run flat MERCEDES-BENZ CLS63AMG 2008 W219 User Guide

413 Practical hints
Flat tire
Preparing the vehicle
Prepare the vehicle as described under
“Preparing the vehicle” on this page.
Take the spare wheel out of the trunk
(
page 393).
Take the wheel wrench and the jack
out of the trunk (
page 393).
Removing tensioning straps
(CLS 63 AMG with Performance Pack-
age* only)
A 19" spare wheel has two tensioning
straps on it that must both be removed be-
fore mounting the spare wheel.1Buckle
2Clip
Press on both clips2 simultaneously
to release buckle1.Lifting the vehicle
Prevent the vehicle from rolling away
by blocking wheels with wheel chocks
or other sizeable objects.
When changing wheel on a level surface:
Place the wheel chock in front of and
another sizeable object behind the
wheel that is diagonally opposite to the
wheel being changed.
Always try lifting the vehicle using the jack
on a level surface. However, should cir-
cumstances require you to do so on a hill,
place the wheel chock and the other size-
able object as follows:
Place the wheel chock and another
sizeable object on the downhill side
blocking both wheels of the axle not
being worked on.iThe tensioning straps are shown in red for
illustration purposes. The tensioning straps on
the spare wheel of your vehicle are black.
iKeep the tensioning straps in a safe place.
You will need them to store the spare wheel in
the trunk after use (
page 394).

416 Practical hints
Flat tire
Unscrew the alignment bolt, install last
wheel bolt and tighten slightly.
Vehicles with Minispare wheel:
Continue the procedure by following
the instructions under “Lowering the
vehicle” (
page 418).
Vehicles with collapsible tire:
Continue the procedure by following
the instructions under “Inflating the
collapsible tire” and then “Lowering the
vehicle” (
page 418).Inflating the collapsible tire
Take the electric air pump out of the
trunk (
page 393).
Warning!G
Always replace wheel bolts that are dam-
aged or rusted.
Never apply oil or grease to wheel bolts.
Damaged wheel hub threads should be
repaired immediately. Do not continue to
drive under these circumstances! Contact
an authorized Mercedes-Benz Center or call
Roadside Assistance.
Incorrect wheel bolts or improperly tight-
ened wheel bolts can cause the wheel to
come off. This could cause an accident. Be
sure to use the correct wheel bolts.
Warning!G
Only use genuine Mercedes-Benz wheel
bolts. Other wheel bolts may come loose.
Do not tighten the wheel bolts when the
vehicle is raised. Otherwise the vehicle
could fall off the jack.
!Do not lower the vehicle before inflating the
collapsible tire. Otherwise the rim may be dam-
aged.
Warning!G
Observe instructions on air pump label.

418 Practical hints
Flat tire
Detach the electric air pump.
Stow electrical plug3 and air hose4
behind flap1 and place the air pump
back in the trunk.Lowering the vehicle
Lower vehicle by turning crank coun-
terclockwise until vehicle is resting ful-
ly on its own weight.
Remove the jack.
1-5 Wheel bolts
Tighten the five wheel bolts evenly, fol-
lowing the diagonal sequence illustrat-
ed (1 to 5), until all bolts are tight.
Observe a tightening torque of 96 lb-ft
(130 Nm).
Before storing the jack in the trunk, it
should be fully collapsed.
Warning!G
Follow recommend inflation pressures.
Do not overinflate tires. Overinflating tires
can result in sudden deflation (blowout)
because they are more likely to become
punctured or damaged by road debris,
potholes, etc.
Do not underinflate tires. Underinflated tires
wear unevenly, adversely affect handling
and fuel economy, and are more likely to fail
from being overheated.
iVehicles with Advanced TPMS*:
Do not activate the tire inflation pressure moni-
tor (
page 309) until a full size wheel/tire with
functioning sensor has been placed back into
service on the vehicle.
Warning!G
Have the tightening torque checked after
changing a wheel. The wheels could come
loose if they are not tightened to a torque of
96 lb-ft (130 Nm).
iWrap the damaged wheel in the protective
film that comes with the spare wheel and put the
wheel in the trunk.
You can also place the damaged wheel down into
the spare wheel well. In this case, you must stow
the luggage bowl in the trunk.


419 Practical hints
Flat tire
MOExtended system*
The MOExtended system allows you to
continue driving your vehicle even if there
is a total loss of pressure in one or more
tires.
You may only use the MOExtended system
in conjunction with Tire Pressure Monitor-
ing System (U.S. vehicles), Run Flat Indica-
tor (Canada vehicles), or Advanced Tire
Pressure Monitoring System* (Canada
only).
!The maximum distance in emergency mode
depends on the vehicle’s load. It is 30 miles
(50 km) if the vehicle is partially loaded and
18 miles (30 km) if the vehicle is fully loaded.
The point at which the maximum driving distance
begins in emergency mode is when the warning
message appears in the multifunction display
indicating that there is a loss of tire inflation
pressure.
Do not exceed the maximum speed of 50 mph
(80 km/h).
Warning!G
In emergency mode, your vehicle’s driving
characteristics are diminished in such situa-
tions as:

driving around curves

while braking

while accelerating rapidly
Therefore, your driving style must be adapt-
ed accordingly. Avoid abrupt steering and
driving maneuvers, as well as driving over
obstacles (road curbs, potholes, or off-road
areas). This is especially important if the
vehicle is heavily loaded.
The emergency driving distance that can be
achieved greatly depends on the demands
placed on the vehicle. Depending on speed,
load, driving maneuvers, road conditions,
outside temperature, etc., the distance can
be significantly shorter or, if the vehicle is
driven cautiously, somewhat longer.
Do not continue driving in emergency mode
if

you notice knocking sounds

the vehicle starts to shake

smoke develops and you smell rubber

ESP® is intervening continuously

you notice tears on the tire sidewalls
After driving in emergency mode, you must
have the rims inspected by an authorized
Mercedes-Benz Center to check if they are
suitable for further use. The failed tire must
be replaced in any case.
iWhen replacing individual or all tires on the
vehicle, make sure only matching tires marked
with “MOExtended” are mounted in the size
specified for your vehicle (
page 444).

425 Practical hints
Towing the vehicle
Towing the vehicle
Mercedes-Benz recommends that the
vehicle be transported with all wheels off
the ground using flatbed or appropriate
wheel lift/dolly equipment. This method is
preferable to other types of towing.
When circumstances do not permit the
recommended towing methods, the
vehicle may be towed with all wheels on
the ground or front wheels raised only so
far as necessary to have the vehicle moved
to a safe location where the recommended
towing methods can be employed.
!Do not tow-start the vehicle.
!Use flatbed or wheel lift/dolly equipment
with SmartKey in starter switch turned to
position0.
Do not tow with sling-type equipment. Towing
with sling-type equipment over bumpy roads will
damage radiator and supports.
To prevent damage during transport, do not tie
down vehicle by its chassis or suspension parts.
Switch off the automatic central (
page 163)
locking.
Warning!G
If circumstances require towing the vehicle
with all wheels on the ground, always tow
with a tow bar if:

the engine will not run

there is a malfunction in the brake sys-
tem

there is a malfunction in the power sup-
ply or in the vehicle’s electrical system
This is necessary to adequately control the
towed vehicle.
Prior to towing the vehicle with all wheels on
the ground, make certain that the SmartKey
is in starter switch position2.
If the SmartKey is left in the starter switch
position0 for an extended period of time, it
can no longer be turned in the switch. In this
case, the steering is locked. To unlock,
remove SmartKey from starter switch and
reinsert.
Warning!G
With the engine not running, there is no
power assistance for the steering system. In
this case, it is important to keep in mind that
a considerably higher degree of effort is nec-
essary to steer the vehicle. Adapt your driv-
ing accordingly.
!If the vehicle is towed with the front axle
raised, the gear selector lever must be in
positionN and the engine must be shut off
(SmartKey in starter switch position0 or1).
Active braking action through the ESP
® may
otherwise seriously damage the brake system.
When towing the vehicle with all wheels on the
ground, the selector lever must be in positionN
and the SmartKey must be in starter switch
position2.
When towing the vehicle with all wheels on the
ground or the front axle raised, the vehicle may
be towed only for distances up to 30 miles
(50 km) and at a speed not to exceed 30 mph
(50 km/h).

429 Practical hints
Fuses
Fuse box in passenger compartment
1CoverOpening
Open the front passenger door.
Insert flat, blunt object as a lever in-be-
tween the edge of cover1 and the
dashboard cover at the position indi-
cated by the arrow.
Carefully pry cover1 away from the
dashboard using lever.
Using your hands, pull cover1 in di-
rection of the arrow and remove it.
Closing
Hook cover1 into the opening at the
front.
Press cover1 back on until it engag-
es.
Fuse box in trunk
2Cover
3Catches
Turn catches3 counter-clockwise
and remove cover2.!Do not use sharp objects such as a screw
driver to open the fuse box cover1 in the dash-
board, as this could damage it.

438 Technical data
Rims and tires
!Only use tires which have been tested and
approved by Mercedes-Benz. Tires approved by
Mercedes-Benz are developed to provide best
possible performance in conjunction with the
driving safety systems on your vehicle such as
ABS or ESP
®. Tires specially developed for your
vehicle and tested and approved by
Mercedes-Benz can be identified by finding the
following on the tire’s sidewall:

MO = Mercedes-Benz Original equipment
tires

MOE = Mercedes-Benz Original Extended
(tires with limited run-flat characteristics)
original equipment tires
Using tires other than those approved by
Mercedes-Benz may result in damage that is
not covered by the Mercedes-Benz Limited
Warranty.
iFor information on driving with MOExtended
tires, see “MOExtended system*” (
page 313).
!Using tires other than those approved by
Mercedes-Benz can have detrimental effects,
such as

poor handling characteristics

increased noise

increased fuel consumption
Moreover, tires and rims not approved by
Mercedes-Benz may, under load, exhibit dimen-
sional variations and different tire deformation
characteristics that could cause them to come
into contact with the vehicle body or axle parts.
Damage to the tires or the vehicle may be the re-
sult.
iFurther information on tires and rims is
available at any authorized Mercedes-Benz
Center. A placard with the recommended tire in-
flation pressures is located on the driver’s door
B-pillar. Some vehicles may have supplemental
tire inflation pressure information for driving at
high speeds (
page 302) or for vehicle loads
less than the maximum loaded vehicle condition
(
page 302). If such information is provided, it
can be found on the placard located on the in-
side of the fuel filler flap. The tire inflation pressure should be checked
regularly and should only be adjusted on cold
tires. Follow tire manufacturer’s maintenance
recommendation included with vehicle.
iThe following pages also list the approved
wheel rim and tire sizes for equipping your vehi-
cles with winter tires. Winter tires are not avail-
able as standard or optional factory equipment,
but can be purchased from an authorized
Mercedes-Benz Center.
Depending on vehicle model and the standard or
optional factory-equipped wheel rim/tire config-
uration on your vehicle (Appearance Package,
AMG Sport Package etc.), equipping your vehicle
with winter tires approved for your vehicle model
may also require the purchase of two or four
wheel rims of the recommended size for use with
these winter tires. See an authorized
Mercedes-Benz Center for more information.

444 Technical data
Rims and tires
MOExtended tires*
ModelCLS 550CLS 550
Front axle:
Rims (light alloy)8.5 J x 18 H28.5 J x 18 H2
Wheel offset1.10 in (28 mm)1.10 in (28 mm)
Summer tires1,2
1Radial-ply tires2Must be used in conjunction with Tire Pressure Monitoring System (U.S. vehicles), Run Flat Indicator (Canada vehicles), or
Advanced Tire Pressure Monitoring System* (Canada only).
245/40 R18 93Y MOExtended –
Winter tires1,2,3
3Not available as factory equipment.
–245/40 R18 97V XL (Extra Load) M+S.MOExtended
Rear axle:
Rims (light alloy)9.5Jx18H28.5Jx18H2
Wheel offset1.30 in (33 mm)0.71 in (18 mm)
Summer tires1,2,4
4Must not be used with snow chains.
275/35 R18 95Y MOExtended –
Winter tires1,2,3 –245/40 R18 97V XL (Extra Load) M+S .MOExtended

467 Index
M
Main Dimensions 447
Maintenance 12
Calling up service indicator 331
Clearing service indicator
message 331
Resetting service indicator 332
Service indicator message 330
Service term exceeded 331
Maintenance, Maintenance system 330
Manual headlamp mode 127
Manual shift program CLS 63 AMG 179
Deactivating 181
Maximum load rating, Tires 324
Maximum loaded vehicle weight 324
Maximum tire inflation pressure 325
Mechanical key 398
Memory functions 123
Menus see Control system menus
Microphone, Hands-free 31
Minispare wheel see Spare wheel 393Mirrors
Adjusting 47
Auto-dimming 183
Exterior rear view mirror 47
Exterior rear view mirror parking
positions 184
Interior rear view mirror 47
Storing exterior mirror parking
position 125
Mobile phone see Telephone*
MOE tires* see MOExtended system*
MOExtended system* 313, 419
MOExtended tires* 313, 444
MON 284
MP3
Selecting track 150
Multicontour seat* 120
Multifunction display 139
Changing settings see Control system
menus and Control system
submenus 139
Selecting language 155
Multifunction display messages
ABS 360, 374
Airmatic DC 391, 392
Brake fluid 374Brake pads 373
Check engine 348, 349
Coolant 375, 376, 377
Cruise control 361
Distronic* 361
Door 372
Engine oil 379
ESP
®360, 363, 374
Fog lamps 382–384, 386
Hood 372
Light sensor 385
Parking brake 374
Parking lamps 384
PRE-SAFE
®360, 368
Reserve fuel 380
SmartKey with KEYLESS-GO* 380,
381
SRS 388
Tail lamps 386, 387
Tele Aid 388
Telephone* 391
Tires 390
Trunk 372
Turn signals 387
Windshield washer fluid 391

470 Index
Recommended tire inflation
pressure 325
Recovery services, Stolen vehicle (Tele
Aid) 262
Refrigerant, Air conditioning 450
Refueling 283
Regular checks 285
Reminder, seat belts see Seat belts, Tell-
tale
Remote control see Key, SmartKey
Remote door unlock (Tele Aid) 261
Replacing bulbs
Additional turn signals 407
Brake lamps 407
Front lamps 407
Headlamps 405
High beam headlamps 408
High mounted brake lamp 407
License plate lamps 409
Low beam headlamps 408
Parking lamps 409
Side marker lamps 407
Tail lamps 409
Turn signal lamps 408
Reporting safety defects 18
Research octane number see RONReserve fuel
Message in display 380
Reset button in the instrument
cluster 136, 153
Reset tool (Active head restraints) 401
Restraint system see Children in the vehi-
cle
Retaining hook 242
Reverse gear position, Automatic
transmission 169, 171
Rims 325, 438
Roadside assistance 12
Button 259
RON 284
Roof rack* 238
Rotating tires 326
Rubber parts, cleaning 339
Run Flat Indicator* 304
S
Safety
Driving safety systems 89
Occupant 64
Reporting defects 18
Safety belts see Seat belts
Satellite radio* 149
Seat belt force limiter 79Seat belts 76
Children in the vehicle 82
Cleaning 340
Fastening 48
Height adjustment 50
Proper use of 50, 78
Safety guidelines 68
Telltale 27, 351, 352
Warning lamp 351, 352
Seating capacity 297
Seats 41, 118
Adjusting 41
Easy entry/exit feature* 45
Heater* 121
Memory function 123
Multicontour seat* 120
Ventilation* 122
Securing cargo
Cargo tie-down hooks 242
Selecting display 156
Selective setting see Key, SmartKey or
Key, SmartKey with KEYLESS-GO*
Selector lever see Gear selector lever
Self-test
OCS 76
Tele Aid 257