PEUGEOT 1007 2005 Owners Manual

160 -Practical information
01-10-2005
161
-
01-10-2005
Fuse N° Rating
Functions
1 10 A Pre-heat unit (Diesel) - Water in diesel sensor (Diesel) - Reversing l
ight -
"2 Tronic" gearbox control unit.
2 15 A Fuel pump.
3 10 A ABS/ESP control unit.
4 10 A Injection and power steering control units - Brake and clutch swi
tches -
"2 Tronic" gearbox relay - Additional heating unit (Diesel) -
Engine coolant level detector (Diesel).
5 - Not used.
6 15 A Front fog lamps.
7 - Not used.
8 20 A Fan assembly relay - Injection control unit.
9 15 A Left dipped headlamp.
Practical information

162 -Practical information
01-10-2005
163
-
01-10-2005
Fuse N° Rating
Functions
10 15 A Right dipped headlamp.
11 10 A Left main beam headlamp.
12 10 A Right main beam headlamp.
13 15 A Horn.
14 10 A Front and rear wash-wipe pumps.
15 30 A Ignition coil (petrol) - Solenoid valves - Purge canister (petrol) - O
xygen sensors (petrol) -
Injectors (petrol) - Air low sensor (Diesel) - Injection pump (Diesel) -
Diesel high pressure regulation (Diesel).
16 30 A Air pump relay - Diesel heater (Diesel).
17 30 A Windscreen wipers.
18 40 A Air blowers.

158 -Practical information
01-10-2005
159
-
01-10-2005
CHANGING A FUSE
The fuse boxes are located under the
fascia on the left-hand side (in the
glove box) and in the engine com-
partment next to the battery.
Correct
Removing and itting a fuse
Before changing a fuse you must ind
out the cause of the fault and have it
put right. The fuse numbers are indi-
cated on the fuse box.
F Use the pliers A.
Incorrect
Pliers A * The maxi fuses provide
additional protection for
the electrical systems. All
work must be carried out
by a PEUGEOT dealer.
Fascia fuse box
F Open the glove box, then tilt the
cover to open it.
F Turn the lever a quarter of a turn,
then push and tilt the box to gain
access to the fuses.
The pliers A and the spare fuses are
ixed on the inside of the cover.
Fuse N° Rating FunctionsFH1* 40 A Left "Sesame" door.
FH2* 40 A Right "Sesame" door.
FH3* - Not used.
FH4* 20 A Audio ampliier.
FH5* - Not used.
Always replace a faulty
fuse with one of the same
rating.

158 -Practical information
01-10-2005
159
-
01-10-2005
Fuse N° Rating
Functions
1 15 A Diagnostic socket supply - Motorised strikers - "Sesame" door switches - Steerin
g wheel
controls.
4 20 A Clock - Multifunction display - Audio equipment - Audio/telepho ne - Alarm unit.
5 15 A Alarm siren.
6 10 A Diagnostic socket - Steering wheel angle sensor - Seat belt buckle s control unit.
7 15 A Alarm unit - Rain/brightness sensor.
9 30 A Towbar socket.
10 40 A Rear screen and exterior mirrors demisting.
11 15 A Rear wiper.
12 30 A Electric windows - Sunroof.
14 10 A Engine fuse box - Steering wheel controls - Air bags and pre-tensio ners control unit.
15 15 A Instrument panel - Multifunction display - Audio equipment - Aud
io/telephone -
CD changer - Air conditioning - Parking assistance - "Sesame" doors.
16 30 A Central locking - Deadlocking.
20 10 A Right brake light.
21 15 A Left brake light - Third brake light.
22 20 A Courtesy light - Map reading lights - Glove box light - Lighte
r - Electric exterior mirrors -
Factory-itted equipment for audio equipment - Number plate lig hts.
SH - PARC shunt.
Practical information

162 -Practical information
01-10-2005
163
-
01-10-2005
CHANGING A WINDSCREEN
WIPER BLADE
Placing the wiper blades in the
special position
F
Less than a minute after switching
off the ignition, operate the wipers
stalk to position the wiper blades
in the centre of the windscreen.
Changing a front wiper blade
F Lift the wiper arm.
F Unclip the blade and remove it.
F Fit the new blade.
F Push back the wiper arm.
Note: the shortest blade is itted on
the right-hand wiper arm.
To return the windscreen wipers
to their normal position, switch on
the ignition and operate the wipers
stalk.
Changing the rear wiper blade
F Lift the wiper arm.
F Unclip the blade and remove it.
F Fit the new blade.
F Push back the wiper arm.
ECONOMY MODE FUNCTION
After the engine has stopped, with
the key in the accessories position,
certain functions (doors, windscreen
wipers, electric windows, courtesy
lights, audio equipment, etc.) can only
be used for a cumulative duration of
thirty minutes, to prevent discharging
of the battery.
Once the thirty minutes are over, a
message informing you of the switch
to economy mode appears on the
multifunction display and the active
functions are put on standby.
To resume the use of these functions
immediately, start the engine and let
it run for a few seconds.
A lat battery will prevent
the engine from starting.
FITTING/REMOVING
THE MAT*
When removing the mat on the driv-
er's side, push the seat as far back
as possible and remove the ixings.
When reitting, position the mat cor-
rectly on the pins and clip the ixings.
Check that the mat is secured cor-
rectly.
To prevent the mat from becoming
caught under the pedals:
- only use mats suited to the ixings already present in the vehicle. It is
imperative that these ixings are
used.
- never it one mat on top of another.
* According to version.
Practical information

164 -Practical information
01-10-2005
165
-
01-10-2005
RUNNING OUT OF FUEL
(DIESEL)
If you should run out of fuel, it is
necessary to re-prime the circuit:
- ill the fuel tank with at least ive
litres of diesel,
- squeeze and release the manual re-priming pump, under the bonnet
under the protective cover, until fuel
appears in the transparent pipe,
- operate the starter until the engine starts.
BATTERY
To charge the battery using
a battery charger:
- Disconnect the battery,
- Follow the instructions for use given by the battery charger manu-
facturer,
- Reconnect starting with the nega- tive (-) terminal,
- Check that the terminals and con- nectors are clean. If they are cov-
ered with sulphate (white or greenish
deposit), disconnect them and clean
them. The batteries contain harm-
ful substances such as sul-
phuric acid and lead. They
must be disposed of in ac-
cordance with regulations and must
never be discarded with household
waste.
Take used remote control and vehi-
cle batteries to a special collection
point.
To start the vehicle from
another battery:
- Connect the red cable to the posi- tive (+) terminals of the two batter-
ies,
- Connect one end of the green or black cable to the negative (-) ter-
minal of the slave battery B,
- Connect the other end of the green or black cable to an earth point C
on the broken down vehicle as far
as possible from the battery,
- Operate the starter, let the engine run,
- Wait for the engine to return to idle, then disconnect the cables.
Before disconnecting the
battery, you must wait for
2 minutes after switching
off the ignition.
Never disconnect a terminal when
the engine is running.
Never charge a battery without irst
disconnecting the terminals.
Close the windows, the sunroof and
the doors before disconnecting the
battery. If they do not operate normally
following reconnection of the battery,
they must be reinitialised (see sections
"Sesame doors" and "Sunroof"). After every reconnection of the bat-
tery, switch on the ignition and wait
1 minute before starting to allow the
electronic systems to be initialised. If
slight dificulties are experienced af-
ter this, please contact a PEUGEOT
dealer.
A. Flat battery
B. Slave battery
C. Metal point (earth) on the
broken down vehicle
It is advisable to disconnect
the battery if the vehicle is
not to be used for a period
of more than one month.

164 -Practical information
01-10-2005
165
-
01-10-2005
TOWING YOUR VEHICLE
Without lifting
(4 wheels on the road)
You should always use a towbar.
The removable towing eye is stored
in the tool case, located in the left
boot trim. From the rear:
F
Unclip the side of the cover using
the lat part of the towing eye,
F Screw in the towing eye until it
locks.
When towing with the en-
gine switched off, there is
no braking assistance.
Special features of the
"2 Tronic" gearbox
When towing with four wheels on the
ground, the following rules must be
obeyed:
- gear lever in position N,
- tow the vehicle at less than 30 mph (50 km/h) over a maximum dis-
tance of 30 miles (50 km),
- do not add oil to the gearbox.
From the front:
F Unclip the bottom of the cover,
using the lat part of the towing
eye.
F Screw in the towing eye until it
locks.
Lifting
(2 wheels only on the road)
It is preferable to raise the vehicle by
the wheels.
Never use the radiator crossmember.
Practical information

166 -Practical information
01-10-2005
167
-
01-10-2005
TOWING A TRAILER,
CARAVAN, BOAT, ETC.
Only use original PEUGEOT tow
bars that have been tested and
approved from the design stage of
your vehicle.
The tow bar must be itted by a
PEUGEOT dealer.
Your vehicle is primarily designed
for transporting people and luggage
but it may also be used for towing a
trailer.
Driving with a trailer subjects the tow-
ing vehicle to more signiicant stress
and its driver must be particularly
careful.
Air density decreases with altitude,
thus reducing engine performance.
The maximum towing load must be re-
duced by 10 % for every 1 000 metres
of altitude. Cooling:
Towing a trailer on a slope
increases the temperature of the
coolant.
As the fan is electrically controlled,
its cooling capacity is not dependent
on the engine speed.
On the contrary, use a high gear to
lower the engine speed, and reduce
your speed.
The maximum towing speed on a
long slope depends on the gradient
and the outside temperature.
For vehicles itted with a direct injec-
tion petrol engine, after towing or
driving at high speed for a long pe-
riod of time, the fan may operate for
approximately 6 minutes.
In all cases, pay attention to the cool-
ant temperature.
In certain cases of particularly arduous
use (towing of the maximum load on
a steep slope when the temperature is
high), switching off the air conditioning
permits the recovery of engine power
and, therefore, an increase in the tow-
ing capacity.
If the warning light comes on, stop
the vehicle and switch off the engine
as soon as possible.
FITTING ROOF BARS
When itting transverse or longitudinal
roof bars, use the accessories recom-
mended by PEUGEOT and follow the
manufacturer's itting instructions.
For further information, contact a
PEUGEOT dealer.
Please refer to national legislation
in order to comply with the regula-
tions concerning the transportation
of objects which are longer than the
vehicle.
Driving advice
Distribution of loads: Distribute the
load in the trailer so that the heaviest
items are as close as possible to the
axle and the nose weight approach-
es the maximum permitted without
exceeding it. Tyres:
Check the tyre pressures of
the towing vehicle and the trailer,
observing the recommended pres-
sures.
Brakes: Towing increases the braking
distance.
Lights: Check the electrical signal-
ling on the trailer.
Side wind: Take into acount the
increased sensitivity to side wind.

166 -Practical information
01-10-2005
167
-
01-10-2005
ACCESSORIES FOR YOUR
1007
A wide range of accessories recom-
mended by PEUGEOT and original
parts are offered by the Network.
They all beneit from PEUGEOT's
recommendation.
These accessories and parts, having
been tested and approved for reli-
ability and safety, are all adapted to
your PEUGEOT vehicle.
This product range offered by
PEUGEOT Accessories is structured
around 5 categories: PROTECTION -
TOURING - IN-CAR TECHNOLOGY -
STYLING - UNIVERSAL.
The itting of electrical
equipment or accessories
which are not recom-
mended by PEUGEOT may
result in a failure of your vehicle's
electronic system.
Please note this speciic warning.
You are advised to contact a repre-
sentative of the Marque to be shown
the range of recommended equip-
ment and accessories.
"Protection":
anti-theft
alarm, engraved windows,
wheel anti-theft devices,
stolen vehicle identiication
system*, irst aid kit, warn-
ing triangle, high visibility
safety jacket, fog lamps kit,
snow chains, rear parking
assistance. "Touring":
armrest, seat
covers, storage under the
rear shelf, mats, boot tray,
sun blinds.
For leisure pursuits: roof
bars, transportation acces-
sories (bicycle carrier, ski
carrier), roof box, child seats and
booster cushions, audio/telephone
console, side blinds, cool box.
Trailer towbar which must be itted by
the PEUGEOT Network.
"In-Car Technology": tele-
phones, hands-free kits,
satellite navigation systems,
CD changer, DVD player,
multimedia, audio equip-
ment, speakers.
"Styling": alloy wheels,
wheel trims, spoiler, styl-
ing strips, door spoilers, sill
protectors, aluminium ped-
als, aluminium footrest, rear
silencer, exhaust tail pipe. "Universal":
windscreen
wash luid, interior and ex-
terior cleaning and mainte-
nance products.
You can obtain other
"Cameleo" customising kits
from PEUGEOT dealers.
You will be offered either a
complete kit, like the original
kit, or a partial kit consisting
of the vent trims only.
Should you need to change one or
more elements of the Cameleo kit of
your vehicle, due to damage..., you
will be offered replacement elements
from the exchange kits available at
that time.
* According to version or country
Note
To prevent jamming under the pedals:
- ensure that the mat is positioned
and secured correctly,
- never it one mat on top of another.
Practical information

168 -Technical data
01-10-2005
169
-Technical data
01-10-2005
ENGINES AND GEARBOXES
* Draining by gravity with oil iller cap open.
MODELS:
Model codes KMKFVB
KMKFVC
KMKFVB/P
KMKFVC/P
KMKFUCKMNFUC/PIF
KMNFUC/P KM8HZB
KM8HZC
ENGINES 1.4 litre
(75 bhp) 1.4 litre 16V
(90 bhp) 1.6 litre 16V
(110 bhp) 1.4 litre Turbo
HDI (70 bhp)
Cubic capacity (cm
3) 1 360 1 360 1 587 1 398
Bore x stroke (mm) 75 x 77 75 x 77 78.5 x 82 73.7 x 82
EU standard maximum power (kW) 54 65 80 50
Maximum power engine speed (rpm) 5 400 5 500 5 800 4 000
EU standard maximum torque (Nm) 118 133 147 160
Maximum torque engine speed (rpm) 3 400 3 400 4 000 2 000
Fuel Unleaded Unleaded Unleaded Diesel
Catalytic converter Yes Yes Yes Yes
Particle emission ilter No
Gearboxes Manual
(5-speed) "2 Tronic"
(5-speed) Manual
(5-speed) "2 Tronic"
(5-speed) Manual
(5-speed)
Oil capacities (in litres)
Engine (with cartridge replacement) 3.15* 3.15* 3.15* 3.35* 3.8*
Gearbox-Final drive 2 - 2 - 1.9