Head light MITSUBISHI LANCER 2006 Workshop Manual

CHARGING SYSTEM
ENGINE ELECTRICAL16-4
2. Turn the ignition switch to the "LOCK" (OFF)
position.
3. Disconnect the negative battery cable.
4. Connect a clamp-type DC test ammeter with a
range of 0
− 120 A to the alternator "B" terminal
output wire.
NOTE: The way of disconnecting the alternator
output wire and of connecting the ammeter is pos
-
sibly not found the problem that the output current
is dropping due to the insufficient connection
between terminal "B" and the output wire.
5. Connect a digital-type voltmeter between the
alternator "B" terminal and the battery (+)
terminal. [Connect the (+) lead of the voltmeter to
the "B" terminal and the connect the (-) lead of the
voltmeter to the battery (+) cable].
6. Reconnect the negative battery cable.
7. Connect a tachometer or the M.U.T.-II/III (Refer to
GROUP 11A
− On-vehicle Service − Idle speed
check <4G1>
P.11A-11 or GROUP 11C −
On-vehicle Service − Idle speed check <4G6>
P.11C-11).
8. Leave the hood open.
9. Start the engine.
10.With the engine running at 2,500 r/min, turn the
headlamps and other lamps on and off to adjust
the alternator load so that the value displayed on
the ammeter is slightly above 30 A.
Adjust the engine speed by gradually decreasing
it until the value displayed on the ammeter is 30
A. Take a reading of the value displayed on the
voltmeter at this time.
Limit: maximum 0.3 V
NOTE: When the alternator output is high and the
value displayed on the ammeter does not
decrease until 30 A, set the value to 40 A. Read
the value displayed on the voltmeter at this time.
When the value range is 40 A, the limit is maxi
-
mum 0.4 V.
11.If the value displayed on the voltmeter is above
the limit value, there is probably a malfunction in
the alternator output wire, so check the wiring
between the alternator "B" terminal and the
battery (+) terminal (including fusible link).
If a terminal is not sufficiently tight or if the
harness has become discolored due to
overheating, repair and then test again.
12.After the test, run the engine at idle.
13.Turn off all lamps and the ignition switch.
14.Remove the tachometer or the M.U.T.-II/III.
15.Disconnect the negative battery cable.
16.Disconnect the ammeter and voltmeter.
17.Connect the negative battery cable.

CHARGING SYSTEM
ENGINE ELECTRICAL16-6
9. Check that the reading on the voltmeter is equal
to the battery voltage.
NOTE: If the voltage is 0 V, the cause is probably
an open circuit in the wire or fusible link between
the alternator "B" terminal and the battery (+) ter
-
minal.
10.Turn the light switch on to turn on headlamps and
then start the engine.
11.Immediately after setting the headlamps to high
beam and turning the heater blower switch to the
high revolution position, increase the engine
speed to 2,500 r/min and read the maximum
current output value displayed on the ammeter.
Limit: 70 % of normal current output
NOTE: .
•For the nominal current output, refer to the
Alternator Specifications.
•Because the current from the battery will soon
drop after the engine is started, the above step
should be carried out as quickly as possible in
order to obtain the maximum current output
value.
•The current output value will depend on the
electrical load and the temperature of the
alternator body.
•If the electrical load is small while testing, the
specified level of current may not be output
even though the alternator is normal. In such
cases, increase the electrical load by leaving
the headlamps turned on for some time to dis
-
charge the battery or by using the lighting sys-
tem in another vehicle, and then test again.
•The specified level of current also may not be
output if the temperature of the alternator body
or the ambient temperature is too high. In such
cases, cool the alternator and then test again.
12.The reading on the ammeter should be above the
limit value. If the reading is below the limit value
and the alternator output wire is normal, remove
the alternator from the engine and check the
alternator.
13.Run the engine at idle after the test.
14.Turn the ignition switch to the "LOCK" (OFF)
position.
15.Remove the tachometer or the M.U.T.-II/III.
16.Disconnect the negative battery cable.
17.Disconnect the ammeter and voltmeter.
18.Connect the negative battery cable.

ON-VEHICLE SERVICE
POWER STEERING37-11
ON-VEHICLE SERVICE
STEERING WHEEL FREE PLAY CHECKM1372001000311
1. With the engine running (hydraulic operation), set the front wheels straight ahead.
ACX01122 AB
2.Measure the play on th e ste e ring wh eel
circumfer ence before the whee ls st a r t to move
when slightly moving the stee ring whe e l in both
direct ions.
Limit: 30 mm
3.Wh en the play exceed s the limit, check fo r the
play on the stee ring shaf t and stee ring linkage
connectio n . Correct or replace .
4.If th e free play still exceeds the limit valu e, set t he
steering wheel stra ight ahead with the engine
stoppe d. Loa d 5 N towards the steer ing whee l
circumfer ence and check the play .
St andard value (steering whee l pla y with the
engine s
t opped): 1 0 mm o r l ess
5.If the play e xce eds the st an dard value , remove
th e ste e ring gear (Refe r to
P.37-23) and check
the tot a l p i nion torqu e (Refer to P.37-26).
STEERING ANGLE CHECKM137200 1 1 0070 5
AC000756AB
1.Place t he fron t wh eel on a tu rning radiu s gau ge
a nd me asure the steering ang le.
St andard va lue:
Inner
wheelsInvite39°30' ± 1°30'
Intense (LH
drive vehicles)33°40' +1°00'/-2°00'
Intense (RH
drive vehicles)37°00' +1°00'/-2°00'
Outer
wheels
(reference)Invite32°30'
Intense (LH
drive vehicles)28°46'
Intense (RH
drive vehicles)30°00'
2.If the steerin g ang le is not within the st a ndard
value , adjust t he toe-in as follows.
St andard va lue:
at the centre of tyre trea d: 1 ± 2 mm
To e angle (p er whee l): 0°03' ± 06'
AC006074 AD
Lock nut
Clip
3.L oose n the lock nut, and un clip the bellows clip .
4.Adjust the toe - in by turning th e lef t an d righ t tie
ro d turnb u ckles by th e sa me a m oun t (in o pposite
directions).
NOTE: The to e will move out as th e lef t turnbuckle
is tur
ned toward the fro n t of th e ve hicle an d the
right tu
rnbuckle is turned toward the rear of the
vehicle.
5. T i ghten the lo ck nut to the specified torque , and
tighten the be llo ws by the clip .
Ti ghte n ing torque: 40 ± 5 N⋅m
6.Recheck the stee ring a ngle .

90-2
TAIL LAMP, POSITION LAMP,
LICENCE PLATE LAMP AND
LIGHTING MONITOR BUZZER
TAIL LAMP, POSITION LAMP, LICENCE
PLATE LAMP AND LIGHTING MONITOR
BUZZER <LHD> . . . . . . . . . . . . . . . . . . . . . 90-118
TAIL LAMP, POSITION LAMP, LICENCE
PLATE LAMP AND LIGHTING MONITOR
BUZZER <RHD> . . . . . . . . . . . . . . . . . . . . . 90-124
FRONT FOG LAMP
FRONT FOG LAMP <LHD> . . . . . . . . . . . . 90-130
FRONT FOG LAMP <RHD> . . . . . . . . . . . . 90-134
ROOM LAMP AND LUGGAGE
COMPARTMENT LAMP
ROOM LAMP AND LUGGAGE
COMPARTMENT LAMP
<SEDAN (LHD)> . . . . . . . . . . . . . . . . . . . . . 90-138
ROOM LAMP AND LUGGAGE
COMPARTMENT LAMP
<SEDAN (RHD)> . . . . . . . . . . . . . . . . . . . . 90-142
ROOM LAMP,PERSONAL LAMP
AND LUGGAGE ROOM LAMP
ROOM LAMP, PERSONAL LAMP AND
LUGGAGE ROOM LAMP
<WAGON (LHD)> . . . . . . . . . . . . . . . . . . . . 90-146
ROOM LAMP, PERSONAL LAMP AND
LUGGAGE ROOM LAMP
<WAGON (RHD)> . . . . . . . . . . . . . . . . . . . . 90-152
REAR FOG LAMP
REAR FOG LAMP <LHD> . . . . . . . . . . . . . 90-158
REAR FOG LAMP <RHD> . . . . . . . . . . . . . 90-162
HEADLAMP LEVELLING SYSTEM
HEADLAMP LEVELLING SYSTEM
<LHD> . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 90-166
HEADLAMP LEVELLING SYSTEM
<RHD> . . . . . . . . . . . . . . . . . . . . . . . . . . . . 90-168
TURN-SIGNAL LAMP AND HAZARD
WARNING LAMP
TURN SIGNAL LAMP AND HAZARD
WARNING LAMP <LHD> . . . . . . . . . . . . . . 90-172
TURN SIGNAL LAMP AND HAZARD
WARNING LAMP <RHD> . . . . . . . . . . . . . . 90-176
BACK-UP LAMP
BACK-UP LAMP <LHD> . . . . . . . . . . . . . . . 90-180
BACK-UP LAMP <RHD> . . . . . . . . . . . . . . . 90-181
STOP LAMP
STOP LAMP <SEDAN (LHD)> . . . . . . . . . . 90-182
STOP LAMP <SEDAN (RHD)> . . . . . . . . . . 90-183
STOP LAMP <WAGON (LHD)> . . . . . . . . . 90-184
STOP LAMP <WAGON (RHD)> . . . . . . . . . 90-185
HORN . . . . . . . . . . . . . . . . . . . . . . . . .90-186
METER AND GAUGE
METER AND GAUGE <LHD> . . . . . . . . . . . 90-188
METER AND GAUGE <RHD> . . . . . . . . . . 90-192
FUEL WARNING LAMP, OIL
PRESSURE WARNING LAMP AND
BRAKE WARNING LAMP
FUEL WARNING LAMP, OIL PRESSURE
WARNING LAMP AND BRAKE WARNING
LAMP <LHD> . . . . . . . . . . . . . . . . . . . . . . . 90-196
FUEL WARNING LAMP, OIL PRESSURE
WARNING LAMP AND BRAKE WARNING
LAMP <RHD> . . . . . . . . . . . . . . . . . . . . . . . 90-198
POWER WINDOWS <LHD> . . . . . . . .90-200
POWER WINDOWS <RHD> . . . . . . . .90-206
Continued on next page

90-3
CENTRAL DOOR LOCKING
SYSTEM . . . . . . . . . . . . . . . . . . . . . . .90-212
CENTRAL DOOR LOCKING SYSTEM
<LHD WITHOUT KEYLESS ENTRY> . . . . 90-212
CENTRAL DOOR LOCKING SYSTEM
<RHD WITHOUT KEYLESS ENTRY> . . . . 90-216
CENTRAL DOOR LOCKING SYSTEM
<SEDAN LHD WITH KEYLESS ENTRY>. . 90-220
CENTRAL DOOR LOCKING SYSTEM
<SEDAN RHD WITH KEYLESS ENTRY> . 90-226
CENTRAL DOOR LOCKING SYSTEM
<WAGON LHD WITH KEYLESS ENTRY> . 90-232
CENTRAL DOOR LOCKING SYSTEM
<WAGON RHD WITH KEYLESS ENTRY> 90-240
HEATER . . . . . . . . . . . . . . . . . . . . . . .90-248
HEATER <LHD> . . . . . . . . . . . . . . . . . . . . . 90-248
HEATER <RHD>. . . . . . . . . . . . . . . . . . . . . 90-252
MANUAL AIR CONDITIONER . . . . . .90-256
MANUAL AIR CONDITIONER <LHD> . . . . 90-256
MANUAL AIR CONDITIONER <RHD> . . . . 90-260
AUTOMATIC AIR CONDITIONER . . .90-264
AUTOMATIC AIR CONDITIONER
<LHD> . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 90-264
AUTOMATIC AIR CONDITIONER
<RHD> . . . . . . . . . . . . . . . . . . . . . . . . . . . . 90-270
WINDSHIELD WIPER AND WASHER90-276
WINDSHIELD WIPER AND WASHER
<LHD> . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 90-276
WINDSHIELD WIPER AND WASHER
<RHD> . . . . . . . . . . . . . . . . . . . . . . . . . . . . 90-280
REAR WIPER AND WASHER . . . . . .90-284
REAR WIPER AND WASHER <LHD> . . . . 90-284
REAR WIPER AND WASHER <RHD> . . . . 90-288
REAR WINDOW DEFOGGER AND
DOOR MIRROR HEATER . . . . . . . . .90-292
REAR WINDOW DEFOGGER AND
DOOR MIRROR HEATER <LHD> . . . . . . . 90-292
REAR WINDOW DEFOGGER AND
DOOR MIRROR HEATER <RHD> . . . . . . . 90-294
REMOTE CONTROLLED MIRROR . .90-296
REMOTE CONTROLLED MIRROR
<LHD> . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 90-296
REMOTE CONTROLLED MIRROR
<RHD>. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 90-297
HEADLAMP WASHER . . . . . . . . . . . .90-298
SPARE CONNECTOR
(FOR AUDIO) . . . . . . . . . . . . . . . . . . .90-300
SPARE CONNECTOR (FOR AUDIO)
<LHD> . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 90-300
SPARE CONNECTOR (FOR AUDIO)
<RHD>. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 90-302
CLOCK . . . . . . . . . . . . . . . . . . . . . . . .90-304
CIGARETTE LIGHTER AND
ASHTRAY ILLUMINATION LAMP . . .90-305
ACCESSORY SOCKET . . . . . . . . . . .90-306
IMMOBILIZER SYSTEM . . . . . . . . . . .90-308
IMMOBILIZER SYSTEM <LHD> . . . . . . . . . 90-308
IMMOBILIZER SYSTEM <RHD> . . . . . . . . 90-310
ABS . . . . . . . . . . . . . . . . . . . . . . . . . . .90-312
ABS <LHD> . . . . . . . . . . . . . . . . . . . . . . . . . 90-312
ABS <RHD> . . . . . . . . . . . . . . . . . . . . . . . . 90-316
HEATED SEAT . . . . . . . . . . . . . . . . . .90-320
RHEOSTAT . . . . . . . . . . . . . . . . . . . . .90-322
RHEOSTAT <LHD> . . . . . . . . . . . . . . . . . . . 90-322
RHEOSTAT <RHD> . . . . . . . . . . . . . . . . . . 90-323
SUPPLEMENTAL RESTRAINT
SYSTEM (SRS) . . . . . . . . . . . . . . . . . .90-324
SUPPLEMENTAL RESTRAINT SYSTEM
(SRS) <LHD> . . . . . . . . . . . . . . . . . . . . . . . 90-324
SUPPLEMENTAL RESTRAINT SYSTEM
(SRS) <RHD> . . . . . . . . . . . . . . . . . . . . . . . 90-330
SPARE CONNECTOR
(FOR FRONT FOG LAMP) . . . . . . . . .90-336

J/C
CIRCUIT DIAGRAMS90-6
J/C
J/C <LHD>M1901014201956
NOTE: IN ACTUAL VEHICLES, ANY OF THE TERMINALS CONNECTED IN J/C
ARE USED. THE TERMINAL ARRANGEMENT DESCRIBED IN THE CIRCUIT
DIAGRAM MAY NOT BE IDENTICAL TO THOSE OF THE VEHICLES.
·CENTRAL DOOR
LOCKING SYSTEM
·FRONT FOG
LAMP
·HEADLAMP
·HEADLAMP
WASHER
·POWER WINDOWS
·REAR FOG LAMP
·ROOM LAMP AND
LUGGAGE
COMPARTMENT
LAMP
·ROOM LAMP
PERSONAL LAMP
AND LUGGAGE
ROOM LAMP ·TAIL LAMP,
POSITION LAMP,
LICENCE PLATE
LAMP AND
LIGHTING MONITOR
BUZZER
·TURN-SIGNAL
LAMP AND
HAZARD
WARNING LAMP
·WINDSHIELD
WIPER AND
WASHER
RELAY BOX
(FUSE )·FRONT FOG LAMP
·HEADLAMP
·HEADLAMP WASHER
·REAR FOG LAMP
·TAIL LAMP, POSITION
LAMP, LICENCE PLATE
LAMP AND LIGHTING
MONITOR BUZZER
·TURN-SIGNAL LAMP AND
HAZARD WARNING LAMP
·WINDSHIELD WIPER
AND WASHER
SPARE
CONNECTOR
(FOR AUDIO)CLOCK
·FUEL WARNING
LAMP
·INVECS-II
4A/T
·METER AND
GAUGE
RELAY BOX
(FUSE )
TURN-SIGNAL
LAMP AND
HAZARD WARNING
LAMP HEATED
SEAT
·AUTOMATIC AIR
CONDITIONER
·HEATER
·MANUAL AIR
CONDITIONER
·REAR WINDOW
DEFOGGER
AND DOOR
MIRROR HEATER CIGARETTE
LIGHTER AND
ASHTRAY
ILLUMINATION
LAMP RHEOSTAT
SPARE
CONNECTOR
(FOR AUDIO) HEADLAMP
LEVELLING
SYSTEM
·FRONT
FOG LAMP
·REAR
FOG LAMP
20
22
AUTOMATIC AIR
CONDITIONER

J/C
CIRCUIT DIAGRAMS90-7
REAR WIPER
AND WASHER
·FRONT FOG LAMP
·HEADLAMP
·HEADLAMP WASHER
·REAR FOG LAMP
·TAIL LAMP, POSITION
LAMP, LICENCE PLATE
LAMP AND LIGHTING
MONITOR BUZZER
·WINDSHIELD WIPER
AND WASHERINVECS-II
4A/T POWER
WINDOWSSTOP
LAMP·INVECS-II
4A/T
·REAR WIPER
AND WASHER
·STOP LAMP
·FRONT FOG LAMP
·HEADLAMP
·HEADLAMP WASHER
·REAR FOG LAMP
·REAR WIPER
AND WASHER
·TAIL LAMP, POSITION
LAMP, LICENCE PLATE
LAMP AND LIGHTING
MONITOR BUZZER
·TURN-SIGNAL LAMP
AND HAZARD
WARNING LAMP
·WINDSHIELD WIPER
AND WASHER·FRONT FOG LAMP
·HEADLAMP
·HEADLAMP WASHER
·POWER WINDOWS
·REAR FOG LAMP
·REAR WIPER
AND WASHER
·TAIL LAMP, POSITION
LAMP, LICENCE PLATE
LAMP AND LIGHTING
MONITOR BUZZER
·TURN-SIGNAL LAMP
AND HAZARD
WARNING LAMP
·WINDSHIELD WIPER
AND WASHER·FRONT FOG LAMP
·HEADLAMP
·HEADLAMP LEVELLING
SYSTEM
·HEADLAMP WASHER
·REAR FOG LAMP
·TAIL LAMP, POSITION
LAMP, LICENCE PLATE
LAMP AND LIGHTING
MONITOR BUZZER
·WINDSHIELD WIPER
AND WASHER
·AUTOMATIC AIR
CONDITIONER
·HEATER
·MANUAL AIR
CONDITIONER
J/B (FUSE ) HEATED
SEAT ·HEADLAMP
LEVELLING
SYSTEM
·WINDSHIELD
WIPER AND
WASHER
REMOTE
CONTROLLED
MIRROR ·HEADLAMP
·HEADLAMP
WASHER
5

J/C
CIRCUIT DIAGRAMS90-8
J/C <LHD> (CONTINUED)
FRONT FOG
LAMP
·FRONT
FOG LAMP·FRONT FOG
LAMP
REAR FOG
LAMP
·REAR FOG
LAMP·REAR FOG
LAMP
HEATED
SEAT
HEATED
SEAT IMMOBILIZER
SYSTEM·CLOCK·HEATER TURN-SIGNAL
LAMP AND
HAZARD
WARNING LAMP·TURN-SIGNAL
LAMP AND HAZARD
WARNING LAMP
TURN-SIGNAL
LAMP AND HAZARD
WARNING LAMP ·MANUAL AIR
CONDITIONER
·HEATER
·MANUAL AIR
CONDITIONER ·HEADLAMP·HEADLAMP
·HEADLAMP
WASHER
ACCESSORY
SOCKET·CENTRAL
DOOR LOCKING
SYSTEM
·POWER WINDOWS
·REAR WIPER
AND WASHER
·ROOM LAMP AND
LUGGAGE
COMPARTMENT
LAMP·ROOM LAMP,
PERSONAL LAMP
AND LUGGAGE
ROOM LAMP
·TAIL LAMP,
POSITION LAMP,
LICENCE PLATE
LAMP AND LIGHTING
MONITOR BUZZER
·WINDSHIELD WIPER
AND WASHER
HEADLAMP
LEVELLING
SYSTEM
·INVECS-II 4A/T
·METER AND
GAUGECIGARETTE
LIGHTER AND
ASHTRAY
ILLUMINATION
LAMP
SPARE
CONNECTOR
(FOR AUDIO)·REAR WINDOW
DEFOGGER AND
DOOR MIRROR
HEATERRHEOSTAT ·AUTOMATIC
AIR
CONDITIONER
·AUTOMATIC AIR
CONDITIONER

J/C
CIRCUIT DIAGRAMS90-9
·FRONT FOG
LAMP
·TURN-SIGNAL
LAMP AND HAZARD
WARNING LAMP ·HEADLAMP
·HEADLAMP
WASHER ·CENTRAL
DOOR LOCKING
SYSTEM
·POWER WINDOWS
·REAR WIPER
AND WASHER
·ROOM LAMP AND
LUGGAGE
COMPARTMENT
LAMP·ROOM LAMP,
PERSONAL LAMP
AND LUGGAGE
ROOM LAMP
·TAIL LAMP,
POSITION LAMP,
LICENCE PLATE
LAMP AND LIGHTING
MONITOR BUZZER
·WINDSHIELD WIPER
AND WASHER
J/C (6)DIAGNOSIS
CONNECTOR
DIAGNOSIS
CONNECTOR
SUPPLEMENTAL
RESTRAINT
SYSTEM (SRS)ABS
·ENGINE
CONTROL
SYSTEM
·IMMOBILIZER
SYSTEM
·INVECS-II
4A/T AUTOMATIC AIR
CONDITIONER

J/C
CIRCUIT DIAGRAMS90-10
J/C <LHD> (CONTINUED)
·FRONT FOG
LAMP ·FRONT FOG
LAMP
FRONT FOG
LAMP
·TURN-SIGNAL
LAMP AND HAZARD
WARNING LAMP ·HEADLAMP
WASHER ·ROOM LAMP AND
LUGGAGE
COMPARTMENT
LAMP
·ROOM LAMP,
PERSONAL LAMP
AND LUGGAGE
ROOM LAMP
·TAIL LAMP,
POSITION LAMP,
LICENCE PLATE
LAMP AND LIGHTING
MONITOR BUZZER
·WINDSHIELD WIPER
AND WASHER·WINDSHIELD
WIPER AND
WASHER
WINDSHIELD
WIPER AND
WASHER
DIAGNOSIS
CONNECTOR·METER AND
GAUGE
·METER AND
GAUGE METER AND
GAUGESPARE
CONNECTOR
(FOR AUDIO)
SPARE
CONNECTOR
(FOR FRONT
FOG LAMP)·SPARE
CONNECTOR
(FOR FRONT
FOG LAMP) CLOCK(FUSE )
23
(FUSE )2
RELAY
BOX
·REAR FOG
LAMP
·REAR WIPER AND
WASHER ·ABS
·BRAKE
WARNING LAMP
·CHARGING
SYSTEM
·ENGINE
CONTROL
SYSTEM
·FUEL WARNING
LAMP
·INVECS-II
4A/T
·SUPPLEMENTAL
RESTRAINT
SYSTEM (SRS) ·OIL PRESSURE
WARNING LAMP J/B
(FUSE )
11J/B ACCESSORY
SOCKET
REMOTE
CONTROLLED
MIRROR