engine coolant KIA OPTIMA PLUG-IN HYBRID 2017 Owners Manual

ENGINE COMPARTMENT
(BTPMJOF
&OHJOF
/V
-

(%*

5IF
BDUVBM
FOHJOF
SPPN
JO
UIF
WFIJDMF
NBZ
EJGGFS
GSPN
UIF
JMMVTUSBUJPO
1. Engine coolant reservoir..................... ..................... p. 9-28
2. Engine oil filler cap.......................... .......................... p. 9-24
3. Engine oil dipstick........................... ........................... p. 9-24
4. Brake fluid reservoir.................................................. p. 9-30
5. Air cleaner................................. ................................. p. 9-33
6. Fuse box................................... ................................... p. 9-52
7. Inverter coolant reservoir.................... .................... p. 9-27
8. Radiator cap............................... ............................... p. 9-28
9. Windshield washer fluid reservoir............. ............. p. 9-31

3-07
3
Your vehicle at a glance

You should refill the fuel tank to pre‐
vent hybrid battery damage.
Refill inverter coolant
This warning message illuminates when
the inverter coolant is nearly empty.
You should refill the inverter coolant.
Check brakes
This warning message illuminates when
the brake performance is low or the re‐ generative brake does not work prop‐
erly due to a failure in the brake sys‐
tem.
In this case, it may take longer for the brake pedal to operate and the braking
distance may become longer.
Stop vehicle and check brakes
This warning message is displayed
when a failure occurs in the brake sys‐ tem.
In this case, park the vehicle in a safe
location and we recommend you to tow
your vehicle to the nearest authorized Kia dealer and have the vehicle inspec‐
ted.
Coasting guide (if equipped)
A chime will sound and the coasting
guide indicator will blink four times to inform the driver when to take the foot
off from the accelerator by anticipating
a decelerating event* based on the analysis of driving routes and road con‐
ditions of the navigation. It encourages
the driver to remove foot from the pedal and allow coasting down the road
with EV motor only. This helps prevent
unnecessary fuel consumption and in‐ creases fuel efficiency. ❈ Example of a deceleration event is
going down an extended hill, slow‐ ing down approaching a toll booth,
and approaching reduced speed
zones.
• User settings
Press the Engine Start/Stop button
and put the shift lever in P (Park). In
the User Settings Mode, select Driv‐
ing Assist, Coasting Guide, and then On to turn on the system. Cancel the
selection of coasting guide to turn off
the system. For the explanation of
the system, press and hold the [OK]
button.
• Operation conditions To activate the system, take the fol‐
lowing procedures. Enter your desti‐
nation information on the navigation
and select the driving route. Select the ECO mode in the Integrated Driv‐
ing Control System. Then, satisfy the
following. - The driving speed should be be‐ tween 60 km/h (37 mph) and
160 km/h (99 mph).
❈ The operating speed may vary due
to difference between instrument
cluster and navigation effected by
tire inflation level.
Unplug vehicle to start (Plug-in
Hybrid)
The message is displayed when you
start the engine without unplugging
the charging cable. Unplug the charging
cable, and then start the vehicle.
Remaining charge time (Plug-in
Hybrid)
The message is displayed to notify the
remaining time to fully charge the bat‐ tery.
Shift to P to charge (Plug-in
Hybrid)
The message is displayed when the
charging connector is plugged with the
shift lever in R (Reverse), N (Neutral) or
D (Drive). Move the shift lever to P
(Park) and re-start the charging proc‐ ess.
Features of your vehicle
5-76

BEFORE DRIVING
Before entering vehicle
• Be sure that all windows, outsidemirror(s), and outside lights are clean.
• Check the condition of the tires.
• Check under the vehicle for any sign of leaks.
• Be sure there are no obstacles behind you if you intend to back up.
Necessary inspections
Fluid levels, such as engine oil, engine
coolant, brake fluid, and washer fluid should be checked on a regular basis,
with the exact interval depending on
the fluid. Further details are provided in Chapter 9, Maintenance.
WARNING
Driving while distracted can result ina loss of vehicle control, that maylead to an accident, severe personalinjury, and death. The driver’s pri‐mary responsibility is in the safe andlegal operation of a vehicle, and useof any handheld devices, otherequipment, or vehicle systems which
(Continued)
(Continued)
take the driver’s eyes, attention andfocus away from the safe operationof a vehicle or which are not permis‐sible by law should never be usedduring operation of the vehicle.
Before starting
• Close and lock all doors.
• Position the seat so that all controls
are easily reached.
• Adjust the inside and outside rear‐ view mirrors.
• Be sure that all lights work.
• Check all gauges.
• Check the operation of warning lights when the engine start/stop button
switch is turned to the ON position.
• Release the parking brake and make sure the brake warning light goes
out.
For safe operation, be sure you are fa‐ miliar with your vehicle and its equip‐
ment.
WARNING
All passengers must be properly bel‐ted whenever the vehicle is moving.Refer to L

• When the coolant temperature is low:The system will be limited until en‐
gine performance becomes normal.
• When driving up a hill: The system will be limited to gain
power when driving uphill because the engine torque is restricted.
• When using manual mode: The system will be limited according
to the shift location.
• When the accelerator pedal is deeply depressed for a few seconds:
The system will be limited, judging
that the driver wants to speed up.
SPORT mode
SPORT
SPORT mode focu‐ ses on dynamic driv‐ing by automatically
controlling thesteering wheel, en‐gine and transaxlesystem.
• When the DRIVE MODE button is pressed and the SPORT mode is se‐
lected, the SPORT indicator (yellow) will illuminate. • Whenever the hybrid system is re‐
started, the Drive Mode will revert
back to ECO mode. If SPORT mode is
desired, re-select SPORT mode from
the DRIVE MODE button
• If the system is activated: - After speeding, it maintains the gear and RPM for some time even
though the accelerator pedal is not depressed.
- Up-shifting is delayed.
NOTICE
In Sport drive mode, the fuel effi‐
ciency may decrease.
Driving your vehicle
7-76

DRIVE MODE INTEGRATED CONTROL SYSTEM (IF EQUIPPED)
Plug-in hybrid vehicle
0+')1-
The drive mode may be selected ac‐
cording to the driver’s preference or road condition.
The system resets to be in the ECO
mode, when the hybrid system is re‐
started.
If there is a problem with the instru‐ ment cluster, the drive mode will be in
ECO mode and may not change to NOR‐
MAL mode.
The mode changes whenever the DRIVE MODE button is pressed.
/03."- &$0
❈ When normal mode is selected, it is
not displayed on the cluster.
ECO mode (Active ECO)
ECO
Active ECO helps
improve fuel effi‐
ciency by control‐ling certain en‐gine and trans‐axle system op‐erating parame‐ters. Fuel effi‐ciency depends
on the driver'sdriving habit and
road condition.
• When the DRIVE MODE button is pressed and the ECO mode is selec‐
ted, the ECO indicator (green) will illu‐ minate to show that the Active ECO
is operating.
• When the Active ECO is activated, it does not turn off even though the
engine is restarted again. To turn off
the system, press the DRIVE MODE button again.
When Active ECO is activated:
• The acceleration may slightly be re‐ duced eventhough you depress the
accelerator fully.
• The air conditioner performance may be limited
• The shift pattern of the automatic transaxle may change.
• The engine noise may get louder.
The above situations are normal condi‐
tions when the active eco system is ac‐
tivated to improve fuel efficiency.
Limitation of Active ECO operation:
If the following conditions occur while Active ECO is operating, the system op‐
eration is limited even though there is
no change in the ECO indicator. • When the coolant temperature is low: The system will be limited until en‐
gine performance becomes normal.
• When driving up a hill: The system will be limited to gainpower when driving uphill because
the engine torque is restricted.
• When using manual mode: The system will be limited according
to the shift location.

7-77
7
Driving your vehicle

Use approved window washer
anti-freeze in system
To keep the water in the window wash‐er system from freezing, add an ap‐
proved window washer anti-freeze sol‐
ution in accordance with instructions on the container. Window washer anti-
freeze is available from an authorized
Kia dealer and most auto parts outlets. Do not use engine coolant or other
types of anti-freeze as these may
damage the paint finish.
Don't let your parking brake
freeze
Under some conditions your parking
brake can freeze in the engaged posi‐ tion. This is most likely to happen when
there is an accumulation of snow or ice
around or near the rear brakes or if the brakes are wet. If there is a risk the
parking brake may freeze, apply it only
temporarily while you put the shift lev‐ er in P (Automatic Transaxle / Dual
clutch transmission) or in first or re‐
verse gear (manual transaxle) and block
the rear wheels so the vehicle cannot roll. Then release the parking brake.
Don't let ice and snow
accumulate underneath
Under some conditions, snow and ice can build up under the fenders and in‐
terfere with the steering. When driving
in severe winter conditions where this may happen, you should periodically
check underneath the vehicle to be sure
the movement of the front wheels and the steering components is not ob‐
structed.
Carry emergency equipment
Depending on the severity of the
weather, you should carry appropriate emergency equipment. Some of the
items you may want to carry include
tire chains, tow straps or chains, flash‐ light, emergency flares, sand, shovel,
jumper cables, window scraper, gloves,
ground cloth, coveralls, blanket, etc.
Driving your vehicle
7-106

CAUTION
•Serious loss of coolant indicatesthere is a leak in the cooling sys‐tem and we recommend that thesystem be checked by an author‐ized Kia dealer.
•When the engine overheats fromlow engine coolant, suddenly add‐ing engine coolant may causecracks in the engine. To preventdamage, add engine coolant slowlyin small quantities.
What to do in an emergency
8-08

Engine compartment................................................................ 9-03
Maintenance services............................................................... 9-04Owner’s responsibility.......................................................... 9-04
Owner maintenance precautions....................................... 9-04
Owner maintenance................................................................. 9-06 Owner maintenance schedule.............................................9-06
Scheduled maintenance service............................................. 9-08 Scheduled maintenance service precaution..................... 9-08
Normal maintenance schedule - for gasoline en‐ gine [for Europe (except Russia)].......................................9-09
Normal maintenance schedule - for gasoline en‐ gine [for Europe (except Russia)] (Continued)................. 9-10
Maintenance under severe usage conditions - for gasoline engine [for Europe (except Russia)]...................9-12
Normal maintenance schedule - for gasoline en‐ gine [except Europe (including Russia)]............................ 9-14
Normal maintenance schedule - for gasoline en‐ gine [except Europe (including Russia)] (Continued).......9-15
Maintenance under severe usage conditions - for gasoline engine [except Europe (including Russia)]........ 9-18
Explanation of scheduled maintenance items..................... 9-21 Engine oil and filter............................................................... 9-21
HSG (hybrid starter & generator) belt.............................. 9-21
Fuel filter (for gasoline)....................................................... 9-21
Fuel lines, fuel hoses and connections.............................. 9-21
Vapor hose (for gasoline engine) and fuel filler cap........9-21
Vacuum crankcase ventilation hoses ................................9-21
Air cleaner filter.....................................................................9-21
Spark plugs (for gasoline engine)....................................... 9-21
Cooling system...................................................................... 9-22 Coolant (Engine/Inverter).................................................... 9-22
Automatic transaxle fluid.................................................... 9-22
Brake hoses and lines........................................................... 9-22
Brake fluid ............................................................................. 9-22
Parking brake ........................................................................ 9-22
Brake discs, pads, calipers and rotors............................... 9-22
Suspension mounting bolts................................................. 9-22Steering gear box, linkage & boots/lower arm
ball joint.................................................................................. 9-22
Drive shafts and boots......................................................... 9-22
Air conditioning refrigerant................................................. 9-23
Engine oil.....................................................................................9-24 Checking the engine oil level................................................9-24
Changing the engine oil and filter...................................... 9-24
Coolant........................................................................................ 9-26 Checking the coolant level................................................... 9-26
Engine coolant....................................................................... 9-27
Inverter coolant..................................................................... 9-27
Recommended coolant.........................................................9-28
Changing the coolant............................................................ 9-29
Brake fluid ................................................................................. 9-30 Checking the brake fluid level............................................. 9-30
Washer fluid............................................................................... 9-31 Checking the washer fluid level.......................................... 9-31
Parking brake ............................................................................ 9-32 Checking the parking brake................................................. 9-32
Air cleaner.................................................................................. 9-33 Filter replacement.................................................................9-33
Climate control air filter........................................................... 9-35 Filter inspection..................................................................... 9-35
Maintenance

9

ENGINE COMPARTMENT
(BTPMJOF
&OHJOF
/V
-

(%*

5IF
BDUVBM
FOHJOF
SPPN
JO
UIF
WFIJDMF
NBZ
EJGGFS
GSPN
UIF
JMMVTUSBUJPO
1. Engine coolant reservoir
2. Engine oil filler cap
3. Engine oil dipstick
4. Brake fluid reservoir
5. Air cleaner
6. Fuse box
7. Inverter coolant reservoir
8. Radiator cap
9. Windshield washer fluid reservoir

9-03
9
Maintenance

OWNER MAINTENANCE
The following lists are vehicle checks
and inspections that should be per‐
formed at the frequencies indicated to help ensure safe, dependable operation
of your vehicle.
Any adverse conditions should be
brought to the attention of your dealer as soon as possible.
These Owner Maintenance Checks are
generally not covered by warranties
and you may be charged for labor, parts and lubricants used.
Owner maintenance schedule
When you stop for fuel:
• Check the engine oil level.
• Check the coolant level in the coolant reservoir.
• Check the windshield washer fluid level.
• Look for low or under-inflated tires.
WARNING
Be careful when checking your en‐gine coolant level when the engine ishot. Scalding hot coolant and steam
(Continued)
(Continued)
may blow out under pressure. Thiscould cause burns or other seriousinjury.
While operating your vehicle:
• Note any changes in the sound of the exhaust or any smell of exhaust
fumes in the vehicle.
• Check for vibrations in the steering wheel. Notice any increased steering
effort or looseness in the steering
wheel, or change in its straight-
ahead position.
• Notice if your vehicle constantly turns slightly or L