gear OPEL COMBO E 2019.1 Service Manual

Vehicle care213Caution
When transporting the vehicle on
a train or on a recovery vehicle, the
mud flaps might be damaged.
Cold protection covers
In order to prevent the accumulation
of snow at the radiator cooling fan, it is recommended to install removable
protection covers.
The protection covers must be
professionally installed, consult a
workshop.
Caution
The protection covers must be removed when one of the
following conditions occur:
● The ambient temperature is above 10 °C.
● When the vehicle is towed.
● The vehicle is driven at speeds
above 120 km/h.
Vehicle storage
Storage for a long period of time If the vehicle is to be stored for several months:
● Wash and wax the vehicle.
● Have the wax in the engine compartment and underbody
checked.
● Clean and preserve the rubber seals.
● Fill up fuel tank completely.
● Change the engine oil.
● Drain the washer fluid reservoir.
● Check the coolant antifreeze and
corrosion protection.
● Adjust tyre pressure to the value specified for full load.
● Park the vehicle in a dry, well ventilated place. Engage first or
reverse gear or set selector lever
to P. Prevent the vehicle from
rolling.
● Do not apply the parking brake.● Open the bonnet, close all doors and lock the vehicle.
● Disconnect the clamp from the negative terminal of the vehicle
battery. Beware that all systems
are not functional, e.g. anti-theft
alarm system.
Putting back into operation When the vehicle is to be put back into
operation:
● Connect the clamp to the negative terminal of the vehicle
battery. Activate the electronics
of the power windows.
● Check tyre pressure.
● Fill up the washer fluid reservoir.
● Check the engine oil level.
● Check the coolant level.
● Fit the number plate if necessary.

236Vehicle careTemporary spare wheel
The use of tyre chains is not permitted
on the temporary spare wheel.
Tyre repair kit
Minor damage to the tyre tread can be repaired with the tyre repair kit.
Do not remove foreign bodies from
the tyres.
Tyre damage exceeding 4 mm or that
is at tyre's sidewall cannot be repaired with the tyre repair kit.9 Warning
Do not drive faster than 80 km/h.
Do not use for a lengthy period.
Steering and handling may be
affected.
In the case of a flat tyre:
Apply the parking brake and engage
first gear, reverse gear or P.
Open the cover of the footwell storage
3 75.
The tyre repair kit is located in the
stowage compartment underneath
the right front seat.
1. Remove the sealant bottle and the
compressor.
2. Pull speed limit label from sealant
bottle and place it in driver's
visible area.3. Remove the electrical connection cable and air hose from the
stowage compartments on the
underside of the compressor.

Vehicle care239Replace the used sealant bottle.
Dispose of the bottle as prescribed
by applicable laws.
The compressor and sealant can be
used from approx. -30 °C.
Wheel changing Make the following preparations and
observe the following information:
● Park the vehicle on a level, firm and non-skid surface. The front
wheels must be in the straight-
ahead position.
● If necessary, place a chock under
the wheel diagonally opposite the wheel to be changed.
● Apply the parking brake and engage first gear, reverse gear or
P .
● If the ground on which the vehicle
is standing is soft, a solid board
(max. 1 cm thick) should be
placed under the jack.
● Take heavy objects out of the vehicle before jacking up.
● No people or animals may be in the vehicle when it is jacked-up.● Never crawl under a jacked-upvehicle.
● Do not start the vehicle when it is
raised on the jack.
● Before screwing in the wheel bolts, clean them.9Warning
Do not grease wheel bolts.
Tightening torques
Caution
If the vehicle is equipped with alloy
wheels, tighten the wheel bolts
manually at least for the first five
turns.
There are two different types of
wheels with two different bolts and tightening torques.
Tightening torque for alloy wheels is
100 Nm.
Tightening torque for steel wheels is
115 Nm.
Use the correct wheel bolts for the respective wheels.
Jacking positions The jacking positions shown refer to
the use of lifting arms and accessory
jacks used for changing winter /
summer tyres.

Vehicle care241
3. Lift the spare wheel holder andunhook the catch.
Lower the spare wheel holder.
4. Remove the spare wheel.
5. Change the wheel.
6. Position the damaged wheel with the outside down in the spare
wheel holder.
7. Lift the spare wheel holder and engage in the catch. The open
side of the catch must point in the
direction of travel.
8. Close the spare wheel holder by turning the hexagon bolt
clockwise using the wheel
wrench.
9. Stow wheel wrench in the storage.
10. Close the tailgate or the rear doors.
Only mount one temporary spare
wheel. The permissible maximum
speed on the label on the temporary
spare wheel is only valid for the
factory-fitted tyre size.
Fitting the spare wheel
Make the following preparations and
observe the following information:
● Park the vehicle on a level, firm and non-skid surface. The front
wheels must be in the straight- ahead position.● If necessary, place a chock under
the wheel diagonally opposite the
wheel to be changed.
● Apply the parking brake and engage first gear, reverse gear or
P .
● Remove the spare wheel 3 240.
● Never change more than one wheel at once.
● Use the jack only to change wheels in case of puncture, not
for seasonal winter or summer
tyre change.
● The jack is maintenance-free.
● If the ground on which the vehicle
is standing is soft, a solid board
(max. 1 cm thick) should be
placed under the jack.
● Take heavy objects out of the vehicle before jacking up.
● No people or animals may be in the vehicle when it is jacked-up.
● Never crawl under a jacked-up vehicle.
● Do not start the vehicle when it is
raised on the jack.

277Climate control systems.............132
Clock............................................. 94
Colour Info Display .....................118
Control indicators........................ 102
Control of the vehicle .................145
Controls ........................................ 90
Convex shape .............................. 38
Coolant and antifreeze ...............255
Cornering lights .......................... 126
Cruise control ....................109, 170
Cupholders .................................. 71
Curtain airbag system .................. 63
D Danger, Warnings and Cautions ...4
Daytime running lights ...............126
Declaration of conformity ............268
DEF ............................................ 154
Deflation detection system .........108
Descent control system .....106, 166
Diesel exhaust fluid ....................154
Diesel fuel system bleeding .......219
Door open .................................. 110
Doors ................................ 30, 31, 32
Driver alert .................................. 203
Driver assistance systems ..........170
Driver Information Centre ...........110
Driving characteristics and towing tips .............................. 208
Driving hints ................................ 145E
Eco mode ................................... 160
Electric adjustment ......................38
Electrical system......................... 227
Electric parking brake. 105, 161, 162
Electric parking brake fault .........106
Electronic climate control system 136
Electronic driving programmes ..159
Electronic key system ...................23
Electronic Stability Control and Traction Control system ..107, 165
End-of-life vehicle recovery .......214
Engine compartment fuse box ...228
Engine coolant ........................... 216
Engine coolant temperature ......107
Engine coolant temperature gauge ..................................... 101
Engine data ............................... 262
Engine exhaust .......................... 153
Engine identification ...................258
Engine oil ................... 215, 255, 259
Engine oil level monitor ..............101
Engine oil pressure ....................108
Entry lighting .............................. 130
Event data recorders ..................272
Exhaust filter ....................... 107, 153
Exit lighting ................................ 130
Exterior care .............................. 247
Exterior light ............................... 109Exterior lighting ....................13, 123
Exterior mirrors ............................. 38
F
Fault ........................................... 160
First aid ......................................... 86
First aid kit ................................... 86
Fixed air vents ........................... 142
Folding front passenger seat ........49
Folding mirrors ............................. 38
Folding seats .......................... 52, 53
Footwell storage ........................... 75
Forward collision alert................. 181
Front airbag system .....................62
Front fog lights ...........109, 127, 222
Front passenger seat Table position ............................ 49
Front pedestrian protection ........185
Front seats.................................... 47 Front storage ................................ 72
Front turn lights .......................... 223
Fuel............................................. 205
Fuel for diesel engines ..............205
Fuel for petrol engines ...............205
Fuel gauge ................................. 101
Fuses ......................................... 227
G Gauges ......................................... 99
Gear shifting ............................... 106
General information ...................208