engine PEUGEOT 1007 DAG 2008 Owner's Guide

7
110
If there is an operating fault,
when reverse gear is enga-
ged, the service warning
light comes on, accompa-
nied by an audible signal
(short bleep) and a message
on the multifunction display.
In bad or wintry weather, ensure that
the sensors are not covered with
mud, frost or snow.
Deactivation
With the engine running, press button A
to deactivate the system permanently.
The indicator light on the button comes
on.
The system will be deactivated
automatically when towing a trailer or
when a bicycle carrier is fi tted (vehicle
fi tted with a towbar or bicycle carrier
recommended by PEUGEOT ).
Reactivation
Press button A again to reactivate
the system. The indicator light on the
button is switched off.

8
112

From outside: lift the catch A and
raise the bonnet. Bonnet strut
Secure the strut to hold the bonnet
open.
Before closing the bonnet, replace
the strut in its housing.
To close
Lower the bonnet and release it at
the end of its travel. Check that the
bonnet is properly locked.
OPENING THE BONNET

From inside: pull the handle on the
left-hand side under the fascia.
RUNNING OUT OF FUEL (DIESEL)
If your vehicle is fi tted with an HDI
engine, the fuel circuit must be rep-
rimed if you run out of fuel (refer to
the corresponding graphic).
This system consists of a repriming
pump and a transparent pipe.
1.4 litre Turbo HDI engine

 Open the bonnet.

 Fill the fuel tank with at least fi ve
litres of diesel.

 Squeeze and release the rep-
riming pump until fuel appears in
the transparent pipe.

 Operate the starter until the en-
gine starts.

 Close the bonnet.
1.6 litre Turbo HDI 16V engine

 Open the bonnet.

 Fill the fuel tank with at least
fi ve litres of diesel.

 Unclip the style cover to gain
access to the repriming pump.

 Squeeze and release the rep-
riming pump until fuel appears
in the transparent pipe with the
green connector.

 Operate the starter until the
engine starts.

 Put the style cover back in posi-
tion and clip it in place.

 Close the bonnet.
Opening the bonnet may
cause serious injuries,
please observe the following
recommendations:
- protect your hands and clothing,
- always allow the engine to cool before opening the bonnet,
- place the strut in its housing on the wing correctly,
- check that the bonnet is fi rmly secured in the open position,
- be aware of gusts of wind as they could cause the bonnet to
close suddenly.

8
113
1.4 LITRE AND 1.6 LITRE16V PETROL ENGINES

1. Coolant reservoir.

2. Windscreen/headlamp wash
reservoir.

3. Passenger compartment fi lter.

4. Brake fl uid reservoir.

5. Fuse box.

6. Battery.

7. Air fi lter.

8. Dipstick.

9. Engine oil fi ller cap.

8
114
1.4 LITRE HDI AND 1.6 LITRE HDI PEF TURBO DIESEL ENGINES

1. Coolant reservoir.

2. Windscreen/headlamp wash
reservoir.

3. Passenger compartment fi lter.

4. Priming pump.

5. Air fi lter.

6. Brake fl uid reservoir.

7. Fuse box.

8. Battery.

9. Dipstick.

10. Engine oil fi ller cap.

8
115

CHECKING THE LEVELS
There are two marks on
the dipstick:

A = maximum
Never fi ll past this mark.

B = minimum
Dipstick
Oil change
According to the information given in
the servicing booklet. Changing the brake fluid
The brake fl uid must be
changed at the intervals
stated, according to the
manufacturer's servicing
schedule.
Use fl uids recommended by the man-
ufacturer, which fulfi l DOT4 standards. Windscreen and headlamp
wash level
For best quality cleaning and
for your safety, we would ad-
vise that you use products
recommended by PEUGEOT .
When the level is low, this is indicated
by an audible signal and a message
on the multifunction display.
Viscosity selection
In all cases, the oil selected must
meet the manufacturer's require-
ments.
Cooling system
Use the fl uid recommended by the
manufacturer.
When the engine is warm, the tem-
perature of the coolant is controlled
by the engine fan. As this fan can ope
rate with the ignition key removed and
because the cooling system is pres-
surised, wait for at least one hour after
the engine has stopped before carry-
ing out any work.
Slacken the cap by two turns to re-
lease the pressure to prevent any
risk of scalding. When the pressure
has dropped, remove the cap and
top up the level. Diesel additive level (Diesel
with particle emission filter)
Lighting of the service warning light,
accompanied by a message and an
audible signal, indicates that the die-
sel additive level is low.
This additive must be topped up.
Contact a PEUGEOT dealer as soon
as possible.
To maintain the reliability of
engines and emission control
systems, the use of additives
in engine oil is prohibited. Used oil
Avoid prolonged contact of used oil
with the skin.
Brake fl uid is harmful to health and
very corrosive.

Note
: the coolant does not need to
be changed.
The level must always be
above the MIN mark and
close to the MAX mark. Do not dispose of used oil,
brake fl uid or coolant into
drains or into the ground.
Oil level
Check the level regularly
and top up between chang-
es. The maximum consump-
tion is 0.5 l per 600 miles
(1 000 km).
Check the level with the vehicle level,
engine cold, using the oil level gauge
on the instrument panel or the dip-
stick.

8
116
CHECKS
Handbrake Where the handbrake travel
is too great or there is a re-
duction in the performance
of the system, the hand-
brake should be adjusted,
even between services.
Have the system checked by a PEUGEOT
dealer.
Air filter and passenger compartment filter
Particle emission filter (Diesel)
It is imperative that maintenance of
the particle emission fi lter is carried
out by a PEUGEOT dealer in accord-
ance with the manufacturer's servicing
schedule.
Brake pads
Brake pad wear depends
on the style of driving, in
particular for vehicles which
are used in town, over short
distances.
Brake disc/drum wear status
For any information relating to the
wear of the surfaces of the discs and
drums, contact a PEUGEOT dealer. Oil filter
Change the fi lter regularly, in
accordance with the servic-
ing schedule.
It may be necessary to
check the thickness of the
pads, even between services.
Unless there is a leak in the circuit, a drop in the brake fl uid level
indicates that the brake pads are
worn.
At the start of winter, have
your battery checked by a
PEUGEOT dealer.
Refer to the servicing book-
let for information on the
replacement interval for
these components.
Depending on the environ-
ment (dusty atmosphere...) and the
use of the vehicle (urban driving...),

change them twice as often, if ne
cessary (refer to the "Engines" para-
graph).
A clogged passenger compartment
fi lter may have an adverse effect on
the performance of the air condition-
ing system and produce unpleasant
odours.
Following prolonged opera-
tion of the vehicle at very
low speed or at idle, you
may, in exceptional circum-
stances, notice steam coming from
the exhaust during acceleration. This
has no effect on the performance of
the vehicle or on the environment.
Battery
Manual gearboxThis does not require an
oil change. Have the level
checked in accordance with
the manufacturer's servicing
schedule.
Only use products recom-
mended by PEUGEOT or
products of equivalent qual-
ity and characteristics.
To ensure best performance from
components as important as the
braking system, PEUGEOT selects
and offers quite specifi c products.
To prevent damage to the electri-
cal units, high pressure washing of
the engine compartment is strictly
prohibited .
To check the main levels
and certain components,
in accordance with the
manufacturer's servicing
schedule, refer to the pages of the
servicing booklet which correspond
to your vehicle's engine.

9
123
CHANGING A FUSE
The fuse boxes are located under the
fascia on the left-hand side and in the
engine compartment next to the bat-
tery.
Correct
Removing and fitting a fuse
Before changing a fuse you must fi nd
out the cause of the fault and have it
put right. The fuse numbers are indi-
cated on the fuse box.

Incorrect * The maxi fuses provide ad-
ditional protection for the
electrical systems. All work
must be carried out by a
PEUGEOT dealer.

Always replace a faulty
fuse with one of the same
rating. Fascia fuse box

 Turn the screw a quarter of a turn,
then tilt the cover to open it.

 Turn the lever a quarter of a turn,
then push and tilt the box to gain
access to the fuses.
RatingFunctions
FH1*-Not used.
FH2*40 ATrailer Fuse Box.
FH3*20 AHeated seats.
FH4*20 AAudio amplifi er.
FH5*5 A"Sesame" doors control unit.

9
123
CHANGING A FUSE
The fuse boxes are located under the
fascia on the left-hand side and in the
engine compartment next to the bat-
tery.
Correct
Removing and fitting a fuse
Before changing a fuse you must fi nd
out the cause of the fault and have it
put right. The fuse numbers are indi-
cated on the fuse box.

Incorrect * The maxi fuses provide ad-
ditional protection for the
electrical systems. All work
must be carried out by a
PEUGEOT dealer.

Always replace a faulty
fuse with one of the same
rating. Fascia fuse box

 Turn the screw a quarter of a turn,
then tilt the cover to open it.

 Turn the lever a quarter of a turn,
then push and tilt the box to gain
access to the fuses.
RatingFunctions
FH1*-Not used.
FH2*40 ATrailer Fuse Box.
FH3*20 AHeated seats.
FH4*20 AAudio amplifi er.
FH5*5 A"Sesame" doors control unit.

9
124
Fuse N°RatingFunctions
115 ARear wiper.
35 AAir bags and pre-tensioners control unit.
410 ADiagnostic socket - Clutch switch - Steering wheel angle sensor - Particle emission fi lter pump.
530 AElectric windows - Sunroof.
6-Not used.
75 ACourtesy light - Glove box lighting.
820 ATyre under-infl ation detection control unit - Electric mirror folding - Alarm siren - Multifunction display - Alarm control unit - Audio equipment - Aud io/telephone.
930 AAudio equipment - Lighter/12 V socket (100 W max).
1015 ASteering wheel controls.
1115 ADiagnostic socket - Low current ignition switch - Motorised strikers.
1215 AAir bags and pre-tensioners control unit - Rain/brightness sensor.
135 AABS relay - Speed sensor - Engine Fuse Box - "2 Tronic" gear lever - Brake swit ch.
1415 AParking assistance control unit - "Sesame" doors control unit and switches - Instrument panel - Seat belt warning lights bar - Air conditioning control panel - Headlamp adjustment - Hands-free kit.
1530 ALocking - Deadlocking - Unlocking.
1740 ARear screen and exterior mirrors demisting.
SH-PARC shunt.

9
125
Engine compartment fuse box

 Unclip the cover to gain access to
the fuses.
 Once the work has been carried
out, close the cover very carefully.
Fuse N°RatingFunctions
MF1**50 AFan assembly.
MF2**30 AABS/ESP control unit.
MF3**30 AABS/ESP control unit.
MF4**60 ABuilt-in Systems Interface supply.
MF5**60 ABuilt-in Systems Interface supply.
MF6**30 A"2 Tronic" gearbox control unit.
MF7**80 APassenger compartment fuse box - "Sesame" doors control unit.
MF8**80 AElectric power steering.
Your vehicle's electrical sys-tem is designed to operate with standard or optional equipment.
** The maxi fuses provide addi-tional protection for the electrical systems. All work must be car-ried out by a PEUGEOT dealer.
Before installing other electrical equipment or accessories on your vehicle, contact a PEUGEOT dealer.
Some electrical accessories or the way in which they are fi tted may have damaging effects on the operation of your vehicle (audio, control and elec-trical load circuits).
PEUGEOT will not accept responsi-bility for the cost incurred in repairing your vehicle or for rectifying malfunc-tions resulting from the installation of auxiliary accessories not supplied and not recommended by PEUGEOT and not installed in accordance with its instructions, in particular where the equipment in question consumes more than 10 milliamperes.