trunk MERCEDES-BENZ CL600 2006 C215 Workshop Manual

391 Practical hints
Battery
Battery
The battery is located in the trunk under
the right hand wheel well cover panel.
1Battery cover
2Locking knob
Rotate and loosen locking knob2 ap-
prox. one-half turn.

Remove battery cover1.
Warning!
G
Failure to follow these instructions can re-
sult in severe injury or death.
Never lean over batteries while connecting,
you might get injured.
Battery fluid contains sulfuric acid. Do not
allow this fluid to come in contact with eyes,
skin or clothing. In case it does, immediately
flush affected area with water and seek
medical help if necessary.
A battery will also produce hydrogen gas,
which is flammable and explosive. Keep
flames or sparks away from battery, avoid
improper connection of jumper cables,
smoking, etc.Warning!
G
Do not place metal objects on the battery as
this could result in a short circuit.
Use leak-proof battery only to avoid the risk
of acid burns in the event of an accident.
!Never loosen or detach battery termi-
nal clamps while the engine is running
or the SmartKey is in the starter switch.
Otherwise the alternator and other
electronic components could be se-
verely damaged.
Have the battery checked regularly by
an authorized Mercedes-Benz Center.
Refer to Maintenance Booklet for main-
tenance intervals or contact your au-
thorized Mercedes-Benz Center for
further information.Warning!
G
With a disconnected battery

you will no longer be able to turn the
SmartKey in the starter switch and
pressing the KEYLESS-GO* start/stop
button (
page 35) on the gear selector
lever will have no effect


the gear selector lever will remain
locked in positionP

392 Practical hintsBatteryDisconnecting the battery
Turn off all electrical consumers.

Open the trunk (
page 101).

Read and observe safety instructions
and precautions (
page 391).

Remove the battery cover1.
3Negative terminal
4Cover over positive terminal

Use a 10-mm open-end wrench to dis-
connect the battery negative lead3.

Remove cover 4 from the positive ter-
minal.

Disconnect the battery positive lead.
Removing the battery
Remove the screw securing the bat-
tery.

Remove the battery support and
bracket.

Pull out the battery ventilation tube
from the battery (depending on battery
arrangement in your vehicle model, the
ventilation tube is located either on the
left or right side of the battery).

Take out the battery.
Charging and reinstalling the battery
Charge battery in accordance with the
instructions of the battery charger
manufacturer.

Reinstall the charged battery. Follow
the previously described steps in re-
verse order.
Warning!
G
Never charge a battery while still installed in
the vehicle unless the accessory battery
charge unit approved by Mercedes-Benz is
being used. Gases may escape during charg-
ing and cause explosions that may result in
paint damage, corrosion or personal injury.
An accessory battery charge unit specially
adapted for Mercedes-Benz vehicles and
tested and approved by Mercedes-Benz is
available, permitting the charging of the bat-
tery in its installed position. Contact an au-
thorized Mercedes-Benz Center for
information and availability. Charge battery
in accordance with the separate instruc-
tions for the accessory battery charger.!The battery, its filler caps and the bat-
tery ventilation tube must always be se-
curely installed when the vehicle is in
operation.

395 Practical hints
Jump starting
The battery is located on the right side of
the trunk under the battery cover
(page 391).

Make sure the two vehicles do not
touch.

Turn off all electrical consumers.

Apply parking brake.

Shift gear selector lever to positionP.

Open the trunk.

Remove battery cover.

Remove red cover from positive
terminal 1. 1Positive terminal of discharged battery
2Negative terminal of discharged bat-
tery
3Positive terminal of charged battery
4Negative terminal of charged battery

Connect positive terminals 1 and3
of the batteries with the jumper cable.
Clamp cable to charged battery3
first.

Start engine of the vehicle with the
charged battery and run at idle speed.

Connect negative terminals2 and4
of the batteries with the jumper cable.
Clamp cable to charged battery4
first.

Start the engine of the disabled vehi-
cle.
Now you can again turn on the electrical
consumers. Do not turn on the lights under
any circumstances.

Remove the jumper cables first from
negative terminals2 and4 and then
from positive terminals1 and3.
You can now turn on the lights.

Have the battery checked at the near-
est authorized Mercedes-Benz Center.
Warning!
G
Keep flames or sparks away from battery.
Do not smoke.
Observe all safety instructions and precau-
tions when handling automotive batteries
(page 281).
!Never invert the terminal connections.

398 Practical hintsTowing the vehicle
Installing towing eye bolt
1Cover on right side of front bumper
2Cover on right side of rear bumperRemoving cover

Press mark on cover in the direction of
arrow.

Lift cover off to reveal the threaded
hole for the towing eye bolt.
Installing towing eye bolt

Take towing eye bolt and wheel wrench
out of trunk (
page 370).

Screw towing eye bolt clockwise into
its stop and tighten with wheel wrench.
Removing towing eye bolt

Loosen towing eye bolt counterclock-
wise with wheel wrench.

Unscrew towing eye bolt.

Store towing eye bolt and wheel
wrench in trunk.
Installing cover

Fit cover and snap into place.
!When towing the vehicle with all wheels
on the ground, please note the follow-
ing:
With the automatic central locking acti-
vated and the SmartKey in starter
switch position2, or KEYLESS-GO*
start/stop button (
page 35) in
position2, the vehicle doors lock if the
left front wheel as well as the right rear
wheel are turning at vehicle speeds of
approx. 9 mph (15 km/h) or more.
Switch off the tow-away alarm
(
page 87).
To prevent the vehicle door locks from
locking, deactivate the automatic cen-
tral locking (
page 162).
Towing of the vehicle should only be
done using the properly installed tow-
ing eye bolt. Never attach tow cable,
tow rope or tow rod to the vehicle chas-
sis, frame or suspension parts.

399 Practical hintsFuses
Fuses
Fuses are designed to protect the electri-
cal circuits in your vehicle from a short cir-
cuit. If a fuse is blown, the component(s)
and systems controlled by that fuse will
stop working.
The following aids are available to help you
replace fuses (
page 399):


Fuse chart


Spare fuses


Special fuse extractorYour vehicle’s electrical fuses are located
in various fuse boxes:


In the dashboard on the passenger side
(page 400)


In the rear passenger compartment un-
der the right rear seat (
page 400)


In the engine compartment on the driv-
er’s side (
page 401)


In the engine compartment on the pas-
senger side (
page 401)
Aids for replacing fuses
Fuse chart
A chart explaining fuse allocation and fuse
amperages can be found in the vehicle tool
kit in the trunk (
page 370).
Spare fuses
Spare fuses are found in the vehicle tool kit
in the trunk (
page 370).
Fuse extractor
The fuse extractor is found in the vehicle
tool kit in the trunk (
page 370).
Warning!
G
Only use fuses approved by Mercedes-Benz
and which have the specified amperage.
Using other fuses may cause an overload
and lead to a fire, or cause damage to elec-
trical components and/or systems.
!Never attempt to repair or bridge a
blown fuse. Have the cause determined
and remedied by an authorized
Mercedes-Benz Center.

417 Technical data
Main dimensions and weights
Main dimensions and weights
Main dimensionsWeightsModel
CL 500
CL 55 AMG
CL 600
CL 65 AMG
Overall vehicle length
196.4 in (4989 mm)
196.4 in (4989 mm)
196.4 in (4989 mm)
196.4 in (4989 mm)
Overall vehicle width (exterior rear
view mirrors folded out)
82.8 in (2104 mm)
82.8 in (2104 mm)
82.8 in (2104 mm)
82.8 in (2104 mm)
Overall vehicle height
55.4 in (1408 mm)
55.4 in (1408 mm)
55.4 in (1408 mm)
55.4 in (1408 mm)
Wheelbase
113.6 in (2885 mm)
113.6 in (2885 mm)
113.6 in (2885 mm)
113.6 in (2885 mm)
Track, front
62.1 in (1577 mm)
62.2 in (1581 mm)
62.1 in (1577 mm)
62.2 in (1581 mm)
Track, rear
62.1 in (1578 mm)
62.2 in (1582 mm)
62.1 in (1578 mm))
62.2 in (1582 mm)
Roof load max.
220 lb (100 kg)
Trunk load max.
220 lb (100 kg)

435 Index
C
CAC 427
California retail buyers and lessees, impor-
tant notice for 11
Can holder see Cup holder
CAN system 428
Capacities and recommended
fuel/lubricants 418
Cargo area see Trunk
Cargo tie-down hooks 229
Carpets, cleaning 325
Catalytic converter 268
CD changer 145
Central locking
Automatic 110, 162
Locking/unlocking from inside 111
Central locking/unlocking switches 111
Certification label 406
Charcoal filter 191
Children in the vehicle 72
Air bags 64
BabySmart
TM compatible child
seat 72
Blocking of rear window operation 78
Indicator lamp, front passenger front
air bag 74Infant and child restraint systems 72
LATCH-type child seat mounts 77
Tether attachment points 76
Cigarette lighter 238
Clock 25
See separate COMAND operating in-
structions
Cockpit 22, 428
COMAND see separate operating instruc-
tions
Combination switch 52, 53, 54, 129
Control system 137, 428
Multifunction display 137
Multifunction steering wheel 138
Resetting to factory default 154
Control system menus
AUDIO 142
Distronic* 150
NAVI 149
Settings 154
Standard display 142
TEL* 147
Trip computer 151
Vehicle status message memory 153Control system submenus
Convenience 163
Instrument cluster 157
Lighting 158
Vehicle 162
Controller Area Network see CAN system
Coolant 271, 280, 422
Anticorrosion/antifreeze mixing ratio
and quantity 424
Capacities 419, 424
Checking level 271, 280
Messages in display 347
Temperature 269
Temperature gauge 25, 135
Courtesy lighting 133
Cruise control 205, 428
Message in display 350
Cruise control lever 205
Cup holder 235
Cup holders
Cleaning 324
Curb weight 309, 428
Customer Assistance Center see CAC

437 Index
Driving safety systems
ABS 80
BAS 81
ESP
®
82, 429
Driving systems 205
ABC 220
Cruise control 205
Distronic* 208
Parktronic* 223
Vehicle level control 221E
Easy-entry/exit feature 112, 163
Electrical fuses see Fuses
Electrical system, Technical data 416
Electronic Stability Program see ESP
®
Emergency call system
Hands-free microphone 29
Emergency calls
Tele Aid 243, 244
Emergency operations
Fuel filler flap 374
Limp Home Mode, Automatic
transmission 177
Locking/unlocking the vehicle 372
Power tilt/sliding sunroof, Manual
operation 375
Remote door unlock (Tele Aid) 248
Trunk, Releasing from inside 109
Trunk, Unlocking 373
Emergency Tensioning Device see ETD
Emergency, In case of
Battery, Jump starting 394
First aid kit 369
Flat tire, Changing 386Fuses 399
Hazard warning flasher 130
Instrument cluster, Indicator
lamps 328
Roadside Assistance 12
Roadside Assistance (Tele Aid) 244
Towing the vehicle 396
Emission control 268
Information label 406
System warranties 10
Vacuum line routing diagram
label 406
Engine
Block heater (Canada only) 314
Break-in recommendations 258
Cleaning 320
Compartment 273
Malfunction indicator lamp 25, 330
Number 406, 428
Poly-V-belt layout 407, 408
Starting 48
Tachometer 25, 136
Technical data 408
Turning off 58
Engine coolant see Coolant

441 Index
J
Jack 370, 388
Jacking up the vehicle 387
Jump starting 394K
Key, Mechanical 372
Key, SmartKey 90
Battery check lamp 90, 92
Checking the batteries 93
Factory setting 92
Locking/unlocking 32, 60, 90
Locking/unlocking, Global setting 92
Locking/unlocking, Selective
setting 92
Loss of 94
Messages in display 353
Opening the trunk 93
Operating the power tilt/sliding
sunroof 200
Operating the power windows 200
Position in starter switch 34
Remote control 90
Replacing the batteries 376
Starting the engine 48
Turning off the engine 59Key, SmartKey with KEYLESS-GO* 94,
429
Battery check lamp 94, 98
Checking the battery 99
Factory setting 97
Locking the vehicle 99
Locking/unlocking 33, 60, 94
Locking/unlocking, Global setting 97
Locking/unlocking, Selective
setting 98
Loss of 100
Messages in display 353
Opening the trunk 100
Operating the power tilt/sliding
sunroof 200
Operating the power windows 200
Remote control 94
Replacing the battery 377
Starting the engine 49
Turning off the engine 59
KEYLESS-GO* see Key, SmartKey with
KEYLESS-GO*
Kickdown 169, 429
Kilopascal 310

444 Index
Hood 353
Instrument cluster 350
Lamp sensor 356
Lamps 354
License plate lamp 355
Low beam headlamps 356
Maintenance service indicator 315
Parking brake 345
Parking lamps 357
Power tilt/sliding sunroof 359
Reverse lamps 357
Seat belts 359
Selector lever 344
Side marker lamps 356
SmartKey 353
SmartKey with KEYLESS-GO* 353
Tail lamps 357
Tele Aid 359
Telephone* 360
Tires 361
Trunk 360
Turn signal lamps 358
Washer fluid 360
Multifunction steering wheel 138, 430
Button operation 138N
Navigation system
See separate COMAND operating in-
structions
Net, parcel 234
Neutral gear position, Automatic
transmission 48, 165, 167
New vehicle break-in 258
Night security illumination 160
Normal occupant weight 310
Number, vehicle identification (VIN) 406O
Occupant distribution 310
Occupant safety 62
Air bags 63
Children and air bags 64
Children in the vehicle 72
Fastening the seat belt 45
Front passenger front air bag off indica-
tor lamp 74
Infant and child restraint systems 72
LATCH-type child seat anchors 77
Seat belts 45, 66
Odometer 135
Oil see Engine oil
One-touch gearshifting 172
Operating safety 16
Ornamental moldings, cleaning 321
Outside temperature indicator 25, 136
Overdue maintenance service 316
Overhead control panel 29
Overspeed range, Engine 430