Immediate Delivery of the vehicle to any authorized Hyundai Dealer upon discovery of failure to comply
with the Inuse emission standard
inspite of proper use\b mainte
nance and care of vehicle in
accordance with the instructions
contained in this Owner’s Manual
and Service Booklet.
o Production of “Pollution Under Control" (PUC) certificate valid for
the period immediately preceding
the test during which the failure is
discovered\b the test having been
carried out either for obtaining a
new certificate\b or pursuant upon
being directed by an officer as
referred to in subrule (2) of Rule
116 of the Central Motor Vehicles
Rules.


"&t%'s%st&'!"'%!'&&

Loose objects
Loose objects in the driver’s foot
area could interfere with the oper
ation of the foot pedals, possibly
causing an accident. Do not place
anything under the front seats.
WARNING
Uprighting seat
When you return the seatback to
its upright position, hold the seat
back and return it slowly and be
sure there are no other occupants
around the seat. If the seatback is
returned without being held and
controlled, the back of the seat
could move forward or backward
resulting in accidental injury to a
person struck by the seatback.
WARNING
Driver responsibility for
passengers
Riding in a vehicle with seatback
reclined could lead to serious or
fatal injury in an accident. If a seat
is reclined during an accident, the
occupant’s hips may slide under the
lap portion of the seat belt applying
great force to the unprotected
abdomen. The protection of your
restraint system (seat belt and air
bags) is greatly reduced by reclin
ing your seat. Serious or fatal inter
nal injuries could result. The driver
m

ust advise the passenger to keep
the seatback in an upright position
whenever the vehicle is in motion.
WARNING
Do not use a sitting cushion that
reduces friction between the seat
and passenger. The passenger's
hips may slide under the lap por
tion of the seat belt during an acci
dent or a sudden stop. Serious or
fatal internal injuries could result
because the seat belt can't oper
ate normally.
WARNING

1
"&t%'s%st&'!"'%!'&&
If you continue not to fasten the seat
belt and you drive over 9 km\fh, the
illuminated warning light will start to
blink until you drive under 6 km\fh.
If you continue not to fasten the seat
belt and you drive over 20 km\fh (12
mph) the seat belt warning chime will
sound for approximately 100 sec
onds and the corresponding warning
light will blink.
*: if equipped
Lap\fshoulder belt
To fasten your seat belt:
To fasten your seat belt, pull it out of
the retractor and insert the metal tab
(1) into the buckle (2). There will be
an audible "click" when the tab locks
into the buckle. You should place the lap belt (1) por
tion across your hips and the shoul
der belt (2) por tion across your
chest.
The seat belt automatically adjusts to
the proper length only after the lap
belt portion is adjusted manually so
that it fits snugly around your hips. If
you lean forward in a slow, easy
motion, the belt will extend and let
you move around. If there is a sud
den stop or impact, however, the belt
will lock into position. It will also lock
if you try to lean forward too quickly.
ODH033055
ODH033053

2
"&t%'s%st&'!"'%!'&&

To reduce the chance of serious or
fatal injuries:
•Children of all ages are safer
when restrained in the rear seat.
A child riding in the front passen
ger seat can be forcefully struck
by an inflating air bag resulting in
serious or fatal injuries.
•Always follow the instructions for
installation and use of the child
restraint maker.
•Always make sure the child seat
is secured properly in the car and
your child is securely
restrained
in the child seat.
•Never hold a child in your arms or
lap when riding in a vehicle. The
violent forces created during a
crash will tear the child from your
arms and throw the child against
the car’s interior.
(Continued)
WARNING (Continued)
•Never put a seat belt over yourself
and a child. During a crash, the
belt could press deep into the
child causing serious internal
injuries.
•Never leave children unattended
in a vehicle – not even for a short
time. The car can heat up very
quickly, resulting in serious
injuries to children inside. Even
very young children may inadver
tently cause the vehicle to move,
entangle themselves in the win
dows, or lock themselves or oth
ers inside the vehicle.
•Never allow two children, or any
two persons, to use the same seat
belt.
•Children often squirm and reposi
tion themselves improperly.
Never let a child ride with the
shoulder belt under their arm or
behind their back. Always proper
ly position and secure children in
rear seat.(Continued)
(Continued)
•Never allow a child to standup or
kneel on the seat or floorboard of
a moving vehicle. During a colli
sion or sudden stop, the child can
be violently thrown against the
vehicles interior, resulting in seri
ous injury.
•Never use an infant carrier or a
child safety seat that "hooks"
over a seatback, it may not pro
vide adequate security in an acci
dent.
•Seat belts can become very hot,
especially when the ca
r is parked
in direct sunlight. Always check
seat belt buckles before fasten
ing them over a child.
•After an accident, we recom
mend that the system be
checked by an authorized
HYUNDAI dealer.
•If there is not enough space to
place the child restraint system
because of the driver's seat,
install the child restraint system
in the rear right seat.


"&t%'s%st&'!"'%!'&&

• There are even circumstancesunder which contact with the steer
ing wheel air bag can cause fatal
injuries, especially if the occupant is
positioned excessively close to the
steering wheel.Noise and smoke
When the air bags inflate, they make
a loud noise and they leave smoke
and powder in the air inside of the
vehicle. This is normal and is a result
of the ignition of the air bag inflator.
After the air bag inflates, you may
feel substantial discomfort in breath
ing due to the contact of your chest
with both the seat belt and the air
bag, as well as from breathing the
smoke and powder. Open your doors
and\for windows as soon as possible
after impact in order to reduce dis
comfort and prevent prolonged expo
sure to the smoke and powder.
Though smoke and powder are non
toxic, it may cause irritation to the
skin (eyes, nose and throat, etc.). If
this is the case, wash and rinse with
cold water immediately and consult
with the doctor if the symptom per
sists.
•To avoid severe personal injury
or death caused by deploying air
bags in a collision, the driver
should sit as far back from the
steering wheel air bag as possi
ble. The front passenger should
always move their seat as far
back as possible and sit back in
their seat.
•Air bag inflates instantly in an
event of a collision, passengers
may be injured by the air bag
expansion force if they are not in
a proper position.
•Air bag inflation may cause
injuries including facial or bodily
abrasions, injuries from broken
glasses or burns.
When the air bags deploy, the air
bag related parts in the steering
wheel and\for instrument panel
and\for in both sides of the roof
rails above the front and rear
doors are very hot. To prevent
injury, do not touch the air bag
storage areas internal compo
nents immediately after an air bag
has inflated.
WARNING
WARNING

 
"&t%'s%st&'!"'%!'&&

They are designed to help protect
the heads of the front seat occupants
and the rear outboard seat occu
pants in certain side impact colli
sions.
The curtain air bags are designed to
deploy only during cer tain side
impact collisions, depending on the
crash severity, angle, speed and
impact. The curtain air bags are not
designed to deploy in all side impact
situations, collisions from the front or
rear of the vehicle or in most rollover
situations.
•In order for side impact and cur
tain air bags to provide the best
protection, both front seat occu
pants and both outboard rear
occupants should sit in an upright
position with the seat belts prop
erly fastened.
Importantly, children should sit in
a proper child restraint system in
the rear seat.
(Continued)
WARNING
(Continued)
•When children are seated in the
rear outboard seats, they must
be seated in the proper child
restraint system. Make sure to
put the child restraint system as
far away from the door side as
possible, and secure the child
restraint system in a locked posi
tion.
•Do not place any objects over the
air bag. Also, do not attach any
objects around the area the air
bag inflates such as the door,
side door glass, front and rear pil
l

ar, roof side rail.
•Do not hang other objects except
clothes, especially hard or break
able objects. In an accident, it
may cause vehicle damage or
personal injury.
(Continued)
(Continued)
•Do not allow the passengers to
lean their heads or bodies onto
doors, put their arms on the
doors, stretch their arms out of
the window, or place objects
between the doors and passen
gers when they are seated on
seats equipped with side and\for
curtain air bags.
•Do not open or repair the side
curtain air bags.
•Never try to open or repair any
components of the side curtain
air bag system. We recommend
that the syst

em be serviced by an
authorized HYUNDAI dealer.
Failure to follow the above men
tioned instructions can result in
injury or death to the vehicle occu
pants in an accident.