engine coolant JEEP WRANGLER 2004 TJ / 2.G User Guide

Miles 93,000 96,000 99,000 102,000 105,000
(Kilometers) (149 000) (154 000) (158 000) (163 000) (168 000)
Change the engine oil and engine oil filter. X X X X X
Inspect the engine air filter element, replace if
necessary.X
Lubricate the steering linkage tie rod ends. X X X X X
Lubricate the steering and suspension ball joints. X X
Inspect the brake linings. X
Drain and refill the front and rear axle fluid³ X
Inspect the drive belt and replace as needed. Not
required if belt was previously replaced.X
Flush and replace the engine coolant. X
SCHEDULE ªBº 271
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 60,000 66,000 72,000 78,000
(Kilometers) (96 000) (106 000) (115 000) (125 000)
[Months] [60] [66] [72] [78]
Change the engine oil and engine oil filter. X X X X
Inspect the engine air filter element, and replace if nec-
essary.X
Inspect the PCV Valve, and replace if necessary.LX
Replace the ignition cables (2.4L Only).X
Replace the spark plugs.X
Lubricate the steering linkage joints and outer tie rod
ends.XXXX
Lubricate the steering and suspension ball joints. X X
Inspect the brake linings. X
Inspect the drive belt, and replace as needed. X
Inspect the drive belt, and replace as needed. Not re-
quired if belt was previously replaced.X
Flush and replace the engine coolant at 60 months, re-
gardless of mileage.X
Inspect transfer case fluid. X
276 SCHEDULE ªAº
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 84,000 90,000 96,000 102, 000
(Kilometers) (134 000) (144 000) (154 000) (163 000)
[Months] [84] [90] [96] [102]
Change the engine oil and engine oil filter. X X X X
Inspect the engine air filter element, and replace if nec-
essary.X
Inspect the PCV Valve, and replace if necessary.LX
Replace the spark plugs.X
Lubricate the steering linkage joints and outer tie rod
ends.XXXX
Lubricate the steering and suspension ball joints. X X
Inspect the brake linings. X
Inspect the drive belt, and replace as needed. Not re-
quired if previously replaced.XX
Flush and replace the engine coolant if not done at 60
months.X
Inspect the transfer case fluid. X
SCHEDULE ªAº 277
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

About Your Brakes...................... 177
Add-A-Trunk........................... 65
Adding Washer Fluid.................... 155
Air Cleaner, Engine..................... 234
Air Conditioner Maintenance.............. 235
Air Conditioning....................... 151
Air Conditioning Controls................ 152
Air Conditioning, Operating Tips........... 154
Air Conditioning Refrigerant.............. 236
Air Filter............................. 234
Air Pressure, Tires...................... 192
Airbag................................ 22
Airbag Deployment...................... 27
Airbag Light........................29,118
Airbag Maintenance...................... 29
Airbag On/Off Switch.................... 26
Alignment and Balance.................. 195
Alterations/Modifications, Vehicle............ 8
Antenna, Satellite Radio.................. 147
Antifreeze (Engine Coolant)............... 258
Anti-Lock Brake System.................. 179
Anti-Lock Warning Light................. 119
Appearance Care....................... 248Ashtray............................... 62
Ashtrays and Lighter..................... 62
Automatic Dimming Mirror................ 46
Automatic Transmission...............165,245
Adding Fluid........................ 246
Fluid and Filter Changes................ 245
Fluid Level Check..................... 245
Fluid Type.......................... 245
Gear Ranges......................... 166
Shifting............................ 165
Special Additives..................... 246
Torque Converter..................... 170
Auxiliary Electrical Outlet................. 63
Auxiliary Power Outlet................... 63
Battery............................... 234
Emergency Starting.................... 216
Voltmeter........................... 116
Belts, Drive........................... 231
Belts, Seat............................. 17
Body Mechanism Lubrication.............. 237
Brake System.......................... 243
Anti-Lock........................... 179
288 INDEX

Hoses.............................. 243
Master Cylinder...................... 244
Parking............................ 175
Warning Light....................... 119
Brakes............................... 177
Brake/Transmission Interlock.............. 166
Break-In Recommendations, New Vehicle...... 39
Bulb Replacement...................... 257
Calibration, Compass..................... 47
Capacities, Fluid....................... 258
Caps, Filler
Fuel............................... 200
Power Steering....................... 236
Car Washes........................... 249
Carpeting............................. 252
Cassette Tape and Player Maintenance....... 148
Cassette Tape Player.........126,130,132,140,142
Catalytic Converter..................... 232
Caution, Exhaust Gas..................... 40
CD Changer........................133,138
CD Player......................128,135,137
CD Player Maintenance.................. 149Cellular Phone......................... 149
Chains, Tire........................... 196
Changing A Flat Tire.................... 213
Chart, Tire Sizing....................... 185
Check Engine Light..................... 118
Child Restraint.....................29,33,36
Child Restraint Tether Anchors............. 33
Cigar Lighter........................... 62
Climate Control........................ 149
Clock................................ 120
Clutch Interlocking Ignition System......160,165
Compact Disc Maintenance............... 149
Compact Disc Player.................... 140
Compass.............................. 46
Compass Calibration..................... 47
Compass Variance....................... 48
Console............................... 65
Console, Floor.......................... 65
Contract, Service....................... 282
Converter, Catalytic..................... 232
Cooling System........................ 239
Adding Coolant (Antifreeze)............. 241
Coolant Capacity..................... 258
INDEX 289
10

Coolant Level........................ 241
Disposal of Used Coolant............... 240
Drain, Flush, and Refill................. 239
Inspection........................... 239
Points to Remember................... 242
Pressure Cap........................ 241
Selection of Coolant................240,258
Temperature Gauge.................... 118
Corrosion Protection.................... 248
Crankcase Emission Control System......... 234
Cruise Control.......................... 60
Cruise Light........................... 116
Cup Holder............................ 64
Customer Assistance.................... 280
Daytime Running Lights.................. 58
Dealer Service......................... 227
Defroster, Rear Window.................. 154
Defroster, Windshield.................151,153
Delay Wipers........................... 58
Deploying, Airbag....................... 27
Diagnostic System, Onboard............... 225
Dimmer Switch, Headlight................. 57Dipsticks
Oil (Engine)......................... 228
Disabled Vehicle Towing................. 219
Disposal
Engine Oil.......................... 231
Used Coolant........................ 240
Door Locks............................ 15
Doors................................ 15
Drive Belts............................ 231
Driving.............................. 181
Off-Pavement........................ 181
Off-Road........................... 181
On Hills............................ 182
On Slippery Surfaces.................. 181
When to Use Low Range............... 181
Dual Top.............................. 66
Electrical Outlet, Auxiliary................. 63
Electrical Power Outlets................... 63
Electronic Speed Control.................. 60
Emergency Brake....................... 175
Emergency, In Case of
Brake Warning Light................... 119
290 INDEX

Coolant Temperature Gauge............. 118
Engine Oil Pressure Gauge.............. 117
Jacking............................. 211
Jump Starting........................ 216
Emission Control System Maintenance....226,262
Engine
Air Cleaner.......................... 234
Block Heater......................... 162
Break-In Recommendations............... 39
Compartment........................ 224
Exhaust Gas Caution................... 40
Fails to Start......................... 161
Flooded, Starting..................... 161
Fuel Requirements.................197,258
Jump Starting........................ 216
Oil .............................228,258
Oil Disposal......................... 231
Oil Filter............................ 231
Oil Pressure Gauge.................... 117
Oil Selection......................... 258
Overheating......................... 210
Starting............................ 160
Temperature Gauge.................... 118Engine Oil Viscosity Chart................ 230
Entry System, Illuminated................. 15
Exhaust Gas Caution..................... 40
Exhaust System........................ 238
Extender, Seat Belt....................... 21
Exterior Finish Care..................... 249
Fabric Care........................250,252
Fabric Top............................ 250
Filters
Air Cleaner.......................... 234
Engine Fuel......................... 234
Engine Oil.......................... 231
Finish Care........................... 249
Flashers
Hazard Warning...................... 210
Turn Signal.......................... 116
Flooded Engine Starting.................. 161
Fluid Capacities........................ 258
Fluid Level Checks...................... 248
Automatic Transmission................ 245
Engine Oil.......................... 228
Manual Transmission.................. 247
INDEX 291
10

Power Steering....................... 236
Fog Lights............................. 58
Folding Rear Seat....................... 52
Folding Windshield..................... 102
Four Wheel Drive...................... 170
Shifting............................ 171
Four Wheel Drive Operation.............. 170
Front Axle............................ 248
Fuel................................. 197
Filler Cap........................... 200
Filter.............................. 234
Gasoline............................ 197
Gauge............................. 120
Materials Added...................... 199
Octane Rating........................ 197
Requirements........................ 258
Tank Capacity........................ 258
Fuel System Caution.................... 200
Fuses................................ 254
GasCap .............................. 200
Gasoline............................. 197
Gasoline, Reformulated.................. 198Gasoline/Oxygenate Blends............... 198
Gauges
Coolant Temperature................... 118
Fuel............................... 120
Odometer........................... 119
Oil Pressure......................... 117
Speedometer......................... 117
Tachometer.......................... 116
Voltmeter........................... 116
Gear Ranges........................164,166
Glass Cleaning......................... 252
Glove Compartment..................... 65
HardTop .............................. 78
Hard Top Removal...................... 79
Hazard Warning Flasher.................. 210
Headlights
Dimmer Switch....................... 57
Switch.............................. 57
Heater............................... 150
Heater, Engine Block.................... 162
High Beam Indicator.................... 117
Holder, Cup........................... 64
292 INDEX

Sentry Key............................ 12
Sentry Key Programming.................. 13
Sentry Key Replacement.................. 13
Service Assistance...................... 280
Service Contract........................ 282
Service Manuals........................ 285
Setting the Clock....................... 120
Shift Indicator Light..................... 117
Shift Speeds, Manual Transmission.......... 164
Shifting.............................. 163
Automatic Transmission................ 165
Manual Transmission.................. 163
Shoulder Belt Upper Anchorage............. 21
Shoulder Belts.......................... 17
Signals, Turn........................58,116
Snow Chains.......................... 196
Snow Plow........................... 205
Soft Top............................... 82
Spare Tire............................ 213
Spark Plugs........................... 232
Specifications
Fuel............................... 197
Oil ................................ 230Speed Control.......................... 60
Speedometer.......................... 117
Starting.............................. 160
Automatic Transmission................ 160
Emergency (Jump Starting).............. 216
Engine Block Heater................... 162
Engine Fails to Start................... 161
Manual Transmission.................. 160
Starting Procedures..................... 160
Steering
Power............................. 236
Tilt Column.......................... 60
Wheel Lock.......................... 14
Wheel, Tilt........................... 60
Storage............................65,256
Storage, Vehicle........................ 256
Storing Your Vehicle..................... 256
Supplemental Restraint System - Airbag....... 22
Tachometer........................... 116
Temperature Gauge, Engine Coolant......... 118
Tether Anchor, Child Restraint.............. 33
Tilt Steering Column..................... 60
INDEX 297
10