Peugeot 206 CC 2004.5 Owners Manual

88 -
31-01-2005
89
-
31-01-2005
In the
"OFF" position, the passenger
air bag will not be triggered in the
event of an impact.
As soon as the child seat is removed,
turn the air bag slot to the "ON"
position to re-activate the air bag
and thus ensure the safety of your
passenger in the event of an impact.SIDE AIRBAGS *
These are incorporated into the
frame of the front seat back, on the
door side.
They are deployed independently
of each other depending on which
side the collision occurs, in collisions
which could cause injury to the chest,
the abdomen or the head.
This is conirmed by an indicator light
on the instrument panel.
It comes on for six seconds, each
time the ignition is switched on.
With the ignition on (2nd
notch), illumination of this
warning light accompanied
by a message on the
multifunction display, indicates that
the passenger air bag is disarmed
(switch in the "OFF" position).
If the two air bag warning
lights are lit continuously,
do not install a rear-facing
child seat. Contact a
PEUGEOT dealer. Operating check
* According to destination.
Safety
If the indicator light:
- does not light up when the ignition is switched on, or
- does not go out after six seconds, or
- lashes for ive minutes then stays on,
contact a PEUGEOT dealer.
Disarming check
This is conirmed by an indicator
light, accompanied by a message on
the multifunction display.

88 -
31-01-2005
89
-
31-01-2005
For the front and side*
air bags to be fully
effective, observe the
following safety rules:
• Wear a correctly adjusted seat belt.
• Sit in a normal upright position.
• Do not leave anything between the occupants and the air bags
(child, animal, object...).
This could hamper the operation of the air bags or injure the
occupants.
• All work on the air bag systems is strictly prohibited unless it is
carried out by qualiied personnel
of the PEUGEOT network.
• After an accident or if the vehicle has been stolen or broken
into, have the air bag systems
checked. Front air bags
• Do not drive holding the steering
wheel by its spokes or resting
your hands on the centre part of
the wheel.
• Passengers must not place their feet on the fascia.
• Smoke as little as possible; deployment of the air bags can
cause burns or the risk of injury
from a cigarette or pipe.
• Never remove or pierce the steering wheel or hit it violently. Side air bags*
• Only put approved covers on
the front seats. Contact your
PEUGEOT dealer.
• Do not ix or glue anything to the front seat backs. This could
cause injury to the chest or arms
when the side air bag inlates.
• Do not sit with the upper part of the body any nearer to the door
than necessary.
* According to country.
Safety

88 -
31-01-2005
89
-
31-01-2005
In the
"OFF" position, the passenger
air bag will not be triggered in the
event of an impact.
As soon as the child seat is removed,
turn the air bag slot to the "ON"
position to re-activate the air bag
and thus ensure the safety of your
passenger in the event of an impact.SIDE AIRBAGS *
These are incorporated into the
frame of the front seat back, on the
door side.
They are deployed independently
of each other depending on which
side the collision occurs, in collisions
which could cause injury to the chest,
the abdomen or the head.
This is conirmed by an indicator light
on the instrument panel.
It comes on for six seconds, each
time the ignition is switched on.
With the ignition on (2nd
notch), illumination of this
warning light accompanied
by a message on the
multifunction display, indicates that
the passenger air bag is disarmed
(switch in the "OFF" position).
If the two air bag warning
lights are lit continuously,
do not install a rear-facing
child seat. Contact a
PEUGEOT dealer. Operating check
* According to destination.
Safety
If the indicator light:
- does not light up when the ignition is switched on, or
- does not go out after six seconds, or
- lashes for ive minutes then stays on,
contact a PEUGEOT dealer.
Disarming check
This is conirmed by an indicator
light, accompanied by a message on
the multifunction display.

88 -
31-01-2005
89
-
31-01-2005
For the front and side*
air bags to be fully
effective, observe the
following safety rules:
• Wear a correctly adjusted seat belt.
• Sit in a normal upright position.
• Do not leave anything between the occupants and the air bags
(child, animal, object...).
This could hamper the operation of the air bags or injure the
occupants.
• All work on the air bag systems is strictly prohibited unless it is
carried out by qualiied personnel
of the PEUGEOT network.
• After an accident or if the vehicle has been stolen or broken
into, have the air bag systems
checked. Front air bags
• Do not drive holding the steering
wheel by its spokes or resting
your hands on the centre part of
the wheel.
• Passengers must not place their feet on the fascia.
• Smoke as little as possible; deployment of the air bags can
cause burns or the risk of injury
from a cigarette or pipe.
• Never remove or pierce the steering wheel or hit it violently. Side air bags*
• Only put approved covers on
the front seats. Contact your
PEUGEOT dealer.
• Do not ix or glue anything to the front seat backs. This could
cause injury to the chest or arms
when the side air bag inlates.
• Do not sit with the upper part of the body any nearer to the door
than necessary.
* According to country.
Safety

90 -
31-01-2005
91
-
31-01-2005
1 -
Power steering reservoir
2 - Windscreen and headlamp*
wash reservoir
3 - Coolant reservoir 4 -
Brake luid reservoir
5 - Battery
6 - Air ilter 7 -
Dipstick
8 - Engine oil reservoir
1.6 LITRE 16V (110 bhp) PETROL ENGINEChecks
* According to destination.

90 -
31-01-2005
91
-
31-01-2005
1 -
Power steering reservoir
2 - Windscreen and headlamp*
wash reservoir
3 - Coolant reservoir 4 -
Brake luid reservoir
5 - Battery
6 - Air ilter 7 -
Dipstick
8 - Engine oil reservoir
2 LITRE 16 V PETROL ENGINE (138 bhp) Checks
* According to country.

92 -
31-01-2005
93
-
31-01-2005
CHECKING THE LEVELS
Oil level
Check the level regularly and top up
between changes. The maximum
consumption is 0.5 l per 600 miles
(1000 km).
Check the level with the vehicle
level, engine cold, using the oil level
gauge on the instrument panel or the
dipstick.
Dipstick
There are two marks
on the dipstick:
A = maximum
Never ill past this
mark.
B = minimum
To maintain the
reliability of engines
and emission control
systems, the use of
additives in engine oil
is prohibited.
Oil change
According to the information given in
the servicing booklet.
Note: avoid used oil coming
into prolonged contact with the
skin. Empty the used oil into the
containers intended for this purpose
in the PEUGEOT network. Viscosity selection
In all cases, the oil selected
must meet the manufacturer's
requirements.
Used oil
Do not dispose of used oil, brake
luid or coolant into drains or onto
the ground.
* According to country.
Checks
Brake luid change:
- must be carried out according to the
manufacturer's servicing schedule.
- use luids recommended by the manufacturer, which fulil DOT4
standards.
Note: brake luid is harmful to health
and very corrosive. Avoid all contact
with the skin.
Cooling system
Use the luid recommended by the
manufacturer.
When the engine is warm, the
temperature of the coolant is
controlled by the engine fan. As this
fan can operate with the ignition key
removed and because the cooling
system is pressurised, wait for at
least one hour after the engine has
stopped before carrying out any
work.
Slacken the cap by two turns to
release the pressure to prevent any
risk of scalding. When the pressure
has dropped, remove the cap and
top up the level.
Note: the coolant does not need to
be changed.
Power steering reservoir
Open the reservoir, with the engine
at ambient temperature. The level
should always be above the MIN.
mark and close to the MAX. mark.
Windscreen and headlamp*
wash level
For best quality cleaning and for
your safety, we would advise that
you use products recommended by
PEUGEOT.

92 -
31-01-2005
93
-
31-01-2005
CHECKS
Battery
At the start of winter, have your
battery checked by a PEUGEOT
dealer.
Oil ilter
Change the ilter regularly, in
accordance with the servicing
schedule. Only use products recom-
mended by PEUGEOT.
To ensure best
performance from
components as important as the
power steering and the braking
system, PEUGEOT selects and
offers quite speciic products.
To prevent damage to the electrical
units, avoid washing the engine.
Checks
Air ilter and passenger
compartment ilter
Have the ilter elements replaced
regularly. If you drive in dusty
conditions, change them twice as
often.
Brake pads
Brake pad wear depends on the style
of driving, in particular for vehicles
which are used in town, over short
distances
.
It may be necessary to check the
thickness of the pads, even between
services.
Handbrake
Where the handbrake travel is too
great or there is a reduction in the
performance of the system, the
handbrake should be adjusted, even
between services.
Have the system checked by a
PEUGEOT dealer.
Manual gearbox
This does not require an oil change.
Check the level in accordance
with the manufacturer's servicing
schedule.
To check the main levels and
certain components, in accordance
with the manufacturer's servicing
schedule, refer to the pages
of the servicing booklet which
correspond to your vehicle's
engine.

94 -
31-01-2005
95
-
31-01-2005
The aerosol cans
enable you to carry
out a temporary repair
(maximum speed 50 mph
(80 km/h)).
After use, the tyre must be
replaced. As the aerosol cans
are pressurised, they must not be
exposed to a temperature above
50°C.
Store them away from heat in their
insulated storage box
.
PUNCTURES
Because this version does not
possess a spare wheel, you have
a repair kit
(two aerosols for tyre
repairs), stored in an insulated
storage box 1 secured by a strap to
the right-hand side or the left-hand
side (if the vehicle is equipped with
the JBL audio system) of the boot. F
Remove the connector and
immediately drive at least 3 miles
(5 km).
F If possible, check the pressure of
the tyre.
F Then immediately drive at
moderate speed to the nearest
garage.
Using a repair aerosol
(See also the instructions on the
aerosols).
F If possible remove the foreign
body which caused the puncture
and delate the tyre.
F Position the wheel so that the
valve is horizontal to the ground.
F Shake the aerosol vigorously
before use. (In very cold weather,
warm the aerosol for a few
minutes in your hands).
F Fix the aerosol connector onto the
valve, keeping it centralised.
F Hold the valve against the hole
in the wheel rim and at the same
time empty the aerosol, keeping it
upright.
F Maintain the pressure irmly for
one minute.
Practical information

94 -
31-01-2005
95
-
31-01-2005
CHANGING A WHEEL
F Park the vehicle on level, stable,
non slippery ground.
F Apply the handbrake, engage irst
gear or reverse (position P on the
automatic gearbox) and switch off
the ignition.
F Chock the rear of the wheel with
the shim 2 diagonally opposite the
wheel to be changed.
Removing the wheel
F Remove the wheel trim using the
wheelbrace 1 by pulling next to
the valve.
F Loosen the wheel bolts (for
vehicles itted with alloy wheels,
remove the chrome wheel bolt
covers irst; see "Features of alloy
wheels", following page). F
Position the jack 3 at one of the
four locations A underneath the
vehicle, as close as possible to
the wheel to be changed. Ensure
that the entire surface of the jack
base plate is in contact with the
ground.
F Extend the jack 3.
F Remove the bolts and release the
wheel.
Practical information
Tools for changing a wheel
1 - Wheelbrace itted to the lining of
the boot on the rear
right side.
2 - Shim.
3 - Jack.
4 - Tool for removing wheel bolt
trims (located on the boot rear
right inner panel).