automatic transmission fluid Lexus ES330 2005 Gauges, Meters and Service Reminder Indicators /

For detailed information, refer to the description given in each Section\
.
PICTORIAL INDEX
xiiPage
1Tachometer
56
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
2Traction control system off indicator light 270 . . . .
3Vehicle stability control system/traction control
system warning light 65. . . . . . . . . . . . . . . . . . . . . . . . . .
4Engine oil replacement reminder light 62
. . . . . . . . . .
5Headlight indicator light 32
. . . . . . . . . . . . . . . . . . . . . . .
6Headlight high beam indicator light 37
. . . . . . . . . . . .
7Turn signal indicator light 37
. . . . . . . . . . . . . . . . . . . . .
8Fog light indicator light 38
. . . . . . . . . . . . . . . . . . . . . . . .
9Cruise control indicator light 266
. . . . . . . . . . . . . . . .
10Slip indicator light 270, 273
. . . . . . . . . . . . . . . . . . . . . .
11Automatic headlight leveling system
warning light 66 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
12Low fuel level warning light 66
. . . . . . . . . . . . . . . . . . . .
13Automatic transmission indicator lights 260 . . . . . .
14Engine coolant temperature gauge 55
. . . . . . . . . . . . . Page
15Odometer and trip meter
56
. . . . . . . . . . . . . . . . . . . . . .
16Trip meter reset knob 56
. . . . . . . . . . . . . . . . . . . . . . . . .
17Fuel gauge 54
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
18Low washer fluid warning light 66
. . . . . . . . . . . . . . . . .
19Low engine oil level warning light 62
. . . . . . . . . . . . . .
20Multiinformation display 67
. . . . . . . . . . . . . . . . . . . . . .
21Rear light failure warning light 65
. . . . . . . . . . . . . . . . .
22Low engine oil pressure warning light 61
. . . . . . . . . .
23Brake system warning light 59
. . . . . . . . . . . . . . . . . . . .
24Antilock brake system warning light 64
. . . . . . . . . . .
25Driver’s seat belt reminder light 60
. . . . . . . . . . . . . . . .
26Discharge warning light 61
. . . . . . . . . . . . . . . . . . . . . . .
27SRS warning light 60
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
28Open door warning light 65
. . . . . . . . . . . . . . . . . . . . . . .
29Malfunction indicator lamp 63
. . . . . . . . . . . . . . . . . . . .

For detailed information, refer to the description given in each Section\
.
PICTORIAL INDEX
xivPage
1Tachometer
56
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
2Traction control system off indicator light 270 . . . .
3Vehicle stability control system/traction control
system warning light 65. . . . . . . . . . . . . . . . . . . . . . . . . .
4Tail light indicator light 34
. . . . . . . . . . . . . . . . . . . . . . . .
5Headlight high beam indicator light 37
. . . . . . . . . . . .
6Turn signal indicator light 37
. . . . . . . . . . . . . . . . . . . . .
7Fog light indicator light 38
. . . . . . . . . . . . . . . . . . . . . . . .
8Cruise control indicator light 266
. . . . . . . . . . . . . . . .
9Slip indicator light 270, 273
. . . . . . . . . . . . . . . . . . . . . .
10Automatic headlight leveling system
warning light 66 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
11Low fuel level warning light 66
. . . . . . . . . . . . . . . . . . . .
12Automatic transmission indicator lights 260 . . . . . .
13Engine coolant temperature gauge 55
. . . . . . . . . . . . . Page
14Odometer and trip meter
56
. . . . . . . . . . . . . . . . . . . . . .
15Trip meter reset knob 56
. . . . . . . . . . . . . . . . . . . . . . . . .
16Fuel gauge 54
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
17Low washer fluid warning light 66
. . . . . . . . . . . . . . . . .
18Low engine oil level warning light 62
. . . . . . . . . . . . . .
19Multiinformation display 67
. . . . . . . . . . . . . . . . . . . . . .
20Rear light failure warning light 65
. . . . . . . . . . . . . . . . .
21Low engine oil pressure warning light 61
. . . . . . . . . .
22Brake system warning light 59
. . . . . . . . . . . . . . . . . . . .
23Antilock brake system warning light 64
. . . . . . . . . . .
24Driver’s seat belt reminder light 60
. . . . . . . . . . . . . . . .
25Discharge warning light 61
. . . . . . . . . . . . . . . . . . . . . . .
26SRS warning light 60
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
27Open door warning light 65
. . . . . . . . . . . . . . . . . . . . . . .
28Malfunction indicator lamp 63
. . . . . . . . . . . . . . . . . . . .

MAINTENANCE
329
Accelerator pedal
Check
the pedal for smooth operation and uneven pedal ef fort
or catching.
Brake pedal
Check the pedal for smooth operation and the proper
clearance and freeplay. Check the brake booster function.
Brakes
In a safe place, check that the brakes do not pull to one side
when applied.
Parking brake
Check that the pedal has the proper travel and that, on a safe
incline, your vehicle is held securely with only the parking brake
applied.
Automatic transmission “Park” mechanism
On a safe incline, check that your vehicle is held securely with
the selector lever in “P” position and all brakes released.
Vehicle exterior
Items listed below should be performed from time to time,
unless otherwise specified.
Wheel nuts
When checking the tires, make sure to check the nuts for
looseness. Tighten them if necessary.
Fluid leaks
Check underneath for leaking fuel, oil, water or other fluid after
the vehicle has been parked for a while. If you smell fuel fumes
or notice any leak, have the cause found and corrected
immediately.
Doors and engine hood
Check that all doors, including trunk lid, operate smoothly and
all latches lock securely. Make sure the engine hood
secondary latch secures the hood when the primary latch is
released.

INTRODUCTION
338
Use eye protection whenever you work on or under
your vehicle where you may be exposed to flying or
falling material, fluid spray, etc.
 Be extremely cautious when working on the battery.
It contains poisonous and corrosive sulfuric acid.
NOTICE
Remember that battery and ignition cables carry high
currents or voltages. Be careful of accidentally
causing a short circuit.
 Before closing the engine hood, check to see that you
have not forgotten any tools, rags, etc.
 Do not drive with the air cleaner removed, or
excessive engine wear could result. Also backfiring
could cause a fire in the engine compartment.
 Do not overfill automatic transmission fluid, or the
transmission could be damaged.
 Be careful not to scratch the glass surface with the
wiper frame.
PARTS AND TOOLS
Here is a list of parts and tools you will need to perform
do−it−yourself maintenance. Remember all Lexus parts are
designed in metric sizes, so your tools must be metric.
Checking the engine oil level
Parts (if level is low):
“Toyota Genuine Motor Oil” or equivalent
See page 353 for details about engine oil selection.
Tools:
 Rag or paper towel
 Funnel (only for adding oil)

INTRODUCTION
339
Checking the engine coolant level
Parts (if level is low):
“Toyota Super Long Life Coolant” or similar high quality
ethylene glycol based non −silicate, non− amine, non−nitrite,
and non −borate coolant with long −life hybrid organic acid
technology (Coolant with long −life hybrid organic acid
technology is a combination of low phosphates and organic
acids.)
“Toyota Super Long Life Coolant” is a mixture of 50% coolant
and 50% deionized water (for the U.S.A.) or 55% coolant
and 45% deionized water (for Canada). This coolant
provides protection down to about −35C (−31F) (for the
U.S.A.) or about −42C (− 44F) (for Canada).
Tools:
 Funnel (only for adding coolant)
Checking brake fluid
Parts (if level is low):
FMVSS No. 116 DOT 3 or SAE J1703 brake fluid
Tools:
 Funnel (only for adding fluid)
Checking power steering fluid
Parts (if level is low):
Automatic transmission fluid DEXRON
II or III
Tools:
 Rag or paper towel
 Funnel (only for adding fluid)
Checking battery condition
Tools:
Warm water
 Baking soda
 Grease
 Conventional wrench (for terminal clamp bolts)
Checking and replacing the blade type fuses
Parts (if replacement is necessary):
Fuse with same amperage rating as original

CHASSIS
360
SPECIFICATIONS
— AUTOMATIC TRANSAXLEFluid capacity Drain and refill
3.5 L (3.7 qt., 3.1 Imp. qt.)
Fluid typeToyota Genuine ATF Type TIV*
*: Change automatic transmission fluid only as necessary.
Generally, it is necessary to change automatic transmission
fluid only if your vehicle is driven under one of the Special
Operating Conditions listed in your “Owner’s Manual
Supplement/Scheduled Maintenance”. When changing the
automatic transmission fluid, use only “Toyota Genuine ATF
Type T−IV” (ATF JWS3309 or NWS6500) to aid in assuring
optimum transaxle performance.NOTICE
Using automatic transmission fluid other than “Toyota
Genuine ATF Type TIV” may cause deterioration in
shift quality, locking up of your transmission
accompanied by vibration, and ultimately damage the
automatic transmission of your vehicle.
Please contact your Lexus dealer for further details.

CHASSIS
361
— BRAKES
Pedal clearance Fixed type
Adjustable type (in frontmost position)
70 mm (2.8 in.) Min. *1
59 mm (2.3 in.) Min. *1
Pedal free playFixed type
Adjustable type (in frontmost position)1 — 6 mm (0.04 — 0.24 in.)
1 — 8 mm (0.04 — 0.31 in.)
Brake pad wear limit1.0 mm (0.04 in.)
Parking brake lining wear limit1.0 mm (0.04 in.)
Parking brake adjustment3 — 6 clicks *2
Fluid typeSAE J1703 or FMVSS No. 116 DOT 3
*1: Minimum pedal clearance when depressed with the force of 490 N (50 kg\
f, 110 lbf) with the engine running
*2: Parking brake adjustment when depressed with the force of 294 N (30 k\
gf, 66 lbf)
— STEERING Wheel free play
Less than 30 mm (1.2 in.)
Power steering fluid typeAutomatic transmission fluid DEXRONII or III

CHASSIS
365
CHECKING POWER STEERINGFLUID
Check the fluid level through the reservoir. If necessary,
add automatic transmission fluid DEXRONII or III.
If the vehicle has been driven around 80 km/h (50 mph) for 20
minutes (a little more in frigid temperatures), the fluid is hot
(60 C — 80 C or 140F — 175F). You may also check the
level when the fluid is cold (about room temperature, 10 C —
30 C or 50F — 85F) if the engine has not been run for about
five hours.
1If cold O.K.2If cold add3If hot O.K.
4If hot add
Clean all dirt off the reservoir and look at the fluid level. If the
fluid is cold, the level should be in the “COLD” range. Similarly,
if it is hot, the fluid level should be in the “HOT” range. If th\
e
level is at the low side of the appropriate range, add automatic
transmission fluid DEXRON
II or III to bring the level within
the range.
To remove the reservoir cap, turn it counterclockwise and lift
up. To reinstall it, turn it clockwise. After replacing the reservoir
cap, visually check the steering box case, vane pump and hose
connections for leaks or damage.
CAUTION
The reservoir may be hot so be careful not to burn
yourself.