PEUGEOT 107 2005 Manual Online

Practical information76 -
02-06-2005
77Practical information-
02-06-2005
Engine compartment fuse box
F Unclip the cover, pressing on the
right on lug E, to gain access to
the fuses. Your vehicle's electrical
circuit is designed to operate
with standard or optional
equipment.
Before installing other electrical equi-
pment or accessories on your vehi-
cle, contact a PEUGEOT dealer.
Some electrical accessories or the
way in which they are itted may have
an adverse effect on the operation of
your vehicle (audio circuit, control cir-
cuit and electrical charging circuit).
PEUGEOT will not accept any res-
ponsibility for the costs incurred in
repairing your vehicle or for the mal-
functions resulting from the installa-
tion of auxiliary accessories which
were not supplied or recommended
by PEUGEOT and which were not
installed in accordance with its ins-
tructions, in particular in the case of
any equipment the consumption of
which exceeds 10 milliamps.
The pliers
A and the replacement
fuses B are ixed at the front of the
box.
When you have inished, close the
cover very carefully.

Practical information76 -
02-06-2005
77Practical information-
02-06-2005
Fuse N° RatingFunctions
1 50 A 2 Tronic gearbox - Fan assembly (diesel)
2 10 A
Headlamps
30 A Headlamps with daytime lights
3 25 A ABS control unit
4 30 A Ignition switch supply
5 10 A Hazard warning lights
6 10 A Headlamps
7 15 A Courtesy light
8 15 A/25 A Petrol/diesel engine control unit
9 10 A Horn
10 30 A Fan assembly (petrol)
11 40 A ABS

Practical information78 -
02-06-2005
79Practical information-
02-06-2005
BATTERY
To charge the battery using a
battery charger:
- Disconnect the battery,
- Follow the instructions for use gi-ven by the battery charger manu-
facturer,
- Reconnect starting with the nega- tive (-) terminal,
- Check that the terminals and connectors are clean. If they are
covered with sulphate (white or
greenish deposit), disconnect them
and clean them.
A. Failed battery
B. Slave battery
C. Metal point (earth) on the
broken down vehicle
Do not push the vehicle to
start the engine if you have a
"2 Tronic" gearbox.
Before disconnecting the
battery, you must wait for
2 minutes after switching off
the ignition.
Never disconnect a terminal when
the engine is running.
Never charge a battery without irst
disconnecting the terminals.
Close the windows and doors before
disconnecting the battery.
After every reconnection of the bat-
tery, switch on the ignition and wait
1 minute before starting to allow the
electronic systems to be initialised. If
slight dificulties are experienced af-
ter this, please consult a PEUGEOT
dealer.
To start the vehicle from
another battery:
- Connect the red cable to the positive (+) terminals of the two batteries,
- Connect one end of the green or black cable to the negative (-)
terminal of the slave battery B,
- Connect the other end of the green or black cable to an earth point C
on the broken down vehicle as far
as possible from the battery,
- Operate the starter, let the engine run,
- Wait for the engine to return to idle, then disconnect the cables. It is advisable to disconnect
the battery if the vehicle is
not to be used for a period of
more than one month.
The batteries contain harmful
substances such as sulphu-
ric acid and lead. They must
be discarded in accordance
with the provisions of the law and
must not, in any circumstances, be
discarded with household waste.
Return used batteries to a special
collection point.

Practical information78 -
02-06-2005
79Practical information-
02-06-2005
FITTING AUDIO EQUIPMENT
Your vehicle is equipped with certain
factory-itted audio equipment:
- roof aerial,
- coaxial aerial cable,
- basic interference suppression,
- supply to front speakers,
- two 8-way connectors.
FITTING SPEAKERS
The factory-itted equipment allows
the itting of 100 mm diameter spea-
kers on the fascia.
As accessories, you can it 165 mm
diameter speakers on the rear shelf.Making the connections
A1:
-
A2: -
A3: -
A4: (+) Accessories
A5: -
A6: (+ve) Side light
A7: (+ve) Permanent
A8: Earth
B1: (+) Rear right speaker
B2: (-) Rear right speaker
B3: (+) Front right speaker
B4: (-) Front right speaker
B5: (+) Front left speaker
B6: (-) Front left speaker
B7: (+) Rear left speaker
B8: (-) Rear left speaker
Consult a PEUGEOT dealer
before installing audio equi-
pment or speakers in your
vehicle.

Practical information80 -
02-06-2005
81Practical information-
02-06-2005
TOWING YOUR VEHICLE
Your vehicle can only be towed at
the front.
Lifting (2 wheels only on the
road)
It is preferable to raise the vehicle by
the wheels.
Never use the radiator crossmem-
ber.
Towing with fours wheels on the
road must be carried out at very low
speed over a very short distance (in
accordance with the legislation in
force).
In all other cases, your vehicle must
be transported on a trailer.When towing with the
engine switched off, there
is no braking or steering
assistance.
Without lifting (4 wheels on
the road)
You should always use a towbar.
The removable towing eye is stored
in the spare wheel, under the boot
carpet.
F Unclip the bottom of the cover,
F Screw in the towing eye until it
locks. Place the gear lever in
position
N for the "2 Tronic"
gearbox.

Practical information80 -
02-06-2005
81Practical information-
02-06-2005
ACCESSORIES FOR
YOUR 107
A wide range of accessories recom-
mended by PEUGEOT and original
parts is offered by the Network.
They all beneit from PEUGEOT's
recommendation.
These accessories and parts, having
been tested and approved for reliabi-
lity and safety, are all adapted to your
PEUGEOT vehicle.
The product range offered by
PEUGEOT Accessories is structured
around 5 categories: PROTECTION -
TOURING - IN-CAR TECHNOLOGY -
STYLING - UNIVERSAL.The itting of electrical equi-
pment or accessories which
are not recommended by
PEUGEOT may result in
a failure of your vehicle's
electronic system and excess con-
sumption.
Please note this speciic warning.
You are advised to contact a repre-
sentative of the Marque to be shown
the range of recommended equip-
ment and accessories.
"Protection": anti-theft
alarm, irst aid kit, warning
triangle, high visibility sa-
fety jacket, snow chains. "Touring":
mats, boot tray,
sun blinds, roof bars, tailga-
te bicycle carrier, cool box,
covers, map reading light.
"In-Car Technology": tele-
phones, satellite navigation
system, CD changer, rear
speakers.
"Styling": alloy wheels,
spoiler, styling strips, door
spoilers, sill protectors.
"Universal": windscreen
wash luid, interior and ex-
terior cleaning and mainte-
nance products.

Technical data82 -
02-06-2005
83Technical data-
02-06-2005
PETROL ENGINES AND GEARBOXES
Model codes PM, PNCFAC CFAC/P
Engines 1.0 litre (≈ 68 bhp)
Cubic capacity (cm
3) 998
Bore x stroke (mm) 71 x 84
EU standard maximum power (kW) 50
Max power engine speed (rpm) 6 000
EU standard max torque (Nm) 93
Max torque engine speed (rpm) 3 600
Fuel Unleaded
Catalytic converter Yes
Gearbox Manual
(5-speed) "2 Tronic"
(5-speed)
Oil capacity (in litres)
Engine (with cartridge replacement) 3.2
Gearbox-Final drive 2

Technical data82 -
02-06-2005
83Technical data-
02-06-2005
These consumption values are established in accordance with Directive 80/1268/CEE. They may vary depending upon
circumtances: handling of the vehicle, trafic and weather condit ions, loading of the vehicle, vehicle maintenance and the use
of accessories.
PETROL CONSUMPTION
In accordance with directive 80/1268/CEE MPG (litres/100 km )
Engines Gearbox Model
codes Urban
driving MPG
(l/100 km) Inter-urban
driving MPG
(l/100 km) Mixed
driving MPG
(l/100 km) Emission of
CO2 by
weight (g/km)
1.0 litre Manual CFAC 51.4 (5.5) 68.9 (4.1) 61.4 (4.6) 109
1.0 litre "2 Tronic" CFAC/P 51.4 (5.5) 68.9 (4.1) 61.4 (4.6) 109
Engines 1.0 litre
Gearbox Manual "2 Tronic"
Model codes PMCFAC / PNCFAC PMCFAC/P / PNCFAC/P
Kerb weight 790 / 800 825 / 835
Gross vehicle weight (GVW) 1 180 / 1 190 1 180 / 1 190
PETROL WEIGHTS (in kg)

Technical data84 -
02-06-2005
85Technical data-
02-06-2005
DIESEL ENGINES AND GEARBOXES
Model codes PM, PN8HTC
ENGINES 1.4 litre Turbo HDI (≈ 54 bhp)
Cubic capacity (cm
3) 1 398
Bore x stroke (mm) 73.7 x 82
EU standard maximum power (kW) 40
Max power engine speed (rpm) 4 000
EU standard max torque (Nm) 130
Max torque engine speed (rpm) 1 750
Fuel Diesel
Catalytic converter Yes
Particle emission ilter No
Gearbox Manual
(5-speed)
Oil capacity (in litres)
Engine (with cartridge replacement) 3.8
Gearbox-Final drive 1.9

Technical data84 -
02-06-2005
85Technical data-
02-06-2005
Engines1.4 litre Turbo HDI
Gearbox Manual
Model codes PM8HTC / PN8HTC
Kerb weight 880 / 890
Gross vehicle weight (GVW) 1 235 / 1 245
DIESEL WEIGHTS (in kg)
DIESEL CONSUMPTION
In accordance with directive 80/1268/CEE MPG (litres/100 km
)
Engines Gearbox Model
codes Urban
driving MPG
(l/100 km) Inter-urban
drivingMPG
(l/100 km) Mixted
driving MPG
(l/100 km) Emission of
CO2 by
weight (g/km)
1.4 litre Turbo HDI Manual 8HTC
53.3 (5.3) 83.1 (3.4) 68.9 (4.1) 109
These consumption values are established in accordance with Direct ive 80/1268/CEE. They may vary depending upon
circumtances: handling of the vehicle, trafic and weather condit ions, loading of the vehicle, vehicle maintenance and the use
of accessories.