Peugeot 206 SW 2005.5 Owner's Manual

Practical information152 -
01-10-2005
153Practical information-
01-10-2005
CHANGING A FUSE
The fuse boxes are located under
the fascia and in the engine
compartment.Correct Incorrect
Pliers A
Fascia fuse box
Unscrew the catch a quarter turn
using a coin then remove the cover
to gain access to the fuses.
The spare fuses and the pliers A
are itted inside of the fascia fuse
box lid. Removing and itting a fuse
Before changing a fuse, the cause of the fault must be foun
d and remedied. The
fuse numbers are indicated on the fuse box.
Use the pliers A.
Always replace a faulty fuse with a fuse of the same rating .

Practical information152 -
01-10-2005
153Practical information-
01-10-2005
Fuse N° RatingFunctions
1 15 A Alarm siren
4 20 A Multifunction display - Navigation control unit - Boot light
ing - Audio equipment - Steering
wheel controls - Trailer
5 15 A Automatic gearbox diagnostics
6 10 A Coolant level - Automatic gearbox - Audio equipment -
Steering wheel angle sensor (ESP)
7 15 A Driving school accessory - Alarm
9 30 A Rear electric windows
10 40 A Rear screen and mirror demisting 11 15 A Rear windscreen wiper
12 30 A Front electric windows - Sunroof
14 10 A Engine fuse box - Air bags - Steering wheel controls - Rain sensor
15 15 A Instrument panel - Multifunction display - Na vigation control unit - Air conditioning - Audio equipment
16 30 A Locking/unlocking controls for doors, bonnet and boot - Deadlocking controls
20 10 A Right-hand brake light
21 15 A Left-hand brake light - 3rd brake light
22 20 A Front courtesy light and rear courtesy light (206 SW) - Map reader -
Glove box lighting - Lighter - 12 volts rear socket (206 SW)
S1 Shunt PARC shunt

Practical information156 -
01-10-2005
157Practical information-
01-10-2005
BATTERY
To charge the battery using a
battery charger:
- Disconnect the battery,
- Follow the instructions for use given by the battery charger
manufacturer,
- Reconnect starting with the negative (-) terminal,
- Check that the terminals and connectors are clean. If they are
covered with sulphate (white or
greenish deposit), disconnect them
and clean them. - Wait for 2 minutes after
switching off the ignition
before disconnecting
the battery.
- Never disconnect a terminal when the
engine is running.
- Never charge a battery without irst disconnecting the terminals.
- Close the windows and the roof before disconnecting the
battery.
- After every reconnection of the battery, switch on the ignition
and wait 1 minute before
starting to allow the electronic
systems to be initialised. If slight
dificulties are experienced after
this, please consult a PEUGEOT
dealer.
It is advisable to disconnect the
battery if the vehicle is not to be
used for a period of more than
one month.
ECONOMY MODE FUNCTION
After the engine has stopped, with
the key in the accessories position,
certain functions (windscreen wiper,
electric windows, courtesy lights,
audio equipment, etc.) can only be
used for a cumulative duration of
thirty minutes, to prevent discharging
the battery.
Once the thirty minutes are over, the
message "Economy mode active"
appears on the multifunction display
and the active functions are put on
standby.
To resume the use of these functions
immediately, start the engine and let
it run for a few minutes.
The time that you will then have
available will be double the time
during which the engine was running.
However, this time will always be
between ive and thirty minutes.
A lat battery will prevent the engine
from starting.
To start the vehicle from another
battery:
- Connect the red cable to the
positive (+) terminals of the two
batteries,
- Connect one end of the green or black cable to the negative (-)
terminal of the slave battery,
- Connect the other end of the green or black cable to an earth point on
the broken down vehicle, as far as
possible from the battery,
Operate the starter, let the engine
run.
Wait for the engine to return to idle,
then disconnect the cables.

Practical information156 -
01-10-2005
157Practical information-
01-10-2005
FITTING SPEAKERS
The factory-itted equipment allows
the itting of:
- 165 mm diameter speakers in the front doors,
- 130 mm diameter speakers in the rear doors,
- 22.5 mm diameter tweeters in the mirror trims. Making the connections
A1 : -
A2 : -
A3 : -
A4 : -
A5 : -
A6 : (+ve) Ignition positive
A7 : (+ve) Permanent
A8 : Earth
B1 : (+) Rear right speaker
B2 : (-) Rear right speaker
B3 : (+) Front right speaker and
tweeter
B4 : (-) Front right speaker and tweeter
B5 : (+) Front left speaker and tweeter
B6 : (-) Front left speaker and tweeter
B7 : (+) Rear left speaker
B8 : (-) Rear left speaker
Consult a PEUGEOT
dealer before install-
ing audio equipment or
speakers in your vehicle.
MONTER UN AUTORADIO
Vous disposez d’origine d’un pré-
équipement radio :
- antenne de toit,
- câble coaxial d’antenne,
- antiparasitage de base,
- alimentation des haut-parleurs AV,
- alimentation des haut-parleurs AR,
- 2 connecteurs 8 voies.

Practical information158 -
01-10-2005
159Practical information-
01-10-2005
Front towing eye 206 SW rear towing eye
TOWING YOUR VEHICLE
By lifting (two wheels only on the
ground)
It is preferable to lift the vehicle by
the wheels.Never use the radiator
crossmember.
Special features of the automatic
gearbox
When towing with all four wheels on
the ground, the following rules must
be adhered to:
- gear lever in position N,
- tow the vehicle at a speed less than 30 mph (50 km/h) over a distance
of not more than 30 miles (50 km),
- do not add oil to the gearbox. Saloon rear towing eye
Saloon
From the front or the rear
Attach the tow bar to the towing eye. 206 SW
From the front,
attach the tow bar to
the towing eye.
Without lifting (four wheels on the
ground)
You must always use a tow bar.
From the rear:
- unclip the cover using a coin,
- screw in the towing eye (located in the jack storage compartment) as
far as it will go.

Practical information158 -
01-10-2005
159Practical information-
01-10-2005
TOWING A TRAILER,
CARAVAN, BOAT etc.
Only use original PEUGEOT tow
bars that have been tested and
approved from the design stage of
your vehicle.
The tow bar must be itted by a
PEUGEOT dealer.
Your vehicle is primarily designed
for transporting people and luggage
but it may also be used for towing a
trailer.
Driving with a trailer subjects the
towing vehicle to more signiicant
stress and its driver must be
particularly careful.
Air density decreases with altitude,
thus reducing engine performance.
Above 1 000 metres, the maximum
towing load must be reduced by 10 %
and so on for every 1 000 metres of
altitude.
Driving advice
Distribution of loads: Distribute the
load in the trailer so that the heaviest
items are as close as possible to the
axle and the nose weight approaches
the maximum permitted without
exceeding it.
Cooling: Towing a trailer on a slope
increases the temperature of the
coolant.
As the fan is electrically controlled,
its cooling capacity is not dependent
on the engine speed.
On the contrary, use a high gear to
lower the engine speed and reduce
your speed.
The maximum towing load on a long
slope depends on the gradient and
the outside temperature. In all cases, pay attention to the
coolant temperature.
If the warning light comes on, stop
the vehicle and switch off the engine
as soon as possible.
Tyres:
Check the tyre pressures
of the towing vehicle and of the
trailer, observing the recommended
pressures.
Braking: Towing increases the
braking distance.
Lights: Check the electrical signal-
ling on the trailer.
Side wind: Take into acount the
increased sensitivity to side wind.

Practical information160 -
01-10-2005
161Practical information-
01-10-2005
Removing the mat
When removing the mat on the
driver's side, move the seat as far
back as possible and remove the
ixings.
When reitting the mat, position it and
replace the ixings by turning them a
quarter of a turn.
Check that the mat is secured
correctly.
To prevent the mat from becoming
caught under the pedals:
- only use mats suited to the ixings which are already present in the
vehicle.
It is imperative that these ixings are used.
- never it one mat on top of another.
FITTING ROOF BARS
(206 SW)
When itting transverse roof bars,
ensure that they are positioned
correctly.
The correct positions are shown by
marks on each of the longitudinal
bars.
Use accessories approved by PEUGEOT
and follow the manufacturer's itting
instructions.
Maximum authorised weight
on the roof rack, for a loading
height not exceeding 40 cm
(except bicycle carriers): 75 kg.
If the height exceeds 40 cm,
adapt the speed of the vehicle
to the condition of the road, to
avoid damaging the roof bars.

Practical information160 -
01-10-2005
161Practical information-
01-10-2005
- Clean off bird droppings, resinous deposits,
tar stains and grease
marks as soon as pos-
sible; (these all contain
substances which can
cause serious damage
to the paintwork).
- Do not use a dry or abrasive cloth or detergent or solvent products
to clean the double lens, complex
surface headlamps as they are
itted with polycarbonate glass
covered in a protective inish.
- Do not use petrol, oil or cloth stain removers to clean the
bodywork and plastic parts of
your vehicle.
- To prevent the development of bodywork corrosion as a result
of accidental damage (stone
chips, scratches, etc.) have
them repaired swiftly.BODYWORK MAINTENANCE
To preserve the paintwork and the
plastic trim on your vehicle, we
recommend that you wash them
regularly.
- by hand: there are no speciic precautions to take;
- using an automatic car wash: repeated use of poorly maintained
automatic car washes can lead
to the appearance of microscopic
scratches which give the paintwork
a matt appearance (especially
visible on dark colours);
- using a high pressure washer: always follow the recommendations
on the equipment (pressure and
spraying distance).
If there are damaged areas on the vehicle (painted bumpers or
headlamps), it is not recommended
to direct the high pressure jet onto
them. Wash these areas by hand.
Also avoid the entry of water into the locks.
For all questions relating to the
maintenance of your vehicle, contact
an approved dealer who can advise
you on quality products selected by
our departments.

Practical information162 -
01-10-2005
206 ACCESSORIES
For your PEUGEOT only use
accessories and original parts
approved by the manufacturer.
These accessories and parts are
all adapted to your PEUGEOT,
after being tested and approved
for reliability and safety, which
PEUGEOT cannot guarantee for
other products.
A wide choice of original accessories,
approved by PEUGEOT, is available
through the dealer network. They all
carry the PEUGEOT guarantee:
Travel and Leisure: Towbar, boot
luggage rack , boot tray, roof bars,
roof boxes, ski carrier, bicycle
carrier**, snow chains, ...
** Do not it the bicycle carrier on the spoiler or on the rear screen.
Exterior style: Alloy wheels, trims,
mud laps, sunroof*, front fog
lamps, tailgate spoiler (saloon),
sports exhaust, aluminium and
wood panel trim, door sills, body kit,
wing extenders, two-tone steering
wheel, ...
* It is imperative that only genuine PEUGEOT products are used for
the itting of a sunroof. Interior equipment
: Central
armrest, writing table, passenger
seat protector, covers suitable for
side air bags (saloon and 206 SW),
mats, boot tray, can holder, CD or
cassette storage, audio/telephone
console, door delectors, under-shelf
storage (saloon), sun blinds, ...
Technology: Audio/telephone,
hands-free kit, satellite navigation
system, CD changers, audio systems,
speakers, audio trim, rear shelf itted
with 4 speakers (saloon), ...
Safety: Anti-theft alarm,
window
engraving, wheel locks, warning
triangle, irst aid kit, high visibility
jacket, booster seats and child seats,
Isoix Kiddy seat, ...
Van: Kit for conversion into a van, ...
Before itting an electrical
accessory in your vehicle,
consult a PEUGEOT
dealer.

163Technical data-
01-10-2005
Models
Model codes PETROL2CHFX
2AHFX
2EHFX 2CK6D
2AK6D 2CKFW 2AKFWA
2AKFW 2CKFWA
2EKFW 2EKFWA 2CKFU
2AKFU
2EKFU 2HKFU
2KKFU
ENGINES1.1 litre 1.4 litre 1.4 litre 1.4 litre 16V
C
ubic capacity (cm3) 1 124 1 360 1 360 1 360
Bore x stroke (mm) 72 x 69 75 x 77 75 x 77 75 x 77
EU standard maximum power (kW) 44.1 55 55 65
Maximum power at engine speed (rpm)5 500 5 500 5 500 5 250
EU standard maximum torque (Nm) 94 118 120 135
Maximum torque at engine speed (rpm)2 700 2 800 2 800 3 250
Fuel Unleaded Leaded Unleaded Unleaded
Catalytic converter Yes No Yes Yes
Gearbox
Manual
(5 speed)Manual
(5 speed)Manual
(5 speed)Automatic
(4 speed)Manual
(5 speed)
Oil capacity (in litres)
Engine (with cartridge replacement)
3.2 (2) - 3.4 (3) 3 (2) -
3.25 (3) 3 (2) -
3.25 (3) 3 (2) -
3.25 (3) 3.2 (2) - 3.5 (3)
Gearbox-Final drive2 2 2 - 2
ENGINES AND GEARBOXES
(2) Draining by gravity - (3) Draining by suction.