check engine LINCOLN NAVIGATOR 2004 Owner's Guide

1. Start the engine and let it run
until it reaches normal operating
temperature (the engine coolant
temperature gauge indicator will be
near the center of the normal area
between H and C).
2. While the engine idles, turn the
steering wheel left and right several
times.
3. Turn the engine off.
4. Check the fluid level in the
reservoir. It should be between the
MIN and MAX lines. Do not add
fluid if the level is in this range.
5. If the fluid is low, add fluid in
small amounts, continuously
checking the level until it reaches
the range between the MIN and
MAX lines. Be sure to put the cap
back on the reservoir.
BRAKE FLUID RESERVOIR
The fluid level will drop slowly as
the brakes wear, and will rise when
the brake components are replaced.
Fluid levels between the “ MIN ” and
“ MAX ” lines are within the normal
operating range, there is no need to
add fluid. If the fluid levels are
outside of the normal operating range, the performance of your brake
system could be compromised, seek service from your dealer
immediately. MAX
MIN
MAX
MIN
MAX
MIN
2004 Navigator (nav)
Owners Guide (post-2002-fmt)
USA English (fus) Maintenance and Specifications
329

TRANSMISSION FLUID
Checking automatic transmission fluid
Refer to your scheduled maintenance guide for scheduled intervals for
fluid checks and changes. Your transmission does not consume fluid.
However, the fluid level should be checked if the transmission is not
working properly, i.e., if the transmission slips or shifts slowly or if you
notice some sign of fluid leakage.
Automatic transmission fluid expands when warmed. To obtain an
accurate fluid check, drive the vehicle until it is at normal operating
temperature (approximately 30 km [20 miles]). If your vehicle has been
operated for an extended period at high speeds, in city traffic during hot
weather or pulling a trailer, the vehicle should be turned off for about 30
minutes to allow fluid to cool before checking.
1. Drive the vehicle 30 km (20 miles) or until it reaches normal operating
temperature.
2. Park the vehicle on a level surface and engage the parking brake.
3. With the parking brake engaged and your foot on the brake pedal,
start the engine and move the gearshift lever through all of the gear
ranges. Allow sufficient time for each gear to engage.
4. Latch the gearshift lever in P (Park) and leave the engine running.
5. Remove the dipstick, wiping it clean with a clean, dry lint free rag. If
necessary, refer to Identifying components in the engine compartment
in this chapter for the location of the dipstick.
6. Install the dipstick making sure it is fully seated in the filler tube.
7. Remove the dipstick and inspect the fluid level. The fluid should be in
the designated area for normal operating temperature or ambient
temperature.
Low fluid level
Do not drive the vehicle if the fluid
level is at the bottom of the dipstick
and the ambient temperature is
above 10 ° C (50 ° F).
Correct fluid level
The transmission fluid should be checked at normal operating
temperature 66 ° C-77 ° C (150 ° F-170 ° F) on a level surface. The normal
operating temperature can be reached after approximately 30 km
(20 miles) of driving. ADD COLD HOT DO NOT ADD
2004 Navigator (nav)
Owners Guide (post-2002-fmt)
USA English (fus)Maintenance and Specifications
330

an automatic transmission application requiring MERCON  may
cause transmission damage. Use of any fluid other than the
recommended fluid may cause transmission damage. 2
Indicates only approximate dry-fill capacity. Some applications may vary
based on cooler size and if equipped with an in-tank cooler. The amount
of transmission fluid and fluid level should be set by the indication on
the dipstick ’ s normal operating range.3
Add the coolant type originally equipped in your vehicle. 4
Your vehicle ’ s rear axle is filled with a synthetic rear axle lubricant and
is considered lubricated for life. These lubricants are not to be checked
or changed unless a leak is suspected, service is required or the axle has
been submerged in water. The axle lubricant should be changed any time
the axle has been submerged in water.
Service refill capacities are determined by filling the rear axle 23mm (0.9
inch) below the bottom of the filler hole. 5
Add 118 ml (4 oz.) of Additive Friction Modifier XL-3 or equivalent
meeting Ford specification EST-M2C118 – A for complete refill of Limited
Slip axles. For complete refills, fill using the Additive Friction Modifier
first. 6
Use of synthetic or synthetic blend motor oil is not mandatory. Engine
oil need only meet the requirements of Ford specification
WSS-M2C153 – H and the API Certification mark.
LUBRICANT SPECIFICATIONS
Item Ford part
name Ford part
number Ford
specification
Hinges, latches,
striker plates
and rotors, seat
tracks, fuel filler
door hinge and
spring Multi-Purpose
Grease XG-4 or XL-5 ESR-M1C159-A
or ESB-M1C93-B
Lock cylinders Penetrating and
Lock Lubricant Motorcraft XL-1 ESB-M2C75-B
2004 Navigator (nav)
Owners Guide (post-2002-fmt)
USA English (fus) Maintenance and Specifications
351

A
ABS (see Brakes) .....................221
Accessory delay ........................122
Air bag supplemental restraint
system ................................195, 199
and child safety seats ............197
description ......................195, 199
disposal ....................................202
driver air bag ..................197, 200
indicator light .................199, 202
operation .........................197, 200
passenger air bag ...........197, 200
side air bag ..............................199
Air cleaner filter ...............332, 348
Air conditioning
auxiliary heater and air
conditioner ................................97
Air suspension ...........................225
description ..............................225
Antifreeze
(see Engine coolant) ................313
Anti-lock brake system
(see Brakes) ......................221 – 222
Audio system (see Radio) ...16, 21
Automatic transmission
driving an automatic
overdrive .................................233
fluid, adding ............................330
fluid, checking ........................330
fluid, refill capacities ..............349
fluid, specification ..................354
Auxiliary power point ...............118
Axle
lubricant specifications ..351, 354
refill capacities ........................349
B
Battery .......................................311 acid, treating emergencies .....311
jumping a disabled battery ....282
maintenance-free ....................311
replacement, specifications ...348
servicing ..................................311
BeltMinder .................................191
Brakes ........................................221
anti-lock ...........................221 – 222
anti-lock brake system (ABS)
warning light ...........................222
fluid, checking and adding ....329
fluid, refill capacities ..............349
fluid, specifications .........351, 354
lubricant specifications ..351, 354
parking ....................................223
shift interlock ..........................231
Bulbs ..........................................103
C
Calculating load ........................254
Capacities for refilling fluids ....349
Cassette tape player ...................21
CD-single premium .....................16
Cell phone use ..........................148
Certification Label ....................356
Changing a tire .........................275
Child safety restraints ..............203
child safety belts ....................203
Child safety seats ......................206
in front seat ............................208
in rear seat ..............................208
Cleaning your vehicle
engine compartment ..............300
instrument panel ....................302
interior .............................302 – 303
interior trim ............................303
plastic parts ............................301
2004 Navigator (nav)
Owners Guide (post-2002-fmt)
USA English (fus)Index
Index
361

safety belts ..............................302
washing ....................................299
waxing .....................................299
wheels ......................................300
wiper blades ............................301
Clock ..........................................117
Compass, electronic
set zone adjustment ...............138
Console ......................................148
overhead ..........................114 – 116
rear ..........................................149
Controls
power seat ...............................170
steering column ......................129
Coolant
checking and adding ..............313
refill capacities ................317, 349
specifications ..................351, 354
Cruise control
(see Speed control) ..................126
Customer Assistance ................262
Ford accessories for your
vehicle .....................................304
Ford Extended Service
Plan ..........................................292
Getting assistance outside the
U.S. and Canada .....................296
Getting roadside assistance ...262
Getting the service you
need .........................................290
Ordering additional owner ’ s
literature .................................297
The Dispute Settlement
Board .......................................292
Utilizing the
Mediation/Arbitration
Program ...................................295 D
Daytime running lamps
(see Lamps) ..............................100
Defrost
rear window ..............................98
Dipstick
automatic transmission
fluid ..........................................330
engine oil .................................308
Doors
lubricant specifications ..........351
Driveline universal joint and
slip yoke ....................................332
Driving under special
conditions ..................238, 245, 248
sand .........................................247
snow and ice ...........................249
through water .................247, 251
E
Electronic message center .......136
Emergencies, roadside
jump-starting ..........................282
Emission control system ..........326
Engine ........................................354
cleaning ...................................300
coolant .....................................313
fail-safe coolant ......................317
idle speed control ...................311
lubrication
specifications ..................351, 354
refill capacities ........................349
service points ..........................307
starting after a collision .........263
Engine block heater .................220
Engine oil ..................................308
2004 Navigator (nav)
Owners Guide (post-2002-fmt)
USA English (fus)Index
362

side view mirrors (power) .....124
Motorcraft parts ................323, 348
N
Navigation system .......................43
cd functions ..............................59
destination mode ......................71
DVD location .............................92
map mode .................................62
quick start .................................45
radio functions ..........................51
O
Octane rating ............................322
Oil (see Engine oil) ..................308
P
Panic alarm feature, remote
entry system ..............................157
Parking brake ............................223
Parts (see Motorcraft parts) ....348
Pedals (see Power adjustable
foot pedals) ...............................125
Power adjustable foot pedals ...125
Power distribution box
(see Fuses) ...............................266
Power door locks ..............153, 162
Power liftgate ............................149
Power point ...............................118
Power steering ..........................224
fluid, checking and adding ....328
fluid, refill capacity ................349
fluid, specifications .........351, 354
Power Windows .........................119 Preparing to drive your
vehicle ........................................227
R
Radio ......................................16, 21
Rear window defroster ...............98
Relays ........................................265
Remote entry system .......154, 157
illuminated entry ....................162
locking/unlocking
doors ........................153 – 155, 163
opening the trunk ...........156 – 157
panic alarm .............................157
replacement/additional
transmitters .............................161
Roadside assistance ..................262
Roof rack ...................................152
S
Safety Belt Maintenance ..........194
Safety belts (see Safety
restraints) ..................183, 186 – 190
Safety defects, reporting ..........298
Safety restraints ........183, 186 – 190
belt minder .............................191
extension assembly ................194
for adults .........................187 – 189
for children .............................203
safety belt maintenance .........194
warning light and
chime ...............................190 – 191
Safety seats for children ..........206
Seat belts
(see Safety restraints) .............183
Seats ..........................................169
child safety seats ....................206
2004 Navigator (nav)
Owners Guide (post-2002-fmt)
USA English (fus) Index
365