engine NISSAN PULSAR 2016 Manual PDF


> (GLW   0RGHO &$@
Extended storagefuseswitch (ifequipped)
GUID-5C0 0252D-3068-4605-8AA0 -2F3EB6F6A1 1D
SDI2705
If any electrical equipment doesnotoperate, remove
the extended storagefuseswitch andcheck foran
open fuse.
NO TE:
If the extended storagefuseswitch malfunc-
tions, orifthe fuse isopen, itis not necessary to
replace theswitch. Inthis case, remove the
extended storagefuseswitch andreplace itwith
a new fuse ofthe same rating.
How toremove theextended storagefuse
switch:
GUID-9E14C2 E6-2E9C-4731-980B-C45B899B9 77B
1. To remove theextended storagefuseswitch, be
sure theignition switchisin the ªOFFº orªLOCKº
position.
2. Besure theheadlight switchisin the ªOFFº
position.
3. Remove thefuse boxcover.
4. Pinch thestorage fuseswitch andpullitin the
direction illustrated.
GUID-0CA4 CBD7-552D -4275-8986-132CF6D FB30B
HEADLIGHTS
GUID-2A2B 2E01-3752-481E-ADE 0-0FB5E738 13F7
Fog may temporarily forminside thelens ofthe exterior
lights inthe rain orinacar wash. Atemperature
difference betweentheinside andtheoutside ofthe
lens causes thefog. This isnot amalfunction. Iflarge
drops ofwater collect insidethelens, contact a
NISSAN dealer.
X enon headlight model
GUID-A 9B63013- 3258-4FA3-B5A7 -51CE4118ED 89
If replacement isrequired, contactaNISSAN dealer.
WARNING:
HIGH VOLTAGE
When xenon headlights areon,they produce a
high voltage. To prevent anelectric shock,never
attempt tomodify ordisassemble. Alwayshave
your xenon headlights replacedataNISSAN
dealer.
Use thesame number andwattage asoriginally
installed:
High/Low beams(Xenon)
Wattage: 35
Bulb no.:D2S
Halogen headlight model
GUID-211 3779C-896 9-4483-818 E-EFB621042A37
The halogen headlight isasemi-sealed beamtype
which usesreplaceable headlight(halogen) bulbs.
They canbereplaced frominside theengine compart-
ment without removing theheadlight assembly.
CAUTION:
High-pressure halogengasissealed insidethe
bulb. Thebulb maybreak ifthe glass envelope is
scratched orthe bulb is
dropped.
JVM0070X
1. Disconnect thebattery negative cable.
2. Disconnect theelectrical connector
*
A
from the
rear endofthe bulb.
3. Pulloffthe rubber cap
*
B
.
4. Push andturn theretaining pin
*
C
to loosen it.
5. Remove theheadlight bulb.Donot shake orrotate
the bulb when removing it.
6. Install thenew bulb inthe reverse orderof
removal.
Maintenance anddo-it-yours elf
8-23
LIGHTS
&RQGLWLRQ


> (GLW   0RGHO &$@
9 Technical information
Recommended fluids/lubricants andcapacities ....
.............................. 9-2
Fuel information ....
...................................................... ...........................9-4
Recommended SAEviscosity number....
....................................... .9-4
Air conditioner systemrefrigerant andlubricant ....
....................... 9-5
Engine ....
............................................ ............................................................. 9-6
Tires andwheels ....
........................................................... ...........................9-7
Dimensions ....
............................................ .................................................... 9-7
When travelling orregistering inanother country ....
........................... 9-8
V ehicle identification ....
............................................ ...................................9-8
V ehicle identification plate....
............................................ ..................9-8
V ehicle Identification Number(VIN)plate(ifequipped) ....
......... 9-8
V ehicle Identification Number(chassis number) ....
...................... 9-8 Engine
serialnumber ....
........................................................... ..........9-9
Certification label(ifequipped) ....
................................................. .9-9
Tire placard ....
........................................................... ...........................9-9
Air conditioner specification label....
.............................................. 9-9
Uniform TireQuality Grading (ifequipped) ....
..................................... 9-9
T readwear ....
...................................................... ...................................9-9
T raction AA,A ,B and C....
............................................ ..................9-9
T emperature A,B and C....
............................................ ...............9-10
Radio approval numberandinformation ....
........................................ 9-10
For Singapore ....
................................................................ ...............9-10
For Nigeria ....
............................................ .........................................9-10
For Jordan ....
...................................................... ................................9-10
&RQGLWLRQ


> (GLW   0RGHO &$@
9-2
T echnical information
GUID-53320E 59-E6E6-477B-926D-8FBE547E0530
The following areapproximate capacities.Theactual refillquantities maybeslightly different. Whenrefilling, followtheprocedures instructedinthe ª8.Maintenance anddo-it-
yourselfº sectiontodetermine theproper refillcapacity .
Capacity (Approximate)
RecommendedFluids/Lubricants
Liter Impmeasure
Fuel 5211-1/2gal
SeeªFuel informationº (P.9-4) .
Engine oil(Refill)
Forchanging engineoil,see ªEngine oilº(P.8-9) .
. Genuine NISSANengineoil
. APIgrade SL,SM orSN
. ILSAC gradeGF-3, GF-4orGF-5
For additional information, seeªRecommended SAE
viscosity numberº(P.9-4) .
MRA8DE
With
oilfilter 3.93-3/8qt
Without oilfilter 3.73-1/4qt
MR16DD T With
oilfilter 4.54
qt
Without oilfilter 4.33-3/4qt
HR16DE With
oilfilter 3.02-5/8qt
Without oilfilter 2.82-1/2qt
Cooling system
(with reservoir) .
Genuine NISSANEngineCoolant orequivalent in
its quality
. UseGenuine NISSAN EngineCoolant orequiva-
lent inits quality ,in order toavoid possible
aluminum corrosionwithintheengine cooling
system caused bythe use ofnon-genuine engine
coolant.
. Note thatanyrepairs forthe incidents within
the engine cooling systemwhileusing non-
genuine enginecoolant maynotbecovered
by the warranty evenifsuch incidents
occurred duringthewarranty period.
T
otal MR16DD
T 8.37-1/4qt
HR16DE and
MRA8DE 6.6
5-7/8qt
Reservoir 0.83/4qt
Continuously Variable Transmission (CVT)fluid
ÐÐ.
Genuine NISSANCVTFluid NS-3
. Useonly Genuine NISSANCVTFluid NS-3.
Using transmission fluidother thanGenuine
NISSAN CVTFluid NS-3willdamage theCVT ,
which isnot covered bythe warranty.
Manual Transmission (MT)gearoil
RECOMMEN DEDFLUIDS/
LUBRICANTS ANDCAPACITIES
&RQGLWLRQ


> (GLW   0RGHO &$@
9-4
T echnical information
FUEL INFORMA TION
GUID-37 026D02-52 91-4945-95 D4-DC57AE1253E5
CAUTION:
Do not use leaded gasoline. Usingleaded gaso-
line willdamage thethree-way catalyst.
MRA8DE enginemodel
GUID-469 86ABD-69B 6-4B65-A7B 8-A7330B55C4D1
Except forThailand andIraq:
GUID-9E14C2 E6-2E9C-4731-980B-C45B899B9 77B
Use UNLEADED REGULARgasolinewithanoctane
rating ofatleast 91(RON) .
For Thailand:
GUID-9E14C2 E6-2E9C-4731-980B-C45B899B9 77B
Use UNLEADED REGULARgasolineorgasohol (upto
E20*) withanoctane ratingofatleast 91(RON) .
*: Gasohol isalcohol blended gasoline. Forexample,
ªE20º isamixture ofapproximately 20%fuelethanol
and 80% unleaded gasoline.
For Iraq:
GUID-9E14C2 E6-2E9C-4731-980B-C45B899B9 77B
Use UNLEADED PREMIUMgasolinewithanoctane
rating ofatleast 91(RON) .
MR16DD Tengine model
GUID-BB E42002-27 CC-4D91-BE9 4-591204436EE9
Except forThailand:
GUID-9E14C2 E6-2E9C-4731-980B-C45B899B9 77B
Use UNLEADED PREMIUMgasolinewithanoctane
rating ofatleast 95(RON) .
If unleaded premiumgasolineisnot used, UNLEADED
REGULAR gasolinewithanoctane ratingofatleast 91
(RON) maybeused atslightly reduced performance.
However, formaximum vehicleperformance andthe
best driveability ,the use ofunleaded premiumgasoline
is recommended. For
Thailand:
GUID-9E14C2 E6-2E9C-4731-980B-C45B899B9 77B
Use UNLEADED gasolineorgasohol (uptoE10*) with
an octane ratingofatleast 95(RON) .
If unleaded gasolineorgasohol (uptoE10*) withan
octane ratingofatleast 95(RON) isnot used,
UNLEADED gasolinewithanoctane ratingofatleast
91 (RON) maybeused atslightly reduced perfor-
mance. However, formaximum vehicleperformance
and thebest driveability ,the use ofunleaded gasoline
or gasohol (uptoE10*) withanoctane ratingofatleast
95 (RON) isrecommended.
*: Gasohol isalcohol blended gasoline. Forexample,
ªE10º isamixture ofapproximately 10%fuelethanol
and 90% unleaded gasoline.
HR16DE enginemodel
GUID-25107F 2B-664D-46D9-94DC- C0E897950935
Except forThailand:
GUID-9E14C2 E6-2E9C-4731-980B-C45B899B9 77B
Use UNLEADED PREMIUMgasolinewithanoctane
rating ofatleast 95(RON) .
If unleaded premiumgasolineisnot used, UNLEADED
REGULAR gasolinewithanoctane ratingofatleast 91
(RON) maybeused atslightly reduced performance.
However, formaximum vehicleperformance andthe
best driveability ,the use ofunleaded premiumgasoline
is recommended.
For Thailand:
GUID-9E14C2 E6-2E9C-4731-980B-C45B899B9 77B
Use UNLEADED PREMIUMgasolineorgasohol (upto
E20*) withanoctane ratingofatleast 95(RON) .
If unleaded premiumgasolineisnot used, UNLEADED
REGULAR gasolinewithanoctane ratingofatleast 91
(RON) maybeused atslightly reduced performance.
However, formaximum vehicleperformance andthe
best driveability ,the use ofunleaded premiumgasoline
is recommended.
*: Gasohol isalcohol blended gasoline. Forexample, ªE20º
isamixture ofapproximately 20%fuelethanol
and 80% unleaded gasoline.
RECOMMENDED SAEVISCOSITY NUM-
BER
GUID-B6 9B25E9-F64 E-4D5C-BAA6-35926C1D 7140
MR16DD Tengine model
GUID-DD7633 83-95BD-4BCD-B3A1-3 32FAF901BF3
5W-30 ispreferable.
If 5W-30 isnot available, selecttheviscosity,
from thechart below, thatissuitable forthe
outside temperature
range.
STI0589
&RQGLWLRQ


> (GLW   0RGHO &$@
MRA8DE andHR16DE enginemodels
GUID-E56FD DBF-A4C2-4 697-AC94-8A BA1E238CE7
10W-30 ispreferable.
If 10W-30 isnot available, selecttheviscosity,
from thechart below, thatissuitable forthe
outside temperature range.
STI0589
AIR CONDITIONER SYSTEM REFRIGER-
ANT AND LUBRICANT
GUID-F5 0D0177-18 DA-4E61-88BE-04797457828A
The airconditioner systemofyour vehicle mustbe
charged withtherefrigerant HFC-134a (R-134a)and
the lubricant NISSANA/CSystem OilType S
(MRA8DE enginemodel) orType R(MR16DD Tand
HR16DE enginemodel) orequivalents. Useofany
other refrigerants orlubricants willcause severe
damage, andyoumay need toreplace yourvehicle's
entire airconditioner system.
The release ofrefrigerants intotheatmosphere is
prohibited inmany countries andregions. Therefrig-
erant HFC-134a (R-134a)inyour vehicle willnotharm
the Earth's ozonelayer.However, itmay contribute ina
small parttothe global warming effect.NISSAN
recommends thattherefrigerant beappropriately
recovered andrecycled. ContactaNISSAN dealer
when servicing theairconditioner system.
T echnical information
9-5
&RQGLWLRQ


> (GLW   0RGHO &$@
9-6
T echnical information
GUID-A 78EA9EA-3D B9-49F8-93FC-A8730 B890A74
Engine model MRA8DEMR16DDT HR16DE
T ype Gasoline,4-cycle,DOHC Gasoline,4-cycle,DOHC Gasoline,4-cycle,DOHC
Cylinder arrangement 4-cylinder,in-line 4-cylinder,in-line 4-cylinder,in-line
Bore 6Stroke mm(in) 79.7690.1 (3.138 63.547) 79.7681.1 (3.138 63.193) 78.0683.6 (3.071 63.291)
Displacement cm
3
(cu in) 1,798(109.71) 1,618(98.78) 1,598(97.51)
Idle speed atthe ªNº (Neutral) position rpm700‹50 650‹50650‹50
Ignition timing(B.T.D.C.) atthe ªNº (Neu-
tral) position degree
at
idle MT
:8‹28
CVT :8‹28 MT
:6‹28
CVT :8‹28 MT
:10‹28
CVT :9‹28
Spark plugs
Type StandardPLZKAR6A-11D*1
LZKAR6AP-11*2 DILKAR7C9HPLZKAR6A-11D*1
LZKAR6AP-11*2
Gap mm(in) 1.1(0.043) 0.9(0.035) 1.1(0.043)
Camshaft operation Timingchain Timingchain Timingchain
Maximum vehiclespeed(forGulf standard models)*3
CVT :km/h (MPH)
180(111) - 175(108)
MT :km/h (MPH)
- -187
(116)
*1: ForThailand
*2: Except forThailand
*3: GulfStandard requiresautomobile manufacturers toindicate themaximum vehiclespeedforapplicable models.Themaximum vehiclespeed,listedabove, isthe measured speedundercertain testingconditions.
The actual valuemaydiffer according tothe vehicle usageandroad andenvironmental conditions.NISSANrecommends youtoALWAY S observe postedspeedlimitsandnever drivetoofast forconditions.
ENGINE
&RQGLWLRQ


> (GLW   0RGHO &$@
9-8
T echnical information
GUID-A 3C259B5-3 957-48F9-A D1A-28F71CFE7919
When planning totravel inanother countryor
region, findoutwhether thefuel required foryour
vehicle isavailable inthat country orregion. Usinga
low octane ratedfuelmay cause engine damage.
Therefore, besure thattherequired fuelisavailable
wherever yougo.For additional information regarding
recommended fuel,seeearlier inthis section.
When transferring theregistration ofyour vehi-
cle toanother country, state,province ordistrict,
contact theappropriate authoritiestofind outthat the
vehicle complies withthelocal legal requirements. In
some cases, avehicle cannotmeetthelegal require-
ments, anditmay benecessary tomodify thevehicle to
meet locallawsandregulations. Inaddition, theremay
be possibilities thatavehicle cannotbeadapted in
certain areas.
The laws andregulations formotor vehicle emission
control andsafety standards varyaccording tothe
country ,state, province ordistrict; therefore, the
vehicle specification maydiffer.
When anyvehicles aretobe taken intoanother
country, state,province ordistrict, itsmodifica-
tion, transportation, registration,andanyother
expenses whichmayresult, aretheresponsi-
bility ofthe user. NISSAN isnot responsible for
any inconveniences thatmay result.
GUID-C345 1F67-29CF-4 696-AC8F-FF53FB6D9318
It is prohibited tocover, paint,weld,cut,drill, alter or
remove Vehicle Identification Number(VIN).
VEHICLE IDENTIFICA TIONPLATE
GUID-A8D4A3 3D-8E44-4B77-9564-66061CA3EC 29
JVT0042X
The plate isaffixed asshown.
Built dateplate (forAustralia andNew
Zealand)
GUID-16A4 323B-4417-4247-A430 -15F1B88D4FEA
Built dateisstamped onthe vehicle identification plate.
The built date means thecalendar monthandtheyear
in which thebody shellandpower trainsubassemblies
are conjoined andthevehicle isdriven ormoved from
the production line.
VEHICLE IDENTIFICA TIONNUMBER (VIN)
PLA TE(ifequipped)
GUID-3B7B2 4DD-84D3-4756-8386-8720807E 4FB9
STI0612
The vehicle identification numberplateisattached as
shown. Thisnumber isthe identification foryour vehicle
and isused inthe vehicle registration.
VEHICLE IDENTIFICA TIONNUMBER
(chassis number)
GUID-505 A7DA9-C3B F-4C75-AB40-5946E E343054
JVT0043X
The vehicle identification numberislocated asshown.
Remove thecover toaccess thenumber.
WHEN TRAVELLING OR
REGISTERING INANO THER
COUNTR Y VEHICLE
IDENTIFICA TION
&RQGLWLRQ

 
> (GLW   0RGHO &$@
ENGINE SERIALNUMBER
GUID-8C4 F3838-A43 3-4C32-8C BD-475661B 53BEE
STI0785
MRA8DE /HR16DE /MR16DDT engine
The engine serialnumber isstamped onthe engine as
shown.
CERTIFICA TIONLABEL (ifequipped)
GUID-8CD1 DEBF-7616-4 A6D-9195-9F3 C4ADA5D2 0
STI0441
TIRE PLACARD
GUID-D14 A8E63-463A- 4F44-9209-FCD6E928E5 F2
STI0720
The cold tirepressures areshown onthe tire placard
affixed tothe driver's sidecenter pillar.
AIR CONDITIONER SPECIFICATIONLABEL
GUID-4D0 37102-4D3 9-497F-B75D -28FF1A2 7ECEA
STI0739
GUID-1A84 4B35-7025-42E7-B48 F-CF34AF5074F4
Quality Grades: Allpassenger cartires must conform
to local safety requirements inaddition tothese
grades.
Quality gradescanbefound where applicable onthe
tire sidewall between treadshoulder andmaximum
section width.Forexample:
T readwear 200Traction AA Temperature A
TREADWEAR
GUID-87 CA7CF8-8 4FA-41DC-8 F1E-3C42A1 42B7F1
The treadwear gradeisacomparative ratingbased on
the wear rateofthe tire when tested undercontrolled
conditions onaspecified government testcourse. For
example, atire graded 150would wearoneand one-
half (11/2) times aswell onthe government courseas
a tire graded 100.Therelative performance oftires
depends upontheactual conditions oftheir use,
however, andmay depart significantly fromthenorm
due tovariations indriving habits,service practices
and differences inroad characteristics andclimate.
TRACTION AA,A ,B AND C
GUID-7E4 038D1-426 B-4B33-913E-7F708D05FE2C
The traction grades,fromhighest tolowest, areAA,A ,
B, and C.Those grades represent thetire's ability to
stop onwet pavement asmeasured undercontrolled
conditions onspecified government testsurfaces of
asphalt andconcrete. Atire marked Cmay have poor
traction performance.
WARNING:
The traction gradeassigned tothis tireisbased
on straight-ahead brakingtraction tests,and
does notinclude acceleration, cornering,hydro-
planing, orpeak traction characteristic s.
T echnical information
9-9
UNIFORM
TIREQUALITY GRADING
(if equipped)
&RQGLWLRQ


> (GLW   0RGHO &$@
10-2
Fluid
Brake fluid...
........................................................... ...8-13
Clutch fluid...
...................................................... .......8-14
Continuously Variable Transmission
(CVT) fluid...
........................................................... ...8-15
Engine coolant ...
......................................................... 8-7
Engine oil...
............................................ .......................8-9
Window washerfluid...
................................. 8-4,8-17
FM-AM radiowithCompact Disc(CD) player ...
.... 4-19
FM-AM radiowithcompact disc(CD) player
(with color display) ...
....................................... ..............4-22
Fog light switch ...
................................................. ..........2-19
Front seat,Front seatadjustment ...
............................. 1-2
Fuel Fuel information ...
................................................. ......9-4
Fuel octane rating...
................................................. ..9-4
Gauge ...
................................................. .......................2-7
Fuses ...
................................................................ ..............8-21
Fusible links...
....................................... ...........................8-21
G
Gauge ...
................................................. .............................2-6
Engine coolant temperature gauge...
.................... 2-7
Fuel gauge ...
...................................................... ..........2-7
T achometer ...
............................................ ...................2-6
T rip computer ...
................................................. ..........2-8
General maintenance ...
....................................... ............8-2
Glove box...
....................................... ...............................2-26
H
Hands-Free PhoneSystem, Bluetooth


> (GLW   0RGHO &$@
N
New vehicle break-in...
............................................ ........5-2
NISSAN Anti-Theft System (NATS) key...
.................. 3-2
O
Oil
Checking engineoillevel ...
...................................... 8-9
Engine oil...
............................................ .......................8-9
Operating precautions ...
............................................... 5-20
Outside airtemperature display...
................................ 2-8
Overheat, Ifyour vehicle overheats ...
.......................... 6-7
P
Panic alarm...
............................................ .......................3-12
Parking
Brake break-in...
....................................... ................5-23
Parking brakeoperation ...
..................................... 5-25
Phone, Bluetooth