PEUGEOT 206 2004.5 Owners Manual

146 -
31-01-2005
147
-
31-01-2005
Fuse N° Rating Functions
1 15 A Alarm siren
4 20 A Multifunction display - Navigation control unit - Boot light
ing - Audio equipment - Steering
wheel controls - Trailer
5 15 A Automatic gearbox diagnostics
6 10 A Coolant level - Automatic gearbox - Audio equipment -
Steering wheel angle sensor (ESP)
7 15 A Driving school accessory - Alarm
9 30 A Rear electric windows
10 40 A Rear screen and mirror demisting 11 15 A Rear windscreen wiper
12 30 A Front electric windows - Sunroof
14 10 A Engine fuse box - Air bags - Steering wheel controls - Rain sensor
15 15 A Instrument panel - Multifunction display - Na vigation control unit - Air conditioning - Audio equipment
16 30 A Locking/unlocking controls for doors, bonnet and boot - Deadlocking controls
20 10 A Right-hand brake light
21 15 A Left-hand brake light - 3rd brake light
22 20 A Front courtesy light and rear courtesy light (206 SW) - Map reader -
Glove box lighting - Lighter - 12 volts rear socket (206 SW)
S1 Shunt PARC shunt
Practical information

150 -
31-01-2005
151
-
31-01-2005
BATTERY
To charge the battery using a
battery charger:
- Disconnect the battery,
- Follow the instructions for use
given by the battery charger manu-
facturer,
- Reconnect starting with the nega- tive (-) terminal,
- Check that the terminals and connectors are clean. If they are
covered with sulphate (white or
greenish deposit), disconnect them
and clean them. - Wait for 2 minutes after
switching off the ignition
before disconnecting
the battery.
- Never disconnect a ter- minal when the engine
is running.
- Never charge a battery without irst disconnecting the terminals.
- Close the windows and the roof before disconnecting the bat-
tery.
- After every reconnection of the battery, switch on the ignition
and wait 1 minute before starting
to allow the electronic systems
to be initialised. If slight dificul-
ties are experienced after this,
please consult a PEUGEOT
dealer.
It is advisable to disconnect the
battery if the vehicle is not to be
used for a period of more than
one month.
ECONOMY MODE FUNCTION
After the engine has stopped, with
the key in the accessories position,
certain functions (windscreen wiper,
electric windows, courtesy lights,
audio equipment, etc.) can only be
used for a cumulative duration of
thirty minutes, to prevent discharging
the battery.
Once the thirty minutes are over, the
message "Economy mode active"
appears on the multifunction display
and the active functions are put on
standby.
To resume the use of these functions
immediately, start the engine and let
it run for a few seconds.
A lat battery will prevent the engine
from starting.
To start the vehicle from another
battery:
- Connect the red cable to the posi-
tive (+) terminals of the two batter-
ies,
- Connect one end of the green or black cable to the negative (-)
terminal of the slave battery,
- Connect the other end of the green or black cable to an earth point on
the broken down vehicle, as far as
possible from the battery,
Operate the starter, let the engine
run.
Wait for the engine to return to idle,
then disconnect the cables.
Practical information

150 -
31-01-2005
151
-
31-01-2005
FITTING SPEAKERS
The factory-itted equipment allows
the itting of:
- 165 mm diameter speakers in the
front doors,
- 130 mm diameter speakers in the rear doors,
- 22.5 mm diameter tweeters in the mirror trims. Making the connections
A1 : -
A2 : -
A3 : -
A4 : -
A5 : -
A6 : (+ve) Ignition positive
A7 : (+ve) Permanent
A8 : Earth
B1 : (+) Rear right speaker
B2 : (-) Rear right speaker
B3 : (+) Front right speaker and
tweeter
B4 : (-) Front right speaker and tweeter
B5 : (+) Front left speaker and tweeter
B6 : (-) Front left speaker and tweeter
B7 : (+) Rear left speaker
B8 : (-) Rear left speaker
Consult a PEUGEOT deal-
er before installing audio
equipment or speakers in
your vehicle.
FITTING AUDIO EQUIPMENT
Your vehicle is equipped with certain
factory-itted audio equipment:
- roof aerial,
- coaxial aerial cable,
- basic interference suppression,
- supply to front speakers,
- supply to rear speakers,
- two 8-way connectors.
Practical information

152 -
31-01-2005
153
-
31-01-2005
Front towing eye 206 SW rear towing eye
TOWING YOUR VEHICLE
By lifting (two wheels only on the
ground)
It is preferable to lift the vehicle by
the wheels.
Never use the radiator
crossmember.
Special features of the automatic
gearbox
When towing with all four wheels on
the ground, the following rules must
be adhered to:
- gear lever in position N,
- tow the vehicle at a speed less than 30 mph (50 km/h) over a distance
of not more than 30 miles (50 km),
- do not add oil to the gearbox. Saloon rear towing eye
Saloon
From the front or the rear
Attach the tow bar to the towing eye. 206 SW
From the front,
attach the tow bar to
the towing eye.
Without lifting (four wheels on the
ground)
You must always use a tow bar.
From the rear:
- unclip the cover using a coin,
- screw in the towing eye (located in the jack storage compartment) as
far as it will go.
Practical information

152 -
31-01-2005
153
-
31-01-2005
TOWING A TRAILER,
CARAVAN, BOAT etc.
Only use original PEUGEOT tow
bars that have been tested and
approved from the design stage of
your vehicle.
The tow bar must be itted by a
PEUGEOT dealer.
Your vehicle is primarily designed
for transporting people and luggage
but it may also be used for towing a
trailer.
Driving with a trailer subjects the tow-
ing vehicle to more signiicant stress
and its driver must be particularly
careful.
Air density decreases with altitude,
thus reducing engine performance.
Above 1 000 metres, the maximum
towing load must be reduced by
10 % and so on for every 1 000 me-
tres of altitude.
Driving advice
Distribution of loads: Distribute the
load in the trailer so that the heaviest
items are as close as possible to the
axle and the nose weight approach-
es the maximum permitted without
exceeding it.
Cooling: Towing a trailer on a slope
increases the temperature of the
coolant.
As the fan is electrically controlled,
its cooling capacity is not dependent
on the engine speed.
On the contrary, use a high gear to
lower the engine speed and reduce
your speed.
The maximum towing load on a long
slope depends on the gradient and
the outside temperature. In all cases, pay attention to the
coolant temperature.
If the warning light comes on, stop
the vehicle and switch off the engine
as soon as possible.
Tyres:
Check the tyre pressures of
the towing vehicle and of the trailer,
observing the recommended pres-
sures.
Braking: Towing increases the braking
distance.
Lights: Check the electrical signalling
on the trailer.
Side wind: Take into acount the
increased sensitivity to side wind.
Practical information

154 -
31-01-2005
155
-
31-01-2005
Removing the mat
When removing the mat on the driver's
side, move the seat as far back as
possible and remove the ixings.
When reitting the mat, position it and
replace the ixings by turning them a
quarter of a turn.
FITTING ROOF BARS
(206 SW)
When itting transverse roof bars,
ensure that they are positioned cor-
rectly.
The correct positions are shown by
marks on each of the longitudinal
bars.
Use accessories approved by PEUGEOT
and follow the manufacturer's itting
instructions.
Maximum authorised weight
on the roof rack, for a loading
height not exceeding 40 cm
(except bicycle carriers): 75 kg.
If the height exceeds 40 cm,
adapt the speed of the vehicle
to the condition of the road, to
avoid damaging the roof bars.
Practical information

154 -
31-01-2005
155
-
31-01-2005
- Clean off bird droppings,
resinous deposits, tar
stains and, grease
marks as soon as pos-
sible; (these all contain
substances which can cause se- rious damage to the paintwork).
- Do not use a dry or abrasive cloth or detergent or sovent
products to clean the double
lens, complex surface head-
lamps as they are itted with
polycarbonate glass covered in
a protective inish.
- Do not use petrol, oil or cloth stain removers to clean the body-
work and plastic parts of your
vehicle.
- To prevent the development of bodywork corrosion as a result
of accidental damage (stone
chips, scratches, etc.) have
them repaired swiftly. BODYWORK MAINTENANCE
To preserve the paintwork and the
plastic trim on your vehicle, we
recommend that you wash them
regularly.
- by hand: there are no speciic pre-cautions to take;
- using an automatic car wash: re- peated use of poorly maintained
automatic car washes can lead
to the appearance of microscopic
scratches which give the paintwork
a matt appearance (especially
visible on dark colours);
- using a high pressure washer: al- ways follow the recommendations
on the equipment (pressure and
spraying distance).
If there are damaged areas on the vehicle (painted bumpers or head-
lamps), it is not recommended to
direct the high pressure jet onto
them.
Wash these areas by hand. Also avoid the entry of water into
the locks.
For all questions relating to the main-
tenance of your vehicle, contact an
approved dealer who can advise you
on quality products selected by our
departments.
Practical information

156 -
31-01-2005
206 ACCESSORIES
For your PEUGEOT only use acces-
sories and original parts approved by
the manufacturer.
These accessories and parts are all
adapted to your PEUGEOT, after be-
ing tested and approved for reliability
and safety, which PEUGEOT cannot
guarantee for other products.
A wide choice of original accessories,
approved by PEUGEOT, is available
through the dealer network. They all
carry the PEUGEOT guarantee.
Safety: Anti-theft alarms, window
engraving, wheel locks, warning
triangle, irst aid kit, high visibility
jacket...
Protection: Covers compatible with
side air bags (saloon and 206 SW),
carpets, boot tray, ...
Communication: Audio/telephone,
hands-free kit, on-board satellite
navigation system, CD changers, ra-
dios, speakers, radio trim, rear shelf
itted with 4 speakers (saloon), ... Customising:
Alloy wheels, trims,
sunroof *, front fog lamps, mud laps,
tailgate spoiler (saloon), sports ex-
haust, aluminium and wood panel
trim, door sills, body kit, wing extend-
ers, two-tone steering wheel...
Before itting an electrical
accessory in your vehicle,
consult a PEUGEOT dealer.
*
To it a sunroof, it is essential that
only original PEUGEOT products
are used.
Comfort: Centre armrest, writing
table, passenger seat protection,
can holder, CD or cassette storage,
telephone console, door delectors,
under shelf storage (saloon), ...
Leisure: Tow bar, roof bars, roof
boxes, ski carrier, bicycle carrier**,
snow chains, ...
** Do not it the bicycle carrier on the spoiler or on the rear screen.
Children: Booster seats and child
seats, Kiddy Isoix seat, sun blinds, ...
Maintenance products: Windscreen
wash luid, interior and exterior main-
tenance and cleaning products, ...
Van: Kit for conversion into a van, ...
Practical information

157
-
31-01-2005
Models
PETROL
2CHFX
2AHFX
2SHFX
2EHFX 2CK6D
2AK6D
2CKFW
2AKFW
2EKFW 2CKFU
2AKFU
2EKFU 2HKFU
2KKFU
ENGINES 1.1 litre 1.4 litre 1.4 litre 1.4 litre 16V
Cubic capacity (cm
3) 1 124 1 360 1 360 1 360
Bore x stroke (mm) 72 x 69 75 x 77 75 x 77 75 x 77
EU standard maximum power (kW) 44.1 55 55 65
Maximum power at engine speed (rpm) 5 500 5 500 5 500 5 250
EU standard maximum torque (Nm) 94 118 120 135
Maximum torque at engine speed (rpm) 2 700 2 800 2 800 3 250
Fuel Unleaded LeadedUnleaded Unleaded
Catalytic converter Yes No Yes Yes
Gearbox Manual
(5 speed) Manual
(5 speed) Manual
(5 speed) Automatic
(4 speed) Manual
(5 speed)
Oil capacity (in litres)
Engine (with cartridge replacement) 3.2 (2) - 3.4 (3)3 (2) - 3.25
(3) 3 (2) - 3.25
(3) 3 (2) - 3.25
(3) 3.2 (2) - 3.5 (3)
Gearbox-Final drive
2 2 2-2
ENGINES AND GEARBOXES
(2) Draining by gravity - (3) Draining by suction.
Technical data

158 -
31-01-2005
159
-
31-01-2005
Models
Model codes PETROL
2CNFU
2ANFU 2HNFU
2KNFU2CRFN
2ARFN
2ERFN 2CRFKA/IF
ENGINES 1.6 litre 16V 2 litre 16V 2 litre 16V
Cubic capacity (cm
3) 1 587 1 997 1 997
Bore x stroke (mm) 78.5 x 82 85 x 88 85 x 88
EU standard maximum power (kW) 80 100 130
Maximum power at engine speed (rpm) 5 800 6 000 7 000
EU standard maximum torque (Nm) 147 190 202
Maximum torque at engine speed (rpm) 4 000 4 100 4 750
Fuel Unleaded Unleaded Unleaded
Catalytic converter Yes Yes Yes
Gearbox Manual
(5 speed) Automatic
(4 speed) Manual
(5 speed) Manual
(5 speed)
Oil capacity (in litres)
Engine (with cartridge replacement) 3.2 (2) - 3.4 (3) 3.2 (2) - 3.4 (3) 4.25 3.8 - 5.3
Gearbox-Final drive
2_ 1.9 1.9
ENGINES AND GEARBOXES
(2) Draining by gravity - (3) Draining by suction
Technical data