engine lexus LS400 1998 Engine / LEXUS 1998 LS400 (OM50498U) Repair Manual

IN CASE OF AN EMERGENCY
197 B: If no steam is coming from your engine:
Leave the engine running and turn off the air conditioning. Check
the following.
Is the cooling fan operating?
Is the coolant in the acceptable range?
Is the engine drive belt O.K.?
CAUTION
When the engine is running, keep hands and clothing away
from the moving fan and engine drive belt.
Do not attempt to remove the radiator cap when the engine
and radiator are hot. Serious injury could result from
scalding hot fluid and steam blown out under pressure.
If the cooling fan is not operating or the coolant is not in the
acceptable range, turn off the engine and call your Lexus dealer.
If both conditions are O.K., after the engine coolant temperature has
cooled to normal, continue driving your vehicle.
If the engine coolant temperature does not cool down, or your
vehicle overheats again, have it checked as soon as possible by your
Lexus dealer.
IF YOU HAVE A FLAT TIRE
1. Reduce your speed gradually, keeping a straight line. Move
cautiously off the road to a safe place well away from the traffic.
Avoid stopping on the center divider of a highway. Park on a level
spot with firm ground.
2. Stop the engine and turn on your emergency flashers.
3. Firmly set the parking brake and put the transmission in ”P”.
4. Have everyone get out of the vehicle on the side away from
traffic.
5. Read the following instructions thoroughly.
NOTICE
For vehicles equipped with the height control switch, be sure to
turn the ignition switch off before jacking. If this is not done, the
vehicle height adjustment function will operate, which may
cause body damage.
CAUTION
When jacking, be sure to observe the following to reduce the
possibility of personal injury:
Follow jacking instructions.
Do not start or run the engine while your vehicle is
supported by the jack.

IN CASE OF AN EMERGENCY
209
CAUTION
Use extreme caution when towing the vehicle. Avoid sudden
starts or erratic driving maneuvers which would place
excessive stress on the emergency towing eyelet and towing
cable or chain. The eyelet and towing cable or chain may
break and cause serious injury or damage.
NOTICE
Use only a cable or chain specifically intended for use in towing
vehicles. Securely fasten the cable or chain to the towing eyelet
provided.
Before towing, release the parking brake and put the transmission in
”N”. The ignition key must be in ”ACC” (engine off) or ”ON”
(engine running).
CAUTION
If the engine is not running, the power assist for the brakes and
steering will not work so steering and braking will be much
harder than usual.
IF YOU CANNOT SHIFT
AUTOMATIC TRANSMISSION
SELECTOR LEVER
40L025-3
If you cannot shift the selector lever, use the shift lock override
button as follows:
1
Turn the ignition key to ”LOCK” or ”ACC”. Make sure the
parking brake is applied. Pry up the cover with a flatbladed
screwdriver or equivalent.

IN CASE OF AN EMERGENCY
210
40L026-3
2
Insert your finger, the screwdriver or equivalent into the hole
to push down the shift lock override button. You can shift the
selector lever while pushing the button.
For your safety, keep the brake pedal depressed.
Be sure to have the system checked by your Lexus dealer as soon as
possible.
IF YOU LOSE YOUR KEYS OR
LOCK YOURSELF OUT
Many Lexus dealers can make a new key if you can give them the
key number. Since your vehicle is equipped with the engine
immobiliser system, the dealer will also need your master key.
See the suggestion given in ”Keys” on page 8.
If your keys are locked in the vehicle and you cannot get a duplicate,
many Lexus dealers can still open the door for you, using their
special tools. If you must break a window to get in, we suggest
breaking the smallest side window because it is the least expensive
to replace. Be extremely cautious to avoid cuts from the glass.
Even if you lose only one key, contact your Lexus dealer to make a
new key. If you lose all your master keys, you cannot make new
keys; the whole system must be replaced.

MAINTENANCE
214Your copy of the repair order is proof that all required maintenance
has been performed for warranty coverage. And if any problems
should arise with your vehicle while under warranty, your Lexus
dealer will promptly take care of it. Again, be sure to keep a copy
of the repair order for any service performed on your Lexus.
What about doityourself maintenance?
Many of the maintenance items are easy to do yourself, if you have
a little mechanical ability and a few basic automotive tools. Simple
instructions for how to perform them are presented in Section 6.
If you are a skilled doityourself mechanic, the Lexus service
manuals are recommended. Please be aware that doityourself
maintenance can affect your warranty coverage. See your Owner’s
Guide, Owner’s Manual Supplement or Warranty Booklet for the
details.
GENERAL MAINTENANCE
Listed below are the general maintenance items that should be
performed at the intervals specified. It is recommended that any
problem you notice be brought to the attention of your Lexus dealer
or qualified service shop for their advice.
CAUTION
Make these checks only where adequate ventilation can be
obtained if you run the engine.
Vehicle exterior
Items listed below should be performed from time to time, unless
otherwise specified.
Tire pressure
Check the pressure with a gauge every two weeks, or at least once
a month and adjust as shown on the tire pressure label. See page 241
for additional information.
Tire surface
Check the tires carefully for cuts, damage or excessive wear. See
page 243 for additional information.
Wheel nuts
When checking the tires, make sure to check the nuts for looseness.
Tighten them if necessary.

MAINTENANCE
215 Tire rotation
Rotate the tires every 12000 km (7500 miles). See page 242 for
additional information.
Fluid leaks
Check underneath for leaking fuel, oil, water or other fluid after the
vehicle has been parked for a while. If you smell fuel fumes or notice
any leak, have the cause found and corrected immediately.
Doors and engine hood
Check that all doors, including trunk lid, operate smoothly and all
latches lock securely. Make sure the engine hood secondary latch
secures the hood when the primary latch is released.
Vehicle interior
Items listed below should be checked regularly, e.g. while
performing periodic services, cleaning the vehicle, etc.
Lights
Make sure the headlights, stop lights, tail lights, turn signal lights,
and other lights are working. Check headlight aim.
Service reminder indicators and warning buzzers
Check that all service reminder indicators and warning buzzers
function properly.Steering wheel
Check that it has the specified freeplay. Be alert for changes in
steering condition, such as hard steering, excessive freeplay or
strange noise.
Seats
Check that all front seat controls such as seat adjusters, seatback
recliner, etc. operate smoothly. Check that the head restraints move
up and down smoothly and that the locks hold securely in any latched
position.
Seat belts
Check that the seat belt system such as buckles, retractors and
anchors operate properly and smoothly. Make sure the belt webbing
is not cut, frayed, worn or damaged.
Accelerator pedal
Check the pedal for smooth operation and uneven pedal effort or
catching.
Brake pedal
Check the pedal for smooth operation and the proper clearance and
freeplay. Check the brake booster function.
Brakes
At a safe place, check that the brakes do not pull to one side when
applied.

MAINTENANCE
216Parking brake
Check that the pedal has the proper travel and that, on a safe incline,
your vehicle is held securely with only the parking brake applied.
Automatic transmission ”Park” mechanism
On a safe incline, check that your vehicle is held securely with the
selector lever in ”P” position and all brakes released.
Engine compartment
Items listed below should be checked from time to time, e.g. each
time when refueling.
Washer fluid
Make sure there is sufficient fluid in the tank. See page 261 for
additional information.
Engine coolant level
Make sure the coolant level is between the Upper and Lower lines
on the seethrough reservoir when the engine is cold. See page 233
for additional information.
Battery
Your Lexus has a maintenance free battery. You do not have to add
distilled water. For longer life of the battery, however, see page 253
for additional information.
Brake fluid level
Make sure the brake fluid level is correct. See page 239 for
additional information.Engine oil level
Check the level on the dipstick with the engine turned off and the
vehicle parked on a level spot. See page 230 for additional
information.
Power steering fluid level
Check the level on the dipstick. The level should be in the ”HOT”
or ”COLD” range depending on the fluid temperature. See page 240
for additional information.
Exhaust system
Look for cracks, holes and loose supports. If you notice any change
in the sound of the exhaust or smell exhaust fumes, have the cause
located and corrected immediately. (See engine exhaust cautions in
Section 31.)

MAINTENANCE
217
DOES YOUR VEHICLE NEED
REPAIRING?
Be on the alert for changes in performance and sounds, and visual
tipoffs that indicate service is needed. Some important clues are:
Engine missing, stumbling, or pinging
Appreciable loss of power
Strange engine noises
A fluid leak under the vehicle (However, water dripping from the
air conditioning after use is normal.)
Change in exhaust sound (This may indicate a dangerous carbon
monoxide leak. Drive with the windows open and have the
exhaust system checked immediately.)
Flatlooking tires, excessive tire squeal when cornering, uneven
tire wear
Vehicle pulls to one side when driving straight on a level road
Strange noises related to suspension movement
Loss of brake effectiveness, spongy feeling brake pedal, pedal
almost touches floors, vehicle pulls to one side when braking
Engine coolant temperature continually higher than normal
If you notice any of these clues, take your vehicle to your Lexus
dealer as soon as possible. It probably needs adjustment or repair.
CAUTION
Do not continue driving with the vehicle unchecked. It could
result in serious vehicle damage and possibly personal injury.

SECTION 6 1
218
SERVICE PROCEDURES AND
SPECIFICATIONS
Introduction
Vehicle identification 219. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Engine compartment overview 220. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Doityourself service precautions 221. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Parts and tools 222. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

INTRODUCTION
219
VEHICLE IDENTIFICATION
61L002
The vehicle identification number (VIN) is the legal identifier for
your vehicle. This number is on the left top of the instrument
panel and can be seen through the windshield from outside.
This is the primary identification number for your Lexus. It is used
in registering the ownership of your vehicle.
61L003
The vehicle identification number (VIN) is also on the Certification
Label.
61L0042
The engine number is stamped on the engine block as shown.

61L005-5
INTRODUCTION
220
ENGINE COMPARTMENT OVERVIEW
1 Brake fluid reservoir
2 Fuse box
3 Battery
4 Washer fluid tank
5 Engine oil level dipstick
6 Engine oil filler cap
7 Power steering fluid
reservoir
8 Engine coolant reservoir