gearbox Peugeot 307 Break 2002.5 User Guide

09-09-2002
Place the jack 4in contact with one
of the four locating points Aon the
subframe, (the one which is clos
est to the wheel to be changed).
Extend the jack 4until its base is in
contact with the ground. Ensure
that the centre line of the base of
the jack is straight above the locat
ing point A.
Raise the vehicle.
Unscrew the bolts and remove the
wheel.
Fitting a wheel
Position the wheel using the cen
tralising tool to assist you.
Tighten the bolts by hand and
remove the centralising tool.
Partly tighten the bolts using the
wheelbrace 1.
Fold the jack 4 and remove it.
Fully tighten the bolts using the
wheelbrace 1.
Replace the wheel trim, starting
by placing the wheel trim notch
opposite the valve, and press it
on using the palm of the hand.
Put the tools and the wheel back
in the boot.
Note: a diagram on the holder indi
cates the location of the tools. .
Tighten the spare wheel securing
strap to prevent noise and for your
safety in the event of impact.
PRACTICAL INFORMATION 143
For your safety, always
change the wheel:
on level, stable, nonslippery ground,
with the handbrake on and the ignition switched off,
with first or reverse gear engaged (position Pfor the
automatic gearbox),
with the vehicle chocked.
Never go underneath a vehicle
that is supported only by a jack
(use a ramp)
After changing the wheel:
have the tightening of the bolts and the tyre pressure checked
by a PEUGEOT dealer as soon
as possible.
have the punctured tyre repaired and refit it to the vehicle
as soon as possible.

09-09-2002
PRACTICAL INFORMATION
144
Tools
The following tools are located:
– in the righthand trim of the boot,
1 Wheelbrace.
2 Removable towing eye.
3 Socket for antitheft bolts.
– in the holder in the centre of the spare wheel,
4 Jack with handle.
5 Centralising tool.
6 Bolt cover tool.
7 Removable chock. Parking the vehicle
As far as possible, park the vehi
cle on level, stable and nonslip
pery ground.
Apply the handbrake, switch off
the ignition and engage first or
reverse gear (position Pfor the
automatic gearbox). Access to the spare wheel
Open the boot.
Open the flap using the lug to
release the winch and gain
access to its control nut.
Unscrew the nut fully, using the
wheelbrace 1, to unroll the winch
cable.
CHANGING A WHEEL (ESTATE)

09-09-2002
PRACTICAL INFORMATION
146
Fitting a wheel Position the wheel using the cen
tralising tool 5to assist you.
Tighten the bolts by hand and
remove the centralising tool 5.
Partly tighten the bolts using the
wheelbrace 1.
Fold the jack 4 and remove it.
Fully tighten the bolts using the
wheelbrace 1.
Replace the wheel trim, starting
by placing the wheel trim notch
opposite the valve, and press it
on using the palm of the hand.
Put the corresponding tools in the
holder and secure its cover.
Place the holder on the ground
and align the spare wheel on it.
Pass the notched hook into the
holder cover.
Refit the wheel under the vehicle
tightening the winch control nut
using the wheelbrace 1.
Fully tighten and check that the
wheel is horizontally flush
against the rear floor .
Close the flap using the lug to
lock the winch.
Store the rest of the tools in the
righthand trim of the boot. For your safety, always
change the wheel:
on level, stable, nonslippery ground,
with the handbrake on and the ignition switched off,
with first or reverse gear engaged (position Pfor the
automatic gearbox),
with the vehicle chocked.
Never go underneath a vehicle
that is supported only by a jack
(use a ramp).
Never refit the holder under the
vehicle without the spare
wheel.
After changing the wheel:
have the correct positioning of the punctured wheel, the tight
ening of the bolts and the tyre
pressure checked by a
PEUGEOT dealer as soon as
possible.
have the punctured tyre repaired and refit it to the vehicle
as soon as possible.
have the correct positioning of the spare wheel checked by a
PEUGEOT dealer.

09-09-2002
Fuse N° RatingFunctions
1 10 A Automatic gearbox reversing lights switch Automatic gearbox starting inhibitor relay
control Manual gearbox reversing lights switch Vehicle speed sen sor
Water in diesel sensor.
2 15 A Canister solenoid valve Fuel pump.
3 10 A Power steering control unit ABS or ESP control unit.
4 10 A Injection control unit Fan unit relay control Additional heating relay control
Automatic gearbox control unit Automatic gearbox sequential cont rol
Automatic gearbox shiftlock relay.
5 15 A Particulate emission filter control unit.
6 15 A Front fog lamps.
7— Not used.
8 20 A Fan unit relay control Engine management control unit supply
Injection pump (Diesel).
9 15 A Left dipped beam.
10 15 A Right dipped beam.
11 10 A Right main beam.
12 10 A Left main beam.
13 15 A Horn.
14 10 A Front and rear headlamp wash pump.
15 30A Oxygen sensors Exhaust gas recirculation solenoid valve Ignition co il
Diesel high pressure regulator Injectors supply (petrol) Preheat co ntrol unit
Air flow sensor (Diesel) Engine management control unit (Diesel)
Injection pump (Diesel) Diesel heater.
16 40A Petrol engine air pump with automatic gearbox.
17 30A Front wiper low/high speed.
18 40A Air conditioning blower.
PRACTICAL INFORMATION
154

09-09-2002
PRACTICAL INFORMATION
152
Fuse no. Rating
Functions
9 30 AElectric windows Press operation windows (incompatible with nonp ress operation windows)
Sunroof.
10 15 A Diagnostic socket 12 volt rear socket.
11 15 A Audio equipment Multi–function display Steering wheel cont rols Automatic gearbox.
12 10 A Front right and rear right side lights Number plate and trai ler lighting Central locking switches light
ing/ alarm/hazard warning lights Air conditioning/ashtray ligh t Automatic gearbox switches lighting
Lighter Headlamp beam corrector.
14 30 A Door opening/closing controls Deadlocking controls.
15 30 A Rear windows.
16 5 A Engine fuse box Alarm Particulate emission filter Steering whee l controls Air bags.
17 10 A Rear right brake light, 3rd brake light.
18 10 A Diagnosic socket Steering wheel controls Brake pedal (stop) and cl utch switches Coolant level
switch Second brake switch.
19 30 A PARC shunt.
22 10 A Front left and rear left side lights
Number plate and trailer lighting.
23 15 A Alarm siren Interior alarm control unit.
24 15 A Instrument panel Audio equipment Multifunction display Air conditioning Rear parking aid.
26 30 A Heated rear screen.

TOWING YOUR VEHICLE
Without lifting (4 wheels on the ground)
You must always use a tow bar.
The removable towing eye is inside the spare wheel.
Estate: The removable towing eye is inside the righthand boot trim.
From the front: Unclip the cover, by pressing the bottom part,
Screw in the towing eye as far as it will go.
From the rear: Unclip the top of the cover using a coin,
Screw in the towing eye as far as it will go.
Lifting (2 wheels only on the ground)
It is preferable to raise the vehicle with a professional lif ting device. Special features of the
automatic gearbox
When towing with four wheels on the
ground, the following rules must be
obeyed:
lever in position
N,
tow the vehicle at less than 30 mph (50 km/h) over a maximum dis
tance of 30 miles (50 km).
do not add oil to the gearbox.
PRACTICAL INFORMATION 157
When towing with the
engine switched off, there
is no braking or steering
assistance.
09-09-2002

09-09-2002
TECHNICAL DATA161
Manual Manual Automatic Manual Automatic
(5 speed) (5 speed) (4 speed) (5 speed) (4 speed) PETROL ENGINES / COMPANY
ENGINES 1.4 litre 1.6 litre 16V 2 litre 16V
Cubic capacity (cm
3
) 1 360 1 587 1 997
Bore x stroke (mm) 75 x 77 78.5 x 82 85 x 88
EU standard maximum power (kW) 5 5 8 0 1 0 0
Maximum power at engine
speed (rpm) 5 500 5 800 6 000
EU standard maximum torque (Nm) 1 2 0 1 4 7 1 9 0
Maximum torque at engine
speed (rpm) 3 000 4 000 4 100
Fuel Unleaded Unleaded Unleaded
Catalytic converter Yes Yes Yes
OIL CAPACITIES (in litres)
Engine
(with cartridge replacement) 3.25 3 3 4.25 4.25
GearboxFinal drive 2 2 1.9
MODELS:
Model codes
GEARBOX
3CKFWB/T 3CNFUB 3CNFUE 3CRFNC/IF 3CRFNE
3AKFWB/T 3ANFUB 3ANFUE 3ARFNC/IF 3ARFNE
3EKFWB 3ENFUB 3ENFUE 3ERFNC/IF 3ERFNE 3CNFUC/IF
3ANFUC/IF

09-09-2002
TECHNICAL DATA
162
3C8HZB/T 3CRHYB/T 3CRHSB
3A8HZB/T 3ARHYB/T 3ARHSB
3E8HZB 3ERHYB 3ERHSB
Manual Manual Manual
(5 speed) (5 speed) (5 speed) DIESEL ENGINES / COMPANY
ENGINES 1.4 litre turbo HDI 2 litre turbo HDI 90 bhp 2 litre
turbo HDI 110 bhp
Cubic capacity (cm 3
) 1 398 1 998 1 997
Bore x stroke (mm) 73.7 x 82 85 x 88 85 x 68
EU standard maximum power (kW) 5 0 6 6 7 9
Maximum power at engine
speed (rpm) 4 000 4 000 4 000
E U standard maximum torque (Nm) 1 6 0 2 0 5 2 5 0
Maximum torque at engine
speed (rpm) 1 900 2 000 1 750
Fuel Diesel Diesel Diesel
Catalytic converter Yes Yes Yes
Particulate emission filter No No Yes
Oil capacities (in litres)
Engine
(with cartridge replacement) 4.3 4.5 4.5
GearboxFinal drive 1.9 1.9 1.9
MODELS:
Model codes
GEARBOX

09-09-2002
Saloon consumption In accordance with directive 99/100 [In MPG (litres/100km)]
Engine Gearbox Model Circuit Circuit Circuit Emission of codesUrban Interurban Mixed CO 2by
3C…3A… weight g/Km
1.4 litre ManualKFWB/T 32.5 (8.7) 51.4 (5.5) 42.2 (6.7) 159
1.6 litre 16V ManualNFUB29.7 (9.5) 48.7 (5.8) 39.2 (7.2) 169
1.6 litre 16V ManualNFUC/IF 28.2 (10.0) 48.7 (5.8) 38.2 (7.4) 174
1.6 litre 16V AutomaticNFUE25.9 (10.9) 45.6 (6.2) 35.8 (7.9) 189
2 litre 16 V ManualRFNC/IF 25.9 (10.9) 45.6 (6.2) 35.8 (7.9) 188
2 litre 16V AutomaticRFNE22.8 (12.4) 42.1 (6.0) 32.5 (8.3) 198
1.4 litre Turbo HDIManual 8HZB/T 51.4 (5.5) 70.4 (4.0) 62.8 (4.5) 120
2 litre Turbo HDI 90 bhpManualRHYB/T 40.9 (6.9) 65.7 (4.3) 54.3 (5.2) 138
2 litre Turbo HDI 110 bhpManual RHSB40.4 (7.0) 67.2 (4.2) 54.2 (5.2) 138
TECHNICAL DATA 163
Fuel consumption values correct at time of printing.

09-09-2002
TECHNICAL DATA
164
Estate consumption In accordance with directive 99/100 [MPG(li
tres/100km)]
Engine Gearbox Model Urban Interurban Mixed Emission codescircuit circuit circuit of CO 2by
weight (g/km)
1.4 litre Manual3EKFWB 31.1 (9.0) 50.4 (5.6) 40.9 (6.9) 163
1.6 litre 16V Manual3ENFUB
28.5 (9.9) 44.8 (6.3) 36.7 (7.7) 178
3ENFUC/IF
1.6 litre 16V Automatic3ENFUE25.3 (11.2) 44.1 (6.4) 34.0 (8.3) 194
2 litre 16V Manual3ERFNB
24.7 (11.5) 44.8 (6.3) 34.0 (8.3) 194
3ERFNC/IF
2 litre 16V Automatic3ERFNE20.9 (13.1) 43.5 (6.5) 32.0 (8.8) 206
1.4 litre Turbo HDIManual3E8HZB 49.6 (5.7) 67.2 (4.2) 60.1 (4.7) 124
2 litre Turbo HDI 90 bhpManual3ERHYB 39.8 (7.1) 62.8 (4.5) 50.4 (5.4) 143
2 litre Turbo HDI 110 bhpManual3ERHSB 39.2 (7.2) 64.2 (4.4) 50.4 (5.4) 143
Fuel consumption values correct at time of printing.