inflation pressure MERCEDES-BENZ ML500 2005 W163 Owner's Manual

ContentsAt the gas station............................... 219
Refueling ...................................... 219
Check regularly and
before a long trip .......................... 221
Engine compartment.......................... 222
Hood ............................................ 222
Engine oil...................................... 223
Transmission fluid level ................ 227
Coolant level ................................ 227
Battery ......................................... 228
Windshield / rear
window washer system and
headlamp cleaning system*......... 230
Tires and wheels ................................ 231
Important guidelines .................... 231
Life of tire ..................................... 232
Direction of rotation ..................... 232
Checking tire inflation pressure ... 232
Rotating wheels............................ 233
Winter driving..................................... 235
Winter tires................................... 235
Block heater (Canada only) .......... 236
Snow chains ................................. 236Maintenance ...................................... 237
Clearing the
maintenance service indicator ..... 237
Maintenance service
term exceeded ............................. 238
Calling up the
maintenance service indicator ..... 238
Resetting the
maintenance service indicator ..... 238
Vehicle care ....................................... 240
Cleaning and care of the vehicle .. 240
Practical hints.................................. 247
What to do if … .................................. 248
Lamps in instrument cluster ........ 248
Additional indicators
in the speedometer display .......... 263
Where will I find ...? ........................... 264
First aid kit ................................... 264
Vehicle tool kit ............................. 264
Spare wheel (space-saver tire) ..... 266Unlocking / locking in
an emergency .................................... 268
Unlocking the vehicle................... 268
Locking the vehicle ...................... 269
Fuel filler flap ............................... 269
Manually unlocking the
transmission gear selector lever .. 270
Opening / closing in
an emergency .................................... 271
Power tilt / sliding sunroof* ......... 271
Replacing key batteries ..................... 272
Remote control ............................ 273
Replacing bulbs ................................. 274
Bulbs ............................................ 274
Replacing bulbs for front lamps ... 276
Replacing bulbs for rear lamps .... 279
Adjusting headlamp aim .............. 282
Replacing wiper blades ...................... 283
Removing ..................................... 283
Installing ...................................... 283
Flat tire .............................................. 284
Mounting the spare wheel ........... 284

221 Operation
At the gas station
Check regularly and before a long trip
Open the hood (
page 222).
1Engine oil level
2Coolant level
3Brake fluid
4Windshield washer system and
headlamp cleaning system*
Engine oil level
For more information on engine oil, see
“Engine oil” (
page 223).Coolant
For normal replenishing, use water (pota-
ble water quality). For more information,
see “Coolant level” (
page 227) and see
“Fuels, coolants, lubricants, etc.”
(
page 312).
Brake fluidWindshield / rear window washer
system and headlamp cleaning
system*
For more information on refilling the reser-
voir, see “Windshield / rear window washer
system and headlamp cleaning system*”
(
page 230).
Vehicle lighting
Check function and cleanliness. For infor-
mation on replacing light bulbs, see “Re-
placing bulbs” (
page 274).
For more information, see “Combination
switch” (
page 107).
Tire inflation pressure
For more information, see “Checking tire
inflation pressure” (
page 232).
!If you find that the brake fluid in the
brake fluid reservoir has fallen to the
minimum mark or below, have the
brake system checked for brake pad
thickness and leaks immediately. Noti-
fy an authorized Mercedes-Benz Light
Truck Center immediately. Do not add
brake fluid as this will not solve the
problem. For more information, see
“Practical Hints” (
page 251).

232 OperationTires and wheelsLife of tire
The service life of a tire is dependent upon
varying factors including but not limited to:

Driving style


Tire pressure


Distance driven
Direction of rotation
Unidirectional tires offer added advantag-
es, such as better hydroplaning perfor-
mance. To benefit, however, you must
make sure the tires rotate in the direction
specified.
An arrow on the sidewall indicates the
intended direction of rotation of the tire.
Checking tire inflation pressure
Correct the tire pressure only when tires
are cold.
Regularly check your tire pressure at inter-
vals of no more than 14 days.
If the tires are warm, you should only
correct the tire pressure if it is too low for
current operating conditions.
A table on the fuel filler flap lists the
specified tire inflation pressures for warm
and cold tires as well as for various
operating conditions.
!When the wheels are heavily soiled,
e.g. after driving through mud, clean
the inside of the wheels with a jet of
water.Warning!
G
Tires and spare tire should be replaced after
six years, regardless of the remaining tread.
!Keep unmounted tires in a cool, dry
place with as little exposure to light as
possible. Protect tires from contact
with oil, grease and gasoline.
Warning!
G
If the tire pressure drops repeatedly:

Check the tires for punctures from
foreign objects.


Check to see whether air is leaking from
the valves or from around the rim.

233 Operation
Tires and wheels
Tire pressure changes by approximately
1.5 psi (0.1 bar) per 18°F (10°C) of air
temperature change. Keep this in mind
when checking tire pressure where the
temperature is different from the outside
temperature.
Tire temperature and tire pressure are also
increased while driving, depending on the
driving speed and the tire load.Check the spare tire periodically for condi-
tion and inflation. Spare tire will age and
b e c o m e w o r n o v e r t i m e e v e n i f n e v e r u s e d ,
and thus should be inspected and replaced
when necessary.
Rotating wheels
The wheels can be rotated every 3000 to
6000 miles (5 000 to 10 000 km) or soon-
er if necessary, according to the degree of
tire wear. The same direction of tire rota-
tion must be retained.
Rotate the wheels before the characteris-
tic tire wear pattern becomes visible
(shoulder wear on front wheels and tread
center wear on rear wheels).
Thoroughly clean the inner side of the
wheels after each rotation. Check and
make sure proper tire inflation pressure.
iThe pressures listed for light loads are
minimum values offering high driving
comfort.
Increased inflation pressures listed for
heavier loads may also be used for light
loads. These higher pressures produce
favorable handling characteristics. The
ride of the vehicle, however, will be
somewhat harder. Never exceed the
max. values or inflate tires below the
min. values listed in the fuel filler flap.
Warning!
G
Follow recommended inflation pressures.
Do not overinflate tires. Overinflated tires
can result in sudden deflation (blowout)
because they are more likely to become
punctured or damaged by road debris,
potholes, etc.
Do not underinflate tires. Underinflated tires
wear unevenly, adversely affect handling
and fuel economy, and are more likely to fail
from being overheated.
Do not overload the tires by exceeding the
Gross Vehicle Weight Rating (GVWR) and
the Gross Axle Weight Rating (GAWR) as
indicated on the certification label on the
driver’s door pillar. Overloading the tires can
overheat them, possibly causing a blowout.
Warning!
G
Rotate front and rear wheels only if they are
of the same size,

307 Technical data
Rims and tires
Rims and tires
Only use tires and rims which have been
specifically developed for your vehicle and
tested and approved by Mercedes-Benz.
Other tires and rims can have detrimental
effects, such as

poor handling characteristics


increased noise


increased fuel consumption
Rims and tires
!Moreover, tires and rims not approved
by Mercedes-Benz may, under load,
exhibit dimensional variations and
different tire deformation characteris-
tics that could cause them to come into
contact with the vehicle body or axle
parts. This may result in damage to the
tires or the vehicle.
iFurther information on tires and rims is
available at any authorized
Mercedes-Benz Light Truck Center. A
tire inflation pressure table is located
on the fuel filler cap of the vehicle. The
tire pressure should be checked regu-
larly and should only be adjusted on
cold tires. Follow tire manufacturer’s
maintenance recommendation includ-
ed with vehicle.
Model
ML 350
ML 500
Rims (light alloy)
8J x 17 H2
81/2J x 17 H2
Wheel offset
2.0in (52mm)
2.0in (52mm)
All-season tires (radial-ply tires)
255 / 60 R17 106 H
275 / 55 R17 109 V
Rims* (light alloy)
81/2 J x 17 H2
81/2 J x 17 H2
Wheel offset*
1.85 in (47 mm)
1.85 in (47 mm)
All-season tires (radial-ply tires)*
275 / 55 R17 109 V
275 / 55 R17 109 V

329 Index
A
ABS 25, 76, 323
ABS control 76
LOW RANGE mode 77
Malfunction indicator lamp 248
Warning lamp 248
Accelerator position,
automatic transmission 124
Accident
In case of 53
Activating
Air circulation mode 141
Air recirculation mode 141
Anti-theft alarm system 83
Automatic climate control 137
ESP 82
Exterior headlamps 50
Hazard warning flasher 113
Headlamps 50
Ignition 33
Immobilizer 55, 83Rear passenger compartment
ventilation and climate control 143
Rear window defroster 135
Rear window wiper 52
Residual heat 142
Seat heater* 98
Tow-away alarm 85
Warning indicators (Parktronic*) 158
Windshield wipers 51
Activating automatic central locking 94
Adding
Coolant 228
Engine oil 226
Additional turn signals 274
Adjustable steering column
Indicator lamp 260
Adjusting 35
Backrest tilt 37, 39
Exterior rear view mirror 41
Head restraint height 37, 39
Head restraint tilt 38, 40Headlamp aim 282
Instrument cluster illumination 117
Interior rear view mirror 41
Manual seat 36
Mirrors 41
Seat cushion tilt 39
Seat fore and aft 36
Seat fore and aft adjustment 38
Seat height 37, 39
Seats 35
Steering wheel 40
Adjusting air distribution
Automatic climate control 139
Adjusting air volume
Automatic climate control 139
Air conditioning
Cooling 141
Air conditioning refrigerant 314
Air pressure see Tire inflation pressure

348 IndexTightening torque 327
Tightening torque (Wheel bolts) 287
Tilt
Head restraint 38, 40
Tilt/sliding sunroof*
Closing 150
Opening 150
Synchronizing 152
Time
Setting hours 119
Setting minutes 119
Tire inflation pressure
Checking 221, 232
Tire speed rating 202, 327
Tire traction 201
Tires 307
Direction of rotation 232
Driving instructions 200
Retreads 231
Rims and tires 307
Service life 232
Temperature 233
Temperature grades 321
Tread depth 235
Wear pattern 233
Winter 235Tools 264
Vehicle jack 265
Vehicles with CD-changer* 265
Wheel bolt wrench 265
Tow-away alarm 29, 84
Arming 84
Disarming 84
Disarming for transport 84
Towing
Trailer 211
Towing a trailer 214
Automatic transmission 125
Towing eye
Front 295
Rear 295
Towing the vehicle 293
Stranded vehicle 296
Tracking services
For stolen vehicle 183
Traction 320, 327
Trailer
Attaching 213
Loading 212
Towing 214Trailer hitches 211
Trailer towing 211
Attaching a trailer 213
Checking weights 213
Electrical connections 212
Hitches 211
Loading 212
Weights and ratings 212
Trailer weights and ratings 212
Transfer case 327
Transmission control – LOW RANGE
mode 127
Switching off 127
Switching on 127
Transmission selector lever 270
Unlocking manually 270
Tread depth (tires) 235
Treadwear 320