Peugeot 107 Dag 2006 Repair Manual

57Safety-
01-01-2006
AIR BAGS
The air bags have been designed to
maximise the safety of the occupants
in the event of serious collisions.
They work in conjunction with the
force-limiting seat belts.
The electronic detectors register and
analyse any abrupt deceleration of
the vehicle: if the triggering threshold
is reached, the air bags inflate
instantly and protect the occupants
of the vehicle.
Immediately after the impact, the
air bags deflate rapidly so that they
do not hinder the visibility of the
occupants nor their exit if necessary
from the vehicle.
The air bags are not deployed in
the case of collisions which are
not serious, for which the seat belt
is sufficient to ensure maximum
protection. The seriousness of a
collision depends on the nature of the
obstacle and the speed of the vehicle
at the moment of the collision.
Air bags only operate when the
ignition is switched on.
FRONT AIR BAGS
These are folded in the centre of the
steering wheel for the driver and in
the fascia for the front passenger.
They are deployed simultaneously,
except in cases where the passenger
air bag is disarmed.
Front air bag malfunction
Flashing indicates an air
bag malfunction, contact a
PEUGEOT dealer to have
the system checked.
Disarming the passenger
air bag
To ensure the safety of your
child, it is essential to disarm
the passenger air bag when you
install a "rear-facing" child seat
on the front passenger seat.
Otherwise, the child would risk
being seriously injured or killed if
the air bag were to inflate.
 With the ignition switched off ,
insert the key into the passenger
air bag disarming switch 1, turn it
to the "OFF" position, then remove
the key keeping the switch in this
position.
Note:
the gas escaping from
the air bags can be a minor
irritant.

Safety58 -
01-01-2006
In the "OFF" position, the passenger
air bag will not be triggered in the
event of an impact.
As soon as the child seat is removed,
turn the air bag switch to the "ON"
position to re-activate the air bag
and thus ensure the safety of your
passenger in the event of an impact.
If the passenger air bag
is disarmed, the warning
light on the instrument
panel remains on until
the passenger air bag is
reactivated.SIDE AIR BAGS* AND
CURTAIN AIR BAGS*
The side air bags are incorporated
into the front seat backs on the door
side.
The curtain air bags are incorporated
in the headlining.
They are deployed independently of
each other depending on which side
the collision occurs.Flashing indicates a
malfunction of at least one
of these air bags.
Contact a PEUGEOT
dealer to have the system
checked.
Disarming (check)
Air bags malfunction
* According to version.

59Safety-
01-01-2006
For the front, side* and
curtain* air bags to be
fully effective, observe the
following safety rules:
Wear a correctly adjusted seat belt.
Sit in a normal upright position.
Do not leave anything between the
occupants and the air bags (child,
animal, object...).
This could hamper the operation of
the air bags or injure the occupants.
All work on the air bag systems is
strictly prohibited unless it is carried
out by qualified personnel of the
PEUGEOT network.
After an accident or if the vehicle has
been stolen or broken into, have the
air bag systems checked. Front air bags
Do not drive holding the steering
wheel by its spokes or resting your
hands on the centre part of the
wheel.
Passengers must not place their feet
on the fascia.
Smoke as little as possible;
deployment of the air bags can
cause burns or the risk of injury from
a cigarette or pipe.
Never remove or pierce the steering
wheel or hit it violently.
Curtain air bags*
Do not fix or glue anything to the
pillars or the roof. This could cause
injury to the head when the curtain
air bag inflates.
Side air bags*
Only put approved covers on the
front seats. Contact your PEUGEOT
dealer.
Do not fix or glue anything to the front
seat backs. This could cause injury
to the chest or arms when the side
air bag inflates.
Do not sit with the upper part of the
body any nearer to the door than
necessary. * According to version.

Safety58 -
01-01-2006
In the "OFF" position, the passenger
air bag will not be triggered in the
event of an impact.
As soon as the child seat is removed,
turn the air bag switch to the "ON"
position to re-activate the air bag
and thus ensure the safety of your
passenger in the event of an impact.
If the passenger air bag
is disarmed, the warning
light on the instrument
panel remains on until
the passenger air bag is
reactivated.SIDE AIR BAGS* AND
CURTAIN AIR BAGS*
The side air bags are incorporated
into the front seat backs on the door
side.
The curtain air bags are incorporated
in the headlining.
They are deployed independently of
each other depending on which side
the collision occurs.Flashing indicates a
malfunction of at least one
of these air bags.
Contact a PEUGEOT
dealer to have the system
checked.
Disarming (check)
Air bags malfunction
* According to version.

59Safety-
01-01-2006
For the front, side* and
curtain* air bags to be
fully effective, observe the
following safety rules:
Wear a correctly adjusted seat belt.
Sit in a normal upright position.
Do not leave anything between the
occupants and the air bags (child,
animal, object...).
This could hamper the operation of
the air bags or injure the occupants.
All work on the air bag systems is
strictly prohibited unless it is carried
out by qualified personnel of the
PEUGEOT network.
After an accident or if the vehicle has
been stolen or broken into, have the
air bag systems checked. Front air bags
Do not drive holding the steering
wheel by its spokes or resting your
hands on the centre part of the
wheel.
Passengers must not place their feet
on the fascia.
Smoke as little as possible;
deployment of the air bags can
cause burns or the risk of injury from
a cigarette or pipe.
Never remove or pierce the steering
wheel or hit it violently.
Curtain air bags*
Do not fix or glue anything to the
pillars or the roof. This could cause
injury to the head when the curtain
air bag inflates.
Side air bags*
Only put approved covers on the
front seats. Contact your PEUGEOT
dealer.
Do not fix or glue anything to the front
seat backs. This could cause injury
to the chest or arms when the side
air bag inflates.
Do not sit with the upper part of the
body any nearer to the door than
necessary. * According to version.

Driving60 -
01-01-2006
Driver information
The symbol which corresponds to
the selection, R, N , E or M and the
number of the gear engaged 1 to
5 , are displayed on the instrument
panel screen.
2 TRONIC GEARBOX
The five-speed "2 Tronic" gearbox
offers a choice between the comfort of
automatic operation or the pleasure
of manual gear changing.
Driving mode
Select the driving mode by moving
the gear lever.
Reverse "R": This gear will be
engaged when stationary or at a
speed below approximately 4 mph
(6 km/h).
The switch to reverse gear is
accompanied by an audible signal.
N eutral "N".
Position the lever to the right in
position N, to start the engine .
E asy "E": automatic gear changing.
M anual (+ / - ) "M": manual gear
changing.
Starting the vehicle
With the handbrake applied, press
the brake pedal then select position
N to start the engine.
With your foot on the brake, select
position R, E or M.
Release the handbrake, take your foot
off the brake pedal, then accelerate.
Notes: with the engine
running, in these three
positions, an audible signal
is heard when the driver’s
door is opened.
You can change from position E to
position M and vice versa at any
time.

61Driving-
01-01-2006
EASY mode (automatic mode)
Select position E using the gear
lever.
The gear engaged is displayed on
the instrument panel screen.
The gearbox continuously selects
the most suitable gear.
If you press the accelerator pedal
beyond the point of resistance*, the
2 Tronic gearbox selects the
gear below to permit sharper
acceleration.
Manuel mode
Place the gear lever in position M,
then change up or down through the
gears by pressing:
- rearwards, "+" to change up,
- forwards, "-" to change down.
The gear engaged is displayed on
the instrument panel screen.
In the event of under-revving, to
prevent any risk of stalling, the gear
below is selected automatically.
In the event of overheating of
the clutch, position N is selected
automatically and the symbol N
flashes accompanied by an audible
signal.
Operating fault
Stopping the vehicle
Before switching off the engine, you
can change to position N to be in
neutral.
In all cases, it is essential that you
apply the handbrake to immobilise
the vehicle. With the ignition on, the
lighting of this warning
light indicates a gearbox
malfunction.
Contact a PEUGEOT dealer.
On a slope, use the brake
to immobilise the vehicle
and place the gear lever in
position N, E or R.
Do not keep the vehicle immobilised
using the accelerator. It is compulsory to press the
brake pedal while starting
the engine.
Never select neutral
N while
the vehicle is moving.
In all cases, it is essential
to apply the handbrake to
immobilise the vehicle.
* According to country.

Checks62 -
01-01-2006
OPENING THE BONNET
On the inside: pull control A, located
under the fascia. On the outside:
lift control B and
raise the bonnet.
Bonnet strut
Fix the strut to hold the bonnet
open.
To close
Before closing the bonnet, return the
strut to its housing.
Lower the bonnet and release it at
the end of its travel. Check that the
bonnet is locked.

Checks64 -
01-01-2006
1.0 LITRE PETROL ENGINE
1. Coolant reservoir
2. Windscreen wash reservoir
3. Brake fluid reservoir 4.
Fuse box
5. Battery
6. Air filter 7.
Dipstick
8. Engine oil filler cap

65Checks-
01-01-2006
1.4 LITRE TURBO DIESEL HDI ENGINE
1. Coolant reservoir
2. Windscreen wash reservoir
3. Priming pump 4.
Air filter
5. Brake fluid reservoir
6. Fuse box 7.
Battery
8. Dipstick
9. Engine oil filler cap