technical data MERCEDES-BENZ E55AMG 2004 W211 User Guide

388 Technical dataSpare parts service
The “Technical data” section provides the
necessary technical data for your vehicle.
Spare parts service
All authorized Mercedes-Benz Centers
maintain a stock of genuine
Mercedes-Benz parts required for mainte-
nance and repair work. In addition, strate-
gically located parts distribution centers
provide quick and reliable parts service.
More than 300 000 different spare parts
for Mercedes-Benz models are available.
Genuine Mercedes-Benz parts are subject-
ed to stringent quality inspections. Each
part has been specifically developed, man-
ufactured or selected for and adapted to
Mercedes-Benz vehicles.
Therefore, genuine Mercedes-Benz parts
should be installed.
!The use of non-genuine Mercedes-Benz
parts and accessories not authorized
by Mercedes-Benz could damage the
vehicle, which is not covered by the
Mercedes-Benz Limited Warranty, or
could compromise the vehicle’s dura-
bility or safety.

389 Technical data
Warranty coverage
Warranty coverage
Your vehicle is covered under the terms of
the warranties printed in the Service and
Warranty Information Booklet. Your
authorized Mercedes-Benz Center will ex-
change or repair any defective parts origi-
nally installed in the vehicle in accordance
with the terms of the following warranties:

New Car Limited Warranty


Emission System Warranty


Emission Performance Warranty


California, Maine, Massachusetts, and
Vermont Emission Control System
WarrantyReplacement parts and accessories are
covered by the Mercedes-Benz Spare Parts
and Accessories Warranties, copies of
which are available at any authorized Mer-
cedes-Benz Center.Loss of Service and Warranty
Information Booklet
Should you lose your Service and Warranty
Information Booklet, have your authorized
Mercedes-Benz Center arrange for a re-
placement. It will be mailed to you.

390 Technical dataIdentification labels
Identification labels1Certification label2Vehicle Identification Number (VIN)3Information label, California version
Vacuum line routing for emission con-
trol system
4Engine number (engraved on engine)
5Emission control label
When ordering spare parts, please specify
vehicle identification and engine numbers.

391 Technical data
Layout of poly-V-belt drive
Layout of poly-V-belt drive
E320/E500
1Automatic belt tensioner
2Power steering pump
3Air conditioning compressor
4Crankshaft
5Coolant pump
6Generator (alternator)
7Idler pulley
E55AMGThe E 55 AMG has two poly-V-belts (belt one
shown in purple / belt two shown in black).1Idler pulley
2Automatic belt tensioner
3Power steering pump
4Air conditioning compressor
5Crankshaft
6Coolant pump
7Generator (alternator)
8Idler pulley
9Automatic belt tensioner
aSuper charger

392 Technical dataEngine
EngineModel
E 320 (211.065
1)
E 320 4MATIC (211.082
1)
1The quoted data apply only to the standard vehicle. See an authorized Mercedes-Benz Center for the corresponding data of all special bodies and special equipment.
E 500 (211.070
1)
E 500 4MATIC (211.083
1)
Engine
112
113
Mode of operation
4-stroke engine, gasoline injection
4-stroke engine, gasoline injection
No. of cylinders
6
8
Bore
3.54 in (89.90 mm)
3.82 in (97.00 mm)
Stroke
3.31 in (84.00 mm)
3.31 in (84.00 mm)
Total piston displacement
195.2 cu.in. (3199 cm
3)
303.0 cu.in. (4966 cm
3)
Compression ratio
10:1
10:1
Output acc. to SAE J 1349
221 hp / 5600 rpm
(165 kW / 5600 rpm)
302 hp / 5600 rpm
(225 kW / 5600 rpm)
Maximum torque acc. to SAE J 1349
232 lb-ft / 3000 rpm-4800 rpm
(315 Nm / 3000 rpm-4800 rpm)
339lb-ft/2700rpm-4250rpm
(460 Nm / 2700 rpm-4250 rpm)
Maximum engine speed
6000 rpm
6000 rpm
Firing order
1-4-3-6-2-5
1-5-4-2-6-3-7-8
Poly-V-belt
2390 mm
2390 mm

393 Technical data
Engine
Model
E 55 AMG (211.076
1)
1The quoted data apply only to the standard vehicle. See an authorized Mercedes-Benz Center for the corre-
sponding data of all special bodies and special equipment.Engine
113
Mode of operation
4-stroke engine, gasoline injection
No. of cylinders
8
Bore
3.82 in (97.00 mm)
Stroke
3.60 in (92.00 mm)
Total piston displacement
331.8 cu.in. (5439 cm
3)
Compression ratio
9:1
Output acc. to SAE J 1349
469 hp /6100 rpm
(350 kW /6100 rpm)
Maximum torque acc. to SAE J 1349
516 lb-ft /2650 rpm
(700 Nm /2650 rpm-4500 rpm)
Maximum engine speed
6500 rpm
Firing order
1-5-4-2-6-3-7-8
Poly-V-belts
Belt one: 1289 mmBelt two: 2449 mm

394 Technical dataRims and tires
Rims and tiresUse only tires and rims which have been
specifically developed for your vehicle and
tested and approved by Mercedes-Benz.
Other tires and rims can have detrimental
effects, such as:

Poor handling characteristics


Increased noise


Increased fuel consumption
Same size tires
16’’ tires
!Moreover, tires and rims not approved
by Mercedes-Benz may, under load, ex-
hibit dimensional variations and differ-
ent tire deformation characteristics
that could cause them to come into
contact with the vehicle body or axle
parts. This may result in damage to the
tires or the vehicle.
iFurther information on tires and rims is
available at any authorized
Mercedes-Benz Center. A tire inflation
pressure table is located on the fuel fill-
er flap of the vehicle. The tire pressure
should be checked regularly and
should only be adjusted on cold tires.
Follow the tire manufacturer’s mainte-
nance recommendation included with
the vehicle.
E320/E3204MATIC
Rims (light alloy)
8 J x 16
Wheel offset
1.4 in (36 mm)
Summer tires(radial-ply tires)
-
All-season tires (radial-ply tires)
225/55 R 16 95H M+S
Winter tires (radial-ply tires)
-

395 Technical data
Rims and tires
17’’ tires
18’’ tires
E 320 / E 500
(Sport Package*)
E 500 / E 500 4MATIC
E 320 4MATIC
E 500 4MATIC
(Sport Package*)
Rims (light alloy)
8 J x 17
8 1/2 J x 17
8 J x 17
Wheel offset
1.5 in (38 mm)
1.5 in (38 mm)
1.5 in (38 mm)
Summer tires (radial-ply tires)
245 / 45 R 17 95W
-
-
All-season tires (radial-ply tires)
-
245 / 45 R 17 95H M+S
245 / 45 R 17 95H M+S
Winter tires (radial-ply tires)
245 / 45 R 17 95V M+S
245 / 45 R 17 95V M+S
245 / 45 R 17 95V M+S
E55AMG
Rims (light alloy)
8 J x 18
Wheel offset
1.18 in (30 mm)
Summer tires (radial-ply tires)
-
All-season tires (radial-ply tires)
-
Winter tires (radial-ply tires)
245 / 40 R 18 93H M+S
or
245 / 40 R 18 97V Extra Load M+S

396 Technical dataRims and tiresMixed size tires (E 55 AMG only)Minispare wheel
E55AMG
Front axle:
AMG light alloy rims
8 J x 18
Wheel offset
1.18 in (30 mm)
Summer tires (radial-ply tires)
245 / 40 ZR18
1
Rear axle:
AMG light alloy rims
9 J x 18
Wheel offset
1.54 in (39 mm)
Summer tires (radial-ply tires)
265 / 35 ZR18 Extra Load M0
1
1Must not be used with snow chains
E 320 / E 320 4MATIC
E 500 / E 500 4MATIC
Rim
4 J x 17
Wheel offset
1.34 (34 mm)
Tire
T 155/70 R 17 110 M
1
1Must not be used with snow chains.
iThe E 55 AMG does not have a spare
wheel. The E 55 AMG is equipped with
TIREFIT (
page 350).

397 Technical data
Electrical system
Electrical system
Model
E320/E3204MATIC
E500/E5004MATIC
E55AMG
Generator (alternator)
14 V / 150 A
14 V / 150 A
14 V / 180 A
Starter motor
14 V / 1.4 kW
14 V / 1.7 kW
14 V / 1.7 kW
Battery (auxiliary)
12 V / 12 Ah
12 V / 12 Ah
12 V / 12 Ah
Battery (main)
12 V/95 Ah
12 V / 95 Ah
12 V / 95 Ah
Spark plugs
Bosch F8 DPP 332U
NGK PFR 5R-11
Bosch F8 DPP 332U
NGK PFR 5R-11
NGK IL FR 6 A
Electrode gap
0.039 in (1.00 mm)
0.039 in (1.00 mm)
0.031 in (0.8 mm)
Tightening torque
18.5 - 22 lb-ft (25 - 30 Nm)
18.5 - 22 lb-ft (25 - 30 Nm)
18.5 - 22 lb-ft (25 - 30 Nm)