PEUGEOT 107 2006.5 Manual Online

9PRACTICAL INFORMATION
73
CHANGING A FUSE
The fuse boxes are located under the
instrument panel trim and next to the
battery in the engine compartment.Correct
Removing and fitting a fuse
Before changing a fuse, the cause of
the incident must be found and recti-
fied.
 Use the pliers A located in the
fuse box under the bonnet. Incorrect
Pliers A
Instrument panel fuse boxes
These are located on each side of
the instrument panel under the trim.
 Turn the steering wheel to the left,
remove bolt B.
 Turn the steering wheel to the right
(do not forget to release the steer-
ing wheel using the key), remove
bolt C.
Always replace a faulty fuse
with a fuse of the same rat-
ing (same colour).

9PRACTICAL INFORMATION
74
 Raise the instrument panel trim,
and the rev counter trim if neces-
sary, to gain access to the fuses
located on the left and on the
right.

For the rev counter, partially
unscrew bolt D located behind it.

9PRACTICAL INFORMATION
75
Fuse N° RatingFunctions
1 10 A Brake lights - ABS - "2 Tronic" gearbox
2 25 A Central locking/unlocking
3 20 A Rear screen demisting
4 7.5 A Rear lights - Number plate lights - Instrument panel - Display
5 7.5 A Diagnostic socket
6 7.5 A Rear fog lamp - Instrument panel - "2 Tronic" gearbox
7 - Not used
8 7.5 A ABS - Power steering - Air conditioning - Fan assembly
9 10 A Rear lights - Central locking/unlocking - Electric windows -
Rear screen demisting - Speedometer - Air conditioning - Heating -
Rev counter
10 20 A Front and rear wipers
11 15 A Audio equipment - Electronic engine immobiliser - 12 V socket (120 W max)
12 7.5 A Rear screen demisting - ABS - Fan assembly - Front and rear wipers -
Power steering - Central locking/unlocking - Air conditioning -
Electric windows - Speedometer - Rev counter
13 15 A Air bag - Engine control unit - Electronic engine immobiliser -
"2 Tronic" gearbox - Instrument panel
14 7.5 A Air conditioning
15* 40 A Accessories - Demisting - ABS - Fan assembly relay - Front and rear wipers
16* 30 A Electric windows
17* 40 A Heating - Air conditioning
* Fuses located behind the instrument panel. To change the m, contact a PEUGEOT dealer.

9PRACTICAL INFORMATION
78
BATTERY
To charge the battery using a
battery charger:
- Disconnect the battery,
- Follow the instructions for use given by the battery charger manu-
facturer,
- Reconnect starting with the nega- tive (-) terminal,
- Check that the terminals and con- nectors are clean. If they are cov-
ered with sulphate (white or green-
ish deposit), disconnect them and
clean them.
A. Failed battery
B. Slave battery
C. Metal point (earth) on the
broken down vehicle
Do not push the vehicle to
start the engine if you have a
"2 Tronic" gearbox.
Before disconnecting the
battery, you must wait for
2 minutes after switching off
the ignition.
Never disconnect a terminal when
the engine is running.
Never charge a battery without first
disconnecting the terminals.
Close the windows and doors before
disconnecting the battery.
After every reconnection of the bat-
tery, switch on the ignition and wait
1 minute before starting to allow the
electronic systems to be initialised.
If slight difficulties are experienced
after this, please consult a PEUGEOT
dealer.
To start the vehicle from
another battery:
- Connect the red cable to the positive (+) terminals of the two batteries,
- Connect one end of the green or black cable to the negative (-) ter-
minal of the slave battery B,
- Connect the other end of the green or black cable to an earth point C
on the broken down vehicle as far
as possible from the battery,
- Operate the starter, let the engine run,
- Wait for the engine to return to idle, then disconnect the cables. It is advisable to disconnect
the battery if the vehicle is
not to be used for a period of
more than one month.
The batteries contain harm-
ful substances such as sul-
phuric acid and lead. They
must be discarded in accord-
ance with the provisions of the law
and must not, in any circumstances,
be discarded with household waste.
Return used batteries to a special
collection point.

9PRACTICAL INFORMATION
79
FITTING AUDIO EQUIPMENT
Your vehicle is equipped with certain
factory-fitted audio equipment:
- roof aerial,
- coaxial aerial cable,
- basic interference suppression,
- supply to front speakers,
- two 8-way connectors.
FITTING SPEAKERS
The factory-fitted equipment allows
the fitting of 100 mm diameter speak-
ers on the fascia.
As accessories, you can fit 165 mm
diameter speakers on the rear shelf.Making the connections
A1:
-
A2: -
A3: -
A4: (+) Accessories
A5: -
A6: (+ve) Side light
A7: (+ve) Permanent
A8: Earth
B1: (+) Rear right speaker
B2: (-) Rear right speaker
B3: (+) Front right speaker
B4: (-) Front right speaker
B5: (+) Front left speaker
B6: (-) Front left speaker
B7: (+) Rear left speaker
B8: (-) Rear left speaker
Consult a PEUGEOT dealer
before installing audio equip-
ment or speakers in your
vehicle.
FITTING / REMOVING THE
MAT*
When removing the mat on the driv-
er's side, push the seat as far back
as possible and remove the fixing.
When refitting, position the mat cor-
rectly on the pin and clip the fixing.
Check that the mat is secured cor-
rectly.
To prevent the mat from becoming
caught under the pedals:
- only use mats suited to the fixing already present in the vehicle.It is
imperative that this fixing is used.
- never fit one mat on top of another.
* According to version.

9PRACTICAL INFORMATION
80
TOWING YOUR VEHICLE
Your vehicle can only be towed at
the front.
Lifting
(2 wheels only on the road)
It is preferable to raise the vehicle by
the wheels.
Never use the radiator crossmem-
ber.
Towing with fours wheels on the road
must be carried out at very low speed
over a very short distance (in accord-
ance with the legislation in force).
In all other cases, your vehicle must
be transported on a trailer.When your vehicle is being
towed with the engine
switched off, there is no brak-
ing or steering assistance.
Without lifting
(4 wheels on the road)
You should always use a towbar.
The removable towing eye is stored
in the spare wheel, under the boot
carpet.
 Unclip the bottom of the cover,
 Screw in the towing eye until it
locks. Place the gear lever in posi-
tion
N for the "2 Tronic" gear-
box.

9PRACTICAL INFORMATION
81
ACCESSORIES FOR
YOUR 107
A wide range of accessories recom-
mended by PEUGEOT and original
parts is offered by the Network.
They all benefit from PEUGEOT's
recommendation.
These accessories and parts, having
been tested and approved for reli-
ability and safety, are all adapted to
your PEUGEOT vehicle.
The product range offered by
PEUGEOT Accessories is structured
around 5 categories: PROTECTION -
TOURING - IN-CAR TECHNOLOGY
- STYLING - UNIVERSAL.The fitting of electrical equip-
ment or accessories which
are not recommended by
PEUGEOT may result in a
failure of your vehicle's elec-
tronic system and excess consump-
tion.
Please note this specific warning.
You are advised to contact a repre-
sentative of the Marque to be shown
the range of recommended equip-
ment and accessories.
"Protection": anti-theft
alarm, first aid kit, warn-
ing triangle, high visibility
safety jacket, snow chains,
fog lamps kit... "Touring":
mats, boot tray,
sun blinds, roof bars, arm-
rest, telephone support, CD
storage, glove box lid...
"In-Car Technology":
bluetooth hands-free kit,
audio equipment, portable
satellite navigation system,
CD changer, auxiliary cable
for audio equipment (e.g.:
connection for portable
MP3 player on audio equipment),
rear speakers...
"Styling": covers, 14 inch
alloy wheels, spoiler, stand-
ard mud flaps, styling strips,
door spoilers, sill protec-
tors, aluminium/leather
gear lever knob, aluminium
interior trim kit, chromed
exhaust tailpipe, anti-scratch cov-
ers under the handles, "Cristal" rear
lights... "Universal":
windscreen
wash fluid, interior and
exterior cleaning and main-
tenance products.
To prevent the mat from becoming
caught under the pedals:
- ensure that the mat is positioned and secured correctly,
- never fit one mat on top of another.

10TECHNICAL DATA
82
PETROL ENGINES AND GEARBOXES
Model codes PM, PNCFAC CFAC/P
Engines 1.0 litre (≈ 68 bhp)
Cubic capacity (cm
3) 998
Bore x stroke (mm) 71 x 84
EU standard maximum power (kW) 50
Max power engine speed (rpm) 6 000
EU standard max torque (Nm) 93
Max torque engine speed (rpm) 3 600
Fuel Unleaded
Catalytic converter Yes
Gearbox Manual
(5-speed) "2 Tronic"
(5-speed)
Oil capacity (in litres)
Engine (with cartridge replacement) 3.2
Gearbox-Final drive 2

10TECHNICAL DATA
83
Fuel consumption values correct at time of printing. These consumption values are established in accordance with EC
Directive 80/1268 (as amended). They may vary depending upon circumst ances: handling of the vehicle, traffic and weather
conditions, loading of the vehicle, vehicle maintenance and the use of accessories.
PETROL CONSUMPTION
In accordance with EC Directive 80/1268 (as amended) mpg (litres/100 km)
Engines Gearbox Model codes
PM,PN Urban
driving mpg
(l/100 km) Inter-urban
drivingmpg
(l/100 km) Mixed
driving mpg
(l/100 km) Emission
of CO2 by weight
(g/km)
1.0 litre Manual CFAC 51.4 (5.5) 68.9 (4.1) 61.4 (4.6) 109
1.0 litre "2 Tronic" CFAC/P 51.4 (5.5) 68.9 (4.1) 61.4 (4.6) 109
PETROL WEIGHTS (in kg)
The design of your vehicle does not permit the fitting of a t owbar.
Engines
1.0 litre
Gearbox Manual "2 Tronic"
Versions 3-door 5-door 3-door 5-door
Model codes PMCFAC PNCFAC PMCFAC/P PNCFAC/P
Kerb weight 790 800 825 835
Gross vehicle weight (GVW) 1 180 1 190 1 180 1 190

10TECHNICAL DATA
84
DIESEL ENGINES AND GEARBOXES
Model codes PM, PN8HTC
Engines 1.4 litre Turbo HDI (≈ 54 bhp)
Cubic capacity (cm
3) 1 398
Bore x stroke (mm) 73.7 x 82
EU standard maximum power (kW) 40
Max power engine speed (rpm) 4 000
EU standard max torque (Nm) 130
Max torque engine speed (rpm) 1 750
Fuel Diesel
Catalytic converter Yes
Particle emission filter No
Gearbox Manual
(5-speed)
Oil capacity (in litres)
Engine (with cartridge replacement) 3.8
Gearbox-Final drive 1.9