power steering OLDSMOBILE SILHOUETTE 2003 User Guide

Part C: Periodic Maintenance
Inspections
Listed in this part are inspections and services which
should be performed at least twice a year (for instance,
each spring and fall).
You should let your dealer’s
service department or other qualified service center
do these
jobs. Make sure any necessary repairs
are completed at once.
Proper procedures to perform these services may be
found in a service manual. See
Service Publications
Ordering Information on page
7- IO.
Steering, Suspension and Front
Drive
Axle Boot and Seal Inspection
Inspect the front and rear suspension and steering
system for damaged, loose or missing parts, signs of
wear or lack of lubrication. Inspect the power steering
lines and hoses for proper hook-up, binding, leaks,
cracks, chafing, etc. Clean and then inspect the drive
axle boot seals for damage, tears or leakage. Replace
seals
if necessary.
Exhaust System Inspection
Inspect the complete exhaust system. Inspect the body
near the exhaust system. Look for broken, damaged,
missing or out-of-position parts as well as open seams,
holes, loose connections or other conditions which
could cause a heat build-up in the floor pan or could let
exhaust fumes into the vehicle. See
Engine Exhaust
on page
2-43.
Fuel System Inspection
Inspect the complete fuel system for damage or leaks.
Engine Cooling System Inspection
Inspect the hoses and have them replaced if they
are cracked, swollen or deteriorated. Inspect all pipes,
fittings and clamps; replace as needed. Clean the
outside of the radiator and air conditioning condenser.
To help ensure proper operation, a pressure test of
the cooling system and pressure cap is recommended
at least once a year.
6-1 4

Part D: Recommended Fluids
and Lubricants
Fluids and lubricants identified below by name, part
number or specification may be obtained from your
dealer.
Usage Engine oil with the American
Engine Oil Fluid/Lubricant
Petroleum Institute Certified for
Gasoline Engines starburst
symbol
of the proper viscosity.
To determine the preferred
viscosity for your vehicle’s engine, see
Engine Oil on
page
5- 14.
Engine Coolant 50/50 mixture of clean, drinkable
water and use only DEX-COOL
Coolant. See
Engine Coolant on
page
5-23.
Usage Fluid/Lubricant
Hydraulic Brake Delco Supreme
11 Brake Fluid
System or equivalent DOT-3 brake fluid.
Windshield GM Optikleen Washer Solvent
Washer Solvent or equivalent.
Power Steering GM Power Steering Fluid
System (GM Part
No. US. 1052884,
Automatic DEXRON-Ill Automatic
Transaxle Transmission Fluid.
Key Lock Multi-Purpose Lubricant,
Cylinders Superlube (GM Part No.
U.S.
in Canada 993294, or equivalent).
12346241, in Canada 10953474,
or equivalent).
Chassis Chassis Lubricant
Lubrication (GM Part
No. U.S. 12377985, in
Canada 88901 242, or equivalent)
or lubricant meeting requirements
of NLGl#2, Category LB or
GC-LB.
6-1 6

Accessory Inflator ........................................... 5-68
Accessory Power Outlets
................................. 3-24
Adding Washer Fluid
....................................... 5-38
Additional Program Information
........................... 7-8
Additives, Fuel
..................... ,... . ......... 5-6
Add-on Electrical Equipment
................. ... 5-96
Adjusting the Captain's Chairs
(Second Row)
............................................. 1-13
Adjusting the Speakers (Balance/Fade)
............................ 3-66, 3-73, 3-82
Air Bag Readiness Light
.......................................... 3-43
Air Bag Systems
............................................. 1-69
Servicing Your Air Bag-Equipped Vehicle
......... 1-76
What Will You See After an
How Does
ari Air Bag Restrain? .................... 1-74
What Makes an Air Bag Inflate?
.................... 1-74
Air Bag Inflates?
...................................... 1-74
When Should an Air Bag Inflate?
................... 1-73
Where Are the Air Bags?
.............................. 1-71
~II 'clttmIw/t-lller, Eflyirle ................................. 5- IS
All Overseas Locations ....... ........................ 7-4
A: . nr- ~ . . I~.ER
All-Wheel Drive ............................................... 5-86
All-Wheel Drive
............................................... 5-50
All-Wheel Drive Disable Warning Message .......... 3-59
All-Wheel-Drive (AWD) System
......................... 4-1 1
Aluminum Wheels ........................................... 5-92 AM
............................................................. 3-103
Antenna, Fixed Mast
...................................... 3-105
Anti-lock Brake System (ABS)
............................ 4-7
Anti-Lock Brake, System Warning Light
.............. 3-45
Appearance Care
............................................ 5-87
Care
of Safety Belts .................................... 5-90
Cleaning the Inside of Your Vehicle
................ 5-87
Cleaning the Outside of Your Vehicle
.............. 5-90
Finish Damage
............................................ 5-92
Chemical Paint Spotting
............................... 5-93
GM Vehicle Care/Appearance Materials
.......... 5-93
Sheet Metal Damage
................................... 5-92
Underbody Maintenance
............................... 5-93
Weatherstrips
.............................................. 5-90
Theft-Deterrent System
............. ......... 2-70
Arming and Disarming the Content
Arming Confirmation
.................... ............ 2-28
Arming with the Power Lock Switch
... ......... 2-27
Arming with the Remote Keyless Entry
Transmitter
................................................. 2-28
Arming with Your Key
...................................... 2-28
Audio Speakers
.............................................. 3-93
hdl0 System(s) ............................................. 3-63
Audio Systems
Audio Steering Wheel Controls
.................... 3-102
Care of Your Cassette Tape Player
............... 3-103
Care of Your CD and DVD Player
................ 3-104
Care
of Your CDs and DVDs ....................... 3-104
Fixed Mast Antenna
................. ... 3-105

Engine (cont.)
Coolant Temperature Warning Message
.......... 3-53
Cooling System Inspection
............................ 6-1 4
Engine Compartment Overview
.... ........... 5-12
Exhaust
..................................................... 2-43
Low Oil Level Message
................................ 3-55
Oil
............................................................. 5-14
Overheating
................................................ 5-26
Starting
...................................................... 2-34
Engine Coolant Level Check
............................. 6-10
Engine Oil Additives
......................... ....... 5-17
Engine Oil and Chassis Lubrication Scheduled Maintenance
................................. 6-5
Engine Oil Level Check
................................... 6-10
Engine Specifications
..................................... 5-1 04
Entering Programming Mode
............................ 2-63
Entertainment System
...................................... 3-91
Cleaning the Video Screen
.......................... 3-105
Cleaning Your DVD Player
.......................... 3-105
DVD Distortion
.......................................... 3-103
Entry Lighting
................................................. 3-18
Erasing HomeLink@ Buttons
.............................. 2-52
Exit Lighting
................................................... 3-19
Exiting Programming Mode
............................... 2-71
Express-Down Window
.................................... 2-25
Extender, Safety Belt
....................................... 1-44
Exterior Lamps
............................................... 3-1 4
F
FabricKarpet ................................................. 5-87
Engine Air Cleaner
...................................... 5-19
Filter
Finding
a PTY Station
..................... 3.67. 3.74. 3-83
Finding a Station
............................ 3-65, 3-72, 3-81
Finish Care
.................................................... 5-91
Finish Damage
............................................... 5-92
Fixed Mast Antenna
....................................... 3-105
Flash-to-Pass
................................................... 3-9
Flat Tire
........................................................ 5-69
Flat Tire, Changing
......................................... 5-70
Flip and Fold Rear Seats
.................................. 1-7
Fluid Automatic Transaxle
..................................... 5-20
Power Steering
........................................... 5-37
Windshield Washer
...................................... 5-38
FM
.............................................................. 3-103
Fog Lamps
.................................................... 3-16
Folding or Reclining the Seatbacks
............. 1-8, 1-14
Folding the Seatback
....................................... 1-18
Following Distance
.......................................... 4-41
Footnotes
........................................................ 6-5
Front Reading Lamps
...... ........................ 3-19
Front Seat Storage Net
................................ 2-55
Fuel
............................................................... 5-5
Additives
................. .......................... 5-6
California Fuel
....................................... 5-6

Fuel (cont.) Filling a Portable Fuel Container
..................... 5-9
Filling Your Tank
........................................... 5-7
Fuels in Foreign Countries
.............................. 5-7
Gage ......................................................... 3-51
Gasoline Octane
........................................... 5-5
Gasoline Specifications .................................. 5-5
System Inspection ....................................... 6-1 4
Fuses and Circuit Breakers
........................... 5-96
Windshield Wiper
......................................... 5-96
Low Warning Message
................................. 3-59
Fuses
G
Gage Engine Coolant Temperature
......................... 3-47
Fuel
.......................................................... 3-51
Speedometer
.............................................. 3-41
Garage Door Opener
....................................... 2-49
Gasoline Octane
........................................................ 5-5
Specifications ............................................... 5-5
Gate Operator and Canadian Programming ........ 2-52
Glass Surfaces
............................................... 5-89
Glove
Box ..................................................... 2-54
GM Mobility Program for Persons with
Disab!!!t!es 7-5 .. E ....................................................
Hatch Ajar Warning Message ............................ 3-58
Hazard Warning Flashers
................................... 3-6
Head Restraints
............................................... 1-6
Headlamp Wiring
............................................ 5-96
Headlamps
.................................................... 5-52
Bulb Replacement ....................................... 5-52
Front Turn Signal, Sidemarker and
Parking Lamps
......................................... 5-54
Halogen Bulbs
............................................ 5-52
Heated Seats
................................................... 1-4
Highway Hypnosis
........................................... 4-24
Hill and Mountain Roads
.................................. 4-24
Hitches
.............................................. ..... 4-39
HomeLink Transmitter, Programming
.............. 2-50
HomeLink@ Transmitter ................................ 2-49
Hood
Checking Things Under
................................ 5-10
Release ..................................................... 5-10
Horn
............................................................... 3-7
iiuw tile Sysierrl Yiurks ................................... 3-za ^^
How to Add Coolant to the Coolant
Recovery Tank
............................................ 5-31
How to Add Coolant to the Radiator
.................. 5-34
How to Add Fluid
............................................ 5-22
How
to Check ........................................ 5-20, 5-61
Headphones
................................................... 3-92
How
to Check Power Steering Fluid .................. 5-38
7

How to Use This Manual ................... .... ii
How to Wear Safety Belts Properly ............... 1-27
Hydroplaning
.................................................. 4-20
I
If No Steam Is Coming From
If Steam Is Coming From Your Engine ............... 5-27
If the Light Is Flashing ..................................... 3-49
If the Light Is On Steady ................................. 3-49
If You Are Stuck in Sand. Mud. Ice or Snow
....... 4-30
If You Do Decide To Pull A Trailer ..................... 4-37
Your
Engine
................................................ 5-28
If You’re Caught in a Blizzard ........................... 4-28
Ignition Positions
............................................. 2-32
Ignition Transaxle Lock Check
.......................... 6-13
Infants and Young Children, Restraints
............... 1-48
Inflation
- Tire Pressure ................................... 5-61
Inspection Brake System
............................................. 6-15
Engine Cooling System
................................ 6-14
Exhaust System
.......................................... 6-14
Fuel System
............................................... 6-14
Part C - Periodic Maintenance ....................... 6-14
Steering, Suspension and Front Drive Axle
Boot and Seal
..................................... 6-14 Inspection
(cont.)
Throttle System
........................................... 6-15
Transfer Care (Power Transfer Unit) and
Carrier Assembly-Differential
(Rear Drive Module) All-Wheel Drive
........... 6-15
Instrument Panel Cluster
..........................................
Overview ......................................
Switchbank ....................................
Instrument Panel Brightness ................
Instrument Panel Fuse Block ...............
Interior Lamps ...................................
Interior Lamps Control ........................
Interior Lamps Override ......................
Interior Plastic Components .................
....
.......... 3-40
........... 3-4
.......... 3-21
.......... 3-17
.......... 5-97
.......... 3-17
.......... 3-17
.......... 3-17
.......... 5-89
Jump Starting
......................... . 5-44
Key Lock Cylinders Service
................. .... .......... 6-11
Keyless Entry System
....................................... 2-5
Keys
............................................................... 2-3

Maintenance Schedule (cont.) Exhaust System Inspection
........................... 6-1 4
Fuel System Inspection
................................ 6-14
How This Section is Organized ....................... 6-3
Introduction
.................................................. 6-2
Maintenance Requirements
............................. 6-2
Part A
- Scheduled Maintenance Services ......... 6-4
Part B
- Owner Checks and Services ............. 6-10
Part
C - Periodic Maintenance Inspections ...... 6-1 4
Part D
- Recommended Fluids and
Lubricants
............................................... 6-1 6
Part E . Maintenance Record ........................ 6-18
Scheduled Maintenance
................................. 6-5
Steering, Suspension and Front Drive Axle
Boot and Seal Inspection
.......................... 6-14
Throttle System Inspection
............................ 6-1 5
Transfer Case (Power Transfer Unit) and
Carrier Assembly-Differential (Rear Drive
Module) All-Wheel Drive Inspection
............. 6-1 5
Using Your ................................................... 6-4
Your Vehicle and the Environment
................... 6-2
Maintenance When Trailer Towing
..................... 4-43
Making Turns
................................................. 4-41
Malfunction Indicator Light
................................ 3-47
Manual Seats
................................................... 1-2 Matching
Transmitter(s) to Your Vehicle
................. 2-7
Message
Memory Seat
................................. ......... 2-72
All-Wheel Drive Disable Warning
....... ..... 3-59
Center
...................................... ......... 3-52
Change Engine Oil
...................................... 3-56
Charging System Indicator
............................ 3-54
Door Ajar Warning
....................................... 3-57
Engine Coolant Temperature Warning
............. 3-53
Low Engine Oil Level ................................... 3-55
Low Fuel Warning
................................... 3-59
Low Oil Pressure
.................... ............. 3-54
PASS-Key@
Ill Security ............................. 3-58
Power Sliding Door Warning
......................... 3-56
Rear Hatch Ajar Warning
.............................. 3-58
Service Traction System Warning
................... 3-52
Traction Active
............................................ 3-53
Manual Rearview Mirror
................................ 2-45
Outside Convex Mirror
................................. 2-46
Outside Heated Mirrors
................................ 2-46
Outside Power Mirrors
.................................. 2-45
Islands/Countries (Except Puerto Rico and
US
. Virgin Islands) ........................................ 7-4
Mirrors
Mexico, Central
America and Caribbean
10

PASS-Key@ Ill Security Message ....................... 3-58
Plan Ahead When Possible
................................ 7-7
Playing a Cassette Tape
.................................. 3-76
Playing a Compact Disc
.................. 3-69, 3-78, 3-86
Playing a Specific Loaded
Compact Disc
............................................. 3-87
Playing the Radio
........................... 3-64, 3-71 , 3-80
Power
Programmable Modes
. ~ ~ ~ ~ ............................... 2-70
Accessory Outlets
..................... ... 3-24
Door Locks
.............................. ....... 2-10
Eight-Way Seats
....................... ..... 1-3
Electrical System
................... ... 5-96
Rear Quarter Windows
.......................... 2-26
Six-Way Seats
.............................................. 1-3
Sliding Door
................................................ 2-16
Sliding Door Warning Message
...................... 3-56
Steering Fluid
............................................. 5-37
Windows
......................................... .... 2-25
Power Steering
............................................... 4-12
Pretensioners, Safety Belt
................................ 1-44
Programmable Automatic Door Locks
................. 2-1 2
Primary
Radio Controls
.................................... 3-98
Programmable Modes
............. 2-63, 2-64, 2-65, 2-66,
Programming Mode 2-67, 2-69
Entering
..................................................... 2-63
Exiting
....................................................... 2-71
Programming the HomeLink Transmitter
............. 2-50
Questions and Answers About Safety Belts ......... 1-26
R
Radiator Pressure Cap .................................... 5-26
Radio Messages
..................................... 3-69, 3-76
Radios
.......................................................... 3-63
Care of Your Cassette Tape Player
............... 3-103
Care of Your CD and DVD Player
................ 3-104
Care of Your CDs and DVDs
....................... 3-104
Radio with Cassette and CD
......................... 3-71
Radio with CD
............................................ 3-64
Radio with Six-Disc CD
................................ 3-80
Rear Seat Audio
................................ 3-98, 3-100
Setting the Time
.......................................... 3-63
Theft-Deterrent
.......................................... 3-1 01
Understandinq Reception
............................ 3-1 03
RDS
Rear
Rear Rear
Rear
Rear
Rear
Rear
Rear u
Messages .............................. 3-68, 3-75, 3-85
Climate Control System
................... 3-32, 3-34
Hatch Ajar Warning Message
.................... 3-58
Reading Lamps
...................................... 3-20
Safety Belt Comfort Guides
...................... 1-42
Seat Audio
................................... 3-98, 3-100
Seat Operation
......................................... 1-7
Seat Outside Passenger Positions
............. 1-39
Seat Passengers, Safety Belts
.................. 1-39
12

Setting the Temperature ........................... 3.33. 3-36
Sheet Metal Damage
....................................... 5-92
Setting the Time
............................................. 3-63
Setting the Tone (BassTTreble)
.......... 3.66. 3.73. 3-82
Shifting Into Park (P)
....................................... 2-40
Shifting Out of Park ‘(P)
.......
Shoulder Belt Height Adjuster
Skidding
............................
Sliding Door
Power
............................
Sliding Door Delayed Locking .
Sliding Door Lock .................
..........
.........
.......
............
..........
..........
............... 2-42
............ 1-30
... 4-16
............... 2-16
............... 2-12
............... 2-14
Sliding Door Security Lock
............................... 2-15
Sliding Doors. Dual
......................................... 2-13
Some Other Rainy Weather Tips
....................... 4-20
Spare Tire Check
.............................. ...... 6-11
Special Fabric Cleaning Problems ... , .......... 5-88
Specifications, Capacities
............................... 5-103
Speedometer
.................................................. 3-41
Split Bench Seats
............................................. 1-8
Starter Switch Check
....................................... 6-12
Starting Your Engine
....................................... 2-34
Steering
in Emergencies .................................. 4-13
Steering, Suspension and Front Drive Axle
Boot and Seal Inspection
.............................. 6-14
Steering Tips
.................................................. 4-12
Steering Wheel Controls, Audio
....................... 3-102
Steering ........................................................ 4 12
Stereo RCA JX~S 3-3~ n nn ..........................................
Storage Areas ......................... ............ 2-54
Compact Overhead Console
... ........ 2-54
Convenience Center
..................................... 2-60
Convenience Net
......................................... 2-59
Cupholder(s)
............................................... 2-54
Glove Box
.................................................. 2-54
Luggage Carrier
.......................................... 2-56
Overhead Console
....................................... 2-55
Rear Storage Area
....................................... 2-58
Storing a Flat or Spare Tire and
Tools ............... 5-81
Storing the Spare Tire and Tools
....................... 5-82
Stowable Seat
................................................ 1-18
Stuck in Sand, Mud. Ice or Snow
...................... 4-30
Sun Visors
..................................................... 2-26
Switchbanks
................................................... 3-21
Overhead Console ....................................... 3-21
Switchbanks, Instrument Panel
.......................... 3-21
Front
Seat Storage Net
................................ 2-55
T
Taillamps
Turn Signal. Stoplamps and Back-up Lamps
...... 5-56
TCS Warning Light
.......................................... 3-46
Theft.Deterrent. Radio
.................................... 3-1 01
Theft-Deterrent Systems
................................... 2-27
Content Theft-Deterrent
................................ 2-27
PASS-Key@
II I ....................................... 2-29
PASS-Key@
Ill Operation .... .... .... 2-30
15

When to Check and Change ............................ 5-20
When to Check Power Steering Fluid
................ 5-38
When You Are Ready to Leave After Parking
on a Hill
..................................................... 4-43
Where to Put the Restraint
............................... 1-54
Why Safety Belts Work .................................... 1-23
Windshield, Backglass and Wiper Blades
........... 5-91
Windows ....................................................... 2-24
Power
........................................................ 2-25
Power Rear Quarter
..................................... 2-26
Windshield Washer
........................................... 3-9
Fluid
.......................................................... 5-38 Windshield
Washer Fluid Level Check
............ 6-10
Windshield Wiper
Blade Replacement
.................. ........ 5-58
Fuses
........................................................ 5-96
Windshield Wipers
............................................ 3-9
Winter Driving
................................................ 4-26
Wiper Blade Check
..................... ............ 6-11
Weight of the Trailer
........................................ 4-38
Your Vehicle and the Environment
....................... 6-2
18