MERCEDES-BENZ ML320CDI 2007 W163 Comand Manual

530 Technical dataIdentification labels1Certification label (on driver’s B-pillar)
The V
ehicle I
dentification N
umber (VIN)
can be found in the following locations:


on the certification label


embossed underneath the
passenger-side rear seat (
page 531)


on the lower edge of the windshield
(page 531)
Example certification label (U.S. vehicles)2Paintwork code
3VIN
Example certification label
(Canada vehicles)2Paintwork code
3VINi
Data shown on certification label are for
illustration purpose only. These data are specific
to each vehicle and may vary from data shown in
the illustration. Refer to certification label on
vehicle for actual data specific to your vehicle.

531 Technical data
Identification labels
4Seat cushion
5Floor cover
6VIN
Fold the seat cushion4 forward
(page 285).

Fold floor cover5 in direction of the
arrow.
The VIN6 is now visible.7Emission control information label,
includes both federal and California
certification exhaust emission
standards
8Engine number (engraved on engine)
9Vacuum line routing diagram label
aVIN (lower edge of windshield)
i
When ordering parts, please specify vehicle
identification and engine numbers.

532 Technical dataLayout of poly-V-belt driveML 350
1Idler pulley
2Idler pulley
3Automatic belt tensioner
4Power steering pump
5Air conditioning compressor
6Crankshaft
7Coolant pump
8Generator (alternator)
ML 320 CDI
1Coolant pump
2Idler pulley
3Automatic belt tensioner
4Power steering pump
5Air conditioning compressor
6Crankshaft
7Idler pulley
8Generator (alternator)
ML 500
1Automatic belt tensioner
2Power steering pump
3Air conditioning compressor
4Crankshaft
5Coolant pump
6Generator (alternator)
7Idler pulley

533 Technical data
Layout of poly-V-belt drive
ML 63 AMG
1Idler pulley
2Idler pulley
3Idler pulley
4Automatic belt tensioner
5Power steering pump
6Air conditioning compressor
7Crankshaft
8Coolant pump
9Generator (alternator)

534 Technical dataEngineModel
ML 320 CDI (164.122
1)
1The quoted data apply only to the standard vehicle. See an authorized Mercedes-Benz Light Truck Center for the corresponding data of all special bodies and
special equipment.
ML 350 (164.186
1)
Engine
642
272
Mode of operation
Diesel 4-stroke engine
4-stroke engine, gasoline injection
No. of cylinders
6
6
Bore
3.27 in (83.00 mm)
3.66 in (92.90 mm)
Stroke
3.62 in (92.00 mm)
3.38 in (86.00 mm)
Total piston displacement
182 cu in (2987 cm
3)
213 cu in (3498 cm
3)
Compression ratio
16.5:1
10.7:1
Output acc. to SAE J 1349
221 hp/3800 rpm
(165 kW/3800 rpm)
268 hp/6000 rpm
2
(200 kW/6000 rpm)
2Premium fuel required. Performance may vary with fuel octane rating.Maximum torque acc. to SAE J 1349
398 lb-ft/1600-2400 rpm
(540 Nm/1600-2400 rpm)
258 lb-ft/2400-5000 rpm
(350 Nm/2400-5000 rpm)
Maximum engine speed
4500 rpm
6500 rpm
Firing order
1-4-2-5-3-6
1-4-3-6-2-5
Poly-V-belt
2 035 mm
2 404 mm

535 Technical data
Engine
Model
ML 500 (164.175
1)
1The quoted data apply only to the standard vehicle. See an authorized Mercedes-Benz Light Truck Center for the corresponding data of all special bodies and special
equipment.
ML 63 AMG (164.177
1)
Engine
113
156
Mode of operation
4-stroke engine, gasoline injection
4-stroke engine, gasoline injection
No. of cylinders
8
8
Bore
3.82 in (97.00 mm)
4.02 in (102.20 mm)
Stroke
3.31 in (84.00 mm)
3.72 in (94.60 mm)
Total piston displacement
303 cu in (4966 cm
3)
378.8 cu in (6208 cm
3)
Compression ratio
10:1
11.3:1
Output acc. to SAE J 1349
302 hp/5600 rpm
2
(225 kW/5600 rpm)
2Premium fuel required. Performance may vary with fuel octane rating.
503 hp/6800 rpm
2
(375 kW/6800 rpm)
Maximum torque acc. to SAE J 1349
339 lb-ft/2700-4750 rpm
(460 Nm/2700-4750 rpm)
465 lb-ft/5200 rpm
(630 Nm/5200 rpm)
Maximum engine speed
6300 rpm
7200 rpm
Firing order
1-5-4-2-6-3-7-8
1-5-4-2-6-3-7-8
Poly-V-belt
2 370 mm
2 369 mm

536 Technical dataRims and tires!
Only use tires which have been tested and
approved by Mercedes-Benz. Tires approved by
Mercedes-Benz are developed to provide best
possible performance in conjunction with the
driving safety systems on your vehicle such as
ABS or ESP
®. Tires specially developed for your
vehicle and tested and approved by
Mercedes-Benz can be identified by finding the
following on the tire’s sidewall:


MO = M
ercedes-Benz O
riginal equipment
tires
AMG vehicles:
Does not apply to all approved tires on AMG
vehicles. For information on tested and
approved tires for AMG vehicles, contact an
authorized Mercedes-Benz Light Truck
Center.
Using tires other than those approved by
Mercedes-Benz may result in damage that is not
covered by the Mercedes-Benz Limited
Warranty.
!
Using tires other than those approved by
Mercedes-Benz can have detrimental effects,
such as


poor handling characteristics


increased noise


increased fuel consumption
Moreover, tires and rims not approved by
Mercedes-Benz may, under load, exhibit dimen-
sional variations and different tire deformation
characteristics that could cause them to come
into contact with the vehicle body or axle parts.
Damage to the tires or the vehicle may be the
result.
i
Further information on tires and rims is
available at any authorized Mercedes-Benz Light
Truck Center. A placard with the recommended
tire inflation pressure is located on the driver’s
door B-pillar (
page 530). Some vehicles may
have supplemental tire inflation pressure infor-
mation for driving at high speeds (
page 375)
or for vehicle loads less than the maximum
loaded vehicle condition (
page 375). If such
information is provided, it can be found on the
placard located on the inside of the fuel filler
flap.The tire inflation pressure should be checked
regularly and should only be adjusted on cold
tires. Follow tire manufacturer’s maintenance
recommendation included with vehicle.
i
The following pages also list the approved
wheel rim and tire sizes for equipping your
vehicles with winter tires. Winter tires are not
available as standard or optional factory equip-
ment, but can be purchased from an authorized
Mercedes-Benz Light Truck Center.
Depending on vehicle model and the standard or
optional factory-equipped wheel rim/tire
configuration on your vehicle (Appearance
Package, Sport Package etc.), equipping your
vehicle with winter tires approved for your
vehicle model may also require the purchase of
two or four wheel rims of the recommended size
for use with these winter tires. See an authorized
Mercedes-Benz Light Truck Center for more
information.

537 Technical data
Rims and tires
Same size tires
ML 320 CDI
ML 350
ML 320 CDI*
ML 350*
ML 500
ML 320 CDI (Sport Package*)
ML 350 (Sport Package*)
ML 500 (Sport Package*)
Rims (light alloy)
7.5 J x 17 H2
8Jx18H2
8Jx19H2
Wheel offset
2.20 in (56 mm)
2.36 in (60 mm)
2.36 in (60 mm)
All-season tires
1
235/65 R17 104H M+S
255/55 R18 105H M+S
255/50 R19 107H XL (Extra Load) M+S
Winter tires
1,3
235/65 R17 104H M+S.
255/55 R18 105H M+S.
255/50 R19 107H XL (Extra Load) M+S.
ML 63 AMG
ML 63 AMG*
ML 320 CDI (Sport Package*)
ML 350 (Sport Package*)
ML 500 (Sport Package*)
AMG rims (light alloy)
9.5Jx19H2
10 J x 20 H2
8.5Jx19H2
Wheel offset
1.81 in (46 mm)
1.81 in (46 mm)
2.28 in (58 mm)
All-season tires
1
–
–
255/50 R19 107H XL (Extra Load) M+S
Summer tires
1,2
295/45 ZR19 109Y
295/40 ZR20 106Y
–
Winter tires
1,3
285/45 R19 107V M+S.
–
255/50 R19 107H XL (Extra Load) M+S.
1Radial-ply tires2Must not be used with snow chains.3Not available as factory equipment.

538 Technical dataRims and tiresSpare wheel
Minispare wheel
Spare wheel with collapsible tire
ML 320 CDI
ML 350
ML 500
Rim
4.0B x 18 H2
Wheel offset
1.58 in (40 mm)
Minispare tire
1
1Must not be used with snow chains.
T 155/90-18 113M
Recommended tire inflation pressure
61 psi (4.2 bar)ML 63 AMG
Rim
5.5 B x 19 H2
Wheel offset
0.51 in (13 mm)
Collapsible tire
1
1Must not be used with snow chains.
185/65-19 104P
Recommended tire inflation pressure
51 psi (3.5 bar)

539 Technical data
Rims and tires
!
Please compare the recommended tire in-
flation pressure for your vehicle with the tire in-
flation pressure on the yellow label located on
the spare wheel rim.
If the tire inflation pressure on the yellow label
on the spare wheel rim differs from the values
given in this Operator’s Manual, inflate the col-
lapsible tire to the recommended tire inflation
pressure given on the yellow label on the spare
wheel rim.
i
Please note that the tire inflation pressure of
the collapsible tire differs from the tire inflation
pressure of the road tires.