heater LAMBORGHINI GALLARDO 2009 Workshop Manual
Page 10 of 1659
10
L714 00 00 00
® Automobili Lamborghini S.p.A. 7 K H L Q I R U P D W L R Q D Q G S U R F H G X U H V S X E O L V K H G E H O R Z D U H V W U L F W O \ F R Q ¿ G H Q W L D O D Q G H [ F O X V L Y H O \ I R U W K H / D P E R U J K L Q L ' H D O H U 1 H W Z R U N D Q G $ X W K R U L ] H G 6 H U Y L F H 3 R L Q W V $ O O F R S \ U L J K W V D U H S U R S H U W \ R I $ X W R P R E L O L
/ D P E R U J K L Q L 6 S $ E D V H G R Q F R S \ U L J K W O D Z $ O O R I W K H 3 ' ) F K D S W H U V L Q W K H : ( % Z R U N V K R S P D Q X D O V G H V F U L E H G E H O R Z D U H E D V H G R Q L Q I R U P D W L R Q D Y D L O D E O H D W W K H W L P H R I S X E O L F D W L R Q 7 K H F R P S D Q \ U H V H U Y H V
W K H U L J K W W R P D N H X S G D W H V D Q G P R G L ¿ F D W L R Q V 7 K H I R O O R Z L Q J D U H S U R K L E L W H G U H S U L Q W L Q J U H S U R G X F W L R Q I R U Z D U G L Q J W R X Q D X W K R U L ] H G S H R S O H D Q G R U W K L U G S D U W L H V D Q G W U D Q V O D W L R Q L Q F O X G L Q J S D U W L D O Z L W K R X W
Z U L W W H Q D X W K R U L ] D W L R Q I U R P $ X W R P R E L O L / D P E R U J K L Q L 6 S $
Main group SubgroupSubgroup 7 L W O H L G H Q W L ¿ F D W L R Q
08Body 00 $ V V H P E O L H V 41Wing door 00Description
01 ) O R R U D V V H P E O \ I R R W U H V W 43Sliding door 01Check (control)
02 Pedal cluster 45 : L Q G R Z J O D V V Z H D W K H U V W U L S V 02Adjustment
03 Engine compartment panels 47 6 L G H Z L Q G R Z V 03 ' L V D V V H P E O H
04Frame 53 6 L G H P H P E H U V 04Cleaning
05Front end upholstery 54Trim & protection strip inner 05 $ V V H P E O H
06 ) U R Q W H Q G E R Q Q H W Z L W K F G K R O G H U
57Interior equipment 06Bleeding
07 Bumper
58Imperial roof accessories 07 ) O X L G V V X E V W L W X W L R Q
09 VACS side spoilers 59Interior equipment 08Filling and topping up
10Side panel 60Optional equipment 09Overhaul
11 ( [ W H U Q D O U H D U Y L H Z P L U U R U 61Optional equipment 10Error code
13 Rear end 62Optional equipment 11
0 H D V X U H P H Q W E O R F N U H D G L Q J
14 Rear end 63Tunnel 12Running-in
15Heater 64Insulation and sound damping 13Adjustment coding
16 $ L U F R Q G L W L R Q L Q J D L U ¿ O W H U V
67Inner trim and licence plates 14
' L D J Q R V L V V R I W Z D U H
17Imperial roof, molding 68Inner trim
19 $ X [ + H D W H U Y H Q W 6 \ V W H P 71 F R Q 7 R S
20 Body
72 F R Q 7 R S
21 ) U R Q W D Q G E D F N I H Q G H U Z K H H O D U F K 75 6 W H H U L Q J Z K H H O
23 Hood
80 6 D I H W \ H T X L S P H Q W S D V V 6 L G H
25 ) O R R U E R W W R P V 81Front seat
27 Rear trunk, fan grille spoiler 82Front seat
29 Tailgate and side gate 83
( [ W H U Q D O S D L Q W Z R U N ± & R O R X U F R G H
31 ' R R U E R G \ S O D L Q I U R Q W 87 & R Q W U R O Q X P E H U
33 ' R R U E R G \ L Q Z K L W H U H D U 90Reserved
37 ' R R U G Z L Q G R Z S D U W V I U R Q W 98Repair kit
39 ' R R U G Z L Q G R Z S D U W U H D U 99 ) L ] L Q J Z L W K V X V S H Q V L R Q
Page 21 of 1659
21
L714 00 00 00
® Automobili Lamborghini S.p.A. 7 K H L Q I R U P D W L R Q D Q G S U R F H G X U H V S X E O L V K H G E H O R Z D U H V W U L F W O \ F R Q ¿ G H Q W L D O D Q G H [ F O X V L Y H O \ I R U W K H / D P E R U J K L Q L ' H D O H U 1 H W Z R U N D Q G $ X W K R U L ] H G 6 H U Y L F H 3 R L Q W V $ O O F R S \ U L J K W V D U H S U R S H U W \ R I $ X W R P R E L O L
/ D P E R U J K L Q L 6 S $ E D V H G R Q F R S \ U L J K W O D Z $ O O R I W K H 3 ' ) F K D S W H U V L Q W K H : ( % Z R U N V K R S P D Q X D O V G H V F U L E H G E H O R Z D U H E D V H G R Q L Q I R U P D W L R Q D Y D L O D E O H D W W K H W L P H R I S X E O L F D W L R Q 7 K H F R P S D Q \ U H V H U Y H V
W K H U L J K W W R P D N H X S G D W H V D Q G P R G L ¿ F D W L R Q V 7 K H I R O O R Z L Q J D U H S U R K L E L W H G U H S U L Q W L Q J U H S U R G X F W L R Q I R U Z D U G L Q J W R X Q D X W K R U L ] H G S H R S O H D Q G R U W K L U G S D U W L H V D Q G W U D Q V O D W L R Q L Q F O X G L Q J S D U W L D O Z L W K R X W
Z U L W W H Q D X W K R U L ] D W L R Q I U R P $ X W R P R E L O L / D P E R U J K L Q L 6 S $
Main group SubgroupSubgroup 7 L W O H L G H Q W L ¿ F D W L R Q
78 5 H W U R ¿ W 2 S W L R Q D O 00 $ V V H P E O L H V 41Wing door 00Description
Body 01 ) O R R U D V V H P E O \ I R R W U H V W 43Sliding door 01Check (control)
02 Pedal cluster 45 : L Q G R Z J O D V V Z H D W K H U V W U L S V 02Adjustment
03 Engine compartment panels 47 6 L G H Z L Q G R Z V 03 ' L V D V V H P E O H
04Frame 53 6 L G H P H P E H U V 04Cleaning
05Front end upholstery 54Trim & protection strip inner 05 $ V V H P E O H
06 ) U R Q W H Q G E R Q Q H W Z L W K F G K R O G H U
57Interior equipment 06Bleeding
07 Bumper
58Imperial roof accessories 07 ) O X L G V V X E V W L W X W L R Q
09 VACS side spoilers 59Interior equipment 08Filling and topping up
10Side panel 60Optional equipment 09Overhaul
11 ( [ W H U Q D O U H D U Y L H Z P L U U R U 61Optional equipment 10Error code
13 Rear end 62Optional equipment 11
0 H D V X U H P H Q W E O R F N U H D G L Q J
14 Rear end 63Tunnel 12Running-in
15Heater 64Insulation and sound damping 13Adjustment coding
16 $ L U F R Q G L W L R Q L Q J D L U ¿ O W H U V
67Inner trim and licence plates 14
' L D J Q R V L V V R I W Z D U H
17Imperial roof, molding 68Inner trim
19 $ X [ + H D W H U Y H Q W 6 \ V W H P 71 F R Q 7 R S
20 Body
72 F R Q 7 R S
21 ) U R Q W D Q G E D F N I H Q G H U Z K H H O D U F K 75 6 W H H U L Q J Z K H H O
23 Hood
80 6 D I H W \ H T X L S P H Q W S D V V 6 L G H
25 ) O R R U E R W W R P V 81Front seat
27 Rear trunk, fan grille spoiler 82Front seat
29 Tailgate and side gate 83
( [ W H U Q D O S D L Q W Z R U N ± & R O R X U F R G H
31 ' R R U E R G \ S O D L Q I U R Q W 87 & R Q W U R O Q X P E H U
33 ' R R U E R G \ L Q Z K L W H U H D U 90Reserved
37 ' R R U G Z L Q G R Z S D U W V I U R Q W 98Repair kit
39 ' R R U G Z L Q G R Z S D U W U H D U 99 ) L ] L Q J Z L W K V X V S H Q V L R Q
Page 513 of 1659
3
L714 02 60 00
Fig.4
BA
BA
® Automobili Lamborghini S.p.A.
7 K H L Q I R U P D W L R Q D Q G S U R F H G X U H V S X E O L V K H G E H O R Z D U H V W U L F W O \ F R Q ¿ G H Q W L D O D Q G H [ F O X V L Y H O \ I R U W K H / D P E R U J K L Q L ' H D O H U 1 H W Z R U N D Q G $ X W K R U L ] H G 6 H U Y L F H 3 R L Q W V $ O O F R S \ U L J K W V D U H S U R S H U W \ R I $ X W R P R E L O L
/ D P E R U J K L Q L 6 S $ E D V H G R Q F R S \ U L J K W O D Z $ O O R I W K H 3 ' ) F K D S W H U V L Q W K H : ( % Z R U N V K R S P D Q X D O V G H V F U L E H G E H O R Z D U H E D V H G R Q L Q I R U P D W L R Q D Y D L O D E O H D W W K H W L P H R I S X E O L F D W L R Q 7 K H F R P S D Q \ U H V H U Y H V
W K H U L J K W W R P D N H X S G D W H V D Q G P R G L ¿ F D W L R Q V 7 K H I R O O R Z L Q J D U H S U R K L E L W H G U H S U L Q W L Q J U H S U R G X F W L R Q I R U Z D U G L Q J W R X Q D X W K R U L ] H G S H R S O H D Q G R U W K L U G S D U W L H V D Q G W U D Q V O D W L R Q L Q F O X G L Q J S D U W L D O Z L W K R X W
Z U L W W H Q D X W K R U L ] D W L R Q I U R P $ X W R P R E L O L / D P E R U J K L Q L 6 S $
The heating, air conditioning and air distribution unit is “dual zone” with: •
a heater battery ( A-Fig.4) divided into two zones, each supplied by the engine coolant by means of an
independent valve
• an evaporator ( B-Fig.4) for air conditioning connected to the air conditioning system R
IGHT SIDE
L EFT SIDE
Page 1420 of 1659
2
L714 10 01 10
® Automobili Lamborghini S.p.A. 7 K H L Q I R U P D W L R Q D Q G S U R F H G X U H V S X E O L V K H G E H O R Z D U H V W U L F W O \ F R Q ¿ G H Q W L D O D Q G H [ F O X V L Y H O \ I R U W K H / D P E R U J K L Q L ' H D O H U 1 H W Z R U N D Q G $ X W K R U L ] H G 6 H U Y L F H 3 R L Q W V $ O O F R S \ U L J K W V D U H S U R S H U W \ R I $ X W R P R E L O L
/ D P E R U J K L Q L 6 S $ E D V H G R Q F R S \ U L J K W O D Z $ O O R I W K H 3 ' ) F K D S W H U V L Q W K H : ( % Z R U N V K R S P D Q X D O V G H V F U L E H G E H O R Z D U H E D V H G R Q L Q I R U P D W L R Q D Y D L O D E O H D W W K H W L P H R I S X E O L F D W L R Q 7 K H F R P S D Q \ U H V H U Y H V
W K H U L J K W W R P D N H X S G D W H V D Q G P R G L ¿ F D W L R Q V 7 K H I R O O R Z L Q J D U H S U R K L E L W H G U H S U L Q W L Q J U H S U R G X F W L R Q I R U Z D U G L Q J W R X Q D X W K R U L ] H G S H R S O H D Q G R U W K L U G S D U W L H V D Q G W U D Q V O D W L R Q L Q F O X G L Q J S D U W L D O Z L W K R X W
Z U L W W H Q D X W K R U L ] D W L R Q I U R P $ X W R P R E L O L / D P E R U J K L Q L 6 S $
Oxygen Sensorfront Bank 1 Bank 2 P0132P0152
short to battery plus
Y L U W X D O P D V V 9 0 1 H U Q V W Y R O W D J H 8 1 D G M X V W P H Q W Y R O W D J H , $ battery voltage engine start engine speed3 DCY
P0131P0151 short to ground
Y L U W X D O P D V V 9 0 1 H U Q V W Y R O W D J H 8 1 D G M X V W P H Q W Y R O W D J H , $ battery voltage engine start engine speed
P2237P2240 open circuit S X P S F X U U H Q W , 3 enrichment or lean out O2S signal front delta lambda value setting battery voltage engine start engine speed lambda control heater control electrical adjustment O2S ceramic temperature lambda modulation amplitude for
P2237 P2240 open circuit S X P S F X U U H Q W , 3 mass air integral in exhaust gas battery voltage engine start engine speed lambda control electrical adjustment O2S ceramic temperature O2S front lambda value
P2237 P2240 open circuit S X P S F X U U H Q W , 3 O2S signal front and
fuel cut off battery voltage engine start engine speed O2S ceramic temperature
( 9 $ 3 6 \ V W H P
OxygenSensorfront Bank 1 Bank 2 P2626P2629
open circuit D G M X V W P H Q W Y R O W D J H , $ O2S signal front battery voltage
engine start engine speed O2S ceramic temperature modeled exhaust temperature
fuel cut off 3 DCY
P2243P2247 open circuit 1 H U Q V W Y R O W D J H 8 1 O2S signal front battery voltage
engine start engine speed internal resistance heater control for
Page 1421 of 1659
3
L714 10 01 10
® Automobili Lamborghini S.p.A. 7 K H L Q I R U P D W L R Q D Q G S U R F H G X U H V S X E O L V K H G E H O R Z D U H V W U L F W O \ F R Q ¿ G H Q W L D O D Q G H [ F O X V L Y H O \ I R U W K H / D P E R U J K L Q L ' H D O H U 1 H W Z R U N D Q G $ X W K R U L ] H G 6 H U Y L F H 3 R L Q W V $ O O F R S \ U L J K W V D U H S U R S H U W \ R I $ X W R P R E L O L
/ D P E R U J K L Q L 6 S $ E D V H G R Q F R S \ U L J K W O D Z $ O O R I W K H 3 ' ) F K D S W H U V L Q W K H : ( % Z R U N V K R S P D Q X D O V G H V F U L E H G E H O R Z D U H E D V H G R Q L Q I R U P D W L R Q D Y D L O D E O H D W W K H W L P H R I S X E O L F D W L R Q 7 K H F R P S D Q \ U H V H U Y H V
W K H U L J K W W R P D N H X S G D W H V D Q G P R G L ¿ F D W L R Q V 7 K H I R O O R Z L Q J D U H S U R K L E L W H G U H S U L Q W L Q J U H S U R G X F W L R Q I R U Z D U G L Q J W R X Q D X W K R U L ] H G S H R S O H D Q G R U W K L U G S D U W L H V D Q G W U D Q V O D W L R Q L Q F O X G L Q J S D U W L D O Z L W K R X W
Z U L W W H Q D X W K R U L ] D W L R Q I U R P $ X W R P R E L O L / D P E R U J K L Q L 6 S $
Oxygen Sensor frontBank 1 Bank 2 P2251P2254
open circuit Y L U W X D O P D V V 9 0 O2S signal front battery voltage
engine start engine speedinternal resistance heater control for3 DCY
P2414 P2415 signal range check signal range check internal voltage internal voltage battery voltage engine start engine speed
fuel cut off desired lambda O2S ceramic temperature O2S calibrated resistance O2S
P0133 P0153 signal dynamic check O2S signal front
vs. Modeled O2S signal lambda controlengine load engine speed actual Lambda
P2231P2234 F R X S O L Q J Z L W K K H D W H U
delta O2S signal front elapsed time since last O2S K H D W H U V Z L W F K R Q modeled exhaust temperature battery voltage O2S heater duty cycle engine speed desired lambda measured lambda engine load O2S ceramic temperature
OxygenSensorfrontBank 1 Bank 2 P2196 P2198
out of range adaptive value trim control after catalyst catalyst temperature
engine speed engine load P D V V D L U À R Z lambda control second control loop O2S rear secondary air
fuel cut off catalyst heat-up3 DCY
P2195 P2197 out of range adaptive value trim control after catalyst
Page 1422 of 1659
4
L714 10 01 10
® Automobili Lamborghini S.p.A. 7 K H L Q I R U P D W L R Q D Q G S U R F H G X U H V S X E O L V K H G E H O R Z D U H V W U L F W O \ F R Q ¿ G H Q W L D O D Q G H [ F O X V L Y H O \ I R U W K H / D P E R U J K L Q L ' H D O H U 1 H W Z R U N D Q G $ X W K R U L ] H G 6 H U Y L F H 3 R L Q W V $ O O F R S \ U L J K W V D U H S U R S H U W \ R I $ X W R P R E L O L
/ D P E R U J K L Q L 6 S $ E D V H G R Q F R S \ U L J K W O D Z $ O O R I W K H 3 ' ) F K D S W H U V L Q W K H : ( % Z R U N V K R S P D Q X D O V G H V F U L E H G E H O R Z D U H E D V H G R Q L Q I R U P D W L R Q D Y D L O D E O H D W W K H W L P H R I S X E O L F D W L R Q 7 K H F R P S D Q \ U H V H U Y H V
W K H U L J K W W R P D N H X S G D W H V D Q G P R G L ¿ F D W L R Q V 7 K H I R O O R Z L Q J D U H S U R K L E L W H G U H S U L Q W L Q J U H S U R G X F W L R Q I R U Z D U G L Q J W R X Q D X W K R U L ] H G S H R S O H D Q G R U W K L U G S D U W L H V D Q G W U D Q V O D W L R Q L Q F O X G L Q J S D U W L D O Z L W K R X W
Z U L W W H Q D X W K R U L ] D W L R Q I U R P $ X W R P R E L O L / D P E R U J K L Q L 6 S $
Oxygen Sensor Heaterfront Bank 1 Bank 2 P0032P0052
short to battery plus signal current
heater engine startengine speed battery voltage heater control for at least3 DCY
P0031 P0051 short to ground signal voltage
heater
P0030 P0050 open circuit
signal voltage heater
P0135 P0155 out of range high heater duty cycle
and O2S ceramic temperature battery voltage heater control
fuel cut off modeled exhaust temperature
P0606 rationality check delta resistance measured vs. modeled battery voltage
P0135 P0155 R X W R I U D Q J H O R Z
sensor ceramic temperature battery voltage
time after engine start
engine shut off time
ECT @ start
fuel cut off
Oxygen Sensor 5 H D U Bank 1 Bank 2 P0138 P0158
short to battery plus signal voltage
battery voltage engine speed 2 6 U H D U G H Z S R L Q W O2S rear andmodeled exhaust temperature for3 DCY
P0137 P0157 short to ground signal voltage
battery voltage engine speed 2 6 U H D U G H Z S R L Q W O2S rear andmodeled exhaust temperature for
ECT @ off
ECT @ start
Page 1423 of 1659
5
L714 10 01 10
® Automobili Lamborghini S.p.A. 7 K H L Q I R U P D W L R Q D Q G S U R F H G X U H V S X E O L V K H G E H O R Z D U H V W U L F W O \ F R Q ¿ G H Q W L D O D Q G H [ F O X V L Y H O \ I R U W K H / D P E R U J K L Q L ' H D O H U 1 H W Z R U N D Q G $ X W K R U L ] H G 6 H U Y L F H 3 R L Q W V $ O O F R S \ U L J K W V D U H S U R S H U W \ R I $ X W R P R E L O L
/ D P E R U J K L Q L 6 S $ E D V H G R Q F R S \ U L J K W O D Z $ O O R I W K H 3 ' ) F K D S W H U V L Q W K H : ( % Z R U N V K R S P D Q X D O V G H V F U L E H G E H O R Z D U H E D V H G R Q L Q I R U P D W L R Q D Y D L O D E O H D W W K H W L P H R I S X E O L F D W L R Q 7 K H F R P S D Q \ U H V H U Y H V
W K H U L J K W W R P D N H X S G D W H V D Q G P R G L ¿ F D W L R Q V 7 K H I R O O R Z L Q J D U H S U R K L E L W H G U H S U L Q W L Q J U H S U R G X F W L R Q I R U Z D U G L Q J W R X Q D X W K R U L ] H G S H R S O H D Q G R U W K L U G S D U W L H V D Q G W U D Q V O D W L R Q L Q F O X G L Q J S D U W L D O Z L W K R X W
Z U L W W H Q D X W K R U L ] D W L R Q I U R P $ X W R P R E L O L / D P E R U J K L Q L 6 S $
Oxygen Sensor 5 H D U Bank 1 Bank 2 P0140 P0160
signal activity check signal voltage
modeled exhaust temp. andO2S rear internal resistance battery voltage engine speed 2 6 U H D U G H Z S R L Q W O2S rear andmodeled exhaust temperature for lambda control*
R Q O \ I R U V L J Q D O Y R O W D J H 3 DCY
P0136P0156 heater coupling check delta O2S signal rear
O2S rear heater has been
V Z L W F K H G R I I L Q W K H O D V W battery voltage engine speed 2 6 U H D U G H Z S R L Q W O2S rear andmodeled exhaust temperature for
P0139 P0159 oscillation check signal output ist not oscillating at
reference value P D V V D L U À R Z O2S rear ready since catalyst temperature
Oxygen Sensor Heater rear Bank 1 Bank 2 P0038P0058
short to battery plus signal current
heater 2 6 U H D U G H Z S R L Q W heater engine speedbattery voltage3 DCY
P0037P0057 short to ground signal voltage heater
2 6 U H D U G H Z S R L Q W heaterengine speed battery voltage
P0036 P0056
open circuit
signal voltage
P0141 P0161 rationality check heater resistance battery voltage
modeled exhaust temperature
engine shut off time
IAT