washer fluid MAZDA MODEL PROTÉGÉ 2002 (in English) User Guide

8-5
Maintenance and Care
Scheduled Maintenance
Form No. 8Q36-EA-01F

Schedule 2
I
: Inspect and repair, clean, adjust, or replace if necessary.
(Oil-permeated air filter cannot be cleaned using the air-blow method.)
R
: Replace
L
: Lubricate
*1: According to state and federal regulations, failure to perform maintenance on these items will not void your
emissions warranties. However, Mazda recommends that all maintenance services be performed at the
recommended time or kilometrage (mileage) period to ensure long-term reliability.
*2: If the vehicle is operated in cold districts { below -18 degrees C (0 degrees F) }, replace the timing belt at
96,000 km (60,000 miles).
Maintenance
Interval
Maintenance
ItemNumber of months or kilometers (miles), whichever comes first
Months 4 8 12 16 20 24 28 32 36 40 44 48
×1000 Km 8 1624324048566472808896
(×1000 Miles) (5) (10) (15) (20) (25) (30) (35) (40) (45) (50) (55) (60)
Engine valve clearanceI
Engine timing belt
*2Inspect at 96,000 km (60,000 miles)
Replace every 168,000 km (105,000 miles)
Drive belts (tension) II
Engine oilExcept Puerto RicoRRRRRRRRRRRR
Puerto RicoReplace every 5,000 km (3,000 miles) (or 3 months)
Engine oil filterRRRRRRRRRRRR
Cooling systemII
Engine coolantReplace at first 72,000 km (45,000 miles) or 36 months ;
after that, every 48,000 km (30,000 miles) or 24 months
Engine coolant levelIIIIIIIIIIII
Idle speedII
Air filter
I
*1R
I *1R
Fuel lines & hoses*1II
Hoses & tubes for emission*1I
Spark plugsRR
Function of all lightsIIIIIIIIIIII
Brake lines, hoses & connectionsII
Brake & clutch fluid level IIIIIIIIIIII
Disc brakesIIII
Drum brakesII
Tire inflation pressure and tire wearIIIIIIIIIIII
Steering operation & linkagesII
Power steering fluid levelIIIIIIIIIIII
Front suspension ball jointsII
Driveshaft dust bootsII
Bolts & nuts on chassis & bodyIIII
Exhaust system heat shieldsII
All locks & hingesLLLLLLLLLLLL
Washer fluid levelIIIIIIIIIIII
Refrigerant amount (if installed) IIII
Compressor operation (if installed) IIII
J39L(02MY).book Page 5 Thursday, November 1, 2001 10:49 AM

8-7
Maintenance and Care
Scheduled Maintenance
Form No. 8Q36-EA-01F
I
: Inspect: Inspect and clean, repair, adjust, or replace if necessary . R: Replace
L
: Lubricate T
: Tightenan
*5: If the brakes are used extensively (for example, continuous hard driving or mountain driving) or if the vehicle
is operated in extremely humid climates, change the brake fluid annually.
*6: This is a full function check of electrical systems such as lights, wiper and washer systems (including wiper
blades), and power windows.
Maintenance
Interval
Maintenance
ItemNumber of months or km (miles), whichever comes first
Months 6 121824303642485460667278849096
×1000 Km 10 20 30 40 50 60 70 80 90 100 110 120 130 140 150 160
(×1000 Miles) (6) (12) (18) (24) (30) (36) (42) (48) (54) (60) (66) (72) (78) (84) (90) (96)
E.G.R. system (if installed)IIIIIIII
Battery electrolyte level
and specific gravityIIIIIIII
Brake and clutch pedalsIIIIIIIIIIIIIIII
Brake lines, hoses and
connectionsIIIIIIII
Brake fluid*
5I I IRI I IRI I IRI I IR
Clutch fluidIIIIIIIIIIIIIIII
Parking brakeIIIIIIIIIIIIIIII
Power brake unit and hosesIIIIIIII
Disc brakesIIIIIIIIIIIIIIII
Drum brakesIIIIIIII
Power steering fluid and linesIIIIIIIIIIIIIIII
Steering operation and gear
housingIIIIIIII
Steering linkage, tie rod ends and
armsIIIIIIII
Manual transaxle oilRR
Automatic transaxle fluid levelIIII III
Automatic transaxle fluid
RRR
Front and rear suspension and
ball jointsIIII
Driveshaft dust bootsIIII
Exhaust system heat shieldsIIII
Wheel nutsTTTTTTTT
Bolts and nuts on chassis and
bodyTTTTTTTT
All electrical system
*6 IIIIIIII
Headlight alignmentIIIII
Body condition (for rust,
corrosion and perforation)Ins
pect annually
Tires
(including spare tire, with
inflation pressure adjustment)IIIIIIII
Hinges and catchesLLLLLLLL
Road testIIIIIIIIIIIIIIII
J39L(02MY).book Page 7 Thursday, November 1, 2001 10:49 AM

8-8
Maintenance and Care
Form No. 8Q36-EA-01F
Owner Maintenance
The owner or a qualified service technician should make these vehicle inspections at the
indicated intervals to ensure safe and dependable operation.
Bring any problem to the attention of an Authorized Mazda Dealer or qualified service
technician as soon as possible.

When Refueling
•Brake and clutch fluid level (page 8-16)
•Engine coolant level (page 8-14)
•Engine oil level (page 8-11)
•Washer fluid level (page 8-20)

At Least Monthly
•Tire inflation pressures (page 8-27)

At Least Twice a Year (For Example, Every Spring and Fall)
•Automatic transaxle fluid level (page 8-18)
•Power steering fluid level (page 8-18)
You can do the following scheduled maintenance items if you have some mechanical
ability and a few basic tools and if you closely follow the directions in this manual.
•Air filter (page 8-21)
•Engine coolant (page 8-14)
•Engine oil (page 8-12)
Owner Maintenance Schedule
J39L(02MY).book Page 8 Thursday, November 1, 2001 10:49 AM

8-10
Maintenance and Care
Owner Maintenance
Form No. 8Q36-EA-01F
Engine Compartment Overview
Automatic transaxle fluid-level dipstick (only for automatic transaxle)
Brake/Clutch fluid reservoir
Battery
Fuse block
Engine coolant reservoir
Air filter
Cooling system cap Engine oil dipstick Engine oil filter 1.6-liter engine
1.8 and 2.0-liter enginesEngine oil-filler cap
Power steering
fluid reservoir
Windshield washer
fluid reservoir
Automatic transaxle fluid-level dipstick (only for automatic transaxle)
Brake/Clutch fluid reservoir
Battery
Fuse block
Engine coolant reservoir
Air filter Cooling system cap Engine oil filter Engine oil-filler cap
Engine oil dipstick
Power steering
fluid reservoir
Windshield washer
fluid reservoir
J39L(02MY).book Page 10 Thursday, November 1, 2001 10:49 AM

8-20
Maintenance and Care
Owner Maintenance
Form No. 8Q36-EA-01F

Inspecting Washer Fluid Level
Inspect fluid level in the washer fluid
reservoir; add fluid if necessary.
The top of the float should be between
FULL and LOW.Use plain water if washer fluid is
unavailable.
But use only washer fluid in cold weather
to prevent it from freezing.
To inspect the washer fluid level in the
front reservoir, pull off the cap. Then,
holding your thumb over the hole in the
center of the cap, lift it straight up. There
should be fluid in the straw. Add fluid if
necessary.
Use plain water if washer fluid is
unavailable. But use only washer fluid in
cold weather to prevent it from freezing.
Washer Fluid
Substitute Washer Fluid:
Using radiator antifreeze as washer
fluid is dangerous. If sprayed on the
windshield, it will dirty the
windshield, affect your visibility, and
could result in an accident. Use only
windshield washer fluid or plain
water in the reservoir.
WARNING
Float
Sedan
Hatchback
J39L(02MY).book Page 20 Thursday, November 1, 2001 10:49 AM

11-6
Index
Form No. 8Q36-EA-01F
W
Warning Lights ................................ 5-24
Air bag system
.......................... 5-29
Anti-lock brake system
(ABS)
........................................ 5-29
Brake system
............................ 5-26
Charging system
....................... 5-27
Check engine
............................ 5-28
Door-ajar
................................... 5-30
Engine oil pressure
................... 5-28
Front seat belt pretensioner
system
....................................... 5-29
Low fuel
.................................... 5-30
Low washer fluid level
............. 5-30
Seat belt
.................................... 5-30
Warranty
............................................ 9-8
Washer Fluid
.................................... 8-20
Weights
............................................ 10-6
Wheel Replacement
......................... 8-29
Windows
Power windows
........................ 3-15
Windshield Washer
.......................... 5-36
Windshield Wipers
.......................... 5-36
Blades replacement
................... 8-22
Winter Driving
................................... 4-8
J39L(02MY).book Page 6 Thursday, November 1, 2001 10:49 AM