fuel OPEL MERIVA 2017 Service Manual

Vehicle care197Tyre pressure
Check the pressure of cold tyres at least every 14 days and before any
long journey. Do not forget the spare
wheel. This also applies to vehicles
with tyre pressure monitoring system.
Unscrew the valve cap.
Tyre pressure 3 235.
The tyre pressure information label
on the right door frame indicates the original equipment tyres and the
correspondent tyre pressures.
The tyre pressure data refers to cold
tyres. It applies to summer and winter tyres.
Always inflate the spare tyre to the
pressure specified for full load.
The ECO tyre pressure serves to
achieve the smallest amount of fuel
consumption possible.
Incorrect tyre pressures will impair
safety, vehicle handling, comfort and
fuel economy and will increase tyre
wear.
Tyre pressures differ depending on
various options. For the correct tyre
pressure value, follow the procedure
below:
1. Identify the engine identifier code.
Engine data 3 228.
2. Identify the respective tyre.
The tyre pressure tables show all
possible tyre combinations 3 235.
For the tyres approved for your
vehicle, refer to the EEC Certificate of Conformity provided with your vehicle
or other national registration
documents.
The driver is responsible for correct adjustment of tyre pressure.9 Warning
If the pressure is too low, this can
result in considerable tyre warm-
up and internal damage, leading to tread separation and even to tyre
blow-out at high speeds.
9 Warning
For specific tyres the
recommended tyre pressure as
shown in the tyre pressure table may exceed the maximum tyre
pressure as indicated on the tyre.
Never exceed the maximum tyre
pressure as indicated on the tyre.
If the tyre pressure must be reduced
or increased on a vehicle with tyre
pressure monitoring system, switch
off ignition.
Temperature dependency
The tyre pressure depends on the
temperature of the tyre. During
driving, tyre temperature and
pressure increase. Tyre pressure

218Vehicle careMoonroof
Never clean with solvents or abrasive agents, fuels, aggressive media (e.g.
paint cleaner, acetone-containing
solutions etc.), acidic or highly
alkaline media or abrasive pads. Do
not apply wax or polishing agents to
the middle part of the moonroof.
Wheels and tyres Do not use high-pressure jet
cleaners.
Clean rims with a pH-neutral wheel
cleaner.
Rims are painted and can be treated
with the same agents as the body.
Paintwork damage Rectify minor paintwork damage with
a touch-up pen before rust forms.
Have more extensive damage or rust areas repaired by a workshop.
Underbody
Some areas of the vehicle underbody
have a PVC undercoating while other critical areas have a durable
protective wax coating.After the underbody is washed, check
the underbody and have it waxed if
necessary.
Bitumen/rubber materials could
damage the PVC coating. Have
underbody work carried out by a
workshop.
Before and after winter, wash the
underbody and have the protective
wax coating checked.
Liquid gas system9 Danger
Liquid gas is heavier than air and
can collect in sink points.
Take care when performing work
at the underbody in a pit.
For painting work and when using a
drying booth at a temperature above
60 °C, the liquid gas tank must be
removed.
Do not make any modifications to the
liquid gas system.
Towing equipment
Do not clean the coupling ball bar with a steam-jet or high-pressure jet
cleaner.
Rear carrier system Clean the rear carrier system with a
steam-jet or high-pressure jet cleaner
at least once a year.
Operate the rear carrier system
periodically if not in regular use, in
particular during winter.
Interior care
Interior and upholstery Only clean the vehicle interior,
including the instrument panel fascia
and panelling, with a dry cloth or
interior cleaner.
Clean the leather upholstery with
clear water and a soft cloth. In case of
heavy soiling, use leather care.
The instrument cluster and the
displays should only be cleaned using
a soft damp cloth. If necessary use a
weak soap solution.

Service and maintenance221ConfirmationsConfirmation of service is recorded inthe Service and warranty booklet.
The date and mileage is completed
with the stamp and signature of the servicing workshop.
Make sure that the Service and
warranty booklet is completed
correctly as continuous proof of
service is essential if any warranty or goodwill claims are to be met, and is
also a benefit when selling the
vehicle.
Service interval with remaining
engine oil life duration
The service interval is based on
several parameters depending on
usage.
The service display lets you know
when to change the engine oil.
Service display 3 91.Recommended fluids,
lubricants and parts
Recommended fluids and lubricants
Only use products that meet the
recommended specifications.9 Warning
Operating materials are
hazardous and could be
poisonous. Handle with care. Pay
attention to information given on
the containers.
Engine oil
Engine oil is identified by its quality
and its viscosity. Quality is more
important than viscosity when
selecting which engine oil to use. The oil quality ensures e.g. engine
cleanliness, wear protection and oil
aging control, whereas viscosity
grade gives information on the oil's
thickness over a temperature range.
Dexos is the newest engine oil quality
that provides optimum protection for
gasoline and diesel engines. If it is
unavailable, engine oils of other listed qualities have to be used.
Recommendations for gasoline
engines are also valid for
Compressed Natural Gas (CNG),
Liquified Petroleum Gas (LPG) and
Ethanol (E85) fuelled engines.
Select the appropriate engine oil
based on its quality and on the
minimum ambient temperature
3 225.
Topping up engine oil
Engine oils of different manufacturers
and brands can be mixed as long as
they comply with the required engine
oil quality and viscosity.
Use of engine oil with only
ACEA A1/B1 or only A5/B5 quality is
prohibited, since it can cause long-
term engine damage under certain
operating conditions.
Select the appropriate engine oil
based on its quality and on the
minimum ambient temperature
3 225.

228Technical dataEngine dataEngine identifier codeB14XERB14NELB14NELB14NETSales designation1.41.41.4 LPG1.4Engineering codeB14XERB14NELB14NELB14NETPiston displacement [cm3
]1398136413641364Engine power [kW]748888103at rpm60004200-60004800-60004900-6000Torque [Nm]130175/200 2)175200/220 3)at rpm40001750-48001750-48001850-4900Fuel typePetrolPetrolLiquid gas/PetrolPetrolOctane rating RON 4)recommended95959595possible98989898possible91919191Additional fuel type––Liquid gas (LPG)–2)
With six-speed transmission.
3) With overboost function.
4) A country specific label at the fuel filler flap can supersede the engine specific requirement.

Technical data229Engine identifier codeB16DTCB16DTLB16DTHB16DTESales designation1.61.61.61.6Engineering codeB16DTLB16DTLB16DTHB16DTEPiston displacement [cm3
]1598159815981598Engine power [kW]708110081at rpm350035003500-40003500Torque [Nm]280300320300at rpm1500-17501750-200020001750-2000Fuel typeDieselDieselDieselDieselEngine identifier codeA13DTCA13DTEA17DTISales designation1.31.31.7Engineering codeA13DTCA13DTEA17DTIPiston displacement [cm 3
]124812481686Engine power [kW]557081at rpm400040003600

230Technical dataEngine identifier codeA13DTCA13DTEA17DTISales designation1.31.31.7Engineering codeA13DTCA13DTEA17DTITorque [Nm]180180280at rpm1750-25001750-35002300Fuel typeDieselDieselDieselPerformanceEngineB14XERB14NELB14NEL LPGB14NETMaximum speed [km/h]Manual transmission177188188196Automatic transmission–185–193EngineB16DTCB16DTLB16DTHB16DTEMaximum speed [km/h]Manual transmission174185197185Automatic transmission––––

234Technical dataCapacities
Engine oilEngineB14XERB14NELB14NEL LPGB14NETA13DTCA13DTEincluding Filter [l]4.04.04.04.03.53.5between MIN and MAX [l]1.01.01.01.01.01.0EngineB16DTCB16DTLB16DTHB16DTEA17DTIincluding Filter [l]5.05.05.05.05.4between MIN and MAX [l]1.01.01.01.01.0
Fuel tank
Petrol/diesel, refilling quantity [l]54LPG, refilling quantity [l]34

245Cigarette lighter ........................... 88
Climate control ............................. 16
Climate control, service ..............137
Climate control systems .............129
Clock............................................. 86
Code ........................................... 106
Collision damage repair ..............240
Control indicators.......................... 92
Control of the vehicle .................139
Controls ........................................ 82
Controls in steering wheel ............82
Convex shape .............................. 29
Coolant ....................................... 175
Coolant and antifreeze ...............221
Coolant temperature gauge ..........90
Coupling ball bar ........................168
Cruise control ....................100, 154
Cupholders .................................. 61
Curtain airbag system .................. 53
Curve lighting.............................. 123
D
Danger, Warnings and Cautions ...4
Dashboard .................................... 10
Daytime running light ..................121
Daytime running lights ...............123
Declaration of conformity ............238
Diesel fuel system bleeding .......179
Diesel particle filter ...............98, 145
Door open .................................. 100Doors............................................ 26
Driver assistance systems ..........154
Driver Information Centre ...........101
Driving characteristics and towing tips .............................. 167
Driving hints ................................ 139
E Electric adjustment ......................29
Electrical system......................... 189
Electric parking brake ...........97, 151
Electric parking brake fault ...........97
Electronic climate control system 132
Electronic driving programmes ..148
Electronic Stability Control.......... 153
Electronic Stability Control and Traction Control system ............98
Electronic Stability Control off....... 98
End-of-life vehicle recovery .......172
Engine compartment fuse box ...191
Engine coolant ........................... 175
Engine coolant temperature gauge ....................................... 90
Engine data ............................... 228
Engine exhaust .......................... 145
Engine identification ...................224
Engine oil ................... 174, 221, 225
Engine oil pressure ......................99
Entry lighting .............................. 127
Event data recorders ..................242Exhaust gases ............................ 145
Exit lighting ................................ 127
Exterior care .............................. 216
Exterior light ................................. 99
Exterior lighting ....................13, 120
Exterior mirrors ............................. 29
F
Fault ........................................... 148
First aid ......................................... 78
First aid kit ................................... 78
Fixed air vents ........................... 137
Flex-Fix system ............................ 64
Fog light ..................................... 100
Fog lights .................... 124, 125, 184
Folding mirrors ............................. 30
Folding tray .................................. 78
Front airbag system .....................52
Front fog lights ........................... 124
Front seats.................................... 37
Front storage ................................ 63
Front turn signal light ..................180
Front turn signal lights ...............184
Fuel............................................. 160
Fuel consumption - CO 2-
Emissions ............................... 165
Fuel for diesel engines ..............160
Fuel for liquid gas operation .......160
Fuel for petrol engines ...............160
Fuel gauge ................................... 90

246Fuel selector ................................ 90
Fuse box ..................................... 191
Fuses ......................................... 189
G Gauges ......................................... 89
General information ...................166
Glovebox ..................................... 61
Graphic-Info-Display, Colour- Info-Display ............................ 104
H Halogen headlights ....................180
Hand brake ......................... 150, 151
Hazard warning flashers ............124
Headlight flash ........................... 122
Headlight range adjustment ......122
Headlights .......................... 120, 122
Headlights when driving abroad 122
Head restraint adjustment .............8
Head restraints ............................ 35
Heated mirrors ............................. 30
Heated rear window ..................... 33
Heated steering wheel .................82
Heating ........................................ 41
Heating and ventilation system . 129
High beam ......................... 100, 122
Hill start assist ........................... 152
Horn ....................................... 14, 83I
Identification plate .....................224
Ignition switch positions .............140
Immobiliser ............................ 29, 99
Indicators ...................................... 89
Information displays.................... 101
Instrument cluster ........................89
Instrument panel fuse box .........193
Instrument panel illumination .....189
Instrument panel illumination control .................................... 126
Instrument panel overview ........... 10
Interior care ............................... 218
Interior lighting ............................ 126
Interior lights ...................... 126, 189
Interior mirrors .............................. 30
Interruption of power supply ......148
Introduction .................................... 3
ISOFIX child restraint systems ....60
J
Jump starting ............................. 213
K Keys ............................................. 20
Keys, locks ................................... 20
Keys, memorised settings ............22
L Lashing eyes ............................... 76
Light covers, misted.................... 125Lighting features .........................127
Light switch ................................ 120
Load compartment ................27, 73
Load compartment cover .............74
Load compartment fuse box ......194
Loading information .....................79
Low fuel ....................................... 99
M Malfunction indicator light ............96
Manual anti-dazzle ......................30
Manual mode ............................. 148
Manual transmission .................. 149
Manual windows ..........................31
Memorised settings ......................22
Midlevel-Display ......................... 101
Mirror adjustment ........................... 8
Misted light covers .....................125
Moonroof ..................................... 34
N New vehicle running-in ..............140
Number plate light .....................188
O
Object detection systems ...........156
Octane rating .............................. 228
Odometer ..................................... 89
Oil ............................................... 174
Oil, engine .......................... 221, 225
Oil pressure .................................. 99

247OnStar........................................ 116
Operate pedal ............................... 96
Outside temperature ....................85
Overrun cut-off ........................... 142
P
Parking ................................ 18, 144
Parking assist ............................ 156
Parking brake ............................ 151
Parking lights ............................. 125
Particulate filter ........................... 145
Performance .............................. 230
Performing work ........................173
Personalisation ........................... 112
Pollen filter ................................. 137
Power outlets ............................... 87
Power steering fluid ....................176
Power windows ............................ 31
Preheating ................................... 98
Puncture ..................................... 207
Q
Quickheat ................................... 136
R Radio Frequency Identification (RFID) ..................................... 243
Radio remote control ...................21
Reading lights ............................ 127
Rear carrier system ......................64
Rear doors ................................... 26Rear floor storage cover ..............75
Rear fog light ............................. 100
Rear fog lights ........................... 125
Rear seats .................................... 42
Rear storage ................................. 74
Rear view camera ...................... 158
Rear window wiper/washer .......... 85 Recommended fluids and lubricants ........................ 221, 225
Reduced engine power ................99
Refuelling ................................... 162
Remote control ............................. 21
Retained power off .....................140
Reversing lights .........................125
Ride control systems ..................153
Roof .............................................. 34
Roof load ...................................... 79
Roof rack ..................................... 79
S Safety belts ................................... 45
Safety net .................................... 76
Seat adjustment ....................... 6, 38
Seat belt ........................................ 8
Seat belt reminder .......................95
Seat belts ..................................... 45
Seat heating ................................. 41
Seat position ................................ 37
Selector lever ............................. 147
Service ............................... 137, 220Service display ............................ 91
Service information ....................220
Service vehicle soon .................... 96
Side airbag system ......................52
Sidelights .................................... 120
Side turn signal lights ................188
Software acknowledgement .......240
Spare wheel ............................... 210
Speedometer ............................... 89
Starting and operating ................140
Starting off ................................... 17
Starting the engine ....................141
Steering ...................................... 140
Steering wheel adjustment ......9, 82
Steering wheel controls ...............82
Steering wheel, heated .................82
Stop-start system........................ 142
Storage ......................................... 61
Storage compartments .................61
Sunvisor lights ........................... 127
Sun visors .................................... 33
Symbols ......................................... 4
T
Tachometer ................................. 89
Tailgate ......................................... 27
Tail lights ................................... 185
Technical data ............................ 228
Three-point seat belt .................... 46
Tools .......................................... 195